On 12-11-22 I had a flat tire. I went to put on the spare, following directions step by step, and placing the jack where the arrow points in the correct spot. I jacked my car up and once the tire was off, the car fell onto the ground bending the jack. I then realized the area the jack sits, along with other areas under the ca…
Read full complaint
On 12-11-22 I had a flat tire. I went to put on the spare, following directions step by step, and placing the jack where the arrow points in the correct spot. I jacked my car up and once the tire was off, the car fell onto the ground bending the jack. I then realized the area the jack sits, along with other areas under the car are badly corroded. It's available for inspection, yes. This could have badly hurt me or my 4 year old who was near me had the jack flew out or my hand had been in the area. I am concerned if there are any other framework issues since the car landed hard on concrete. I also dont know if there is other hidden corrosion I cannot see that could pose saftey issues while driving.
NHTSA ODI #11496983
5,800 miles · Dec 20, 2011
Electrical SystemEquipment
THE NAVIGATION IS PROBABLY THE MOST USER UNFRIENDLY UNIT WE HAVE EVER USED AND HAVE WRITTEN THREE TIMES TO CORRECT THE BAD INFORMATION IN IT; I.E. TAKES YOU TO THE WRONG LOCATION. A NAVIGATIONAL SYSTEM THAT CANNOT BE TRUSTED IS WORSE THAN NOT HAVING ONE AT ALL. THERE ARE MANY PROBLEMS WITH THIS NAVIGATION SYSTEM IN ADDITION TO…
Read full complaint
THE NAVIGATION IS PROBABLY THE MOST USER UNFRIENDLY UNIT WE HAVE EVER USED AND HAVE WRITTEN THREE TIMES TO CORRECT THE BAD INFORMATION IN IT; I.E. TAKES YOU TO THE WRONG LOCATION. A NAVIGATIONAL SYSTEM THAT CANNOT BE TRUSTED IS WORSE THAN NOT HAVING ONE AT ALL. THERE ARE MANY PROBLEMS WITH THIS NAVIGATION SYSTEM IN ADDITION TO THE OTHER 'SENSOR' SAFETY GOODIES ON THIS VEHICLE. THE BLISS IS A SAFETY HAZARD; WORTHLESS. MY SYNC SYSTEM KEEPS BLANKING OUT (REFERRED TO BY EVERYONE AS THE 'BLACK SCREEN') OR A SCREEN THAT LOCKS UP AND WILL NOT PERFORM ANY FUNCTION WHATSOEVER. WHEN RESEARCHING THIS VEHICLE I FOUND INFORMATION ON THIS PROBLEM AS EARLY AS 2008. I PRINTED ALL THE INFORMATION TO SHOW THE SALESMAN. I HANDED HIM 40 PAGES OF INFORMATION ON THE 'BLACK SCREEN' AND ASKED IF THIS IS STILL A PROBLEM HE SAID NO. WE PURCHASED THE 2011 FORD EDGE LIMITED WITH ALL THE GOODIES. NOW AND SINCE THE LAST ROUND WE EXPERIENCED THE 'LOCKED SCREEN' AGAIN WHICH REQUIRED ANOTHER TRIP TO OUR FORD DEALER. BY THE WAY WE RECEIVED NO PAPER WORK ON THE REPAIR. WE HAVE OVER 15K MILES ON THE VEHICLE NOW AND HAVE HAD EXPERIENCED THIS PROBLEM NUMEROUS TIMES. THE NAVIGATION AND THE BLISS SYSTEMS ARE NOT ONLY WORTHLESS BUT SAFETY HAZARDS. A $42,000 MISTAKE?? SHAME ON FORD FOR CONTINUING ON SELLING THIS PRODUCT AND OUR GOVERNMENT FOR LETTING THEM DO SO - EVER WONDER WHY THE CONSUMER LOST THEIR FAITH??? FORD - REALLY? *TR
