Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 1 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
1 reports
43,000 miles · Jan 26, 2015
Electrical System
TL*THE CONTACT OWNS A 2003 FORD E-550. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE F…
Read full complaint
TL*THE CONTACT OWNS A 2003 FORD E-550. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS 43,000.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
Consequence & remedy
Consequence: OVERHEATING COULD RESULT IN SMOKE, BURN, OR AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON MARCH 12, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017, 05V388, AND 06V286)
ON CERTAIN VANS, A DIODE IN THE ANTI-LOCK BRAKING SYSTEM (ABS) MODULE MAY EXPERIENCE AN ELECTRICAL SHORT.
Consequence & remedy
Consequence: THE ELECTRICAL SHORT MAY CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, OR THE MODULE MAY OVERHEAT RESULTING IN A BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS BEING DRIVEN OR UNATTENDED.
Remedy: DEALERS WILL INSTALL A NEW FUSE IN THE ABS CIRCUIT AND INSTALL A HEAT SHIELD OVER THE ABS MODULE. THE RECALL BEGAN ON OCTOBER 15, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. ALSO FORD IS EXTENDING THE LIMITED WARRANTY (FOR A ONE TIME REPLACEMENT) OF THE ABS MODULE FOR A TOTAL OF 10 YEARS OR 150,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. IF YOUR VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL SEPTEMBER 30, 2005.
ON CERTAIN VANS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO CONTACT THE AIR FILTER ELEMENT DURING CERTAIN DRIVING CONDITIONS THAT CREATE HOT PARTICLES.
Consequence & remedy
Consequence: THESE HOT PARTICLES MAY IGNITE THE AIR FILTER ELEMENT WITH THE POTENTIAL FOR AIR INDUCTION SYSTEM DAMAGE OR UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND REPLACE THE AIR FILTER ELEMENT. THE RECALL BEGAN SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. ALSO FORD IS EXTENDING THE LIMITED WARRANTY (FOR A ONE TIME REPLACEMENT) OF THE ABS MODULE FOR A TOTAL OF 10 YEARS OR 150,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. IF YOUR VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL SEPTEMBER 30, 2005.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2003 Ford E-550 Problems, Complaints & Recalls | Skip That Year
Illustration