Structure. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Gasoline. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

1 crash reports2 fire reports1 injury reports

What owners actually said

37 reports

107,000 miles · Feb 5, 2005

Power Train

Read full complaint

ABOUT TWO MONTHS AGO MY TRANSMISSION WENT OUT IN MY 92 FORD BRONCO ON MY WAY TO WORK WITH A CO-WORKER WITH ME, I WAS PULLING UP TO A RED LIGHT AND WENT TO DOWNSHIFT TO FIRST BUT IT WASN'T THERE, TRIED SECOND NOT THERE EITHER,I HAS TO GIMP ME BRONCO HOME IN THIRD GEAR THERE BY SMOKING AND BURNING UP THE CLUTCH,AFTER GETTING THE POS(PIECE OF ?!@#$%) HOME I CALLED A FEW SHOPS AND FOUND THIS TO BE A COMMON PROBLEM WITH ALL FORD TRUCKS USING A MAZDA MANUAL TRANSMISSION,BEING A MECHANIC MYSELF I PROCEEDED TO BUY A REBUILT TRANSMISSION AND INSTALL IT MYSELF, NOW IT IS OUT AGAIN WITH THE SAME PROBLEM NO FIRST OR SECOND. NOW UNTIL I BOUGHT THIS POS I HAVE ALWAYS BEEN A FORD MAN BUT NOW I DON'T KNOW WHAT MANUFACTURER TO TRUST, CHEVY HAS PROBLEMS WITH THEIR BLAZER TRANSMISSIONS TOO. I BOUGHT THIS CAR USED WITH LESS THAN A HUNDRED THOUSAND ON THE ODOMETER AND FOUND THAT THE TRANSMISSION WAS NOT ORIGINAL WHEN I CHANGED IT LAST TIME NOW AFTER I FIX IT I WILL SELL IT A DRIVE IT THROUGH THE LOCAL FORD DEALERSHIP SHOW ROOM,MAYBE THAT WOULD MAKE THEM ANSWER FOR ALL THE PROBLEMS EVERYONE HAS WITH THESE PROBLEMS. MAYBE WHAT MY BROTHER SAYS IS TRUE FORD MEANS F%*@ED OVER REBUILT DODGE. *JB

NHTSA ODI #10109881

75,000 miles · Apr 28, 2003

Fuel System, Diesel

FUEL TANK DEVELOPED LEAKS DUE TO RUST CAUSED BY WATER TRAPPED BETWEEN BRUSH GUARD AND TANK BOTTOM. BRUSH GUARD DESIGNED WITHOUT HOLES TO ALLOW WATER TO DRAIN PROPERLY THUS TRAPPING WATER BETWEEN THE GUARD AND TANK BOTTOM. *NLM

NHTSA ODI #10016616

Mileage unknown · Mar 27, 2003

Parking Brake

THE PARKING BRAKE DID NOT HOLD THE VEHICLE. THE CONSUMER LOOKED ON NHTSA SITE AND DISCOVERED A RECALL (94V-169001) FOR THE SAME PROBLEM. THE CONSUMER CONTACTED A LOCAL DEALER WHO INDICATED THE CONSUMERS VEHICLE WAS NOT INCLUDED DUE TO VIN. *NLM *NLM

NHTSA ODI #10011246

56,000 miles · Feb 6, 2003

Parking Brake

CONSUMER IS HAVING THE SAME DEFECT WITH THERE VEHICLE'S EMERGENCY PARKING BRAKES, AS STATED IN RECALL NUMBER 94 V 169 000 BUT THERE VIN NUMBER IS NOT INCLUDED. PH

NHTSA ODI #10006718

85,000 miles · Jan 30, 2003

Structure

TAILGATE RUSTS EXCESSIVELY, AND IT IS THE ONLY PART OF THE CAR TO DO SO.

NHTSA ODI #10004938

Mileage unknown · Mar 24, 2002

Latches/locks/linkages

BOTH DOORS WILL NOT OPEN FROM INSIDE FIRST PASSENGER SIDE, MONTHS LATER DRIVER'S SIDE. *AK

NHTSA ODI #759719

Mileage unknown · Mar 13, 2002

Structure

I DONT KNOW IF RECALL IS STILL VALID, DEALER DOES NOT SHOW ON COMPUTER. *AK

NHTSA ODI #759315

Mileage unknown · Oct 23, 2000

Tires

REPLACEMENT TIRES ON A FORD, BRONCO 1992, VNHL P23575R15. TWO FRONT TIRES HAVE CRACKS GOING ALL THE WAY AROUND. TOOK TO MECHANIC, AND HE SAID THAT TREAD WAS ABOUT TO SEPARATE. *AK

NHTSA ODI #873557

Mileage unknown · Oct 19, 2000

Engine And Engine CoolingService Brakes, HydraulicStructure

THE FRONT BRAKES WERE REPLACED FOUR TIMES, METALLIC DISC PADS WERE INSTALLED, AND ROTORS WERE REPLACED, RESURFACED, AND MACHINED. *SLC

NHTSA ODI #556711

Mileage unknown · Oct 13, 2000

Fuel System, Gasoline

VEHICLE STALLS LIKE A VAPOR LOCK IN MIDDLE OF TRAFFIC. SOMETHING TELLS THE CAR THAT IT OVERHEATING AND IT WILL JUST STOP RUNNING.*AK

NHTSA ODI #872952

Official recalls

94V169001 · Parking Brake:conventional

Sep 7, 1994

THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.

Consequence & remedy

Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.

Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.

92V006000 · Structure:body:door

Jan 14, 1992

WATER CAN ENTER THE DOOR LATCH RELEASE CABLE. IF THE VEHICLE IS OPERATED IN BELOW FREEZING TEMPERATURES, THE WATER IN THE DOOR LATCH RELEASE CABLE CAN FREEZE AND CAUSE THE LATCH MECHANISM TO MALFUNCTION.

Consequence & remedy

Consequence: THE MALFUNCTION OF THE DOOR LATCH RELEASE CAN RESULT INTHREE DIFFERENT PROBLEMS: 1) THE DOOR WILL NOT BE ABLE TO BE RELATCHED, 2) THEINSIDE DOOR HANDLE CAN BECOME INOPERATIVE, AND 3) THE DOOR COULD APPEAR TO BELATCHED WHEN IT IS NOT, ALLOWING THE DOOR TO OPEN UNEXPECTEDLY IF IT IS JARRED,AND INCREASING THE RISK OF INJURY TO THE ADJACENT SEAT OCCUPANT.

Remedy: REVISED DOOR RELEASE CABLES AND WATER SHIELDS WILL BE INSTALLED.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