CAR KEPT ACCELERATING AFTER I LET OFF. I HAD TO STAND ON THE BRAKES TO MAKE IT STOP. THE FRONT WHEELS LOCKED UP BUT THE CAR KEPT MOVING. USING 250-280 POUNDS OF PRESSURE ON THE BRAKE PEDAL I FINALLY STOPPED WITHOUT INCIDENT. THE INCIDENT CAN BE VIEWED AT YOUTUBE. IT IS TITLED RAM CAM EPISODE 5. IT IS THE LAST PART OF THE VIDEO.…
Read full complaint
CAR KEPT ACCELERATING AFTER I LET OFF. I HAD TO STAND ON THE BRAKES TO MAKE IT STOP. THE FRONT WHEELS LOCKED UP BUT THE CAR KEPT MOVING. USING 250-280 POUNDS OF PRESSURE ON THE BRAKE PEDAL I FINALLY STOPPED WITHOUT INCIDENT. THE INCIDENT CAN BE VIEWED AT YOUTUBE. IT IS TITLED RAM CAM EPISODE 5. IT IS THE LAST PART OF THE VIDEO. *TR
NHTSA ODI #10547143
91,000 miles · Mar 21, 2008
Fuel System, GasolineUnknown Or OtherVehicle Speed Control
TL*THE CONTACT OWNS A 1992 FORD CROWN VICTORIA. THE CONTACT RECEIVED A RECALL NOTICE FOR THE VEHICLE SPEED CONTROL: CRUISE CONTROL. WHILE AT A LOCAL REPAIR SHOP, THE MECHANIC IDENTIFIED ANOTHER FAILURE IN THE FUEL LINE. THE DEALER INFORMED THE CONTACT THAT THEY HAD THE PARTS AVAILABLE AND ADVISED HER TO BRING THE VEHICLE IN F…
Read full complaint
TL*THE CONTACT OWNS A 1992 FORD CROWN VICTORIA. THE CONTACT RECEIVED A RECALL NOTICE FOR THE VEHICLE SPEED CONTROL: CRUISE CONTROL. WHILE AT A LOCAL REPAIR SHOP, THE MECHANIC IDENTIFIED ANOTHER FAILURE IN THE FUEL LINE. THE DEALER INFORMED THE CONTACT THAT THEY HAD THE PARTS AVAILABLE AND ADVISED HER TO BRING THE VEHICLE IN FOR REPAIR. AT THE TIME, SHE COULD NOT DRIVE TO THE DEALER DUE TO THE FUEL LINE FAILURE. THE PURCHASE DATE AND RECALL NUMBER WERE UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 91,000. UPDATED 07/07/08. *LJ WATER LEAKED INSIDE THE VEHICLE. UPDATED*JB
NHTSA ODI #10221967
116,666 miles · Feb 21, 2005
Fuel System, Gasoline
FUEL RETURN LINE FROM ENGINE TO TANK RUSTED THROUGH CAUSING A FUEL LEAK THAT CREATED A FIRE HAZARD.
NHTSA ODI #10111891
11,780 miles · Dec 8, 2004
Fuel System, Gasoline
HIGH PRESSURE FUEL LINE LEAK DUE WHERE IT PASSES (PAIRED WITH THE RETURN LINE - ALSO LEAKING) UNDER THE LEFT REAR FRAME ARCH. LINES WERE WORN THROUGH WHERE THEY CONTACTED FRAME (SHOULD HAVE BEEN SHIELDED OR CLAMPED). REPAIRED (SINCE PART IS ONLY AVAILABLE PAIRED WITH BRAKE LINES FOR$400+ FROM DEALER) USING BULK STEEL TUBE WITH C…
Read full complaint
HIGH PRESSURE FUEL LINE LEAK DUE WHERE IT PASSES (PAIRED WITH THE RETURN LINE - ALSO LEAKING) UNDER THE LEFT REAR FRAME ARCH. LINES WERE WORN THROUGH WHERE THEY CONTACTED FRAME (SHOULD HAVE BEEN SHIELDED OR CLAMPED). REPAIRED (SINCE PART IS ONLY AVAILABLE PAIRED WITH BRAKE LINES FOR$400+ FROM DEALER) USING BULK STEEL TUBE WITH COMPRESSION FITTINGS. *JB
NHTSA ODI #10102390
197,060 miles · May 8, 2003
Fuel System, Gasoline
THE FUEL PUMP FAILED BECAUSE THE WIRING RUBBED AGAINST THE SENDING UNIT AND BLEW THE FUSE. *JB
NHTSA ODI #10019446
Mileage unknown · Mar 27, 2003
