NHTSA owner reports · September 18, 2026 snapshot.
Tires complaints
4 reportsClear category filter151,000 miles · Sep 3, 2005
Tires
WE PURCHASED A SET OF B.F. GOODRICH RADIAL T/A (P21570S15) TIRES FROM SEARS, WHICH WERE COMPLETELY WORN AND CONSIDERED UNDER THE LEGAL LIMITATIONS AFTER ONLY 25,000 MILES OF USE. THE TIRES HAD A 50,000 MILE WARRANTY. WE HAVE HAD THE CAR FULLY MAINTAINED SINCE THE PURCHASE OF THE CAR AND THE TIRES, AND WERE TOLD BY PROFESSIONAL…
Read full complaint
WE PURCHASED A SET OF B.F. GOODRICH RADIAL T/A (P21570S15) TIRES FROM SEARS, WHICH WERE COMPLETELY WORN AND CONSIDERED UNDER THE LEGAL LIMITATIONS AFTER ONLY 25,000 MILES OF USE. THE TIRES HAD A 50,000 MILE WARRANTY. WE HAVE HAD THE CAR FULLY MAINTAINED SINCE THE PURCHASE OF THE CAR AND THE TIRES, AND WERE TOLD BY PROFESSIONALS THAT THEY FELT THE TIRES WERE A MANUFACTURER DEFECT. THEY ALSO TOLD US WE SHOULD REPLACE THE TIRES IMMEDIATELY OR WE COULD BE PUTTING OURSELVES AND OUR CHILD IN DANGER. WE WENT TO SEARS AND THEY REFUSED TO HELP US AND SIMPLY WANTED US TO BUY A WHOLE NEW SET OF TIRES, EVEN AFTER I SHOWED THEM EVERY RECEIPT ON THE MAINTENANCE TO PROVE THIS DID NOT HAPPEN BECAUSE OF NEGLECT ON OUR PART. *JB
NHTSA ODI #10135262
151,000 miles · Sep 2, 2005
Tires
WE PURCHASED A SET OF B.F. GOODRICH P21570S15 TIRES FROM SEARS, WHICH WERE COMPLETELY WORN AND CONSIDERED UNDER THE LEGAL LIMITATIONS AFTER ONLY 25,000 MILES OF USE. THE TIRES HAD A 50,000 MILE WARRANTY. WE HAVE HAD THE CAR FULLY MAINTAINED SINCE THE PURCHASE OF THE CAR AND THE TIRES, AND WERE TOLD BY PROFESSIONALS THAT THEY F…
Read full complaint
WE PURCHASED A SET OF B.F. GOODRICH P21570S15 TIRES FROM SEARS, WHICH WERE COMPLETELY WORN AND CONSIDERED UNDER THE LEGAL LIMITATIONS AFTER ONLY 25,000 MILES OF USE. THE TIRES HAD A 50,000 MILE WARRANTY. WE HAVE HAD THE CAR FULLY MAINTAINED SINCE THE PURCHASE OF THE CAR AND THE TIRES, AND WERE TOLD BY PROFESSIONALS THAT THEY FELT THE TIRES WERE A MANUFACTURER DEFECT. THEY ALSO TOLD US WE SHOULD REPLACE THE TIRES IMMEDIATELY OR WE COULD BE PUTTING OURSELVES AND OUR CHILD IN DANGER. WE WENT TO SEARS AND THEY REFUSED TO HELP US AND SIMPLY WANTED US TO BUY A WHOLE NEW SET OF TIRES, EVEN AFTER I SHOWED THEM EVERY RECEIPT I HAD ON THE MAINTENANCE TO PROVE THIS DID NOT HAPPEN BECAUSE OF NEGLECT ON OUR PART.
