NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
19 reportsClear category filterMileage unknown · May 4, 2026
EngineFuel/propulsion SystemFire
My husband was sitting at a stop light when he noticed what appeared to be steam/smoke coming out from under the hood of the Bronco. Then smoke came into the vehicle through the air vents. When he looked up, flames were coming out from under the hood. He got out and the whole front of the car burst into flames and torched the ca…
Read full complaint
My husband was sitting at a stop light when he noticed what appeared to be steam/smoke coming out from under the hood of the Bronco. Then smoke came into the vehicle through the air vents. When he looked up, flames were coming out from under the hood. He got out and the whole front of the car burst into flames and torched the car.
NHTSA ODI #11735666
Mileage unknown · Apr 25, 2026
Engine
Going 80 on the fwy. It stared shaking, engine light came on. Immediately go off the fwy as soon as I stopped it died and wouldn’t start.
NHTSA ODI #11733715
Mileage unknown · Mar 5, 2026
Electrical SystemEngineFuel/propulsion System
The vehicle experienced recurring electrical system failures beginning in December 2023. The vehicle intermittently would not start and on several occasions lost power unexpectedly. The vehicle was taken multiple times to an authorized Ford dealership for diagnosis while still under the manufacturer warranty. The dealership rep…
Read full complaint
The vehicle experienced recurring electrical system failures beginning in December 2023. The vehicle intermittently would not start and on several occasions lost power unexpectedly. The vehicle was taken multiple times to an authorized Ford dealership for diagnosis while still under the manufacturer warranty. The dealership repeatedly reported that no issue could be identified despite the recurring electrical malfunction. The vehicle battery was replaced more than once within three years, however the underlying electrical issue persisted. In August 2025 the dealership instructed that the vehicle remain at the service center for extended diagnosis. The vehicle remained at the dealership for more than 40 consecutive days before being returned on October 8, 2025. Because the vehicle intermittently fails to start and has experienced electrical system malfunction, this creates a potential safety risk if the vehicle stalls or loses power while operating in traffic. Additionally, the vehicle currently has two outstanding manufacturer safety recalls that remain unresolved after nearly three years of ownership. This complaint is being submitted because the defect remains unresolved despite multiple repair attempts while the vehicle was under the manufacturer warranty.
NHTSA ODI #11722270
Mileage unknown · Dec 17, 2025
Engine
Check engine light stayed on, constant. Code run showed cylinder 4 misfire. Bronco still under warranty so took to dealership. Mechanic said coolant was inside cylinder so he requested recommended remedy from Ford and would probably be engine replacement.
NHTSA ODI #11705547
Mileage unknown · Jun 2, 2025
Engine
Engine began to leak air in intake where this is a faulty problem in the previous two models years and is an active recall on them also, 23 Ford Bronco, began to misfire causing to have to get engine replaced
NHTSA ODI #11664312
Mileage unknown · Nov 18, 2024
Engine
My engine has had a knocking problem since 3000 miles. Everytime I take it to Ford they agreed it has a knock but won't fix the problem stating it's normal and some engine knock more than others. The engine knocks at low rpm when stepping on the accelerator then smooths out about 1500 to 2000 rpm. One mechanic said it's an issue…
Read full complaint
My engine has had a knocking problem since 3000 miles. Everytime I take it to Ford they agreed it has a knock but won't fix the problem stating it's normal and some engine knock more than others. The engine knocks at low rpm when stepping on the accelerator then smooths out about 1500 to 2000 rpm. One mechanic said it's an issue but they won't fix it unless it has a catastrophic failure this is unacceptable to me as they just want the vehicle to fall out of warranty when the engine finally gives way and doesn't turn on anymore. There are multiple Ford vehicles that have this issue and Ford does not seem to look into it and fix it please investigate the issues with knocking on all the Ford vehicles with the EcoBoost engines.
NHTSA ODI #11626073
Mileage unknown · Nov 18, 2024
Engine
My vehicle has the 2.7L V6 Ecoboost engine. This engine apparently has a design defect that results in repeated cam phaser failure. My engine recently had cam phaser failure and I had them replaced. A week later I was driving at speed on a highway when my engine completely died. I had to pull to the side of the road and could no…
Read full complaint
My vehicle has the 2.7L V6 Ecoboost engine. This engine apparently has a design defect that results in repeated cam phaser failure. My engine recently had cam phaser failure and I had them replaced. A week later I was driving at speed on a highway when my engine completely died. I had to pull to the side of the road and could not restart my engine. I ended up being towed to a dealership and am awaiting diagnosis.
NHTSA ODI #11625971
Mileage unknown · Oct 9, 2024
EngineWheels
We installed new tires and wheels on our vehicle and it immediately started having engine problems and the check engine light comes on. We took it to the dealer and after several days back and forth Ford told the deal that it's a known problem with the 2.3L version of the Ford Bronco however they had no fix and no timeline to fi…
Read full complaint
We installed new tires and wheels on our vehicle and it immediately started having engine problems and the check engine light comes on. We took it to the dealer and after several days back and forth Ford told the deal that it's a known problem with the 2.3L version of the Ford Bronco however they had no fix and no timeline to fix the problem. This creates a safety hazard as the engine program can't be updated and could cause damage to the engine and cause it to fail. The dealer then stated that they could not return the vehicle to us with the new tires and wheels we purchased and we had to put our old tires and wheels on. We counted on the old tires for a spare since we already blew one tire out. So in addition to a safety hazard we are currently out $2,500 we spent on new tires and wheels, and now have to purchase another tire of the exact same original size to have a spare, costing us another $300.
