2018 Ford Ecosport

I have had issues in the past with the transmission of this car for the past few months, it initially started to give me issues around 49k miles in this car, so I got it flushed out by a mechanic and it ran fine for a few months. Just a few days ago, I was headed home and my transmission went completely out as I was about to enter a state highway and I had to pull over into a neighborhood to get it towed. I had to send it over to my mechanic again, and he said the transmission is completely done for. My car could've almost went out on me completely if I kept pushing it, but I knew it was a hazard. I've heard from multiple other sources as I checked online to see if this was an issue with other Ecosports as well, and it seems like there's multiple complaints of this issue. I had no idea this car had an issue, at there was no warning light or anything indicating there was something wrong with it, until I noticed the acceleration wasn't quite right.

What component or system failed or malfunctioned, and is it available for inspection upon request? The braking system failed, preventing the vehicle from stopping properly. The vehicle is currently at a tow yard and is available for inspection upon request. How was your safety or the safety of others put at risk? Because the brakes failed, I was unable to stop at a traffic light. The vehicle entered oncoming traffic and was involved in a collision, placing my safety and the safety of other motorists at risk. Has the problem been reproduced or confirmed by a dealer or independent service center? No. I previously took the vehicle to the dealership several times for misfire and powertrain-related issues. The dealership was unable to identify the underlying problem and advised that the spark plugs were not tightened properly. Similar issues have occurred multiple times over the past few years. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The vehicle is currently at a tow yard and is awaiting inspection by the insurance company. Additional inspections may be conducted as part of the claim investigation. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? Yes. Warning lights appeared earlier this week, and I brought the vehicle to the dealership for diagnosis. The dealership was unable to determine the cause of the warnings. I picked up the vehicle on June 11, 2026. On June 12, 2026, the brakes failed, resulting in the accident.

My Ford EcoSport had safety recall 23S64 performed at Diamond Ford in Lancaster, California. The recall involved the oil pump drive belt system. After the recall repair was completed, the vehicle began displaying a low oil pressure warning and the engine started shaking. These symptoms involve the same oil system addressed in the recall. Because the vehicle is now experiencing low oil pressure and engine vibration after the recall repair, I am concerned that the recall remedy did not correct the defect and that engine damage may have occurred as a result of the recalled component.

The affected systems are the engine and powertrain. After completion of Safety Recall 23S64 (NHTSA #23V905) in November 2025, my vehicle began experiencing repeated loss of power, stalling, and reduced-power “limp mode” events. The check engine light illuminated and diagnostic trouble code P0299 (Turbocharger Underboost Condition) was identified. The vehicle remains available for inspection upon request. My safety and the safety of others were put at risk due to sudden loss of engine power while driving, including hesitation and reduced acceleration in traffic. The vehicle has stalled and entered limp mode unexpectedly, creating a risk of being unable to maintain speed or safely merge. The problem has been reproduced and documented through multiple return visits to the same Ford dealership following the recall repair. The dealership attempted repairs including spark plug replacement and battery replacement, which did not resolve the issue. On the most recent visit, the dealership stated the issue was “unable to duplicate” and returned the vehicle without repair, despite prior documented limp mode behavior. The vehicle has been inspected by the manufacturer’s authorized dealership multiple times. Additionally, an independent diagnostic scan confirmed P0299 turbocharger underboost. Warning indicators included the check engine light, reduced engine power, and limp mode behavior, which first appeared after the recall repair was completed. These symptoms have continued despite repeated service visits. Given the vehicle’s history of prior engine failure at approximately 29, 313 miles, and the fact that Recall 23S64 involves oil pump belt failure and oil pressure loss, I am concerned that the recall repair was incomplete or ineffective, potentially allowing residual oil starvation damage affecting the turbocharger and related components.

Three days after I purchased the vehicle from ideal cars, I went to Showlow, Arizona and the car on the hill started spitting and sputtering lost power and shut off and I had to pull over to the side about 20 minutes later. It was able to start again and we went Then a week later I went to Payson, Arizona and my vehicle again lost power on the hill and shut off and I had to pull over to the side and wait for it to start again that’s when I called Ford and the car lot I purchased it from which they don’t want anything to do with me, but Ford told me about the recall and how that’s what my car is going to do or could do but I’m telling you it already did it. It’s already made. The transmission sounds whiny, and clunky, and the motor shifting is not better. This is all after the recall repairs.

I got my engine replaced during the summer of 2024 since the oil drive belt failed in my engine. This was due to the recall. I took my car to Baumann Ford in Genoa. I got my car back in August of 2024 after this occurred in June of 2024. I went 2.5 months without my car. Once I got it back the check engine light has come on several times for various issues pertaining to the engine. In the last couple of months, my car has stalled twice and it has been refusing to start. I took my car to Tuffy's in Perrysburg to get inspected and they said my starter was going out, my transmission is going out and is leaking fluid, and my coolant is leaking too. All of these components were part of the engine that was put into my vehicle in August of 2024. Another issue is that the gas valve that detects vapors causes my check engine light to come on as well. I do not feel that this vehicle is safe to drive. I was told that the recall was to be fixed by the end of the first quarter of 2025. It is now the last quarter of the year and I just was called to get the recall fixed. The first dealership (Baumann Genoa) said they had no time to fix the issue even though they called me to get me scheduled. This has been over a year of stress with this vehicle and I do not feel like this is safe to be on the road. Ford has taken their time fixing this issue and I do not feel like they have taken this recall seriously when it comes to their consumer safety.

The contact owns a 2018 Ford EcoSport. The contact stated that on several occasions while driving at various speeds, the vehicle hesitated and jerked abnormally while the transmission was shifting gear. The vehicle was taken to a dealer to be diagnosed. The contact was informed there were metal shavings found inside the transmission. The contact was informed that the transmission and torque converter needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 83,000.