2020 Ford Ecosport

Engine blown while driving on freeway with child. No prior error lights on dash. Mechanic stated due to internal failure of oil belt, which frayed and exploded into engine. Car received all regular required maintenance & was inspected at oil change 60 days ago with no issues reported. Have diagnostic stating manufacturing failure.

On 9/23, the vehicle was traveling on !-94 in SE Michigan when it suddenly lost power. The vehicle had to be towed to a service center. The mechanic stated that the oil pump had failed, causing the engine to completely fail. The car was 3 years old, with 67.000 miles. Oil changes had been performed every 5K miles since the car was purchased. Because we did not purchase the ESP, we are now looking at $8K-$10K to get this fixed - we have no idea what to do. it needs a new engine.

I was driving the vehicle to work and after about 15 minutes of driving it, the low oil pressure light came on and started to lose speed. I was on a highway and had cars behind me and wasn't sure what to do. I attempted to speed up so I could pull over at a gas station, but I was not able to go above 20 mph. I had to quickly pull over to the side of the road. After a few minutes, I attempted to get back on the road to reach a gas station near by, but was not able to get above 15-20 mph. I put my flashers on and attempted to make it to the gas station and finally made it and called a tow truck. I had to call in to work that day. The car was towed to our home and I called our local Ford dealer to make an appt to check it out. I was not able to get a service appt for 3 months! I had tobhave the vehicle towed to the dealership and they told me the oil pump was bad and I would need to have the engine replaced and it would cost me $6,000. It's ridiculous to have a car for 3 years and 64,000 and have to replace the engine!!! This conveniently happened right after the warranty ran up. I had just had the turbocharger replaced and the vacuum pump a couple minutes prior to the low oil pressure issue! No reason this should happen on a 3 year old car that has had the maintenance kept up on it.

The contact owns a 2020 Ford EcoSport. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently decelerated while the accelerator pedal was depressed, and the vehicle lost motive power. The oil pressure warning light and the service warning light illuminated. The vehicle was towed to the dealer where it was diagnosed that the engine had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was provided a case number and informed that the warranty coverage had been exceeded due to the mileage. The failure mileage was approximately 65,000.

The contact owns a 2020 Ford EcoSport. The contact stated that while driving approximately 50 MPH, the oil pressure warning light had illuminated, and the vehicle lost motive power. The vehicle was towed to the local dealer to be diagnosed. The contact was informed that the engine was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was not contacted. The failure mileage was 62,000.

On July 27, 2023 as I was accelerating to enter a busy interstate, my vehicle warning light came on for low oil pressure and went into a limp mode only allowing the vehicle to drive 45MPH. There were no warnings other than this light and message appearing on dash as the vehicle lost power. The 18 wheeler approaching behind my vehicle was able to get in a different lane and not hit me and I pulled onto shoulder until I could exit. I had approximately 87,000 miles on the odometer. I contacted the local dealership to have the vehicle towed for an inspection. When the vehicle was brought in for inspection, the technician seemed to know the precise problem from just the description of events. After they inspected the car, they confirmed that the vehicle’s engine experienced an oil pump failure that would require a new engine. The vehicle has been at dealership since that day awaiting the back ordered engine to arrive so it can be installed. Today is September 25, 2023 and I still have not heard of an estimated date for the back ordered engine from Ford to arrive. The repair is estimated to be $8,300 since it was out of warranty. I have already given a $4,000 deposit to the service department so they could order the engine parts, although the engine isn’t even accessible. I have since rented a car totaling $1050 and just went and purchased a second vehicle so I wouldn’t have to waste more money renting a vehicle.

On December 30, 2022 I was driving my EcoSport when the "low oil pressure" light first came on followed by the "check engine" light. I immediately pulled to the side of the road and called the dealership where my vehicle was just serviced for The Works the week before and spoke to the service advisor. I asked what the problem could be since it was just serviced and he said it sounds like the engine. I had to have my car towed (thank goodness for AAA) to the dealership. The warranty on the powertrain/engine was up at 60K miles and I was at 72,000. I paid out of pocket almost $6300 for the new engine. I have NEVER had to pay for any engine in all the years I have owned and driven any make/model of car. I am very disappointed with how FORD handled this problem.