NHTSA ODI #10440554
9,000 miles · Aug 8, 2011
Equipment
FORD SYNC SYSTEM HAS BEEN FREEZING, BACK UP CAMERA BLACKING OUT, GPS STALLING. CAR HAS BEEN RETURNED TO DEALER 3 TIMES FOR A REBOOT SYSTEM. DEALER SAID IT HAS TO DO WITH THE NEW SYSTEM AND THERE BEING BUGS. *TR
NHTSA ODI #10418053
2,906 miles · Aug 2, 2011
Electrical SystemEquipment
VARIOUS PROBLEMS WITH SYNC/COMPUTER SCREEN IN CAR - SIDE WARNING CAR COMING LIGHTS GO ON FOR NO REASON , SCREEN GOES DARK AND BLACK BOX APPEARS IN CENTER INCLUDING WHEN IN REVERSE THUS BLANKING OUT CENTER VISUAL FIELD OF BACK UP CAMERA (SEE CAMERON GULBRANSEN TRANSPORTATION SAFETY ACT FEB 2008). ALL THIS BEGAN AFTER FORD RECALL…
Read full complaint
VARIOUS PROBLEMS WITH SYNC/COMPUTER SCREEN IN CAR - SIDE WARNING CAR COMING LIGHTS GO ON FOR NO REASON , SCREEN GOES DARK AND BLACK BOX APPEARS IN CENTER INCLUDING WHEN IN REVERSE THUS BLANKING OUT CENTER VISUAL FIELD OF BACK UP CAMERA (SEE CAMERON GULBRANSEN TRANSPORTATION SAFETY ACT FEB 2008). ALL THIS BEGAN AFTER FORD RECALL PROGRAM 10B20 DONE MARCH 29, 2011. IT WORKED PERFECTLY PRIOR TO THAT TIME. CAR WAS BROUGHT BACK TO DEALER AP 2, AP 21, AP 27, MAY 5-9 AND AUG 2 2011 FOR SAME ISSUES. COMPUTER WORKS FOR SHORT TIME THEN PROBLEMS START AGAIN. I DO HAVE A PHOTO IN MY PHONE OF THE BLACK SCREEN HAPPENING WHICH WAS SHOWN TO THE DEALER. IT IS OFTEN TOO UNSAFE TO DRIVE AND TAKE A PHOTO AT THE SAME TIME TO COLLECT BETTER EVIDENCE OF EPISODES SO I ONLY HAVE A COUPLE OF PHOTOS THAT CAME OUT CLEARLY. ALSO VARIOUS OTHER PROBLEMS- PHONE SUDDENLY UNSYNCS ITSELF WHILE DRIVING - I MADE A CALL THEN TRIED TO MAKE A SECOND CALL A FEW MOMENTS LATER AND IT HAD DISCONNECTED FROM CAR INCLUDING ALL 911 SERVICE. WHILE DRIVING ON ROAD WITH NO OTHER CARS NOR OBJECTS, SUDDENLY BEGAN RINGING ALARM AND FLASHING THAT CARS WERE COMING FROM THE SIDES AND THERE WAS NO ONE ON EITHER SIDE AND NO WIND NOR RAIN. WHILE AT DEALER PAST 3 TIMES, DETROIT HOME OFFICE WAS CALLED BY THE DEALER FOR FURTHER ADVICE BY DEALER. *KB
NHTSA ODI #10416771
100 miles · Jun 4, 2011
Electrical SystemEquipment
