Cel light and P0456 diagnostic reading indicates an EVAP leak. Large fuel leak discovered emanating from the fuel tank area when tank is at full. Fuel tank was removed and upon inspection it revealed the fuel tank had cracked at the top of the rollover valve just underneath a vent line. There is no recall for this fuel tank a…
Read full complaint
Cel light and P0456 diagnostic reading indicates an EVAP leak. Large fuel leak discovered emanating from the fuel tank area when tank is at full. Fuel tank was removed and upon inspection it revealed the fuel tank had cracked at the top of the rollover valve just underneath a vent line. There is no recall for this fuel tank as there should be. A new fuel tank is ordered and awaiting delivery as there is no replacement part or means to install a new rollover valve. Cost of tank at discount is $1000. Photo of cracked area is attached.
NHTSA ODI #11488913
116,364 miles · Apr 8, 2021
Fuel/propulsion System
PTU IS LEAKING I KNOW THERE WAS A RECALL FOR THE F-350S
NHTSA ODI #11407071
28,000 miles · Mar 31, 2021
Fuel/propulsion System
THE ROLL-OVER VALVE ON THE TOP OF THE FUEL TANK CRACKED ALLOWING GAS TO ESCAPE WHEN THE TANK WAS OVER HALF FULL. THE ROLLOVER VALVE IS PART OF THE TANK ASSEMBLY AND CANNOT BE REPLACED BY ITSELF. I HAD TO PURCHASE A NEW TANK ASSEMBLY FOR $1300 PLUS LABOR.
NHTSA ODI #11405761
Mileage unknown · Jan 11, 2021
Fuel/propulsion System
FUEL LEAK. THERE ARE RECALLS FOR THE SAME PARTS ON THE 2012 AND 2013 FORD EDGE. JUST WANT TO GET MY EDGE FIXED SO IT DOES NOT CATCH FIRE
NHTSA ODI #11387599
115,000 miles · Dec 3, 2020
Fuel/propulsion System
UPON FUELING OF VEHICLE A STRONG SMELL OF FUEL IS PRESENT AND AFTER PARKING OVERNIGHT A SIGNIFICANT PUDDLE OF FUEL IS DISCOVERED UNDER THE VEHICLE. THIS IS A SEVER ISSUE WHICH NEEDEDS TO BE RECALLED TO PREVENT A CATASTROPHIC EVENT.
NHTSA ODI #11377723
104,000 miles · Apr 20, 2020
EngineFuel/propulsion SystemPower Train
65 MPH ON HIGHWAY, COMPLETE LOSS OF POWER... ELECTRONICS SEEMED TO SPUTTER OFF, THEN BACK ON FOR A FEW SECONDS, THEN OFF AGAIN, BUT THE VEHICLE SHUT COMPLETELY OFF MID HIGHWAY DRIVING WITH NO ABILITY TO STEER, ACCELERATE OR DECELERATE. ENDED UP AT A COMPLETE STOP ON THE HIGHWAY WITH NOTHING WORKING TO POWER THE VEHICLE BACK ON.…
Read full complaint
65 MPH ON HIGHWAY, COMPLETE LOSS OF POWER... ELECTRONICS SEEMED TO SPUTTER OFF, THEN BACK ON FOR A FEW SECONDS, THEN OFF AGAIN, BUT THE VEHICLE SHUT COMPLETELY OFF MID HIGHWAY DRIVING WITH NO ABILITY TO STEER, ACCELERATE OR DECELERATE. ENDED UP AT A COMPLETE STOP ON THE HIGHWAY WITH NOTHING WORKING TO POWER THE VEHICLE BACK ON. HEATER SEEMED TO CONTINUE TO WORK, BUT NOTHING AS FAR AS THE ENGINE OR DASH, NO ELECTRONICS. CONTINUED TO TRY TO START THE VEHICLE OVER AND OVER AS ONCOMING VEHICLES SWERVED AROUND ME AT 60 TO 70 MPH. DIALED 911 AND HAD TO WAIT 15 MINUTES BEFORE A POLICE CAR PARKED BEHIND THE FORD EDGE WITH FLASHERS ON. LITERALLY NO WARNING, NO WARNING LIGHTS, NO NOTHING. VEHICLE SIMPLY LOST POWER... COMPLETELY TURNED OFF. THIS WAS HANDS DOWN ONE OF THE MOST FRIGHTENING EXPERIENCES FOR MY DAUGHTER WHO WAS DRIVING AT THE TIME. SHE'LL LIKELY NOT GET BACK INTO THAT VEHICLE.