NHTSA ODI #10135214
Mileage unknown · Mar 23, 2001
Tires
DEFECTIVE TIRES CAUSED THE FLOORBOARD TO VIBRATE AND THE VEHICLE TO SHIMMY WHILE DRIVING, THE VEHICLE COULD NOT BE DRIVEN OVER 40 MPH, THE CONSUMER PURCHASED A DIFFERENT BRAND OF TIRES NOW THE VIBRATION AND SHIMMY HAS CEASED (MICHELIN P215-60RX15). NLM
NHTSA ODI #560509
Mileage unknown · Jun 29, 1998
Engine And Engine CoolingFuel System, GasolineService Brakes, Hydraulic
CHIEF OF POLICE CALLED TO INFORM OF RECALL NOTICE RECEIVED CONCERNING FORD CROWN VICTORIA LOWER BALL JOINT FAILURE. *AK DOOR HANDLES WERE REPLACED. REAR BRAKE PADS AND ROTORS REPLACED AT 18290, FRONT PADS AND ROTORS WERE REPLACED AT 28679 MILES, FRONT AND REAR BRAKE PADS REPLACED AT 51031 MILES. INTAKE MANIFOLD REPLACED TWIC…
Read full complaint
CHIEF OF POLICE CALLED TO INFORM OF RECALL NOTICE RECEIVED CONCERNING FORD CROWN VICTORIA LOWER BALL JOINT FAILURE. *AK DOOR HANDLES WERE REPLACED. REAR BRAKE PADS AND ROTORS REPLACED AT 18290, FRONT PADS AND ROTORS WERE REPLACED AT 28679 MILES, FRONT AND REAR BRAKE PADS REPLACED AT 51031 MILES. INTAKE MANIFOLD REPLACED TWICE. HEATER HOSE REPLACED. PASSENGER SIDE TAIL LIGHT REPLACED. TIRE ROTATIONS ARE DONE EVERY 3000 MILES, HOWEVER TIRES HAD TO BE REPLACED AT APPROXIMATELY 9600 MILES AND AT 600000 MILES, NO SPECIFIC TIRE INFORMATION GIVEN. COOLING FANT AND MOTOR REPLACED. TPC, PVC, AND FUEL REGULATOR REPLACED. *SLC
NHTSA ODI #824783
Official recalls
9Feb 4, 2008
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Aug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Nov 6, 2003
ON CERTAIN NATURAL GAS VEHICLES, IF A FLAME FROM A VEHICLE INTERIOR FIRE BECOMES LOCALLY DIRECTED AT THE NATURAL GAS FUEL TANK LOCATED IMMEDIATELY BEHIND THE REAR SEAT, THE FLAME COULD DAMAGE THE FIBERGLASS WRAP ON THE TANK WEAKENING THE TANK.
Consequence & remedy
Consequence: IF THE STRENGTH OF THE TANK IS SIGNIFICANTLY COMPROMISED, IT COULD RUPTURE, INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL INSTALL AN INSULATOR BEHIND THE CURRENT SEAT BACK. OWNER NOTIFICATION BEGAN ON JANUARY 7, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Jun 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES USING AFTERMARKET DRIVER'S SEAT BELT ASSEMBLIES THAT WERE SOLD BY FORD PARTS DEPARTMENTS FROM JANUARY 1, THROUGH JUNE 13, 2000. THESE SEAT BELT ASSEMBLIES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE EQUIPMENT INVOLVED IS SERVICE STOCK SEAT BELT ASSEMBLIES, MODEL NOS. H 9977, H 9979, T 9063, AND T 9217, BUILT BY TRW VEHICLE SAFETY SYSTEMS, INC. (TRW) MANUFACTURED FROM JUNE 1, 1998 THROUGH MAY 21, 2000. SOME OF THESE SEAT BELT ASSEMBLIES MAY HAVE BEEN INSTALLED AS SERVICE REPLACEMENT EQUIPMENT ON THE VEHICLES INVOLVED IN THE RECALL.
Consequence & remedy
Consequence: IN THE EVENT OF A COLLISION, THESE SEAT BELTS MAY NOT RESTRAIN AN OCCUPANT INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THE SERVICE SEAT BELT ASSEMBLIES THAT WERE INSTALLED IN THESE VEHICLES FROM JANUARY 1 THROUGH JUNE 13, 2000.