NHTSA ODI #11618945
Mileage unknown · Jun 2, 2024
EngineService BrakesVehicle Speed Control
When driving or breaking at slower speeds, the car feels as if the transmission is “slipping” and the car jerks forward. The same thing happens when braking the car.
NHTSA ODI #11591983
Mileage unknown · Mar 24, 2024
Engine
My 2023 Bronco with 6k miles died without any warning back in late January 2024. Ford service dept said it was a failed catalytic converter. After it was in the shop for a 1.5 months, waiting on the back ordered part, we picked up our truck around March 10. Fast forward to today, truck has 7k miles. We were southbound on the …
Read full complaint
My 2023 Bronco with 6k miles died without any warning back in late January 2024. Ford service dept said it was a failed catalytic converter. After it was in the shop for a 1.5 months, waiting on the back ordered part, we picked up our truck around March 10. Fast forward to today, truck has 7k miles. We were southbound on the interstate in bumper to bumper traffic heading to Disney World when the truck’s engine died, yet again. Luckily we were not traveling typical interstate speed and we safely maneuvered the vehicle to the side of the road and contacted Ford roadside assistance and a tow truck was quickly dispatched. The truck is currently sitting at a Ford dealership on a Sunday, 485 miles from home and a lot of money tied up in our vacation plans. Just thankful nobody was hurt, but waiting for this to happen a third time just to file a lemon law is reckless to customers and everyone else on the road, for that matter.
NHTSA ODI #11579199
Official recalls
18Jul 20, 2026
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco and Bronco Raptor vehicles. The engine compartment wiring harness may become damaged and short circuit.
Consequence & remedy
Consequence: A short circuit in the engine compartment can create heat or spark, increasing the risk of a fire.
Remedy: Dealers will install sheathing over the wiring, free of charge. This is a Phased campaign. Phase 1 will include 2026 Bronco Raptor notified owners on 7/31/2026. Phase 2 will include 2021-2025 Bronco Raptor vehicle will notify owners on or about 8/14/2026. Phase 3 will include 2021-2026 Bronco will notify owners on or about 9/1/2026. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S55. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 23, 2026.
Additional source detail variants (2)
Engine
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco and Bronco Raptor vehicles. The engine compartment wiring harness may become damaged and short circuit.
Consequence: A short circuit in the engine compartment can create heat or spark, increasing the risk of a fire.
Remedy: Dealers will install sheathing over the wiring, free of charge. This is a Phased campaign. Phase 1 will include 2026 Bronco Raptor notified owners on 7/31/2026. Phase 2 will include 2021-2025 Bronco Raptor vehicle will notify owners on or about 8/14/2026. Phase 3 will include 2021-2026 Bronco will notify owners on or about 9/1/2026. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S55. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 23, 2026.
Electrical System:wiring:front Underhood
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco and Bronco Raptor vehicles. The engine compartment wiring harness may become damaged and short circuit.
Consequence: A short circuit in the engine compartment can create heat or spark, increasing the risk of a fire.
Remedy: Dealers will install sheathing over the wiring, free of charge. This is a Phased campaign. Phase 1 will include 2026 Bronco Raptor notified owners on 7/31/2026. Phase 2 will include 2021-2025 Bronco Raptor vehicle will notify owners on or about 8/14/2026. Phase 3 will include 2021-2026 Bronco will notify owners on or about 9/1/2026. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S55. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 23, 2026.
Jun 24, 2026
Ford Motor Company (Ford) is recalling certain 2022-2026 Bronco vehicles. The fender flares may not be properly secured and detach from the vehicle.
Consequence & remedy
Consequence: A detached fender flare can become a road hazard and increase the risk of a crash.
Remedy: Dealers will inspect and repair, or replace the fender flares as necessary, free of charge. Owner notification letters were mailed September 1, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S47. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning August 7, 2026.
Apr 14, 2026
Ford Motor Company (Ford) is recalling certain 2021-2025 Bronco vehicles. The transmission to transfer case joint may be misaligned due to an incorrectly performed previous repair, which could lead to wear of the transmission output shaft splines and transfer case input splines.
Consequence & remedy
Consequence: Excessive wear of the transmission and transfer case splines may result in a loss of drive power or vehicle rollaway, increasing the risk of a crash.
Remedy: Dealers will inspect the transmission to transfer case joint and replace the transmission and transfer case as necessary, free of charge. Owner notification letters were mailed July 9, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S26. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 15, 2026.