NHTSA ODI #11321741
Mileage unknown · Jan 7, 2020
Fuel/propulsion System
I HAVE BEEN SMELLING FUEL/GAS OR SULFUR LIKE SMELL IN MY SUV TOOK IT TO THE FORD DEALER IN RICHMOND, CA 3 TIMES STARTING IN APRIL 2017, JAN 2019 AND AGAIN SEPT 2019 FINALLY I WAS TOLD I NEEDED A PTU UNIT EACH TIME I TOOK IT NEED THEY COULD NOT LOCATE THE PROBLEM. IT HAS BECOME VERY BAD AND MORE OFTEN MY CAR DOES NOT LEAK GAS. …
Read full complaint
I HAVE BEEN SMELLING FUEL/GAS OR SULFUR LIKE SMELL IN MY SUV TOOK IT TO THE FORD DEALER IN RICHMOND, CA 3 TIMES STARTING IN APRIL 2017, JAN 2019 AND AGAIN SEPT 2019 FINALLY I WAS TOLD I NEEDED A PTU UNIT EACH TIME I TOOK IT NEED THEY COULD NOT LOCATE THE PROBLEM. IT HAS BECOME VERY BAD AND MORE OFTEN MY CAR DOES NOT LEAK GAS. I AM REALLY CONCERN BECAUSE NOW I HAVE TO TAKE MY GRANDDAUGHTER TO SCHOOL PLUS I AM OVER 70 YRS AND WORRY IF SOMEONE RUNS INTO ME WILL MY CAR CATCH ON FIRE OR ONE DAY IT WILL CATCH ON FIRE IT HAPPENS UNEXPECTEDLY SOMETIMES IF I'M DRIVING UP A HILL OR FOR A LONG PERIOD OF TIME (MAYBE AN HOUR OR SO) AND IT ONLY HAPPEN WHEN I AM DRIVING AND THE SMELL FILLS MY ENTIRE CAR THAT I HAVE TO LET ALL THE WINDOWS DOWN AND ONCE I GET HOME THE WHOLE CAR SMELLS TO THE POINT I GET SICK (NAUSEA) EYES BURN AND A HEADACHE. I HAVE BEEN SO DISCUSSED WITH DEALERSHIP THAT THEY WERE NOT ABLE TO DETECT THIS PROBLEM 2 YRS AGO. I AM SO SURPRISED THAT THERE HAS NOT BE A RECALL ON THIS DANGEROUS PROBLEM BY FORD.
NHTSA ODI #11297832
100,003 miles · Dec 24, 2019
Fuel/propulsion System
UPON FILLING THE GAS TANK, ONCE PARK IN THE GARAGE THERE IS AN OVERPOWERING SMELL OF GASOLINE. I'VE CLEANED THE FILLER SEAL, CHECKED FOR LEAKS "NONE NOTED." NO FUEL ON THE GROUND BENEATH THE VEHICLE. THE TANK IS NOT OVER FILLED, NO RESIDUAL FUEL AROUND THE FILLER NECK OR RUNNING DOWN THE OVERFILL DRAIN. FUEL SMELL GOES AWAY AFTE…
Read full complaint
UPON FILLING THE GAS TANK, ONCE PARK IN THE GARAGE THERE IS AN OVERPOWERING SMELL OF GASOLINE. I'VE CLEANED THE FILLER SEAL, CHECKED FOR LEAKS "NONE NOTED." NO FUEL ON THE GROUND BENEATH THE VEHICLE. THE TANK IS NOT OVER FILLED, NO RESIDUAL FUEL AROUND THE FILLER NECK OR RUNNING DOWN THE OVERFILL DRAIN. FUEL SMELL GOES AWAY AFTER THE TANK IS BETWEEN 3/4 TO 1/2 FULL. THIS IS A DANGEROUS SITUATION WHICH NEEDS TO BE ADDRESSED BY A RECALL. I SUSPECT THAT THERE IS A BAD SEAL ON THE FUEL PUMP OR TANK MY BE DAMAGED
NHTSA ODI #11291022
154,000 miles · Aug 30, 2019
Fuel/propulsion System
FUEL TANK LEAK, FUEL ODOR
NHTSA ODI #11252511
110,000 miles · May 24, 2019
Fuel/propulsion System
CHECK ENGINE LIGHT COMES ON FROM ERROR CODE P0456 - SMALL LEAK DETECTED IN THE EVAPORATIONS EMISSIONS (EVAP) SYSTEM. THE CHECK ENGINE LIGHT COMES ON EVERY TIME THE VEHICLE IS FUELED WITH GASOLINE. MY MECHANIC ADVISED THIS IS A COMMON PROBLEM IN FORDS WITH THE NO GAS CAP SYSTEM.
