2021 Ford Ecosport

The contact owns a 2021 Ford EcoSport. The contact stated that while driving at unknown speeds, the vehicle stalled. The vehicle restarted after 20 minutes. The Check Engine warning light was illuminated. The "Charging System Failed" message was displayed. The vehicle was previously taken to the local dealer for NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling) recall repair. The vehicle was taken back to the local dealer, where it was diagnosed with needing the EVAP purge system replacement. The vehicle was repaired; however, the Check Engine warning light illuminated while leaving the dealer. The vehicle was taken to the same dealer, who informed the contact that a diagnostic test was needed, and that there was no warranty coverage. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 60,688.

After having to have my vehicle towed to & held by the dealership for a total of 3 months altogether over the course of two separate engine rebuilds due to a national recall on faulty oil pump parts, my vehicle's check engine light came on & gave a message that there was an issue with the emissions system. I am now experiencing multiple engine system faults EVERY SINGLE TIME I refuel my vehicle where my engine will not start until after 10+ attempts & now that the weather is hotter, I'm also experiencing engine system faults while driving in town & on the highway where the engine completely shuts down & I lose all power, including steering power, while I'm driving! The system instructs me to put the car in park, turn the key to the off position & restart the vehicle WHILE I'M STILL TRYING TO MANUEVER TO SAFETYWITH ZERO POWER IN THE MIDDLE OF THE ROAD/HIGHWAY! I was almost hit by other vehicles multiple times! This vehicle is my only source of transportation but it is wholly dangerous & totally unsafe to drive!

Vehicle: Ford EcoSport Issue: Overheating / Unsafe to Drive After Recall Repairs Dealership: Bolton Ford Dates: Vehicle at dealership since December 31, 2025 Complaint Text: My Ford EcoSport has been at the dealership since December 31 for multiple recall repairs. After the recall work was completed, the dealership informed me that the vehicle now has an overheating issue and another non‑recall issue; Transmission Roller Restrictor Mount totaling over $580. These issues were not present before the recall repairs. The dealership told me the vehicle is unsafe to drive because the overheating could cause engine damage or failure. Ford is refusing to extend the rental vehicle past March 29th even though my car is unsafe to operate and the parts for the overheating repair will not arrive until the dealership gets to go ahead to fix the repairs, and I was informed that may take a week for those parts to come in. I’m starting a new job and cannot safely drive the vehicle in its current condition. I’am being pressured to take back an unsafe vehicle or pay for repairs I cannot afford. I am requesting NHTSA to investigate this safety issue, as Ford is attempting to return a vehicle that is overheating and unsafe to drive. This creates a serious risk of engine failure, breakdown, or accident.

The contact owns a 2021 Ford EcoSport. The contact stated that while driving at an undisclosed speed, the traction control and other unknown warning lights were illuminated. The vehicle was taken to a local dealer, where it was diagnosed and determined that a software update was needed. The vehicle was repaired out of pocket. The battery was previously replaced as a temporary repair. The manufacturer was made aware of the failure. The failure mileage was approximately 30,000.

The contact owns a 2021 Ford EcoSport. The contact stated that the engine seized while driving at an undisclosed speed. The vehicle was towed to the local dealer after several months, where it was diagnosed, and it was determined that the engine needed to be replaced. The vehicle was repaired. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling). Upon retrieval of the vehicle, the battery light started flickering. The contact called another dealer, Gullo Ford of Conroe (925 Interstate 45 S #2, Conroe, TX 77301), but no further assistance was provided. The manufacturer was notified of the failure. The failure mileage was approximately 124,000.

The contact owns a 2021 Ford EcoSport. The contact stated that while driving 30-40 MPH, the messages "Save the Battery", "Turn off Engine", and "Restart" were displayed. The program restarted, and the screen went blank, and the instrument cluster became inoperable. Additionally, the contact was informed about NHTSA Campaign Number: 25V126000 (Power Train). The vehicle was taken to the local dealer, who was unable to duplicate the failure. The vehicle was taken to the local dealer again, where it was diagnosed and determined that the alternator, engine, transmission, and computer needed to be replaced. The mechanic informed the contact that there was no warranty coverage for the failure. The vehicle was repaired, but the failure reoccurred. The manufacturer was not notified of the failure. The failure mileage was approximately 50,000.

Myself, my husband and our son were driving on the freeway going 70 mph and all of a sudden with no warning and our engine lost all power we almost got killed by a semi my husband had to put the car in neutral to restart it and then it would only go about 40 mph, the RPM were between 4 and 5 going 30 mph, I took my car to valley Ford of Columbus and they told me it was some kind of valve and it was going to take 2 months for the part to come in, I told valley Ford we almost got killed and this car is a death trap, they didn't care at all they made me drive this car for 2 months with the motor shutting down on me We almost got killed 3 times from semi almost killing us, so finally after 2 months valley ford called and said the valve came in, we took it in and with in 3 minutes of leaving valley Ford we got on the freeway ramp and as soon as we switched lanes the car lost power again. A semi almost hit us from behind, I called valley Ford immediately and calab said oh maybe it's your transmission they didn't care at all, I contacted the Ford complaint department and for months I was talking on the phone and emailing with jamarian tate at Ford and then out of no where she completely abanded me, no response to phone calls or emails, I'm paying 480.00 a month for a car that terrifies myself my husband and our son, it's so bad that we all have major anxiety now, I mean we've had 3 near death experiences in this car, Ford should have gave me a different car due to the recall product liability I mean my motor shutting down and loosing brakes is not good Ford put a temporary fix on my car so it's going to happen again, we are afraid every time we get in the car, we just lost our 5 Year old Grand daughter to a rare brain cancer, and we can't even pick any of the other 8 Grand kids in the car were scared to death every day and ford could care less, they were supposed to have this part months ago and they still don't, and now we Don't trust this car at all. We need help.

The contact owned a 2021 Ford EcoSport. The contact stated that while driving at an undisclosed speed, several unknown warning lights illuminated. The contact managed to pull over to the shoulder of the road and the vehicle experience a loss of automotive power. The contact stated that black smoke was leaking from under the hood and the driver-side door would not unlock or unlatch to open. In addition, the contact stated that she managed to exit through the front passenger side door before the vehicle caught on fire. The contact sustained a bruise and scrapes on her left leg however, did not seek medical attention. The local fire department arrived to extinguish the fire. A police report was filed. The vehicle was towed to a local tow lot, where it was deemed a total loss. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 41,000.

I was exiting the freeway and my engine shut down and was unable to manever the vehicle. Stuck on feeder road, unable to place car in neutral to move car out of the road. Police and passerby have to disconnect transmission in order to move my car out of the road. I had car towed to ford dealership. Ford dealership submitted for recall repair approval twice. Both times denied. Dealership advised car is running but they can not repair anything because Ford will approve repair. When Ford Dealership repair service started to put the car back together they realized bolts were one time use and have to order parts. They have had my car for 5 days and still need to keep it for 3 or 4 more days for the replacement bolts to arrive. My car has not been repaired because Ford won't honor recall because they believe what happened to my car is not recall related. They also stated they don't know why my car lost full power while driving and can't tell me if it will happen again. I do not feel safe driving the car, I feel lucky I was exiting the freeway when it happened, but if I was going full speed on the freeway when I lost power I believe it could have been catastrophic! How can Ford not approve a repair that is a known problem with the vehicle even with the severely of the consequences if the engine fails again. I don't feel safe driving this car, but I don't have a choice because it is the only car I have.