Jun 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES USING AFTERMARKET FRONT PASSENGER SIDE SEAT BELT ASSEMBLIES THAT WERE SOLD BY FORD PARTS DEPARTMENTS FROM JANUARY 1, THROUGH JUNE 13, 2000. THESE SEAT BELT ASSEMBLIES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE EQUIPMENT INVOLVED IS SERVICE STOCK SEAT BELT ASSEMBLIES, MODEL NOS. H 9977, H 9979, T 9063, AND T 9217, BUILT BY TRW VEHICLE SAFETY SYSTEMS, INC. (TRW) MANUFACTURED FROM JUNE 1, 1998 THROUGH MAY 21, 2000. SOME OF THESE SEAT BELT ASSEMBLIES MAY HAVE BEEN INSTALLED AS SERVICE REPLACEMENT EQUIPMENT ON THE VEHICLES INVOLVED IN THE RECALL.
Consequence & remedy
Consequence: IN THE EVENT OF A COLLISION, THESE SEAT BELTS MAY NOT RESTRAIN AN OCCUPANT INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THE SERVICE SEAT BELT ASSEMBLIES THAT WERE INSTALLED IN THESE VEHICLES FROM JANUARY 1 THROUGH JUNE 13, 2000.
Dec 16, 1998
VEHICLE DESCRIPTION: CERTAIN 1996-1999 FORD CROWN VICTORIA POLICE, FLEET, NATURAL GAS, AND 1996-1999 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT WERE PRODUCED WITH A LOWER CONTROL ARM BALL JOINT CONTAINING A ONE PIECE BEARING; AND 1990-1996 FORD CROWN VICTORIA POLICE, FLEET, AND NGV VEHICLES AND 1990-1996 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT HAVE BEEN SERVICED WITH EITHER A BALL JOINT CONTAINING THE ONE-PIECE BEARING OR A FRONT LOWER CONTROL ARM CONTAINING A BALL JOINT WITH A ONE-PIECE BEARING. THE ONE-PIECE BEARING WITHIN THE LOWER CONTROL ARM BALL JOINT CAN WEAKEN SLOWLY DURING USE AND EVENTUALLY CRACK. THIS COULD RESULT IN SEPARATION OF THE BALL AND CAP OF THE JOINT, ALLOWING THE CONTROL ARM TO DROP TO THE GROUND.
Consequence & remedy
Consequence: IF THIS OCCURS WHILE THE VEHICLE IS MOVING, REDUCED STEERING CONTROL COULD OCCUR, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE LOWER CONTROL ARM BALL JOINTS (2).
Mar 4, 1997
VEHICLE DESCRIPTION: POLICE AND TAXI VEHICLES. THE HOOD LATCH STRIKER CAN WEAR OR BECOME DETACHED FROM THE HOOD.
Consequence & remedy
Consequence: EITHER OF THESE CONDITIONS CAN RESULT IN THE HOOD OPENING WITHOUT WARNING WHILE THE VEHICLE IS BEING OPERATED IMPAIRING THE DRIVER'S VISIBILITY.
Remedy: DEALERS WILL INSTALL AN IMPROVED HOOD LATCH STRIKER (VEHICLES WITH 1992 MODEL HOODS) OR REVISED STRIKER PLATE ATTACHING FASTENERS (VEHICLES WITH 1993-1997 MODEL HOODS).
Jul 18, 1996
THE PITMAN ARMS WERE NOT FULLY LUBRICATED AT THE ASSEMBLY PLANT. THE "BALL JOINT" AT THE OUTER END OF THE PITMAN ARM CAN BECOME CONTAMINATED AND CORRODE.
Consequence & remedy
Consequence: SUCH CORROSION CAN RESULT IN ABNORMAL WEAR OF THE JOINT, RESULTING IN SEPARATION OF THE JOINT. LOSS OF STEERING CONTROL CAN OCCUR INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT THE VEHICLES AND IF THE JOINT IS FOUND TO HAVE SIGNIFICANT WEAR, THE ARM WILL BE REPLACED. THOSE PITMAN ARMS NOT REPLACED WILL HAVE THE "BALL JOINT" FULLY GREASED.