Fuel System, Gasoline
THE CONSUMER IS CONCERNED BECAUSE THE NATION WIDE RECALL TO PROVIDE SHIELDS AROUND CROWN VICTORIA FUEL TANK DOES NOT INCLUDE CIVILIAN VEHICLES, ONLY POLICE VEHICLES. *NLM *NLM
NHTSA ODI #10011892
Mileage unknown · Jun 26, 2002
Fuel System, GasolineFire
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #763504
Mileage unknown · Apr 12, 2002
Fuel System, Gasoline
CONSUMER STATED FORD KNOWS THERE IS A PROBLEM WITH THE FUEL TANK, AND IS VERY DISTURBED BECAUSE THERE IS NO RECALL. *AK *TT
NHTSA ODI #8007463
Mileage unknown · Aug 28, 2000
Fuel System, Gasoline
THE FUEL PUMP OUTLET TUBE/LINE ON THE FUEL PUMP RUSTED CAUSING GAS LEAKAGE. *MJS
NHTSA ODI #554038
Mileage unknown · Jul 15, 1999
Fuel System, Gasoline
AT 25,000 MILES THE FUEL LINE THAT TO GOES TO GAS TANK AND CARBURETOR RUPTURED, CAUSING FUEL LEAKAGE. CAUSE UNKNOWN. *AK *ML
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SPEED CONTROL DEACTIVATION SWITCH CAN DEVELOP A RESISTIVE SHORT IN THE ELECTRICAL CIRCUIT THAT COULD POTENTIALLY RESULT IN AN UNDERHOOD FIRE. A FIRE IS POSSIBLE BOTH WHEN THE VEHICLE IS RUNNING AND WHEN THE VEHICLE ENGINE IS OFF. ALSO, THE SHORT COULD DISABLE THE SPEED CONTROL SYSTEM OR CAUSE THE BRAKE LIGHT FUSE TO OPEN.
Consequence & remedy
Consequence: A FIRE CAN ORIGINATE IN THE LEFT FRONT UNDERHOOD AREA.
Remedy: DEALERS WILL INSTALL A NEW SPEED CONTROL DEACTIVATION SWITCH AND CONNECTOR SHELL. OWNER NOTIFICATION BEGAN MAY 20, 1999.
VEHICLE DESCRIPTION: CERTAIN 1996-1999 FORD CROWN VICTORIA POLICE, FLEET, NATURAL GAS, AND 1996-1999 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT WERE PRODUCED WITH A LOWER CONTROL ARM BALL JOINT CONTAINING A ONE PIECE BEARING; AND 1990-1996 FORD CROWN VICTORIA POLICE, FLEET, AND NGV VEHICLES AND 1990-1996 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT HAVE BEEN SERVICED WITH EITHER A BALL JOINT CONTAINING THE ONE-PIECE BEARING OR A FRONT LOWER CONTROL ARM CONTAINING A BALL JOINT WITH A ONE-PIECE BEARING. THE ONE-PIECE BEARING WITHIN THE LOWER CONTROL ARM BALL JOINT CAN WEAKEN SLOWLY DURING USE AND EVENTUALLY CRACK. THIS COULD RESULT IN SEPARATION OF THE BALL AND CAP OF THE JOINT, ALLOWING THE CONTROL ARM TO DROP TO THE GROUND.
Consequence & remedy
Consequence: IF THIS OCCURS WHILE THE VEHICLE IS MOVING, REDUCED STEERING CONTROL COULD OCCUR, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE LOWER CONTROL ARM BALL JOINTS (2).
VEHICLE DESCRIPTION: POLICE AND TAXI VEHICLES. THE HOOD LATCH STRIKER CAN WEAR OR BECOME DETACHED FROM THE HOOD.
Consequence & remedy
Consequence: EITHER OF THESE CONDITIONS CAN RESULT IN THE HOOD OPENING WITHOUT WARNING WHILE THE VEHICLE IS BEING OPERATED IMPAIRING THE DRIVER'S VISIBILITY.
Remedy: DEALERS WILL INSTALL AN IMPROVED HOOD LATCH STRIKER (VEHICLES WITH 1992 MODEL HOODS) OR REVISED STRIKER PLATE ATTACHING FASTENERS (VEHICLES WITH 1993-1997 MODEL HOODS).
