SUBJECT VEHICLE IS A FORD E350 SUPERDUTY VAN CHASSIS MANUFACTURED IN MAY 1996 WITH VN [XXX] EQUIPPED WITH A E40D TRANSMISSION. THE TRANSMISSION IN A 1997 CLASS C MOTORHOME STARTED TO LEAK. THE PROBLEM WAS DETECTED BEFORE COMPLETE FAILURE, WHICH COULD HAVE RESULTED IN A FIRE. VEHICLE HAD TO BE TOWED TO GARAGE. WHEN TRANSMISSI…
Read full complaint
SUBJECT VEHICLE IS A FORD E350 SUPERDUTY VAN CHASSIS MANUFACTURED IN MAY 1996 WITH VN [XXX] EQUIPPED WITH A E40D TRANSMISSION. THE TRANSMISSION IN A 1997 CLASS C MOTORHOME STARTED TO LEAK. THE PROBLEM WAS DETECTED BEFORE COMPLETE FAILURE, WHICH COULD HAVE RESULTED IN A FIRE. VEHICLE HAD TO BE TOWED TO GARAGE. WHEN TRANSMISSION WAS REBUILT A SEAL HAD TO BE REPLACE. THE OEM PART NUMBER WAS E9TP 7AP48 AA. THE SEAL WAS REPLACE WITH A PART FROM PERCISION INTERNATIONAL WITH PART NUMBER 16601EV, WHICH CAME WITH THE FOLLOWING ADVISORY "THE ORIGINAL DESIGN SILICONE RUBBER IS NOT AS COMPATIBLE WITH NEW FORD MERCRON V FLUID. ALSO IT'S NOT ABLE TO HOLD UP TO THE DEMANDS OF HEAVY DUTY TRUCK APPLICATIONS." IF THIS IS IN FACT THE CASES THE AFFECTED VEHICLES SHOULD BE REVIEWED AND IF NECESSARY RECALLED. *LA INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10041552
Mileage unknown · Apr 13, 1999
Power TrainService Brakes, Hydraulic
ONGOING PROBLEM WITH ABS SYSTEM FAILING TO OPERATE PROPERLY WHILE DRIVING. THE ABS SENSOR LIGHT WOULD COME ON. ALSO, TRANSMISSION FAILS SIMULTANEOUSLY/ONE OR MORE WHEELS WOULD LOCK UP, AND BRAKE PADS FAILED AT 8-10,000 MILES. DEALER NOTIFIED. *AK
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
Consequence & remedy
Consequence: OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE02070 · Alleged Brake Hose Failures
Opened Oct 1, 2002 · Closed Jan 9, 2003
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD HAS RECEIVED NO OWNER REPORTS OF FAILURE, OTHER THAN THE FOUR ODI REPORTS THAT CAME FROM A SINGLE FLEET IN NEW YORK STATE.FORD ALSO REPORTS THAT IT HAS RECEIVED NO FIELD REPORTS AND DID NOT IDENTIFY ANY WARRANTY CLAIMS ALLEGING THE SUBJECT PROBLEM.FORD ESTIMATES THAT THE 86,910 SUBJECT VEHICLES (THAT HAVE OVER 6 YEARS EXPOSURE), HAVE ACCUMULATED OVER SIX BILLION MILES OF SERVICE AND THAT THE VIRTUAL LACK OF REPORTS INDICATES THAT THERE IS NO DEFECT TREND.BASED ON FORD'S DATA, A SAFETY RELATED DEFECT TREND DOES NOT APPEAR TO EXIST AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION ON THE SUBJECT VEHICLES IF WARRANTED BY THE CIRCUMSTANCES.ODI WILL CONTINUE TO MONITOR FIELD REPORTS FOR THIS PROBLEM AND TAKE APPROPRIATE ACTION IN THE FUTURE IF INDICATED.
1996 Ford E-350 Problems, Complaints & Recalls | Skip That Year
Illustration