NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
19 reportsClear category filterMileage unknown · Mar 11, 2024
EnginePower Train
I have a 2023 Ford bronco that has the 2.3 L engine and seven speed manual transmission. It was originally purchased in January 2023. I live in Colorado so it is cold and on cold mornings, since I have received delivery of the vehicle, It has made and continues to make a grinding, scraping sound when the vehicle is in neutral, o…
Read full complaint
I have a 2023 Ford bronco that has the 2.3 L engine and seven speed manual transmission. It was originally purchased in January 2023. I live in Colorado so it is cold and on cold mornings, since I have received delivery of the vehicle, It has made and continues to make a grinding, scraping sound when the vehicle is in neutral, or the transmission is not engaged. The grinding, scraping sound will occur when driving in first, second, and third gear. If the weather is warm, as over last summer, it does not make the grinding, scraping sound. It has been consistently documented amongst other owners of this particular vehicle, the new sixth generation Ford bronco full-size vehicle with the 2.3 L engine and seven speed manual transmission , that these transmissions make this grinding, scraping sound. I have had it investigated by my local Ford dealership on two separate occasions, and although the tech on site at the dealership states that he can hear the grinding sound and agrees that it is an abnormal sound for a vehicle transmission to make, the Ford motor company has refused to do any type of repair or modification, or replacement of the transmission in my particular vehicle to correct the problem. However, when discussing this problem with other Ford bronco owners, Ford motor company’s response has been very irregular, one friend, in particular, has had his transmission replaced. I am very concerned that as transmissions tend to suffer with wear and tear, that should this transmission fail early due to the grinding, scraping sound, ford motor company will not replace it under warranty, stating that it was my fault or expected wear and tear, that the transmission failed early, when, in reality, it is just as likely that the early failure would be due to this abnormal, grinding, scraping sound.
NHTSA ODI #11576611
Mileage unknown · Mar 8, 2024
EngineFuel/propulsion System
While driving the vehicle began to misfire and became unsafe to drive. It was towed to the local dealer where error codes confirmed that cylinder 4 had misfired. Ford was unable to duplicate the issue nor where they able to find any issues that would have caused the misfire after trouble shooting.
NHTSA ODI #11576255
Mileage unknown · Feb 7, 2024
Engine
I was driving uphill in a neighborhood going about 15 mph when my Bronco suddenly lost power. I was not able to restart and had to manually restart the truck using the fob to ignition method. It started back up, but a terrible sulfur smell was coming from the vehicle. I brought it into our nearest Ford dealership and they cla…
Read full complaint
I was driving uphill in a neighborhood going about 15 mph when my Bronco suddenly lost power. I was not able to restart and had to manually restart the truck using the fob to ignition method. It started back up, but a terrible sulfur smell was coming from the vehicle. I brought it into our nearest Ford dealership and they claimed there was nothing they could do because no code was reported from the truck. I continued to drive it for another day and the check engine light came on. My Ford Pass relayed a message claiming that the issue was the catalytic converter. I took it to my Ford dealership who claims this could take months to fix because the parts are on back order. My 2023 Ford Bronco, 2.7 liter V6 had less than 6k miles.
NHTSA ODI #11570685
Mileage unknown · Nov 22, 2023
Engine
Engine service light came on indicating reduced power/power failure. Called Ford dealership and they said to bring it in asap. After diagnosis the Ford dealership said there was a problem with the wastegate. The dealership has no eta on when the part will be available.