Apr 22, 1996
WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
10EA03012 · Rear Brake Line Failure
Opened Jul 25, 2003 · Closed Apr 11, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
IN A LETTER DATED FEBRUARY 25, 2005, FORD MOTOR COMPANY (FORD) NOTIFIED ODI THAT IT WOULD BE CONDUCTING A CUSTOMER SATISFACTION PROGRAM (FORD NO. 04B26) TO CORRECT A REAR BRAKE LINE CHAFING CONCERN IN APPROXIMATELY 44,000 MODEL YEAR (MY) 1997 FORD CROWN VICTORIA AND GRAND MARQUIS NON-FLEET VEHICLES EQUIPPED WITH ELECTRONIC TRACTION CONTROL THAT WEREBUILT AFTER MARCH 19, 1997.THESE VEHICLES HAVE AN ADDITIONAL REAR BRAKE LINE AND A MASTIC PATCH CAUSING REDUCED CLEARANCE FROM A STIFFENING RIB IN THE FLOOR PAN.ODI?S ANALYSIS SHOWED HIGHER COMPLAINT AND WARRANTY RATES RELATED TO REAR BRAKE LINE FAILURES IN THIS POPULATION THAN IN OTHER SUBJECT VEHICLES AND PEER MID-SIZED PASSENGER CARS THAT WERE EVALUATED DURING THE INVESTIGATION.VEHICLES INVOLVED IN FORD?S PROGRAM WILL HAVE THE REAR BRAKE LINES INSPECTED FOR CONTACT WITH THE FLOOR PAN STIFFING RIB.IF THERE IS CONTACT, BUT NO ABRASION OR LEAKAGE, THE BRAKE LINES WILL BE REPOSITIONED.IF THERE IS ABRASION OR A LEAK IS EVIDENT THE BRAKE LINE WILL BE REPAIRED.IF NECESSARY, BOTH OF THE REAR BRAKE LINES WILL BE REPLACED. THOUGH FORD DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE BECAUSE THE INSUFFICIENT CLEARANCE IN THE ROUTING OF THOSE BRAKE LINES MAY RESULT IN LEAKS IN THOSE LINES THAT MAY RESULT IN INCREASED STOPPING DISTANCES.ODI IS DESIGNATING THE CAMPAIGN A SAFETY RECALL (NHTSA RECALL NO. 05V-086).BECAUSE OF THE LOW RATES OF BRAKE LINE FAILURES IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Service Brakes, Hydraulic:fluid
IN A LETTER DATED FEBRUARY 25, 2005, FORD MOTOR COMPANY (FORD) NOTIFIED ODI THAT IT WOULD BE CONDUCTING A CUSTOMER SATISFACTION PROGRAM (FORD NO. 04B26) TO CORRECT A REAR BRAKE LINE CHAFING CONCERN IN APPROXIMATELY 44,000 MODEL YEAR (MY) 1997 FORD CROWN VICTORIA AND GRAND MARQUIS NON-FLEET VEHICLES EQUIPPED WITH ELECTRONIC TRACTION CONTROL THAT WEREBUILT AFTER MARCH 19, 1997.THESE VEHICLES HAVE AN ADDITIONAL REAR BRAKE LINE AND A MASTIC PATCH CAUSING REDUCED CLEARANCE FROM A STIFFENING RIB IN THE FLOOR PAN.ODI?S ANALYSIS SHOWED HIGHER COMPLAINT AND WARRANTY RATES RELATED TO REAR BRAKE LINE FAILURES IN THIS POPULATION THAN IN OTHER SUBJECT VEHICLES AND PEER MID-SIZED PASSENGER CARS THAT WERE EVALUATED DURING THE INVESTIGATION.VEHICLES INVOLVED IN FORD?S PROGRAM WILL HAVE THE REAR BRAKE LINES INSPECTED FOR CONTACT WITH THE FLOOR PAN STIFFING RIB.IF THERE IS CONTACT, BUT NO ABRASION OR LEAKAGE, THE BRAKE LINES WILL BE REPOSITIONED.IF THERE IS ABRASION OR A LEAK IS EVIDENT THE BRAKE LINE WILL BE REPAIRED.IF NECESSARY, BOTH OF THE REAR BRAKE LINES WILL BE REPLACED. THOUGH FORD DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE BECAUSE THE INSUFFICIENT CLEARANCE IN THE ROUTING OF THOSE BRAKE LINES MAY RESULT IN LEAKS IN THOSE LINES THAT MAY RESULT IN INCREASED STOPPING DISTANCES.ODI IS DESIGNATING THE CAMPAIGN A SAFETY RECALL (NHTSA RECALL NO. 05V-086).BECAUSE OF THE LOW RATES OF BRAKE LINE FAILURES IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Service Brakes, Hydraulic