PURCHASED A 2011 FORD EDGE WITH SYNC AND MY FORD TOUCH AFTER THE 3RD TIME THE DEALER FINALLY UPGRADED THE SYSTEM ON THE WITH THE 4TH VISIT WITH AN UPDATE,ONLY HAD THE CAR BACK LESS THEN A WEEK AND NOW THE ENTIRE SYSTEM CRASHED NOTHING WORKS AND I MEAN NOTHING TOOK IT BACK TO THE DEALER AND WAS TOLD THERE IS NOTHING THEY CAN DO …
Read full complaint
PURCHASED A 2011 FORD EDGE WITH SYNC AND MY FORD TOUCH AFTER THE 3RD TIME THE DEALER FINALLY UPGRADED THE SYSTEM ON THE WITH THE 4TH VISIT WITH AN UPDATE,ONLY HAD THE CAR BACK LESS THEN A WEEK AND NOW THE ENTIRE SYSTEM CRASHED NOTHING WORKS AND I MEAN NOTHING TOOK IT BACK TO THE DEALER AND WAS TOLD THERE IS NOTHING THEY CAN DO EXCEPT WAIT FOR FORD TO COME OUT WITH A FIX. SPENT OVER 40,000 FOR A LEMON AND A DEALER THAT DOES NOT CARE. DOES ANYONE HAVE ANY IDEAS THAT COULD HELP ME OUT WILL BE GREATLY APPRECIATED. *TR
NHTSA ODI #10404457
100 miles · Mar 27, 2011
Electrical SystemEquipment
FORD'S SYNC SYSTEM IS A SAFETY HAZARD. IT DOES NOT WORK AS ADVERTISED, CONSTANTLY CRASHES AND IS A GRAVE DISTRACTION FOR DRIVERS. *TR
NHTSA ODI #10393012
500 miles · Mar 22, 2011
Equipment
2011 FORD EDGE LIMITED WITH MYFORD TOUCH SYSTEM. TOOK DELIVERY OF THIS VEHICLE ON 2/23/11. SINCE, THE MYFORD TOUCH SYSTEM HAS EITHER OPERATED ON A VERY LIMITED BASIS, OR, AND MOST IMPORTANTLY, HAS BEEN ENTIRELY INOPERABLE. THE VEHICLE HAS BEEN IN DEALER SERVICE DEPARTMENT FROM 3/10/11 - 3/17/11 AND UPON FURTHER FAILURE OF THE SY…
Read full complaint
2011 FORD EDGE LIMITED WITH MYFORD TOUCH SYSTEM. TOOK DELIVERY OF THIS VEHICLE ON 2/23/11. SINCE, THE MYFORD TOUCH SYSTEM HAS EITHER OPERATED ON A VERY LIMITED BASIS, OR, AND MOST IMPORTANTLY, HAS BEEN ENTIRELY INOPERABLE. THE VEHICLE HAS BEEN IN DEALER SERVICE DEPARTMENT FROM 3/10/11 - 3/17/11 AND UPON FURTHER FAILURE OF THE SYSTEM, WE PICKED UP ONCE AGAIN BY THE DEALER ON 3/21/11 WHERE IT REMAINS, AWAITING AN INSPECTION BY A FORD FIELD SERVICE ENGINEER. THE DEALER INITIALLY RE-PROGRAMMED THE SYSTEM, WHICH FAILED, ATTEMPTED TO UPGRADE THE SYSTEM SOFTWARE TO V2.7, WITH NO SUCCESS AND THEN REPLACED THE APIM (AUDIO PROTOCOL INTERFACE MODULE) 3 TIMES, WITHOUT SUCCESS. AFTER E-MAILS TO KEY CONTACTS AT FORD, WE RECEIVED A CALL FROM FORD'S EXECUTIVE OFFICES, WHO ARE NOW COORDINATION THE FURTHER REPAIR ATTEMPTS. HAVE BEEN ADVISED THAT IF REPAIRS DO NOT REMEDY THE PROBLEM, THAT THEY WILL HAVE TO CONSIDER OTHER ALTERNATIVES. WE ASSUME THAT IS REPLACING THE VEHICLE, BUT THEY WOULD NOT YET COMMIT TO SUCH. THIS ISSUE HAS LEFT US WITH AN ENTIRE LACK OF FAITH IN FORD AND THE QUALITY OF ITS VEHICLES.