NHTSA ODI #11556516
12,000 miles · Oct 18, 2023
Electrical SystemEngine
The contact owns a 2023 Ford Bronco. The contact stated that while driving at 70 MPH and attempting to brake, the brake pedal traveled all the way to the floorboard and all the lights had flashed on the instrument panel. The contact stated that after restarting the vehicle the entire dashboard shook uncontrollably. Several unkno…
Read full complaint
The contact owns a 2023 Ford Bronco. The contact stated that while driving at 70 MPH and attempting to brake, the brake pedal traveled all the way to the floorboard and all the lights had flashed on the instrument panel. The contact stated that after restarting the vehicle the entire dashboard shook uncontrollably. Several unknown warning lights were illuminated. The vehicle was towed to a dealer to be diagnosed. The contact was informed that the failure was due to a faulty cam phaser. The vehicle had not been repaired. The manufacturer was made aware of the failure and determined that the VIN was not included in a recall. The failure mileage was approximately 12,000
NHTSA ODI #11550696
1,100 miles · Oct 5, 2023
Engine
The contact owns a 2023 Ford Bronco. The contact stated while driving 65 MPH, the power train and service engine soon had warning lights illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was informed that there was bad gasoline in the vehicle, and gasoline needed to be drained from the fuel tank. The …
Read full complaint
The contact owns a 2023 Ford Bronco. The contact stated while driving 65 MPH, the power train and service engine soon had warning lights illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was informed that there was bad gasoline in the vehicle, and gasoline needed to be drained from the fuel tank. The fuel tank was drained and refilled; however, the failure recurred. The vehicle was taken to another dealer and diagnosed with a faulty turbocharger. The contact was informed that the turbocharger needed to be replaced. The vehicle was repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 1,100.
NHTSA ODI #11548505
Mileage unknown · Jun 2, 2023
Engine
My engine in 2023 Ford Bronco with approximately 2900 miles failed in lunch time traffic. The dealership is saying they have to order me a new engine. This is borderline criminal.
NHTSA ODI #11525138
Mileage unknown · May 8, 2023
EnginePower TrainSuspension
We have had two major issues with this new Vehicle. It has less 1,872 miles on it and it is only about 2 months old. Within a week of owning it, the stabilizer bar went out and render the vehicle un drive able. We have a second issue that is even larger safety issue. The Vehicle is now dying and leaving you stranded on the …
Read full complaint
We have had two major issues with this new Vehicle. It has less 1,872 miles on it and it is only about 2 months old. Within a week of owning it, the stabilizer bar went out and render the vehicle un drive able. We have a second issue that is even larger safety issue. The Vehicle is now dying and leaving you stranded on the side of the road. We have now had this happened to us three times on separate occasions. Once was on a trip back from Oklahoma to Dallas and the highway is under repair/construction and there are miles that there are only two lanes with no shoulder or exit to get off in case of auto problems. We found ourself at night that our Bronco lost total power and would not start back up. The vehicle has some kind of timer that will allow you to attempt to start it so many times in a period and then disable the ability to crank the engine. It gives you an error of "Cranking Time Exceeded" So where ever you are "Stuck on the highway in traffic, off the road on in your driveway, you will not be able to attempt to restart your motor if you exceed this time limit. This is a very dangerous issue and I feel many people could lose their life if they are in an situation where they can not attempt to start their motor and try to move to a safer location if the engin can be restarted.
NHTSA ODI #11521052
Mileage unknown · Apr 23, 2023
Engine
While at a stop with vehicle running, the vehicle sputters and stalls when trying to accelerate/start moving. This has happened multiple times when stopped at an intersection and creating a safety hazard for the occupants of the vehicle. Multiple attempts to restart it have to be made and it eventually gets going again but this …
Read full complaint
While at a stop with vehicle running, the vehicle sputters and stalls when trying to accelerate/start moving. This has happened multiple times when stopped at an intersection and creating a safety hazard for the occupants of the vehicle. Multiple attempts to restart it have to be made and it eventually gets going again but this is very dangerous to be stalled at a busy intersection. Vehicle is going into the dealer to be checked out this week. The only message we have seen is "Manual Restart Required" on the instrument panel.
NHTSA ODI #11518527
Official recalls
18Jul 20, 2026
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco and Bronco Raptor vehicles. The engine compartment wiring harness may become damaged and short circuit.
Consequence & remedy
Consequence: A short circuit in the engine compartment can create heat or spark, increasing the risk of a fire.
