Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 55 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Air Bags. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports5 fire reports6 injury reports
What owners actually said
55 reports
2,000 miles · Sep 9, 2017
Tires
YOUR SELECTION OPTIONS DO NOT HAVE THE YEAR OF THE CAR, MAKE, MODEL, TIRE SIZE OR TIRE MODEL SO I FILLED SOMETHING IN TO ALLOW ME TO GO FURTHER ON YOUR OPTIONS RIGHT REAR TIRE WENT FLAT ON MY 1938 STUDEBAKER STATE COMMANDER. I WAS DOING APPROXIMATELY 35-40 MILES PER HOUR. I DID NOT HIT ANY POT HOLES OR GET A PUNCTURE. THE INSIDE…
Read full complaint
YOUR SELECTION OPTIONS DO NOT HAVE THE YEAR OF THE CAR, MAKE, MODEL, TIRE SIZE OR TIRE MODEL SO I FILLED SOMETHING IN TO ALLOW ME TO GO FURTHER ON YOUR OPTIONS RIGHT REAR TIRE WENT FLAT ON MY 1938 STUDEBAKER STATE COMMANDER. I WAS DOING APPROXIMATELY 35-40 MILES PER HOUR. I DID NOT HIT ANY POT HOLES OR GET A PUNCTURE. THE INSIDE CORD SEPARATED FROM THE REST OF THE TIRE AND SHREDDED THE INNER TUBE. I CONTACTED THE TIRE MANUFACTURER, MCCREARY TIRE & RUBBER BUT HAVE HAD NO RESPONSE FROM THEM. THIS IS A GENERAL TIRE BRAND AND THE JET AIR MODEL. THE TIRE NUMBER IS CYWMC4D82211. THE TIRE SIZE IS 6.00 X 16. I REALIZE THE TIRE IS SIX YEARS OLD BUT IT ONLY HAS 2000 MILES ON IT AND I AM WORRIED THE OTHER TIRES ON THE CAR CAN HAVE THE SAME PROBLEM HAPPEN TOO THEM. I JUST WANT TO KNOW IF THIS IS A DEFECT ON A SINGLE TIRE OR IS THIS A MFG RUN PROBLEM? THREE POLICE OFFICERS PULLED UP BEHIND ME PUT ON THERE SAFETY LIGHTS AND THEN CHANGED THE TIRE FOR ME. I'M A 71 YEAR OLD DISABLED VET.
NHTSA ODI #11022487
100,000 miles · Oct 20, 2006
Vehicle Speed Control
DT*: THE CONTACT STATED WHILE AT A STOP, THE GEARSHIFT WAS SHIFTED INTO DRIVE AND THE VEHICLE ACCELERATED OUT OF CONTROL, BOUNCED OVER A HIGH CURB, AND WAS FISHTAILING. THE CONTACT ESTIMATED THE SPEED TO HAVE REACHED 70 MPH BEFORE THE IGNITION WAS TURNED OFF. THE VEHICLE WAS TOWED TO THE SERVICE DEALER, WHO DETERMINED THAT THE…
Read full complaint
DT*: THE CONTACT STATED WHILE AT A STOP, THE GEARSHIFT WAS SHIFTED INTO DRIVE AND THE VEHICLE ACCELERATED OUT OF CONTROL, BOUNCED OVER A HIGH CURB, AND WAS FISHTAILING. THE CONTACT ESTIMATED THE SPEED TO HAVE REACHED 70 MPH BEFORE THE IGNITION WAS TURNED OFF. THE VEHICLE WAS TOWED TO THE SERVICE DEALER, WHO DETERMINED THAT THE THROTTLE PEDAL HAD SEIZED. THE MANUFACTURER WAS NOTIFIED. UPDATED 12/5/2006 - *NM