IN A LETTER DATED FEBRUARY 25, 2005, FORD MOTOR COMPANY (FORD) NOTIFIED ODI THAT IT WOULD BE CONDUCTING A CUSTOMER SATISFACTION PROGRAM (FORD NO. 04B26) TO CORRECT A REAR BRAKE LINE CHAFING CONCERN IN APPROXIMATELY 44,000 MODEL YEAR (MY) 1997 FORD CROWN VICTORIA AND GRAND MARQUIS NON-FLEET VEHICLES EQUIPPED WITH ELECTRONIC TRACTION CONTROL THAT WEREBUILT AFTER MARCH 19, 1997.THESE VEHICLES HAVE AN ADDITIONAL REAR BRAKE LINE AND A MASTIC PATCH CAUSING REDUCED CLEARANCE FROM A STIFFENING RIB IN THE FLOOR PAN.ODI?S ANALYSIS SHOWED HIGHER COMPLAINT AND WARRANTY RATES RELATED TO REAR BRAKE LINE FAILURES IN THIS POPULATION THAN IN OTHER SUBJECT VEHICLES AND PEER MID-SIZED PASSENGER CARS THAT WERE EVALUATED DURING THE INVESTIGATION.VEHICLES INVOLVED IN FORD?S PROGRAM WILL HAVE THE REAR BRAKE LINES INSPECTED FOR CONTACT WITH THE FLOOR PAN STIFFING RIB.IF THERE IS CONTACT, BUT NO ABRASION OR LEAKAGE, THE BRAKE LINES WILL BE REPOSITIONED.IF THERE IS ABRASION OR A LEAK IS EVIDENT THE BRAKE LINE WILL BE REPAIRED.IF NECESSARY, BOTH OF THE REAR BRAKE LINES WILL BE REPLACED. THOUGH FORD DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE BECAUSE THE INSUFFICIENT CLEARANCE IN THE ROUTING OF THOSE BRAKE LINES MAY RESULT IN LEAKS IN THOSE LINES THAT MAY RESULT IN INCREASED STOPPING DISTANCES.ODI IS DESIGNATING THE CAMPAIGN A SAFETY RECALL (NHTSA RECALL NO. 05V-086).BECAUSE OF THE LOW RATES OF BRAKE LINE FAILURES IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
IN A LETTER DATED FEBRUARY 25, 2005, FORD MOTOR COMPANY (FORD) NOTIFIED ODI THAT IT WOULD BE CONDUCTING A CUSTOMER SATISFACTION PROGRAM (FORD NO. 04B26) TO CORRECT A REAR BRAKE LINE CHAFING CONCERN IN APPROXIMATELY 44,000 MODEL YEAR (MY) 1997 FORD CROWN VICTORIA AND GRAND MARQUIS NON-FLEET VEHICLES EQUIPPED WITH ELECTRONIC TRACTION CONTROL THAT WEREBUILT AFTER MARCH 19, 1997.THESE VEHICLES HAVE AN ADDITIONAL REAR BRAKE LINE AND A MASTIC PATCH CAUSING REDUCED CLEARANCE FROM A STIFFENING RIB IN THE FLOOR PAN.ODI?S ANALYSIS SHOWED HIGHER COMPLAINT AND WARRANTY RATES RELATED TO REAR BRAKE LINE FAILURES IN THIS POPULATION THAN IN OTHER SUBJECT VEHICLES AND PEER MID-SIZED PASSENGER CARS THAT WERE EVALUATED DURING THE INVESTIGATION.VEHICLES INVOLVED IN FORD?S PROGRAM WILL HAVE THE REAR BRAKE LINES INSPECTED FOR CONTACT WITH THE FLOOR PAN STIFFING RIB.IF THERE IS CONTACT, BUT NO ABRASION OR LEAKAGE, THE BRAKE LINES WILL BE REPOSITIONED.IF THERE IS ABRASION OR A LEAK IS EVIDENT THE BRAKE LINE WILL BE REPAIRED.IF NECESSARY, BOTH OF THE REAR BRAKE LINES WILL BE REPLACED. THOUGH FORD DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE BECAUSE THE INSUFFICIENT CLEARANCE IN THE ROUTING OF THOSE BRAKE LINES MAY RESULT IN LEAKS IN THOSE LINES THAT MAY RESULT IN INCREASED STOPPING DISTANCES.ODI IS DESIGNATING THE CAMPAIGN A SAFETY RECALL (NHTSA RECALL NO. 05V-086).BECAUSE OF THE LOW RATES OF BRAKE LINE FAILURES IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
