IllustrationWHILE DRIVING AT 45/55 MPH RIGHT FRONT TIRE WENT OUT OF ROUND, AND THE LEFT FRONT TIRE STARTED SHOWING SIGNS OF FATIGUE. WHEN THIS OCCURRED FRONT SHOCKS FAILED, AND THE HYDRAULIC FLUID SPILLED ONTO THE CATALYTIC CONVERTER. THIS RESULTED IN SEVERE FRONTAL VEHICLE DAMAGE. THE MANUFACTURER HAD BEEN NOTIFIED.*AK
1996 Ford E-350
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all E-350 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 10 of 50 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Tires. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports1 fire reports1 injury reports
Tires complaints
17 reportsCONSUMER STATES THAT VALVE STEMS RECOMMENDED FOR VEHICLE IS NOT EFFECTIVE AFTER 8000 MILES. ON SEVERAL OCCASIONS TIRES WOULD BECOME FLAT FOR NO APPARENT REASON. VEHICLE WAS TAKEN TO A REPAIR SHOP, WHO INFORMED CONSUMER OF THE VALVE PROBLEM.*AK
CONSUMER STATES THAT WHILE DRIVING AT 55 MPH TREAD ON THE PASSENGER SIDE REAR SEPARATED FROM THE TIRE. SEVERAL WEEKS LATER THE SAME THING HAPPENED WITH THE FRONT PASSENGER TIRE WHILE DRIVING AT 65 MPH. *AK
CONSUMER'S VEHICLE EXPERIENCED 3 TREAD SEPARATIONS ON FIRESTONE STEEL TEX BRAND. DEALER AND MANUFACTURER HAD BEEN CONTACTED. TS ONE OTHER TIRE SHOWED SIGNS OF TREAD SEPARATION WHICH INCLUDED THE SPARE. ALL TIRES HAD TO BE REPLACED. *TT *JB
3 TIRES ALL SEPERATED AT DIFFERENT TIMES WITHIN A 3 MONTH. BOTH FRONT TIRES AND ONE REAR TIRE. ALL 3 TIRES HAD THE SAME DOT NUMBER. THE OTHER 3 TIRES DID NOT SEPERATE AND HAD A DIFFERENT DOT NUMBER. I STILL HAVE ALL OF THE TIRES. DT
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
TIRES CAME APART& BLEWOUT.*AK (TIRESIZE: 225/75R16R)
ORIGINAL MANUFACTURING EQUIPMENT ON A FORD, E350, 1996. 10,000 MILES ON TIRES. TIRE SIZE LT24575R16. TREAD SEPARATED FROM SIDEWALL OF RIGHT PASSENGER SIDE TIRE. CONSUMER REPLACED TIRE WITH SAME MODEL TIRE THAT HAD DEVELOPED SPLITS IN THE SIDEWALL. *AK *SLC
CONSUMER HAS A 1996, FORD, 350 AND LEFT REAR TIRE TREAD CAME OFF WITHOUT WARNING. TIRE WAS STILL INFLATED. TREAD GOT CAUGHT AND WIPED OUT HEATER AND A/C LINE. CONSUMER WAS WAS TRAVELING 60MPH. DEALER REPLACED TIRE WITH A SPARE. AT THIS TIME VEHICLE HAD 21,000 MILES. *AK RIGHT REAR TIRE ALSO EXPERIENCED TREAD SEPARATION, FIR…
Read full complaint
CONSUMER HAS A 1996, FORD, 350 AND LEFT REAR TIRE TREAD CAME OFF WITHOUT WARNING. TIRE WAS STILL INFLATED. TREAD GOT CAUGHT AND WIPED OUT HEATER AND A/C LINE. CONSUMER WAS WAS TRAVELING 60MPH. DEALER REPLACED TIRE WITH A SPARE. AT THIS TIME VEHICLE HAD 21,000 MILES. *AK RIGHT REAR TIRE ALSO EXPERIENCED TREAD SEPARATION, FIRESTONE TIRES, P225/75R16. *SLC
WHILE DRIVING AT 60 MPH, THE ENTIRE TREAD CAME OF THE RIGHT INSIDE DUAL TIRE, FIRESTONE LT 22575R16, WHICH PUT A HOLE IN THE BOTTOM OF THE MOTORHOME.
Official recalls
309V399000 · Vehicle Speed Control
Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
08V051000 · Vehicle Speed Control:cruise Control
Feb 4, 2008
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
06V286000 · Vehicle Speed Control
Aug 1, 2006
ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
Consequence & remedy
Consequence: OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE02070 · Alleged Brake Hose Failures
Opened Oct 1, 2002 · Closed Jan 9, 2003
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD HAS RECEIVED NO OWNER REPORTS OF FAILURE, OTHER THAN THE FOUR ODI REPORTS THAT CAME FROM A SINGLE FLEET IN NEW YORK STATE.FORD ALSO REPORTS THAT IT HAS RECEIVED NO FIELD REPORTS AND DID NOT IDENTIFY ANY WARRANTY CLAIMS ALLEGING THE SUBJECT PROBLEM.FORD ESTIMATES THAT THE 86,910 SUBJECT VEHICLES (THAT HAVE OVER 6 YEARS EXPOSURE), HAVE ACCUMULATED OVER SIX BILLION MILES OF SERVICE AND THAT THE VIRTUAL LACK OF REPORTS INDICATES THAT THERE IS NO DEFECT TREND.BASED ON FORD'S DATA, A SAFETY RELATED DEFECT TREND DOES NOT APPEAR TO EXIST AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION ON THE SUBJECT VEHICLES IF WARRANTED BY THE CIRCUMSTANCES.ODI WILL CONTINUE TO MONITOR FIELD REPORTS FOR THIS PROBLEM AND TAKE APPROPRIATE ACTION IN THE FUTURE IF INDICATED.