NHTSA ODI #10171453
89,000 miles · Dec 2, 2003
Engine And Engine CoolingPower Train
WHEN THE VEHICLE WAS IDLING THE CONSUMER SMELLED A HEAVY SCENT OF OIL BURNING. WHILE DRIVING AT 65 MPH, THE ENGINE BEGAN REVVING AT A HIGH RATE. ALSO, THE TRANSMISSION GEARS WOULD NOT GO INTO THIRD OR FOURTH GEAR. THE VEHICLE WAS TAKEN TO THE DEALER, WHO INFORMED THE CONSUMER THAT THE BUSHING WAS MADE OF PLASTIC. HOWEVER, …
Read full complaint
WHEN THE VEHICLE WAS IDLING THE CONSUMER SMELLED A HEAVY SCENT OF OIL BURNING. WHILE DRIVING AT 65 MPH, THE ENGINE BEGAN REVVING AT A HIGH RATE. ALSO, THE TRANSMISSION GEARS WOULD NOT GO INTO THIRD OR FOURTH GEAR. THE VEHICLE WAS TAKEN TO THE DEALER, WHO INFORMED THE CONSUMER THAT THE BUSHING WAS MADE OF PLASTIC. HOWEVER, THE BUSHING SHOULD BE MADE FROM METAL. THE MANUFACTURER HAD BEEN INFORMED. *AK WHEN THE CABLE LINKAGE WAS DISCONNECTED, THE DESTRUCTION OF THE CLUTCH WOULD OCCUR. (LOCKING UP THE HIGHER TWO GEARS, WITHOUT THE LOCK UP ONLY THE FIRST AND SECOND GEAR WOULD WORK) *SCC *JB
NHTSA ODI #10046325
Mileage unknown · Feb 12, 2003
Tires
THE CONSUMER NOTICED AN INDENTION IN THE SIDEWALL OF THE SPARE TIRE. THE SPARE TIRE WAS DAMAGED ON THE BRACKET THAT HOLDS THE JACK POLE. *SCC *JB
NHTSA ODI #10006165
Mileage unknown · May 3, 2002
Electrical SystemFire
ALTERNATOR PLUG SHORTED OUT AND CAUSED A HIGH POTENTIONAL OVERLOAD THAT CAUGHT THE ALTERNATOR ON FIRE. THE SHORT DID NOT TRIP ANY FUSE IN VEHICLE. FIRE WAS VERY INTENSE. THE FIRE QUICKLY SPREAD TO ADJACENT COMPONENT AND MELTED PLUG WIRES, WIRE HARNESSES. FIRE ALSO DAMAGED HOOD AND RIGHT FRONT FENDER. THE FIRE WAS QUICKLY SPREADI…
Read full complaint
ALTERNATOR PLUG SHORTED OUT AND CAUSED A HIGH POTENTIONAL OVERLOAD THAT CAUGHT THE ALTERNATOR ON FIRE. THE SHORT DID NOT TRIP ANY FUSE IN VEHICLE. FIRE WAS VERY INTENSE. THE FIRE QUICKLY SPREAD TO ADJACENT COMPONENT AND MELTED PLUG WIRES, WIRE HARNESSES. FIRE ALSO DAMAGED HOOD AND RIGHT FRONT FENDER. THE FIRE WAS QUICKLY SPREADING WHEN HELP ARRIVED TO EXTINGUISH THE FIRE. AND YET NO FUSE EVER TRIPPED TO ENGINE ELECTRICAL TO STOP SHORT!