RQ03004 · Rear Brake Line Failure
Opened Mar 11, 2003 · Closed Jul 25, 2003
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
Additional source detail variants (4)
Service Brakes, Hydraulic:fluid
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
Service Brakes, Hydraulic
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
Service Brakes, Hydraulic:foundation Components
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
EA03001 · Cng Tank Explosion
Opened Jan 27, 2003 · Closed Nov 19, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
IN SEPTEMBER 2002, A FUEL CYLINDER IN A NATURAL GAS POWERED VEHICLE (NGV) EXPLODED DURING A FIRE.FORD AND VRTC TEST ENGINEERS JOINTLY EXAMINED THE INCIDENT VEHICLE AND REVIEWED TESTING TO DETERMINE WHETHER THE PERFORMANCE OF THE PRESSURE RELIEF VALVE (PRD) WAS PROPER.THE PURPOSE OF A PRD IS TO PROTECT A COMPRESSED NATURAL GAS TANK FROM OVERPRESSURE BY ALLOWING THE CNG TO VENT WHEN THE TEMPERATURE REACHES A SPECIFIC POINT.THE PRD WAS REMOVED FROM THE FAILED TANK AND SUBJECTED TO A YIELD TEMPERATURE DETERMINATION TEST. IT WAS CONCLUDED THAT A DIRECT FLAME (FROM THE INTERIOR OF THE VEHICLE) ONTO THE CYLINDER (LOCATED BEHIND THE REAR SEAT IN THE TRUNK)COMPROMISED THE HOOP STRENGTH OF THE NATURAL GAS CYLINDER, THUS ALLOWING THE CYLINDER TO FAIL PRIOR TO THE PRD RELEASING AT ITSDESIGNED TEMPERATURE.AS A RESULT OF THIS TESTING AND REVIEW OF THE INVOLVED VEHICLE, FORD HAS DEVELOPED AN INSULATOR TO INSULATE THE NATURAL GAS FUEL TANK FROM A LOCALLY DIRECTED FLAME PROJECTING FROM THE INTERIOR OF THE VEHICLE.INSULATORS WILL BE INSTALLED BEHIND THE BACK SEAT ON SUBJECT VEHICLES TO PREVENT FUTURE FAILURES OF THIS TYPE. FORD'S ACTION ADDRESSES THE CONCERNS OF ODI.THEREFORE, THIS INVESTIGATION IS CLOSED.
RQ03002 · Ball Joint Separation
Opened Jan 3, 2003 · Closed Jun 3, 2003
Status: closed (inferred from source dates) · Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
PE02071 · Cng Tank Exploding In A Fire
Opened Oct 1, 2002 · Closed Jan 27, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
AN EXPLOSION OF A COMPRESSED NATURAL GAS (CNG) TANK SHOULD NOT BE ABLE TO OCCUR, AS THE TANK IS FITTED WITH A PRESSURE RELIEF DEVICE (PRD). THIS PRD SHOULD RELEASE THE CNG IN THE TANK, PRIOR TO THE PRESSURE REACHING THE TANK BURST PRESSURE.THE PRD DID NOT RELEASE IN THE SUBJECT WISCONSIN POLICE CRUISER EXPLOSION.NHTSA HAS RECOVERED THE PRD VALVE FROM THE TANK THAT EXPLODED AND TESTING WILL BE NECESSARY TO ESTABLISH WHY THIS TANK SAFETY VALVE DID NOT RELEASE IN THE VERY HIGH TEMPERATURE FIRE THAT OCCURRED IN THE POLICE CRUISER.THERE IS ONLY THE SINGLE KNOWN EVENT, BUT DUE TO THE CATASTROPIC FORCE OF SUCH AN EXPLOSION AND THE POTENTIAL FOR INJURY AND LOSS OF LIFE, THIS INVESTIGATION IS BEING UPGRADED.
