2020 Ford Ecosport

I replaced the battery on October 31, 2023. Everything seemed fine. While I was driving, the car sounded a bit rough, and there was more vibration. Later that evening, I took my car out and then I got a low oil pressure alert. Turns out that I had an oil pump failure that also led to my engine, needing to be rebuilt. The dealership is attempting to charge me $6400.35 for repairs, which also happen to be on back order until December 14, 2023. I had previously gotten a check engine light alert, and the error code was about the emission system. I replaced the relevant part, and the error code was cleared. Then the check engine light came on again. Sometime later once again, it was the same error code. I replaced the part a second time, and the error code eventually went off. Sometime later, it came back on yet again. I had a mechanic do a smoke test. There was no leak in the emission system. He then reset the code again during this time of trouble, my car would not restart after doing an auto stop after becoming idle. I had to manually restart the car when this happened. Sometime after the smoke test, I drove the car to Colorado and back. A couple of days after I got back, the check engine light turned on again. I also noticed that it was getting kind of hard to start the car. It had difficulty turning over. Late October I went out of town for a few days. After I came back, I had trouble starting the car. It would not turn over at all. On October 31 I replaced the battery. And after that is when the low oil pressure problem started. I am without a car, and I am at the mercy of car rentals. I don’t have any other job except driving for Uber. Of course, this happened after the powertrain warranty expired.

Teenage was driving home from school when the oil pump failed and the engine stalled out cause lost of power to the car and would not start back up she could of been seriously injured if it was not for being right next to a driveway when it happened. This is all over the Internet about how the engine is destroying itself from the inside out. Cannot believe there has not been a recall on this.

Only July 8, 2023 I was driving 75MPH in a 75MPH zone approximately 200 miles from home when I received a warning on my dash "change oil soon." I pressed OK to dismiss the alert. Immediately after my oil pressure light came on, and my check engine light. The car started to sputter and I lost power. On the highway, far from home my children and I suddenly had no power and were in danger. I was scared and had the car towed at my expense to the closest dealership. Here I was told the engine needed to be replaced because of a known issue with the tensioner belt in these engines. My engine was seized. I have been without a car since that date.

Oil pump failure causing entire motor to need to be replaced. Motor failed at 60,400 miles just outside of warranty while going down the interstate at 70 miles an hour. Ford has offered to do nothing with the repair and the engine is on back order for 6 months. This is a know issue already under investigation by the NHSTA and i want to add my case.

I have a 2020 Ford EcoSport that was 3 years old and had 84000 miles on it. As I was driving down the highway I lost all oil pressure and the engine seized up. As I was 47 miles away from home I became stuck in the side of the road upon taking it to a local mechanic they reported the oil pump chain has failed and the entire engine will need to be rebuilt. The car had had all usual repairs and maintenance and regular oil changes

The contact owns a 2020 Ford EcoSport. The contact stated that while driving at an undisclosed speed, the check engine and low oil pressure warning lights illuminated. The vehicle was taken to the dealer. The vehicle was diagnosed with an engine failure. The engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 87,000.

Was driving my vehicle 2020 Ford EcoSport, engine blew due to oil pump being internally belt driven and submersed in oil. It caused the belt to decay and plug my uptake which brings oil to the top of the engine. Paid for a tow to the nearest dealership after my vehicle failed driving 75 on an interstate down a mountain to Phoenix AZ. Lights went off and a low oil pressure light came on and the vehicle and in to limp mode and would not accelerate. It took the dealer a month to figure out and resolve my issue but over 2 months to get my car repaired and back to me. Ford accepted some responsibility and assisted in laying 60% of a $7,000 bill. This happened 2/8/2023. Got my car back end of April 2023 and within in the first month check engine light returned. Brought it to a dealer in Flagstaff AZ and discovered a sensor had gone bad (cam shaft sensor) and I paid over $209 for that to be completed and the previous dealer reinstalled my subframe incorrectly when they replaced the engine. Fast forward to yesterday 10/10/23 and I’m in my car with my new engine with less than 10,000 miles on it. I try to accelerate to highway speeds and check engine light comes on with a “see manual message” and it goes in to limp mode with no way to accelerate. I safely drove it 2 miles to the nearest Ford dealer in Lake Havasu AZ and was informed that my engine was blown once again due to a failed oil pump. I still owe on this car and it’s cost me so much money in repairs and rental cars and I’m going belly up financially because of it: huge safety issue and a terribly flawed engine design. It should never have been sold.

Going 55 mph down a local 2 lane road, I received a low oil pressure warning followed by loud knocking of the engine. I had to stop the car and have it towed home. Car has 76,000 miles on it and the oil level is perfect. Dealership blames oil pump failure, resulting in a new engine. Seems to be a reoccurring issue with the EcoSports