NHTSA ODI #761507
Mileage unknown · Jan 31, 2002
Electrical System
WHILE DRIVING AROUND CORNERS OR SLOWING DOWN VEHICLE WOULD STALL, DEALER CONTACTED AND INFORMED CONSUMER THAT OWNERS PROBLEM WAS CAUSED BY A MALFUNCTIONED IGNITION.*AK *SLC
NHTSA ODI #8003299
Mileage unknown · Jan 11, 2002
Engine And Engine Cooling
WHEN MAKING A TURN IN EITHER DIRECTION VEHICLE INTERMITTENTLY STALLS. DEALER HAS REPLACED IDLE SENSOR, HAS NOT REMEDIED THE PROBLEM.*AK
NHTSA ODI #8002020
Mileage unknown · Dec 21, 2001
Electrical SystemFire
VEHICLE HAD NOT BEEN DRIVEN IN DAYS, IT CAUGHT ON FIRE AND BURNED TO THE GROUND, CAUSE OF FIRE NOT DETERMINED YET. *AK CONSUMER STATED THAT FORD ENGINEER TOLD HIM THAT FAULTY COMPONENTS WOULD CAUSE A FIRE. *YD
NHTSA ODI #8001026
Mileage unknown · Oct 9, 2001
Air BagsEngine And Engine Cooling
CAR HAS STARTED TO STALL REPEATEDLY AT IDLE OR NEAR IDLE SPEEDS BUT NOT CONSISTANTLY, OTHERWISE RUNS FINE. AIRBAG LIGHT ALSO BLINKS ON AND OFF 9 TIMES STOPS AND RE STARTS BLINKS CONSISTANTLY, WORKS?*AK
NHTSA ODI #753024
Mileage unknown · Apr 27, 2001
Engine And Engine Cooling
WHILE DRIVING 30-40 MPH VEHICLE COMPLETELY SHUTDOWN WITHOUT WARNING, CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS. *AK
VEHICLE DESCRIPTION: CERTAIN 1996-1999 FORD CROWN VICTORIA POLICE, FLEET, NATURAL GAS, AND 1996-1999 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT WERE PRODUCED WITH A LOWER CONTROL ARM BALL JOINT CONTAINING A ONE PIECE BEARING; AND 1990-1996 FORD CROWN VICTORIA POLICE, FLEET, AND NGV VEHICLES AND 1990-1996 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT HAVE BEEN SERVICED WITH EITHER A BALL JOINT CONTAINING THE ONE-PIECE BEARING OR A FRONT LOWER CONTROL ARM CONTAINING A BALL JOINT WITH A ONE-PIECE BEARING. THE ONE-PIECE BEARING WITHIN THE LOWER CONTROL ARM BALL JOINT CAN WEAKEN SLOWLY DURING USE AND EVENTUALLY CRACK. THIS COULD RESULT IN SEPARATION OF THE BALL AND CAP OF THE JOINT, ALLOWING THE CONTROL ARM TO DROP TO THE GROUND.
Consequence & remedy
Consequence: IF THIS OCCURS WHILE THE VEHICLE IS MOVING, REDUCED STEERING CONTROL COULD OCCUR, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE LOWER CONTROL ARM BALL JOINTS (2).
THE REAR BRAKE LINES HAVE INADEQUATE CLEARANCE BETWEEN THE BRAKE TUBE AND THE VEHICLE UNDERBODY IN THE AREA OF THE LEFT REAR WHEEL OPENING.
Consequence & remedy
Consequence: INADEQUATE CLEARANCE CAN CAUSE ABRASION OF THE BRAKE LINEAND A LEAK CAN DEVELOP, RESULTING IN LOSS OF BRAKE FLUID TO THE REAR BRAKESYSTEM AND INCREASED STOPPING DISTANCES.
Remedy: REPAIR ANY BRAKE LINES THAT HAVE AN INDICATION OF CONTACT OR HAVE THE POTENTIAL FOR CONTACT WITH THE BODY OF THE VEHICLE. RELOCATE LINES, IF NECESSARY.
THE PARK ROD ASSEMBLY CONTAINS A PARK CAM WITH INADEQUATE SURFACE HARDNESS, WHICH COULD LEAD TO PARK DISENGAGEMENT OR NO PARK ENGAGEMENT WHEN THE LEVER IS PLACED IN PARK.
Consequence & remedy
Consequence: IF PARK IS NOT ENGAGED AND THE PARKING BRAKE IS OFF, AVEHICLE ROLL-AWAY COULD RESULT.
Remedy: REPLACE PARK ROD ASSEMBLY ON AUTOMATIC TRANSMISSIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA92002 · Brake Line Punctures
Opened Jan 15, 1992 · Closed May 21, 1992
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE91125 · Brake Line Punctures
Opened Sep 11, 1991 · Closed Jan 15, 1992
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
1991 Ford Crown Victoria Problems, Complaints & Recalls | Skip That Year
Illustration