SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2013 Ford C-MAX Hybrid

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →
120Owner complaints

Model-year median: 17

2Recall campaigns

View recall details →

3Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
120
201317
20150
2016
Compare all C-MAX Hybrid years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Electrical System
49Engine
17Power Train
15Steering
15Structure
13
All reported categories
Latches/locks/linkages
11Unknown Or Other
8Service Brakes
7Air Bags
6Fuel/propulsion System
5Electronic Stability Control (esc)
4Exterior Lighting
4Seat Belts
4Vehicle Speed Control
4Back Over Prevention
2Equipment
2Suspension
2Engine And Engine Cooling
1Fuel System, Gasoline
1Hybrid Propulsion System
1Seats
1Tires
1Visibility
1Visibility/wiper
1Wheels
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

101 reports with mileage · 19 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Power Train. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

5 crash reports0 fire reports4 injury reports

What owners actually said

120 reports
107,000 miles · Mar 13, 2026
Hybrid Propulsion System

The contact owns a 2013 Ford C-Max Hybrid. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The message "Stop Safely Now'" was displayed on the screen. The contact was able to pull to the side of the road. However, no cause for the…

Read full complaint

The contact owns a 2013 Ford C-Max Hybrid. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The message "Stop Safely Now'" was displayed on the screen. The contact was able to pull to the side of the road. However, no cause for the failure was found. The vehicle was not repaired. The contact stated that on a separate occasion, while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The vehicle was taken to the dealer; however, no cause for the failure was found. The failure persisted. The vehicle failed to accelerate as intended while depressing the accelerator pedal, and the vehicle stalled. The message "Stop Safely Now'" was displayed on the screen. The contact was able to coast to the side of the road. After waiting for several minutes, the contact was able to restart the vehicle. The vehicle functioned as intended. The vehicle was towed to the dealer; however, no cause for the failure was found. The contact stated that the failure first occurred three years ago, and the dealer diagnosed that it as a battery failure. The contact was unsure if the battery was replaced. The manufacturer was notified of the failure but offered no assistance. The failure mileage was approximately 107,000.

NHTSA ODI #11724213

36,463 miles · Feb 23, 2026
Electrical System

The contact owns a 2013 Ford C-Max Hybrid. The contact stated that on several occasions, while the vehicle was parked, it failed to start. The vehicle was jump-started on several occasions but needed to be towed occasionally. The vehicle was taken to an independent mechanic, where it was diagnosed with battery failure. The cont…

Read full complaint

The contact owns a 2013 Ford C-Max Hybrid. The contact stated that on several occasions, while the vehicle was parked, it failed to start. The vehicle was jump-started on several occasions but needed to be towed occasionally. The vehicle was taken to an independent mechanic, where it was diagnosed with battery failure. The contact was informed that the battery needed to be replaced. The battery was replaced; however, the failure reoccurred. The vehicle was then taken to the dealer, but was not diagnosed. The dealer suggested that a waiver be signed for the battery replacement. The vehicle was repaired. The contact stated that the vehicle had experienced electrical failures. The instrument panel intermittently malfunctioned, and the turn signals failed to operate properly. The manufacturer was made aware of the failure. The approximate failure mileage was 36,463.

NHTSA ODI #11719818

230,000 miles · Oct 22, 2025
Back Over Prevention

The contact owns a 2013 Ford C-Max Hybrid. The contact stated that while in reverse, the rearview camera failed to display a rearview image, potentially compromising the back over prevention system. The vehicle returned to normal functionality, but the failure became a regular occurrence. The rearview camera warning light was il…

Read full complaint

The contact owns a 2013 Ford C-Max Hybrid. The contact stated that while in reverse, the rearview camera failed to display a rearview image, potentially compromising the back over prevention system. The vehicle returned to normal functionality, but the failure became a regular occurrence. The rearview camera warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V695000 (Back Over Prevention), but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 230,000.

NHTSA ODI #11695114

90,000 miles · Aug 1, 2025
Electrical SystemStructure

The contact owns a 2013 Ford C-Max Hybrid. The contact stated while driving approximately 15-20 MPH, the steering wheel was wobbly. The contact exited the highway immediately and was able to pull over to the side of the roadway. The contact then pulled into a parking lot and the vehicle was towed to the dealer, where it was diag…

Read full complaint

The contact owns a 2013 Ford C-Max Hybrid. The contact stated while driving approximately 15-20 MPH, the steering wheel was wobbly. The contact exited the highway immediately and was able to pull over to the side of the roadway. The contact then pulled into a parking lot and the vehicle was towed to the dealer, where it was diagnosed that the rear subframe was rusted, causing the control arms to separate. The dealer determined that the rear subframe and connecting parts needed to be replaced. Additionally, the dealer informed the contact that a high voltage wire was chewed on by rodents. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 90,000.

NHTSA ODI #11677787

70,000 miles · Dec 10, 2024
Electrical SystemEngine

The contact owns a 2013 Ford C-Max Hybrid. The contact stated while driving on three occasions at approximately 30-55 MPH, several unknown warning lights were flashing. The message to shift to park(P) was flashing. The vehicle was shifted to park, and the vehicle stalled and failed to restart. The contact's husband assisted with…

Read full complaint

The contact owns a 2013 Ford C-Max Hybrid. The contact stated while driving on three occasions at approximately 30-55 MPH, several unknown warning lights were flashing. The message to shift to park(P) was flashing. The vehicle was shifted to park, and the vehicle stalled and failed to restart. The contact's husband assisted with restarting the vehicle. The contact determined that the battery was working as designed. The vehicle was taken to the local dealer for five weeks, where it was diagnosed that the battery junction box had corrosion and defective fuses. Additionally, there was a failing control unit. The dealer informed the contact a Ford engineer was advising with the repairs. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was approximately 70,000.

NHTSA ODI #11629946

180,000 miles · Nov 12, 2024
Power Train

The contact's wife owns a 2013 Ford C-Max Hybrid. The contact stated while driving at various speeds, the vehicle hesitated while depressing the accelerator pedal. The contact stated there was an abnormal hissing and crackling sound coming from the vehicle. There was no warning light illuminated. The vehicle was taken to a deale…

Read full complaint

The contact's wife owns a 2013 Ford C-Max Hybrid. The contact stated while driving at various speeds, the vehicle hesitated while depressing the accelerator pedal. The contact stated there was an abnormal hissing and crackling sound coming from the vehicle. There was no warning light illuminated. The vehicle was taken to a dealer where it was diagnosed with a defective transmission. The vehicle was not repaired. The manufacturer was notified of the failure and was informed that there were no recalls or warranties on the vehicle. The vehicle remained in the possession of the dealer. The failure mileage was approximately 180,000.

NHTSA ODI #11624737

80,000 miles · Oct 9, 2024
Electrical SystemLatches/locks/linkagesStructure

The contact owns a 2013 Ford C-Max Hybrid. The contact stated that upon exiting the vehicle, the driver’s side doors failed to latch closed. The contact also stated that while driving at an undisclosed speed and attempting to get another driver’s attention, he became aware that the horn was not functioning as needed. The vehicle…

Read full complaint

The contact owns a 2013 Ford C-Max Hybrid. The contact stated that upon exiting the vehicle, the driver’s side doors failed to latch closed. The contact also stated that while driving at an undisclosed speed and attempting to get another driver’s attention, he became aware that the horn was not functioning as needed. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Action Number: RQ19005 (Latches/Locks/Linkages, Structure); but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 80,000. The VIN was not available.

NHTSA ODI #11618860

160,000 miles · Sep 19, 2024
Structure

The contact owns a 2013 Ford C-Max Hybrid. The contact stated while driving 35 MPH, the hatchback ajar message was displayed. The contact attempted to raise the liftgate; however, the liftgate failed to raise up. The vehicle was taken to the dealer but was not diagnosed or repaired. The contact stated that the failure persisted.…

Read full complaint

The contact owns a 2013 Ford C-Max Hybrid. The contact stated while driving 35 MPH, the hatchback ajar message was displayed. The contact attempted to raise the liftgate; however, the liftgate failed to raise up. The vehicle was taken to the dealer but was not diagnosed or repaired. The contact stated that the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 160,000.