NHTSA ODI #10392438
Mileage unknown · Nov 30, 2010
Equipment
I HAVE OWNED A 2011 FORD EDGE NOW FOR ALMOST 2 MONTHS, THIS CAME WITH THE MYFORD TOUCH SYSTEM WITH SYNC SERVICES. THIS SERVICE HAS YET TO WORK. AFTER HAVING THE DEALER HAVE IT FOR A DAY, THEY COME BACK AND SAY ITS A FORD PROBLEM THAT THEY ARE LOOKING INTO. I CALL SYNC SERVICE AND THEY SAY THE DEALER ONLY HAS TO FLASH THE MEMORY …
Read full complaint
I HAVE OWNED A 2011 FORD EDGE NOW FOR ALMOST 2 MONTHS, THIS CAME WITH THE MYFORD TOUCH SYSTEM WITH SYNC SERVICES. THIS SERVICE HAS YET TO WORK. AFTER HAVING THE DEALER HAVE IT FOR A DAY, THEY COME BACK AND SAY ITS A FORD PROBLEM THAT THEY ARE LOOKING INTO. I CALL SYNC SERVICE AND THEY SAY THE DEALER ONLY HAS TO FLASH THE MEMORY AND THIS WILL FIX IT. THE DEALER DOESN'T HAVE THE TOOLS TO DO THIS YET. I WAS EVEN TOLD TO TAKE IT TO ANOTHER DEALER AND THIS IS HOW I FOUND OUT THEY NEED TO ORDER CABLES. THEY STILL HAVE NOT GOT THESE AND I WAS TOLD EVEN AFTER THEY GET THEM NOW, NOT TO WORK ON ANY VEHICLES TILL FORD GETS A FIX FOR IT. WHY WAS THIS SYSTEM EVEN PUT INTO THE MARKET IF THEY HAVE THESE ISSUES!!! HOW MUCH LONGER DO WE HAVE TO WAIT ON THIS AND WHAT KIND OF RESTITUTION SHOULD BE GIVEN TO THE PEOPLE WITH THIS VEHICLE THAT WAS BOUGHT WITH THIS SYSTEM THAT DOESN'T WORK. *TR
NHTSA ODI #10368439
10 miles · Nov 15, 2010
Equipment
THIS IS A PREEMPTIVE COMPLAINT, AS I THANKFULLY HAVE NOT HAD AN ACCIDENT YET. THE MYFORDTOUCH SYSTEM IN ALL 2011 FORD MOTOR CO VEHICLES ARE DEFECTIVE. THE SYSTEM HAS A MULTITUDE OF DEFECTS, BUT THE SAFETY RELATED DEFECT IS THAT THE SYSTEM CAN SPONTANEOUSLY REBOOT AT ANY TIME WITH NO WARNING TO THE DRIVER. THIS CAN HAPPEN AT RAND…
Read full complaint
THIS IS A PREEMPTIVE COMPLAINT, AS I THANKFULLY HAVE NOT HAD AN ACCIDENT YET. THE MYFORDTOUCH SYSTEM IN ALL 2011 FORD MOTOR CO VEHICLES ARE DEFECTIVE. THE SYSTEM HAS A MULTITUDE OF DEFECTS, BUT THE SAFETY RELATED DEFECT IS THAT THE SYSTEM CAN SPONTANEOUSLY REBOOT AT ANY TIME WITH NO WARNING TO THE DRIVER. THIS CAN HAPPEN AT RANDOM, AND MULTIPLE TIMES WITHIN A SHORT PERIOD OF TIME. WHEN BACKING UP THIS SHUTS DOWN THE BACKUP CAMERA WHICH COULD RESULT IN INJURIES TO CHILDREN WHO GET BEHIND THE VEHICLE. AT NIGHT THIS CAUSES THE SCREEN TO SUDDENLY GO FULL WHITE AT FULL BACKLIGHT, WHICH IS EXTREMELY DISTRACTING TO A DRIVER AT NIGHT. ANOTHER SAFETY ISSUE WOULD BE WHEN THE SYSTEM REBOOTS WHEN THE DRIVE IS BEING GUIDED TO AN EMERGENCY FACILITY OR IS ON THE PHONE WITH 911. FORD ACKNOWLEDGED THE PROBLEMS TO DEALERSHIPS ON OCT 20TH AND INFORMED THEM NOT TO DO ANYTHING AT THIS TIME. MANY CUSTOMERS HAVE BEEN REPORTING THESE PROBLEMS ON THE OWNER2OWNER WEBSITE FOR THE FORD SYNC SYSTEM. I AM SUBMITTING THIS COMPLAINT IN HOPES IT CAN BE DEALT WITH BEFORE SOMEONE GETS HURT RATHER THAN AFTER. THANK YOU *TR