FORD IS RECALLING CERTAIN MODEL YEAR 2011 FORD F-150, F-250, F-350, F-450, F-550, EDGE, AND LINCOLN MKX TRUCKS MANUFACTURED FROM OCTOBER 25, 2010, THROUGH NOVEMBER 20, 2010. THESE VEHICLES WERE INSPECTED USING INTEGRATED DIAGNOSTIC SYSTEM (IDS) THAT HAD A CUSTOM SOFTWARE ROUTINE TO READ THE SUSPECT BODY CONTROL MODULE (BCM) SERIAL NUMBER. BASED ON THE SERIAL NUMBER THE BCM WAS EITHER NOT AFFECTED OR REPLACED. THE CUSTOM SOFTWARE ROUTINE WAS NOT READING THE CORRECT SET OF CHARACTERS, AND WAS NOT ABLE TO IDENTIFY A BCM THAT REQUIRED REPLACEMENT AFFECTED BCMS MAY HAVE THE POTENTIAL FOR AN INTERNAL SHORT.
Consequence & remedy
Consequence: IF AN ELECTRICAL SHORT DEVELOPS, AN OVERHEATING CONDITION MAY OCCUR WHICH COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALER WILL INSPECT THE BODY CONTROL MODULE AND IF NECESSARY REPLACE IT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 7, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
FORD IS RECALLING CERTAIN MODEL YEAR 2011 F-150, F-250, F-350, F-450, F-550, EDGE AND LINCOLN MKX VEHICLES. DURING A SIX-DAY PRODUCTION PERIOD, THE SUPPLIER OF THE BODY CONTROL MODULE MANUFACTURED MODULES THAT MAY HAVE THE POTENTIAL FOR AN INTERNAL SHORT.
Consequence & remedy
Consequence: IF AN ELECTRICAL SHORT DEVELOPS, AN OVERHEATING CONDITION MAY OCCUR WHICH CAN RESULT IN AN UNATTENDED VEHICLE FIRE.
Remedy: DEALER WILL REPLACE THE BODY CONTROL MODULE IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 11, 2011. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
FORD IS RECALLING CERTAIN MODEL YEAR 2011 EDGE AND LINCOLN MKX VEHICLES MANUFACTURED FROM JULY 1, 2010, THROUGH OCTOBER 8, 2010. THESE VEHICLES WERE SHIPPED WITH INCORRECTLY CONFIGURED ELECTRONIC MODULE SETTINGS THAT DISABLE THE LOCKING FUNCTION OF THE LIFTGATE. ACCORDINGLY, THE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: THE LIFTGATE LOCK MAY BE DISABLED AND THE DRIVER MAY NOT BE ABLE TO LOCK THE LIFTGATE USING INTERIOR LOCK SWITCHES OR REMOTE KEY FOB BUTTONS.
Remedy: FORD WILL NOTIFY OWNERS AND DEALERS WILL HAVE THE AFFECTED CONTROL MODULES UPDATED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 1, 2010. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
Additional source detail variants (3)
Interior Lighting
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
Latches/locks/linkages:doors:latch
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
Latches/locks/linkages
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
2011 Ford Edge Problems, Complaints & Recalls | Skip That Year
Illustration