NHTSA ODI #11615448

Mileage unknown · Aug 1, 2022
Power Train

The contact owns a 2013 Ford C-MAX Hybrid. The contact received notification of NHTSA Campaign Number: 22V413000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The vehicle was able to restart after severa…

Read full complaint

The contact owns a 2013 Ford C-MAX Hybrid. The contact received notification of NHTSA Campaign Number: 22V413000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The vehicle was able to restart after several attempts. Additionally, the vehicle remained on after the contact had pushed the Auto Start/Stop button to turn off the vehicle. The contact was able to turn off the vehicle after pushing the Auto Start/Stop button numerous times. The dealer and Five Star Ford Stone Mountain (3800 US-78, Snellville, GA 30039) were made aware of the failure but confirmed that parts were not yet available. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown. VIN tool confirms parts not available.

NHTSA ODI #11476859

Mileage unknown · Jul 26, 2022
Latches/locks/linkagesPower Train

The contact owns a 2013 Ford C-Max Hybrid. The contact received notification of NHTSA Campaign Number: 22V413000 (Power Train) and 20V331000 (Latches, Locks, and Linkages) however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall rep…

Read full complaint

The contact owns a 2013 Ford C-Max Hybrid. The contact received notification of NHTSA Campaign Number: 22V413000 (Power Train) and 20V331000 (Latches, Locks, and Linkages) however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue. The contact had experienced a transmission failure and the vehicle was towed to the dealer. Parts distribution disconnect.

NHTSA ODI #11476016

Official recalls

2

13V303000 · Structure

Jul 10, 2013

Ford Motor Company is recalling certain model year 2013 C-Max hybrid vehicles, without panoramic roofs, that were manufactured January 19, 2012, through June 25, 2013. During vehicle testing, the vehicle exceeded a head injury criteria requirement set by the standard. Thus, these vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 201, "Occupant Protection in Interior Impact."

Consequence & remedy

Consequence: In the event of a crash, an occupant could be at an increased risk of an injury.

Remedy: Ford will notify owners, and dealers will install energy absorbers between the headliner and the roof. The recall began on August 5, 2013. Owners may contact the Ford customer relationship center at 1-866-436-7332. Ford's recall number is 13C02.

13V085000 · Latches/locks/linkages

Mar 7, 2013

Ford is recalling certain model year 2013 Focus and C-Max vehicles built from November 16, 2012, through November 21, 2012; and model year 2013 Escape vehicles manufactured from November 14, 2012, through November 21, 2012. The left rear door child lock was built incorrectly. As a result, the child lock may not engage when the operator uses normal force to activate the child lock.

Consequence & remedy

Consequence: The operator may incorrectly believe the child lock is engaged. However, the door may be opened from the inside, increasing the risk of injury to an unrestrained child.

Remedy: Ford will notify owners, and dealers will inspect the affected rear door latches, and replace them as necessary, free of charge. The recall began on March 27, 2013. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

RQ19005 · Door Latch Failures

Opened Dec 19, 2019 · Closed Feb 7, 2022

Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:doors:latch; Structure:body; Structure:body:door

In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD

Additional source detail variants (8)

Latches/locks/linkages:doors:latch

In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD

Latches/locks/linkages:doors:latch

In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD

Latches/locks/linkages

In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD

Latches/locks/linkages

In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD

Structure:body:door

In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD

Structure:body:door

In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD

Structure:body

In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD

Structure:body

In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD

PE16001 · Door Latch Failure

Opened Jan 16, 2016 · Closed Oct 29, 2016

Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:doors:latch

In January, the Office of Defects Investigation (ODI) opened this Preliminary Evaluation based on consumers' allegations of doors failing to latch and/or inadvertently opening on model year (MY) 2012-2013 Ford Focus vehicles (subject vehicles).ODI has received 464 unique reports related to the alleged problem, with over 200 claiming that the door(s) opened inadvertently while the vehicle was in motion.One consumer alleged an injury that occurred while driving when a door inadvertently opened and then closed on a child's arm.Another alleged that a door that inadvertently opened struck a parked vehicle.In response to ODI's information request, Ford Motor Company (Ford) provided 500 unique reports related to the alleged problem on the subject vehicles.Ford reported no injury or accident claims.Ford also submitted 1,513 warranty claims related to door latch failures.Many customers indicated that the affected door could not be latched at all and some of them decided to restrain the door by other means in order to operate the vehicle.Some customers also reported door latch failures occurring on multiple doors and at different times.Additionally, Ford stated that MY 2014-2015 Ford Focus, 2013-2015 Ford Escape, 2013-2015 Ford C-Max, 2014-2016 Ford Transit Connect, 2015 Ford Mustang, and 2015 Lincoln MKC, all use the same door latch as the 2012-2013 Ford Focus.On September 6, 2016, Ford notified ODI that it would conduct a safety recall (16V-643) to remedy the door latches in the MY 2012-2015 Ford Focus and other Ford models mentioned above (total of approximately 2 million vehicles).According to Ford, a component within the door latch may break preventing the door from latching.Ford dealers will replace all four door latches in the recalled vehicles with a new more robust latch design that is currently in production.The recall action initiated by the manufacturer appears to address the safety risks.Accordingly, this investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Latches/locks/linkages:doors:latch