AN UNUSED POWER SEAT HARNESS CONNECTOR IS POSITIONED ON THE RUBBER FLOOR MAT UNDER THE SEAT. IF THE VEHICLE IS OPERATED IN COLD WEATHER IN AREAS THAT HAVE LARGE AMOUNTS OF SALT USED FOR SNOW AND ICE CONTROL, A PUDDLE OF SALTWATER CAN ACCUMULATE ON THE RUBBER FLOOR MATS, REPEATEDLY WETTING THE CONNECTOR. THIS WILL RESULT IN CORROSION OF THE CONNECTOR, CAUSING A CURRENT TO FLOW BETWEEN THE TERMINALS WITHOUT TRIPPING THE CIRCUIT BREAKER.
Consequence & remedy
Consequence: IF THIS OCCURS, CURRENT FLOW CAN HEAT THE CONNECTOR ANDRELEASE FUMES INTO THE PASSENGER COMPARTMENT, AND CAN RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL REMOVE THE UNUSED CONNECTOR AND INSTALL A SEALED HEAT SHRINK CAP OVER THE AFFECTED WIRES.
INCORRECT INSTRUMENT PANEL WIRING ASSEMBLIES IN SOME VEHICLES WILL NOT ACTUATE THE "ANTI-LOCK" BRAKE WARNING LIGHTS.
Consequence & remedy
Consequence: THE VEHICLES DO NOT MEET THE SPECIFICATIONS OF FMVSS 105.THE DRIVER WOULD NOT BE AWARE WHEN THE ANTI-LOCK BRAKE SYSTEM IS MALFUNCTIONING.
Remedy: MODIFY THE WIRE ASSEMBLY TO ALLOW ACTUATION OF THE ANTI-LOCK BRAKE WARNING LIGHTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
10
EA02025 · Speed Control Deactivation Switch Fires
Opened Sep 6, 2002 · Closed Jun 30, 2004
Status: closed (inferred from source dates) · Engine And Engine Cooling
BASED ON THE LOW RATE OF FIRE INCIDENTS (2.5 INCIDENTS PER 100,000 VEHICLES SOLD) WHERE FAILURE OF THE SCDS IS INVOLVED AND THE AGE OF THE VEHICLES ? 7 TO 11 YEARS ? A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
DP02007 · FUEL-FED Fires
Opened Aug 22, 2002 · Closed Dec 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE FARS DATA SHOWS THAT THE RISK OF FIRE FROM IMPACT IN ALL DIRECTIONS IN THE SUBJECT VEHICLES IS THE SAME AS ALL OTHER SEDANS.THE SUBJECT VEHICLES ARE NOT OVER REPRESENTED WITH RESPECT TO THE RISK OF FIRE IN REAL-WORLD HIGH-ENERGY CRASHES.A FURTHER DISCUSSION OF ISSUES RELATED TO POST CRASH FIRES IN THE SUBJECT VEHICLES IS SET OUT IN THE CLOSING REPORT FOR SQ 01-014 AND THAT REPORT IS IN THE DOCKET FOR THIS PETITION.AFTER REVIEWING THE PETITION AND ITS SUPPORTING MATERIALS, AS WELL AS INFORMATION FURNISHED BY FORD AND GM, AND INFORMATION WITHIN THE AGENCY'S POSSESSION FROM PREVIOUS INVESTIGATIONS AND OTHER RELATED ACTIONS,NHTSA HAS CONCLUDED THAT FUTHER INVESTIGATION CONCERNING POST-CRASH FIRES IN THE SUBJECT VEHICLES IS NOT LIKELY TO LEAD TO A DECISION THAT THE VEHICLES CONTAIN A SAFETY DEFECT.
SQ01014 · Post Rear End Collision Fires
Opened Nov 27, 2001 · Closed Oct 3, 2002
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage
There is no summary currently available
RQ01002 · Engine Compartment Fires
Opened Sep 20, 2001 · Closed Sep 6, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA95011 · Undercarriage Fuel Line Interference
Opened Mar 29, 1995 · Closed Jan 30, 1997
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE94077 · Fuel Line Interference
Opened Nov 4, 1994 · Closed Mar 29, 1995
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE94073 · Brake Line Punctures
Opened Oct 4, 1994 · Closed Dec 28, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
EA94022 · Steering Power Assist Fail
Opened Jun 30, 1994 · Closed Mar 2, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE94032 · Steering Power Assist Failure
Opened Apr 8, 1994 · Closed Jun 30, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93086 · Hood FLY-UP While Driving
Opened Oct 1, 1993 · Closed Feb 28, 1994
Status: closed (inferred from source dates) · Structure
There is no summary currently available
1992 Ford Crown Victoria Problems, Complaints & Recalls | Skip That Year
Illustration