FORD IS RECALLING CERTAIN MODEL YEAR 2011 FORD F-150, F-250, F-350, F-450, F-550, EDGE, AND LINCOLN MKX TRUCKS MANUFACTURED FROM OCTOBER 25, 2010, THROUGH NOVEMBER 20, 2010. THESE VEHICLES WERE INSPECTED USING INTEGRATED DIAGNOSTIC SYSTEM (IDS) THAT HAD A CUSTOM SOFTWARE ROUTINE TO READ THE SUSPECT BODY CONTROL MODULE (BCM) SERIAL NUMBER. BASED ON THE SERIAL NUMBER THE BCM WAS EITHER NOT AFFECTED OR REPLACED. THE CUSTOM SOFTWARE ROUTINE WAS NOT READING THE CORRECT SET OF CHARACTERS, AND WAS NOT ABLE TO IDENTIFY A BCM THAT REQUIRED REPLACEMENT AFFECTED BCMS MAY HAVE THE POTENTIAL FOR AN INTERNAL SHORT.
Consequence & remedy
Consequence: IF AN ELECTRICAL SHORT DEVELOPS, AN OVERHEATING CONDITION MAY OCCUR WHICH COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALER WILL INSPECT THE BODY CONTROL MODULE AND IF NECESSARY REPLACE IT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 7, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
FORD IS RECALLING CERTAIN MODEL YEAR 2011 F-150, F-250, F-350, F-450, F-550, EDGE AND LINCOLN MKX VEHICLES. DURING A SIX-DAY PRODUCTION PERIOD, THE SUPPLIER OF THE BODY CONTROL MODULE MANUFACTURED MODULES THAT MAY HAVE THE POTENTIAL FOR AN INTERNAL SHORT.
Consequence & remedy
Consequence: IF AN ELECTRICAL SHORT DEVELOPS, AN OVERHEATING CONDITION MAY OCCUR WHICH CAN RESULT IN AN UNATTENDED VEHICLE FIRE.
Remedy: DEALER WILL REPLACE THE BODY CONTROL MODULE IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 11, 2011. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
FORD IS RECALLING CERTAIN MODEL YEAR 2011 EDGE AND LINCOLN MKX VEHICLES MANUFACTURED FROM JULY 1, 2010, THROUGH OCTOBER 8, 2010. THESE VEHICLES WERE SHIPPED WITH INCORRECTLY CONFIGURED ELECTRONIC MODULE SETTINGS THAT DISABLE THE LOCKING FUNCTION OF THE LIFTGATE. ACCORDINGLY, THE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: THE LIFTGATE LOCK MAY BE DISABLED AND THE DRIVER MAY NOT BE ABLE TO LOCK THE LIFTGATE USING INTERIOR LOCK SWITCHES OR REMOTE KEY FOB BUTTONS.
Remedy: FORD WILL NOTIFY OWNERS AND DEALERS WILL HAVE THE AFFECTED CONTROL MODULES UPDATED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 1, 2010. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
Additional source detail variants (3)
Interior Lighting
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
Latches/locks/linkages:doors:latch
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
Latches/locks/linkages
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
2011 Ford Edge Problems, Complaints & Recalls | Skip That Year
Illustration