SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2004 Ford E-550

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →
1Owner complaints

Model-year median: 0

2Recall campaigns

View recall details →

0Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
0
20011
20021
20031
20044
20053
2006
Compare all E-550 years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Engine And Engine Cooling
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

Limited mileage data: 1 of 1 reports include usable mileage. There isn’t enough coverage to show a useful chart.

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Engine And Engine Cooling. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports0 fire reports0 injury reports

Engine And Engine Cooling complaints

1 reports
Clear category filter
38,000 miles · Jan 5, 2007
Engine And Engine Cooling

TL* - THE CONTACT STATED THAT BETWEEN THE TURBO AND THE INNER COOLER, THERE WERE TWO STAINLESS STEEL LINES CONNECTED WITH A FLEXIBLE JOINT AND THE FLEXIBLE JOINT WAS COMING LOOSE. THE CONTACT STATED THAT WHEN IT CAME OFF HE LOST POWER . THE CONTACT STATED THAT VEHICLE PULLED A 5TH WHEEL TRAILER, AND THAT THIS HAS HAPPENED T…

Read full complaint

TL* - THE CONTACT STATED THAT BETWEEN THE TURBO AND THE INNER COOLER, THERE WERE TWO STAINLESS STEEL LINES CONNECTED WITH A FLEXIBLE JOINT AND THE FLEXIBLE JOINT WAS COMING LOOSE. THE CONTACT STATED THAT WHEN IT CAME OFF HE LOST POWER . THE CONTACT STATED THAT VEHICLE PULLED A 5TH WHEEL TRAILER, AND THAT THIS HAS HAPPENED TWICE. THE CONTACT STATED THAT NEITHER THE WEATHER NOR THE ROAD CONDITIONS WERE A FACTOR. THE CONTACT ALSO STATED THAT HE WAS DRIVING 50 MPH. AK THE CONSUMER STATED THE PART WAS REPLACED UNDER WARRANTY/ UPDATED 06/08/07. *JB

NHTSA ODI #10177885

Official recalls

2

04V444000 · Electrical System:wiring

Sep 13, 2004

ON CERTAIN VANS, A DIODE IN THE ANTI-LOCK BRAKING SYSTEM (ABS) MODULE MAY EXPERIENCE AN ELECTRICAL SHORT.

Consequence & remedy

Consequence: THE ELECTRICAL SHORT MAY CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, OR THE MODULE MAY OVERHEAT RESULTING IN A BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS BEING DRIVEN OR UNATTENDED.

Remedy: DEALERS WILL INSTALL A NEW FUSE IN THE ABS CIRCUIT AND INSTALL A HEAT SHIELD OVER THE ABS MODULE. THE RECALL BEGAN ON OCTOBER 15, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. ALSO FORD IS EXTENDING THE LIMITED WARRANTY (FOR A ONE TIME REPLACEMENT) OF THE ABS MODULE FOR A TOTAL OF 10 YEARS OR 150,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. IF YOUR VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL SEPTEMBER 30, 2005.

04V445000 · Engine And Engine Cooling

Sep 13, 2004

ON CERTAIN VANS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO CONTACT THE AIR FILTER ELEMENT DURING CERTAIN DRIVING CONDITIONS THAT CREATE HOT PARTICLES.

Consequence & remedy

Consequence: THESE HOT PARTICLES MAY IGNITE THE AIR FILTER ELEMENT WITH THE POTENTIAL FOR AIR INDUCTION SYSTEM DAMAGE OR UNDERHOOD FIRE.

Remedy: DEALERS WILL INSPECT AND REPLACE THE AIR FILTER ELEMENT. THE RECALL BEGAN SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. ALSO FORD IS EXTENDING THE LIMITED WARRANTY (FOR A ONE TIME REPLACEMENT) OF THE ABS MODULE FOR A TOTAL OF 10 YEARS OR 150,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. IF YOUR VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL SEPTEMBER 30, 2005.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

0

No exact-year investigations in this snapshot.