Remedy: Dealers will install sheathing over the wiring, free of charge. This is a Phased campaign. Phase 1 will include 2026 Bronco Raptor notified owners on 7/31/2026. Phase 2 will include 2021-2025 Bronco Raptor vehicle will notify owners on or about 8/14/2026. Phase 3 will include 2021-2026 Bronco will notify owners on or about 9/1/2026. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S55. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 23, 2026.
Additional source detail variants (2)
Engine
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco and Bronco Raptor vehicles. The engine compartment wiring harness may become damaged and short circuit.
Consequence: A short circuit in the engine compartment can create heat or spark, increasing the risk of a fire.
Remedy: Dealers will install sheathing over the wiring, free of charge. This is a Phased campaign. Phase 1 will include 2026 Bronco Raptor notified owners on 7/31/2026. Phase 2 will include 2021-2025 Bronco Raptor vehicle will notify owners on or about 8/14/2026. Phase 3 will include 2021-2026 Bronco will notify owners on or about 9/1/2026. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S55. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 23, 2026.
Electrical System:wiring:front Underhood
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco and Bronco Raptor vehicles. The engine compartment wiring harness may become damaged and short circuit.
Consequence: A short circuit in the engine compartment can create heat or spark, increasing the risk of a fire.
Remedy: Dealers will install sheathing over the wiring, free of charge. This is a Phased campaign. Phase 1 will include 2026 Bronco Raptor notified owners on 7/31/2026. Phase 2 will include 2021-2025 Bronco Raptor vehicle will notify owners on or about 8/14/2026. Phase 3 will include 2021-2026 Bronco will notify owners on or about 9/1/2026. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S55. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 23, 2026.
Jun 24, 2026
Ford Motor Company (Ford) is recalling certain 2022-2026 Bronco vehicles. The fender flares may not be properly secured and detach from the vehicle.
Consequence & remedy
Consequence: A detached fender flare can become a road hazard and increase the risk of a crash.
Remedy: Dealers will inspect and repair, or replace the fender flares as necessary, free of charge. Owner notification letters were mailed September 1, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S47. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning August 7, 2026.
Apr 14, 2026
Ford Motor Company (Ford) is recalling certain 2021-2025 Bronco vehicles. The transmission to transfer case joint may be misaligned due to an incorrectly performed previous repair, which could lead to wear of the transmission output shaft splines and transfer case input splines.
Consequence & remedy
Consequence: Excessive wear of the transmission and transfer case splines may result in a loss of drive power or vehicle rollaway, increasing the risk of a crash.
Remedy: Dealers will inspect the transmission to transfer case joint and replace the transmission and transfer case as necessary, free of charge. Owner notification letters were mailed July 9, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S26. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 15, 2026.
Mar 3, 2026
Ford Motor Company (Ford) is recalling certain 2021-2026 Ford Bronco and 2021-2024 Ford Edge vehicles. The Accessory Protocol Interface Module (APIM) may overheat and shutdown, which can prevent the rearview camera image from displaying as intended.
Consequence & remedy
Consequence: A rearview camera that fails to display an image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: The APIM software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed April 13, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S09. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.
Oct 23, 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco vehicles. The front seats may have a loose or dislodged seat frame height-adjust pivot bolt.
Consequence & remedy
Consequence: A seat with a dislodged bolt may not properly restrain an occupant in a crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace the pivot links and bolts as necessary, free of charge. Owner notification letters were mailed April 28, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB5. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning October 28, 2025.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Jul 7, 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.
May 14, 2025
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco vehicles. The 360-degree view camera may not display a rearview image when the vehicle is placed in reverse.
Consequence & remedy
Consequence: Loss of the rearview camera image can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed October 8, 2025. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 23S48. This recall expands previous recall number 23V-598.
May 9, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.
Consequence & remedy
Consequence: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.
Jan 17, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco vehicles. The rear shock absorbers may corrode and fail, resulting in detachment of the external reservoir.
Consequence & remedy
Consequence: An external reservoir that detaches from a vehicle can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will replace the rear shock absorbers, as necessary free of charge. Owner notification letters were mailed August 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S01.
Mar 8, 2024
Ford Motor Company (Ford) is recalling certain 2023-2024 Bronco 4-door vehicles. The left-side rear door may be opened from the inside of the vehicle when the child safety lock is in the "ON" position.
Consequence & remedy
Consequence: A malfunctioning child safety lock that allows a rear door to be opened unintentionally can increase the risk of injury.
Remedy: Dealers will inspect the child safety locks and replace the rear door latch, as necessary, free of charge. Owner notification letters were mailed April 9, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S15.
Feb 23, 2024
Ford Motor Company (Ford) is recalling certain 2023-2024 Bronco and Bronco Heritage vehicles. The rear quarter glass panels may have been improperly installed to the vehicle hard top, which can allow them to detach.
Consequence & remedy
Consequence: Detached rear glass panels may create a road hazard and increase the risk of a crash.
Remedy: Dealers will inspect and reinstall the rear glass panels on Bronco vehicles. On Bronco Heritage vehicles, dealers will replace the rear left-hand removable quarter glass panel. Repairs will be performed free of charge. Bronco owner notification letters were mailed June 6, 2024. Bronco Heritage owner letters were mailed June 12, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S10.
Aug 3, 2023
Ford Motor Company (Ford) is recalling certain 2023 Bronco vehicles. The transmission park system may have been damaged during assembly, which can prevent the parking pawl from fully engaging and result in a vehicle rollaway.
Consequence & remedy
Consequence: A vehicle rollaway can increase the risk of a crash.
Remedy: Dealers will replace the transmission, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S44.
May 26, 2023
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco, 2023 Super Duty F-250, and 2019-2023 Ranger vehicles. The Tire and Loading Information (TREAD) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An overloaded vehicle increases the risk of a crash.
Remedy: Ford will mail a new TREAD label to install over the existing label, free of charge. Owners will also have the option to take their vehicle to a Ford or Lincoln dealer to have the new label installed, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C18.
May 18, 2023
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco vehicles built with the 5-Door body style. The first-row seat belt latch plates may be difficult to access from their stowed position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Difficulty accessing the seat belt latches may result in occupants not wearing their seat belts, increasing the risk of injury in a crash.
Remedy: Dealers will add a sliding clip latch stop to the driver and front passenger seat belts, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed July 14, 2023. Owner letters informing owners that parts are available were mailed on October 2, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C16.
Apr 20, 2023
Ford Motor Company (Ford) is recalling certain 2023 Bronco and Ranger vehicles. The lug nuts on the driver's side wheels may have been improperly tightened.
Consequence & remedy
Consequence: Loose lug nuts may result in wheel detachment while driving, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicles until the remedy is completed. Dealers will inspect, and if necessary, retighten the lug nuts, free of charge. Owner notification letters were mailed May 2, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S17.
Mar 8, 2023
Ford Motor Company (Ford) is recalling certain 2023 Bronco Wildtrak and 2022 Bronco Raptor vehicles. Internal damage to the steering gear may require increased steering effort or cause the steering wheel to lock-up.
Consequence & remedy
Consequence: A steering wheel that locks-up can result in a complete loss of steering control, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. Dealers will replace the steering gear, free of charge. Owner notification letters were mailed March 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S09.
Feb 10, 2023
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150, Mustang, Explorer, Bronco, and 2023 Lincoln Aviator vehicles equipped with automatic transmissions. The transmission may contain a loose bolt which could prevent the transmission from engaging the park gear, although the gear shifter position may indicate that the vehicle has been shifted to "PARK."
Consequence & remedy
Consequence: The inability to secure the vehicle in the park position can result in a rollaway, increasing the risk of a crash or injury.
Remedy: Dealers will inspect and, if necessary, replace the transmissions, free of charge. Owner notification letters were mailed April 25, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S06.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration