2021 Ford Ecosport

Airbag failure (VERY IMPORTANT) I am reporting a serious vehicle safety issue involving airbag failure. I was driving a vehicle rented through Turo from Moon Rental Corporation when I was involved in a rear-end collision (hit-and-run) on the highway where I was going 65 and hit by a large SUV going 80 MPH. During the crash, the airbags did not deploy as photo, video, and police witness confirm. The impact was significant enough that airbags should have deployed, and I sustained injuries as a result. This raises serious concerns about the safety and condition of the vehicle, including possible defects or failure to properly maintain critical safety systems. The owner runs a rental car business Moon Rentals Corporation and uses Turo and is insured by Travelers Insurance Company. I am requesting that this incident be investigated as a potential safety defect in addition to negligence by the rental car owner for not inspecting or maintaining the vehicle to check for such defects.

Vehicle: Ford EcoSport Issue: Overheating / Unsafe to Drive After Recall Repairs Dealership: Bolton Ford Dates: Vehicle at dealership since December 31, 2025 Complaint Text: My Ford EcoSport has been at the dealership since December 31 for multiple recall repairs. After the recall work was completed, the dealership informed me that the vehicle now has an overheating issue and another non‑recall issue; Transmission Roller Restrictor Mount totaling over $580. These issues were not present before the recall repairs. The dealership told me the vehicle is unsafe to drive because the overheating could cause engine damage or failure. Ford is refusing to extend the rental vehicle past March 29th even though my car is unsafe to operate and the parts for the overheating repair will not arrive until the dealership gets to go ahead to fix the repairs, and I was informed that may take a week for those parts to come in. I’m starting a new job and cannot safely drive the vehicle in its current condition. I’am being pressured to take back an unsafe vehicle or pay for repairs I cannot afford. I am requesting NHTSA to investigate this safety issue, as Ford is attempting to return a vehicle that is overheating and unsafe to drive. This creates a serious risk of engine failure, breakdown, or accident.

My Ecosport prior to going to Celebrity Ford had no mechanical and electricial issues. It went to into Celebrity Ford of Toms River for the Engine Pump Recall on Dec. 23, 2025. I did not get the vehicle back until Feb 4, 2026 after major engine work was completed by Celebrity Ford. Substantial engine parts replacement—was performed as part of this recall repair (can been seen on service invoice). Since that installation, the vehicle has had continuous mechanical problems that did not exist beforehand. Since then, the vehicle has had multiple mechanical and electrical failures- from "Full Accessory Power Message" along with numerous times failing to start with multiple warning lights illuminated as well as the most recent incident on March 5th. While driving home from work on the Garden State Parkway at 70 mph, my vehicle began to shudder/ shake violently almost stalling with lose of power along with the check engine light blinking from an engine that had significant work done according to the first service invoice from 12/23/25 to 2/4/26. At the time, I was in the center lane. I had to carefully maneuver across parkway work traffic to the right lane while my vehicle continued operating abnormally. This was a frightening and dangerous experience that could have resulted in a serious accident.Since bringing my vehicle in for this recall, it has experienced repeated failures and serious safety concerns that have made it unreliable and unsafe to drive due to Celebrity Ford's liability issue for negligence and improper recall repair. Celebrity Ford performed the recall repair, installed/ replaced major engine components, caused repeated breakdowns and now is disrepair to a vehicle that was in perfect working condition prior. I am seeking accountability for the damage caused and a resolution to this ongoing issue. I do not have my vehicle currently as they are still trying to duplicate the concern and in contact with a "Hotline" team with no ETA of completion.

The contact owns a 2021 Ford EcoSport. The contact stated that while driving at an undisclosed speed, the low engine oil warning light illuminated. The contact researched and confirmed that the VIN was included in NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling). The dealer was made aware of the failure. The vehicle was taken to the dealer, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact was informed that parts had been ordered for the repair. The vehicle had remained at the dealer for five months, and the vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. In addition, the contact was informed that the VIN would be placed on a waiting list for an engine replacement. The failure mileage was approximately 50,000.

The contact owns a 2021 Ford EcoSport. The contact stated that while driving 65 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended, and the vehicle lost motive power. No warning lights were illuminated. The vehicle was driven to the shoulder of the roadway. The contact stated that the vehicle was overheating and was parked until the engine cooled down. The failure was persistent, and the engine continued to overheat. The vehicle was driven to the residence. The vehicle was then towed to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact was informed of an unknown recall repair for the replacement of the engine. In addition, the contact was informed that the engine was on back order. The vehicle was repaired; however, the failure reoccurred. The vehicle was towed back to the dealer where it was diagnosed with cooling fan and control module failures. The contact was informed that the cooling fan and cooling module needed to be replaced. The vehicle was not repaired. The contact was informed that the repair was not covered under the recall. The contact declined to pay for the repair. The contact stated that the vehicle was purchased in September 2025. The contact stated that prior to the purchase, the vehicle was taken to the dealer to be serviced. The original owner was informed that there were no open recalls associated with the VIN. The contact stated the dealer was the original dealer that serviced the vehicle in September 2025. The manufacturer was made aware of the failure, and three cases were filed. The failure mileage was 80,460.

The contact's father owns a 2021 Ford EcoSport. While the owner was driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The crankshaft warning light was illuminated. The contact stated that the vehicle failed to accelerate above 50 MPH. The vehicle was taken to the dealer, where the contact's father was informed that the spark plugs were smashed. The owner was informed that the spark plugs needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken to the dealer, where it was diagnosed with ignition coil failures. The contact was informed that the ignition coils needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The failure occurred while the contact's parents were traveling out of state, through the mountains. The vehicle was previously repaired in December 2025 under NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling). The contact stated that the engine was replaced. In addition, the replacement engine failure had started after less than 1,000 miles. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 38,457.

As I pulled into my driveway, my brakes locked up resulting in my vehicle only coming to a stop because it crashed into another vehicle in my driveway. It is still in my driveway, the function of breaking has not been reproduced. The car will not even start now. The vehicle has not yet been inspected by a dealer, an independent service center, or anyone else. I will be contacting my insurance today. A police report was not made as no one was at fault. There were no warning lamps or messages displayed. I did receive a letter this week from Brian Leonard, a service Manager at Price Ford Simi Valley regarding recall 23S64. The letter notified me of the new recall, that their business will "pick up and deliver my vehicle, provide me a loaner vehicle, and complete the recall repairs for me". I received this letter the day before the brake failure. The morning after the brakes failed causing the crash, I contacted Mr. Leonard who told me they will now not fix any of the issues or comply with any part of the letter, that I should file a claim with my insurance and take the car to a Ford dealership in Turlock. This was communication was all via email and Simi Valley Ford has now ended communication with me. This car was purchased brand new and I have had nothing but issues and recalls with it. Additionally while driving it 3 weeks ago on [XXX] , the car lost all power. I pulled over to the side of the road and sat for about 10 minutes debating what to do. I attempted to restart the vehicle, it started and I was able to complete my drive home with no warning or indicator lights appearing. This car is a lemon! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Ford EcoSport. The contact stated that while driving at an undisclosed speed, the traction control and other unknown warning lights were illuminated. The vehicle was taken to a local dealer, where it was diagnosed and determined that a software update was needed. The vehicle was repaired out of pocket. The battery was previously replaced as a temporary repair. The manufacturer was made aware of the failure. The failure mileage was approximately 30,000.

The contact owns a 2021 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING). The vehicle was taken to the dealer, and the contact was informed that the part was not available and needed to be ordered. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

On December 24, 2025, I was traveling from Arizona to California when WITHOUT WARNING I lost all power from my Ford EcoSport while on the 10 freeway. At that moment I was able to navigate to the side of the road. This placed myself and others in an unsafe situation on the freeway. The vehicle was then towed to a dealership in Temecula, CA where upon inspection they stated that I would need a new engine. The vehicle has sat at the dealership since unrepairable and the weekly text from the dealership is "still waiting for parts". I have lost confidence that this vehicle will ever be safe and that my safety is at risk and that it is unrepairable as it is still sitting at the dealership it was towed to. By way of background, on May 19, 2025 I brought my Ford EcoSport for a pre-scheduled appointment to a dealership in Phoenix, AZ to have recall manufacturer number 23S64 and 25S12 completed. I was told by the service tech that they could not assess the NEED for 23S64 due to a recent oil change in the vehicle. I later learned that 23S64 is a 100% replacement rate and that a recent oil change should not matter. I won't go into the negligence of this dealer in Phoenix, AZ., but for sure this vehicle is not safe for me or anyone on the roadways.