EA02025 · Speed Control Deactivation Switch Fires
Opened Sep 6, 2002 · Closed Jun 30, 2004
Status: closed (inferred from source dates) · Engine And Engine Cooling
BASED ON THE LOW RATE OF FIRE INCIDENTS (2.5 INCIDENTS PER 100,000 VEHICLES SOLD) WHERE FAILURE OF THE SCDS IS INVOLVED AND THE AGE OF THE VEHICLES ? 7 TO 11 YEARS ? A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
DP02007 · FUEL-FED Fires
Opened Aug 22, 2002 · Closed Dec 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE FARS DATA SHOWS THAT THE RISK OF FIRE FROM IMPACT IN ALL DIRECTIONS IN THE SUBJECT VEHICLES IS THE SAME AS ALL OTHER SEDANS.THE SUBJECT VEHICLES ARE NOT OVER REPRESENTED WITH RESPECT TO THE RISK OF FIRE IN REAL-WORLD HIGH-ENERGY CRASHES.A FURTHER DISCUSSION OF ISSUES RELATED TO POST CRASH FIRES IN THE SUBJECT VEHICLES IS SET OUT IN THE CLOSING REPORT FOR SQ 01-014 AND THAT REPORT IS IN THE DOCKET FOR THIS PETITION.AFTER REVIEWING THE PETITION AND ITS SUPPORTING MATERIALS, AS WELL AS INFORMATION FURNISHED BY FORD AND GM, AND INFORMATION WITHIN THE AGENCY'S POSSESSION FROM PREVIOUS INVESTIGATIONS AND OTHER RELATED ACTIONS,NHTSA HAS CONCLUDED THAT FUTHER INVESTIGATION CONCERNING POST-CRASH FIRES IN THE SUBJECT VEHICLES IS NOT LIKELY TO LEAD TO A DECISION THAT THE VEHICLES CONTAIN A SAFETY DEFECT.
SQ01014 · Post Rear End Collision Fires
Opened Nov 27, 2001 · Closed Oct 3, 2002
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage
There is no summary currently available
PE98045 · Ball Joint Failure
Opened Aug 13, 1998 · Closed Dec 18, 1998
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE98041 · Front Seat Anchor Bolt Failure
Opened Jul 23, 1998 · Closed Sep 29, 1998
Status: closed (inferred from source dates) · Seats
THE DRIVER'S SEAT, OF THE SUBJECT SPLIT-SEAT CONFIGURATION, IS SECURED TO THE VEHICLE FLOOR PAN WITH FOUR BOLTS.A SINGLE BOLT IS LOCATED AT BOTH THE FRONT AND REAR OF EACH OF THE TWO SEAT TRACKS.THESE TRACKS ARE LOCATED ON EACH SIDE OF THE SEAT.IF THE OUTBOARD-FORWARD BOLT FAILS, THE SEAT IS RETAINED BY 3 REMAINING BOLTS.WHEN RETAINED BY 3 BOLTS, THE REARWARD MOVEMENT OF THE LEFT SIDE OF THE SEAT BACK IS LIMITED TO APPROXIMATELY 4 INCHES.THIS WAS DETERMINED BY FORD TESTING AND CONFIRMED BY ODI.THIS MINIMAL MOVEMENT SHOULD NOT CAUSE A DRIVER TO EXPERIENCE DIFFICULTIES CONTROLLING THE VEHICLE.FORD HAS DEVELOPED A KIT TO REPAIR THE SEAT BOLT BOSS, CONSISTING OF A LARGE, 3/16 INCH THICK WASHER, CONTOURED TO FIT INSIDE THE FLOOR PAN SEAT BOLT BOSS REINFORCEMENT.THIS FIX WAS ADDED TO PRODUCTION VEHICLES IN SEPTEMBER, 1997.FORD IS CURRENTLY PREPARTING A TECHNICAL SERVICE BULLETIN, TO BE SENT TO BOTH DEALER AND OPERATORS OF POLICE VEHICLES, ANNOUNCING THE AVAILABILITY OF THE KIT FOR IN-SEVICE REPAIRS.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION ON THESE MODELS IF WARRANTED BY THE CIRCUMSTANCES.
Illustration