In January, the Office of Defects Investigation (ODI) opened this Preliminary Evaluation based on consumers' allegations of doors failing to latch and/or inadvertently opening on model year (MY) 2012-2013 Ford Focus vehicles (subject vehicles).ODI has received 464 unique reports related to the alleged problem, with over 200 claiming that the door(s) opened inadvertently while the vehicle was in motion.One consumer alleged an injury that occurred while driving when a door inadvertently opened and then closed on a child's arm.Another alleged that a door that inadvertently opened struck a parked vehicle.In response to ODI's information request, Ford Motor Company (Ford) provided 500 unique reports related to the alleged problem on the subject vehicles.Ford reported no injury or accident claims.Ford also submitted 1,513 warranty claims related to door latch failures.Many customers indicated that the affected door could not be latched at all and some of them decided to restrain the door by other means in order to operate the vehicle.Some customers also reported door latch failures occurring on multiple doors and at different times.Additionally, Ford stated that MY 2014-2015 Ford Focus, 2013-2015 Ford Escape, 2013-2015 Ford C-Max, 2014-2016 Ford Transit Connect, 2015 Ford Mustang, and 2015 Lincoln MKC, all use the same door latch as the 2012-2013 Ford Focus.On September 6, 2016, Ford notified ODI that it would conduct a safety recall (16V-643) to remedy the door latches in the MY 2012-2015 Ford Focus and other Ford models mentioned above (total of approximately 2 million vehicles).According to Ford, a component within the door latch may break preventing the door from latching.Ford dealers will replace all four door latches in the recalled vehicles with a new more robust latch design that is currently in production.The recall action initiated by the manufacturer appears to address the safety risks.Accordingly, this investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Latches/locks/linkages

In January, the Office of Defects Investigation (ODI) opened this Preliminary Evaluation based on consumers' allegations of doors failing to latch and/or inadvertently opening on model year (MY) 2012-2013 Ford Focus vehicles (subject vehicles).ODI has received 464 unique reports related to the alleged problem, with over 200 claiming that the door(s) opened inadvertently while the vehicle was in motion.One consumer alleged an injury that occurred while driving when a door inadvertently opened and then closed on a child's arm.Another alleged that a door that inadvertently opened struck a parked vehicle.In response to ODI's information request, Ford Motor Company (Ford) provided 500 unique reports related to the alleged problem on the subject vehicles.Ford reported no injury or accident claims.Ford also submitted 1,513 warranty claims related to door latch failures.Many customers indicated that the affected door could not be latched at all and some of them decided to restrain the door by other means in order to operate the vehicle.Some customers also reported door latch failures occurring on multiple doors and at different times.Additionally, Ford stated that MY 2014-2015 Ford Focus, 2013-2015 Ford Escape, 2013-2015 Ford C-Max, 2014-2016 Ford Transit Connect, 2015 Ford Mustang, and 2015 Lincoln MKC, all use the same door latch as the 2012-2013 Ford Focus.On September 6, 2016, Ford notified ODI that it would conduct a safety recall (16V-643) to remedy the door latches in the MY 2012-2015 Ford Focus and other Ford models mentioned above (total of approximately 2 million vehicles).According to Ford, a component within the door latch may break preventing the door from latching.Ford dealers will replace all four door latches in the recalled vehicles with a new more robust latch design that is currently in production.The recall action initiated by the manufacturer appears to address the safety risks.Accordingly, this investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.