MY 1993 FORD BRONCO HAS AN ESOF (ELECTRONIC SHIFT ON THE FLY) TRANSFER CASE. WITH FOUR WHEEL DRIVE ENGAGED, ON ROAD AND OFF, WHENEVER THE VEHICLE IS COASTING THE TRUCK WILL SUDDENLY ACT LIKE IT IS NO LONGER IN GEAR. SHIFTING INTO PARK AND AND BACK WILL NOT CHANGE ANYTHING. THE TRUCK MUST BE TAKEN OUT OF FOUR WHEEL DRIVE IN ORDER…
Read full complaint
MY 1993 FORD BRONCO HAS AN ESOF (ELECTRONIC SHIFT ON THE FLY) TRANSFER CASE. WITH FOUR WHEEL DRIVE ENGAGED, ON ROAD AND OFF, WHENEVER THE VEHICLE IS COASTING THE TRUCK WILL SUDDENLY ACT LIKE IT IS NO LONGER IN GEAR. SHIFTING INTO PARK AND AND BACK WILL NOT CHANGE ANYTHING. THE TRUCK MUST BE TAKEN OUT OF FOUR WHEEL DRIVE IN ORDER TO START DRIVING AGAIN. I BELIEVE THIS TO BE DANGEROUS AS IT COULD ALLOW ME TO NOT REACT IN THE CASE OF AN EMERGENCY. IT THINK THAT IT IS A SIMILAR PROBLEM TO THE RECALL 93V089000.
NHTSA ODI #11281440
37,000 miles · Jan 10, 2014
Power Train
TL* THE CONTACT OWNS A 1993 FORD BRONCO. THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH WHILE COASTING HE ATTEMPTED TO ACCELERATE AND THE VEHICLE WOULD NOT RESPOND. THE CONTACT STATED THAT THE DEFECT WAS ONLY OCCURRED AFTER THE VEHICLE WAS COASTING. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE TRANS…
Read full complaint
TL* THE CONTACT OWNS A 1993 FORD BRONCO. THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH WHILE COASTING HE ATTEMPTED TO ACCELERATE AND THE VEHICLE WOULD NOT RESPOND. THE CONTACT STATED THAT THE DEFECT WAS ONLY OCCURRED AFTER THE VEHICLE WAS COASTING. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE TRANSFER CASES SLIPPED OUT OF THE 4X4 GEAR DURING THE INCIDENT. THE CONTACT INDICATED THAT HE EXPERIENCED THE SAME DEFECT LISTED IN THE NHTSA CAMPAIGN NUMBER 93V089000 (POWER TRAIN) BUT THE MANUFACTURER DID NOT INCLUDE THE VEHICLE IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 37,000. UPDATE 4/7/14 VA THE CONSUMER REQUESTED ASSISTANCE WITH HAVING FORD REIMBURSE THE $1,500 FOR REPAIR OF THE VEHICLE. THE CONSUMER BELIEVES THE VEHICLE SHOULD HAVE BEEN INCLUDED IN THE RECALL. *JS
NHTSA ODI #10559415
Mileage unknown · Feb 6, 2001
Power Train
WHILE DRIVING WITH THE TOUCH DRIVE ELECTRIC SHIFT 4X4 IN THE VEHICLE STOPPED MOVING, CONSUMER BELIVES THE PROBLEM IS THE SAME AS RECALL 93V-089 BUT CUSTOMER SERVICE CLAIMS THEY KNOW NOTHING ABOUT THE RECALL. NLM
NHTSA ODI #559449
Mileage unknown · Sep 5, 2000
Power Train
WHILE DRIVING UP HILL OR CHANGING GEARS, SUCH AS FROM REVERSE INTO DRIVE, VEHICLE WILL STALL UNEXPECTEDLY WHICH MAY CAUSE A CRASH. PEP BOYS CANNOT DETERMINE THE CAUSE. PLEASE PROVIDE FURTHER INFORMATION.*AK
NHTSA ODI #869530
Mileage unknown · Jun 30, 2000
Power Train
DIFFERENTIAL FALLS INTO NEUTRAL WHEN GOING DOWN HILL. CAR FREEWHEELS WITHOUT ENGINE BRAKING AND HAS NO FORWARD POWER UNTIL 4X4 IS ENGAGED. *AK
NHTSA ODI #724793
Mileage unknown · Jul 9, 1999
Power Train
WHEN THE VEHICLE WAS PARKED IN DRIVEWAY WITH ENGINE OFF IT ROLLED ABOUT 30 FEET OUT OF THE DRIVEWAY, CAUSING DAMAGES TO NEIGHBORS HOUSE. CONSUMER ALSO NOTICED THAT VEHICLE HAD SHIFTED GEARS FROM PARK TO REVERSE, BUT ROLLED FORWARD CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS. *AK
NHTSA ODI #842002
Mileage unknown · Dec 10, 1996
Power Train
TRANSMISSION FAILURE. *AK
NHTSA ODI #512173
Mileage unknown · Jan 23, 1995
Engine And Engine CoolingPower TrainService Brakes, Hydraulic
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Consequence & remedy
Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.
THE U-CLIP STYLE NUTS THAT RETAIN THE FRONT BUMPERS TO THE FRONT BUMPER INNER ARMS CAN FRACTURE.
Consequence & remedy
Consequence: IF ONE OF THE U-CLIP NUTS FRACTURES, THE BUMPER WILL LOOSEN AND RATTLE CAUSING FRACTURE OF THE REMAINING U-CLIP NUTS, RESULTING IN SEPARATION OF THE BUMPER FROM THE VEHICLE. IF THE BUMPER WERE TO DETACH FROM THE VEHICLE WHILE IT IS BEING DRIVEN, A VEHICLE COLLISION COULD RESULT.
Remedy: INSPECTION AND REPLACEMENT OF THE FOUR U-CLIP NUTS AND THE ASSOCIATED BOLTS.
THE TRANSFER CASES HAVE BEEN BUILT WITH THE WRONG ELECTRIC SHIFT MOTOR. THE TRANSFER CASES CAN SLIP OUT OF THE 4 X 4 HIGH GEAR POSITION DURING COASTING IN FORWARD GEARS OR WITH POWER APPLIED IN REVERSE GEAR.
Consequence & remedy
Consequence: IF THIS OCCURS, THE VEHICLE CAN ROLL FREELY AS IF INNEUTRAL POSITION REGARDLESS OF THE TRANSMISSION GEAR SELECTOR POSITION. THIS CANRESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Remedy: REPLACE DEFECTIVE TRANSFER CASES WITH THE CORRECT VERSION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1993 Ford Bronco Problems, Complaints & Recalls | Skip That Year
Illustration