Mar 3, 2026
Ford Motor Company (Ford) is recalling certain 2021-2026 Ford Bronco and 2021-2024 Ford Edge vehicles. The Accessory Protocol Interface Module (APIM) may overheat and shutdown, which can prevent the rearview camera image from displaying as intended.
Consequence & remedy
Consequence: A rearview camera that fails to display an image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: The APIM software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed April 13, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S09. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.
Oct 23, 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco vehicles. The front seats may have a loose or dislodged seat frame height-adjust pivot bolt.
Consequence & remedy
Consequence: A seat with a dislodged bolt may not properly restrain an occupant in a crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace the pivot links and bolts as necessary, free of charge. Owner notification letters were mailed April 28, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB5. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning October 28, 2025.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Jul 7, 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.
May 14, 2025
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco vehicles. The 360-degree view camera may not display a rearview image when the vehicle is placed in reverse.
Consequence & remedy
Consequence: Loss of the rearview camera image can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed October 8, 2025. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 23S48. This recall expands previous recall number 23V-598.
May 9, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.
Consequence & remedy
Consequence: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.
Jan 17, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco vehicles. The rear shock absorbers may corrode and fail, resulting in detachment of the external reservoir.
Consequence & remedy
Consequence: An external reservoir that detaches from a vehicle can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will replace the rear shock absorbers, as necessary free of charge. Owner notification letters were mailed August 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S01.
Mar 8, 2024
Ford Motor Company (Ford) is recalling certain 2023-2024 Bronco 4-door vehicles. The left-side rear door may be opened from the inside of the vehicle when the child safety lock is in the "ON" position.
Consequence & remedy
Consequence: A malfunctioning child safety lock that allows a rear door to be opened unintentionally can increase the risk of injury.
Remedy: Dealers will inspect the child safety locks and replace the rear door latch, as necessary, free of charge. Owner notification letters were mailed April 9, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S15.
Feb 23, 2024
Ford Motor Company (Ford) is recalling certain 2023-2024 Bronco and Bronco Heritage vehicles. The rear quarter glass panels may have been improperly installed to the vehicle hard top, which can allow them to detach.
Consequence & remedy
Consequence: Detached rear glass panels may create a road hazard and increase the risk of a crash.
Remedy: Dealers will inspect and reinstall the rear glass panels on Bronco vehicles. On Bronco Heritage vehicles, dealers will replace the rear left-hand removable quarter glass panel. Repairs will be performed free of charge. Bronco owner notification letters were mailed June 6, 2024. Bronco Heritage owner letters were mailed June 12, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S10.
Aug 3, 2023
Ford Motor Company (Ford) is recalling certain 2023 Bronco vehicles. The transmission park system may have been damaged during assembly, which can prevent the parking pawl from fully engaging and result in a vehicle rollaway.
Consequence & remedy
Consequence: A vehicle rollaway can increase the risk of a crash.
Remedy: Dealers will replace the transmission, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S44.
May 26, 2023
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco, 2023 Super Duty F-250, and 2019-2023 Ranger vehicles. The Tire and Loading Information (TREAD) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An overloaded vehicle increases the risk of a crash.
Remedy: Ford will mail a new TREAD label to install over the existing label, free of charge. Owners will also have the option to take their vehicle to a Ford or Lincoln dealer to have the new label installed, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C18.
May 18, 2023
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco vehicles built with the 5-Door body style. The first-row seat belt latch plates may be difficult to access from their stowed position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Difficulty accessing the seat belt latches may result in occupants not wearing their seat belts, increasing the risk of injury in a crash.
Remedy: Dealers will add a sliding clip latch stop to the driver and front passenger seat belts, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed July 14, 2023. Owner letters informing owners that parts are available were mailed on October 2, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C16.
Apr 20, 2023
Ford Motor Company (Ford) is recalling certain 2023 Bronco and Ranger vehicles. The lug nuts on the driver's side wheels may have been improperly tightened.
Consequence & remedy
Consequence: Loose lug nuts may result in wheel detachment while driving, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicles until the remedy is completed. Dealers will inspect, and if necessary, retighten the lug nuts, free of charge. Owner notification letters were mailed May 2, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S17.
Mar 8, 2023
Ford Motor Company (Ford) is recalling certain 2023 Bronco Wildtrak and 2022 Bronco Raptor vehicles. Internal damage to the steering gear may require increased steering effort or cause the steering wheel to lock-up.
Consequence & remedy
Consequence: A steering wheel that locks-up can result in a complete loss of steering control, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. Dealers will replace the steering gear, free of charge. Owner notification letters were mailed March 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S09.
Feb 10, 2023
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150, Mustang, Explorer, Bronco, and 2023 Lincoln Aviator vehicles equipped with automatic transmissions. The transmission may contain a loose bolt which could prevent the transmission from engaging the park gear, although the gear shifter position may indicate that the vehicle has been shifted to "PARK."
Consequence & remedy
Consequence: The inability to secure the vehicle in the park position can result in a rollaway, increasing the risk of a crash or injury.
Remedy: Dealers will inspect and, if necessary, replace the transmissions, free of charge. Owner notification letters were mailed April 25, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S06.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration