NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
19 reportsClear category filterMileage unknown · Jul 24, 2026
Power Train
What component or system failed or malfunctioned, and is it available for inspection upon request? The vehicle’s drivetrain or all-wheel-drive system appears to be malfunctioning. During turns, the vehicle runs rough, feels as though it is binding or shuddering, and becomes harder to accelerate. The exact failed component has no…
Read full complaint
What component or system failed or malfunctioned, and is it available for inspection upon request? The vehicle’s drivetrain or all-wheel-drive system appears to be malfunctioning. During turns, the vehicle runs rough, feels as though it is binding or shuddering, and becomes harder to accelerate. The exact failed component has not yet been diagnosed. The vehicle is available for inspection upon request, and I have a service appointment scheduled in approximately two weeks. How was your safety or the safety of others put at risk? The reduced acceleration and rough operation while turning make the vehicle respond unpredictably. This could prevent me from accelerating safely through an intersection, entering traffic, or avoiding another vehicle or hazard. Has the problem been reproduced or confirmed by a dealer or independent service center? No. The problem has not yet been reproduced or confirmed by a dealer or independent service center. I have an appointment scheduled in approximately two weeks for inspection and diagnosis. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No. The vehicle and suspected component have not yet been inspected by the manufacturer, police, insurance representatives, or others. An inspection appointment is scheduled in approximately two weeks. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No warning lamps or dashboard messages appeared. The symptoms consisted of rough running, shuddering or binding while turning, and reduced acceleration. The symptoms first appeared recently when the vehicle had approximately 48,000 miles.
NHTSA ODI #11752642
Mileage unknown · Jun 8, 2026
Power Train
My vehicle is currently experiencing drivability issues including: * Wrench warning light with “See Manual” message, * Hesitation during acceleration, * Intermittent reduced engine power, * Prior fuel odor concerns, * Unsafe acceleration response while driving.
NHTSA ODI #11742816
Mileage unknown · Jun 1, 2026
Electrical SystemFuel/propulsion SystemPower TrainCrash
On May 15, 2006 I was turning slowly into a parking space perhaps 3 to 5 miles an hour. My vehicle suddenly surged forwarded and accelerated on its own. I hit a wall. No warning lights appeared. No crash warning or any beeping of any sort. My car had a recall for the fuel injector. In October 2025 Ford sent out someone to adjust…
Read full complaint
On May 15, 2006 I was turning slowly into a parking space perhaps 3 to 5 miles an hour. My vehicle suddenly surged forwarded and accelerated on its own. I hit a wall. No warning lights appeared. No crash warning or any beeping of any sort. My car had a recall for the fuel injector. In October 2025 Ford sent out someone to adjust the software at my home. I do not believe a tube was ever inserted. Witnesses reported I was going slow and the car accelerated. I eat at the location almost every day so they watch for my car and whether there were 1 or 2 people. So it is not just a random witness. I do not know what parts are involved other than to say there was an un commanded acceleration and engine surge.
NHTSA ODI #11741370
Mileage unknown · May 28, 2026
Power Train
My vehicle makes a horrible noise when I’m driving and making a turn. According to a mechanic shop I took my vehicle to, the RDU vent hose that was put on by the manufacturer is highly susceptible to get clogged and drawing in outside moisture causing this horrible noise. The mechanic stated that they have seen this issue wi…
Read full complaint
My vehicle makes a horrible noise when I’m driving and making a turn. According to a mechanic shop I took my vehicle to, the RDU vent hose that was put on by the manufacturer is highly susceptible to get clogged and drawing in outside moisture causing this horrible noise. The mechanic stated that they have seen this issue with other Ford Bronco Sport vehicles.
NHTSA ODI #11740719
Mileage unknown · May 17, 2026
EngineFuel/propulsion SystemPower Train
On or about December 2025, the vehicle began emitting strong fuel/exhaust fumes through the air conditioning vents during operation. The fumes were noticeable inside the passenger cabin and created concerns of toxic exposure and possible fire risk. The condition was reported to an authorized Ford dealership, Hacienda Ford, which…
Read full complaint
On or about December 2025, the vehicle began emitting strong fuel/exhaust fumes through the air conditioning vents during operation. The fumes were noticeable inside the passenger cabin and created concerns of toxic exposure and possible fire risk. The condition was reported to an authorized Ford dealership, Hacienda Ford, which retained the vehicle for inspection for approximately two months. The dealership acknowledged concerns involving the fuel system/fuel injectors and performed inspection procedures and software-related recall work; however, the vehicle was later returned without replacement or repair of fuel system components. After the vehicle was released, the same fuel/fume odor condition reoccurred during normal driving, including an incident where the fumes became overwhelming inside the cabin while driving toward [XXX] . The vehicle is associated with an open safety recall identified as manufacturer recall 25S76 / NHTSA campaign 25V467, described as “remedy not yet available.” Despite repeated reports of fuel/exhaust fumes and concerns involving possible fuel injector defects, Ford Motor Company and the dealership have not provided a written determination that the vehicle is safe to operate. A formal final escalation letter was sent to Ford Motor Company demanding a safety determination, alternate repair authorization, reimbursement of towing expenses, and clarification regarding open recalls and known fuel system issues. The letter was delivered on April 29, 2026, but no response was received within the requested deadline. The consumer believes the vehicle may present an ongoing safety hazard involving fuel vapor intrusion and potential fire risk. The defect remains unresolved. The vehicle remains parked. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11738392
Mileage unknown · May 4, 2026
Electrical SystemEnginePower Train
I was driving on the highway and my car started making a lot of noise. I got a notice “The Engine system has detected a fault.” Then another notification saying 4 wheel drive was disabled and then my car stopped running, leaving me stranded in the middle of the highway. My car would start, but it would not go into any gear. When…
Read full complaint
I was driving on the highway and my car started making a lot of noise. I got a notice “The Engine system has detected a fault.” Then another notification saying 4 wheel drive was disabled and then my car stopped running, leaving me stranded in the middle of the highway. My car would start, but it would not go into any gear. When I tried putting it in gear, I got a notification that said “Powertrain Malfunction/Reduced Speed Your Malfunction warning is on because your vehicle’s transmission cannot be shifted or moved out of park.” I had to wait in the middle of the highway for approximately 30-45 minutes for a tow truck to come, and the whole time, there were cars traveling 80 mph swerving to miss me. I was sincerely afraid for my life.
NHTSA ODI #11735518
Mileage unknown · Apr 27, 2026
Power Train
2023 Bronco Sport had its serpentine belt replaced in February of 2026 because it was loose causing my engine to overheat. I had to have it towed because I was sitting on the side of the road. Then in April of 2026 the Bronco started making horrible loud clanging sounds and jerking when it was put in gear. Towed again to the sho…
Read full complaint
2023 Bronco Sport had its serpentine belt replaced in February of 2026 because it was loose causing my engine to overheat. I had to have it towed because I was sitting on the side of the road. Then in April of 2026 the Bronco started making horrible loud clanging sounds and jerking when it was put in gear. Towed again to the shop. Now I am told this 3 year old car needs a new transmission. Doing research i have found that several Bronco owners have the same problem. Why does Ford not have a recall for this!! My mechanic was looking for a rebuilt one and can't find one because the demand for them is higher than what the supply is. This should tell you something!!
NHTSA ODI #11734146
Mileage unknown · Mar 4, 2026
EngineFuel/propulsion SystemPower Train
The fuel injectors are failing, the vehicle smells of gasoline fumes in the cabin if the vehicle and we are now getting check engine lights due to emissions which I contribute to the failing fuel injectors which have been under recall for quite some time now and Ford does not seem to want to fix this issue. They can only tell us…
Read full complaint
The fuel injectors are failing, the vehicle smells of gasoline fumes in the cabin if the vehicle and we are now getting check engine lights due to emissions which I contribute to the failing fuel injectors which have been under recall for quite some time now and Ford does not seem to want to fix this issue. They can only tell us they do not have a fix yet at this time. My understanding this is a very dangerous issue as the vehicle can catch on fire due to this malfunction. I have young children who all ride in this vehicle.
NHTSA ODI #11722064
Mileage unknown · Dec 31, 2025
Power Train
Transmission jerking or not shifting into gear and intermittent park in reverse shifting inoperable. Also, my car has been in the shop.Under warranty repair for most of the last four months. , we are still required to make payments on a vehicle.And cannot even transfer insurance from that vehicle to another temporarily.Because o…
Read full complaint
Transmission jerking or not shifting into gear and intermittent park in reverse shifting inoperable. Also, my car has been in the shop.Under warranty repair for most of the last four months. , we are still required to make payments on a vehicle.And cannot even transfer insurance from that vehicle to another temporarily.Because of the sales contract. The service manager recently told me that our eight speed ecoboost transmission is a one of thousands of transmissions that were assembled without vital parts. And that ford has no workaround or plan in place to correct The problem
NHTSA ODI #11708005
Mileage unknown · Sep 3, 2025
Power Train
Transmission violently jerks when shifting making it unsafe to even drive. Severe uneven shifting. RPM fluctuations exacerbate the problem ( since a normal automatic transmission will naturally shift upon acceleration at specific intervals, but not this one). Also would not shift into Park or reverse. We finally had to have it t…
Read full complaint
Transmission violently jerks when shifting making it unsafe to even drive. Severe uneven shifting. RPM fluctuations exacerbate the problem ( since a normal automatic transmission will naturally shift upon acceleration at specific intervals, but not this one). Also would not shift into Park or reverse. We finally had to have it towed to the shop. This is a 2023 Ford Bronco sport and should be recalled. The transmission is a severely flawed and unsafe design.
NHTSA ODI #11684701
Official recalls
14May 27, 2026
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco Sport and 2022-2026 Maverick vehicles. The front lower control arm ball joints may have been incorrectly installed or incorrectly repaired at the vehicle assembly plant, allowing the control arm to disconnect from the front wheel knuckle.
Consequence & remedy
Consequence: A detached control arm can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicles until the remedy is completed. Dealers will inspect and repair the front lower control arm ball joints as necessary, free of charge.Owner notification letters were mailed September 2, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S36. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 29, 2026.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Jul 11, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2020-2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will update the engine control software. In addition, dealers will replace the high-pressure fuel rail assembly and fuel injectors, free of charge. As an interim repair, dealers will update the engine control software, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed August 29, 2025. Second letters will be sent once the final remedy is available, anticipated in July 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S76. This recall expands and replaces previous recall numbers 22V-859, 24V187, and 25V165. Vehicles previously remedied under 22V-859, 24V187, and 25V165 will need to have the new final remedy performed once it is available.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence & remedy
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S26.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S26.
Electrical System:body Control Module/bcm
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S26.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2023 Bronco Sport vehicles previously repaired incorrectly under recall numbers 22V-859 or 24V-187. A fuel injector may crack and leak fuel inside the engine compartment.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S21.
Jan 17, 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco Sport and 2022-2023 Maverick vehicles. The 12-volt battery may experience degradation and suddenly fail.
Consequence & remedy
Consequence: Battery failure can result in a loss of electrical accessories, including the hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will inspect and if necessary, replace the 12-volt battery, free of charge. Owner notification letters were mailed May 2, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S02. Vehicles in this recall were previously repaired under 24V-267 and will need to have the new remedy completed.
Aug 9, 2024
Ford Motor Company (Ford) is recalling certain 2023-2024 Maverick, Ford Bronco Sport, and Mustang Mach-E vehicles. The front windshield wiper motor may become inoperative, causing the wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain conditions, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the windshield wiper motor as necessary, free of charge. Owner notification letters were mailed on December 6, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S51.
Apr 12, 2024
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence & remedy
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed on June 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S24.
Additional source detail variants (2)
Electrical System:body Control Module/bcm
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed on June 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S24.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed on June 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S24.
Mar 22, 2024
Ford Motor Company (Ford) is recalling certain 2023 Maverick and Bronco Sport vehicles. The tires may have been manufactured incorrectly, which may result in a loss of vehicle handling and control.
Consequence & remedy
Consequence: A loss of vehicle handling and control increases the risk of a crash.
Remedy: Dealers will inspect and replace the tires, as necessary, free of charge. Owner notification letters were mailed April 5, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S20.
Mar 8, 2024
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco Sport and 2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Owner notification letters were mailed on April 24, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S16. This recall is an expansion of previous recall number 22V-859.
Jan 23, 2023
Ford Motor Company (Ford) is recalling certain 2023 Bronco Sport vehicles. Valves inside the Anti-lock Brake System (ABS) module may have been damaged during manufacturing, causing an internal ABS module leak.
Consequence & remedy
Consequence: A leak inside the ABS module can cause an unexpected increase in brake pedal travel or unexpected movement during an Auto Hold event, increasing the risk of a crash.
Remedy: Dealers will replace the ABS Module, free of charge. Owner notification letters were mailed on May 2, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S01.
Nov 18, 2022
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape and 2021-2023 Bronco Sport vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Interim owner notification letters informing owners of the safety risk were mailed January 9, 2023. Remedy parts are expected to be available in 1st Quarter of 2023. Owner notification letters were mailed February 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S73. This recall includes all vehicles previously recalled under 22V-191. Vehicles previously remedied under 22V-191 will need to have the new remedy performed.
Sep 14, 2022
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco Sport and 2022 F-150 vehicles. The parking lights may flicker when the headlights are activated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Flickering parking lights can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will replace the LED Driver module, free of charge. Owner notification letters were mailed March 29, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C22.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ24014 · Loss Of Motive Power
Opened Nov 15, 2024 · Closed Oct 10, 2025
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
On January 31, 2024, The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24002) to investigate loss of motive power allegations in model year (MY) 2021 Ford Bronco Sport vehicles. Consumers reported a loss of engine power accompanied by complete electrical system failure either while driving or after stopping at a traffic light or stop sign. The vehicles generally could not be restarted, and the incidents were commonly diagnosed by dealerships to a failed 12-Volt (12V) battery. On April 12, 2024, Ford issued safety recall 24V-267 covering 456,565 MY 2021-2024 Ford Bronco Sport and MY 2022-2023 Ford Maverick vehicles. The recall addressed loss of motive power resulting from sudden degradation of the 12V battery during the drive cycle. The recall remedy consisted of software updates to the body control module and the powertrain control module. The updated software aimed to provide warning to consumers when the battery is failing and inhibit certain vehicle functions which can lead to loss of motive power incidents. Additionally, Ford removed the existing 12V Enhanced Flooded Battery (EFB) as both a service component for the subject vehicles and original equipment for newly built Bronco Sport vehicles (during MY 2024 production), replacing it with a more robust absorbed glass mat (AGM) battery. The same AGM battery had been incorporated into Ford Maverick production in late 2022. Following recall 24V-267, ODI received loss of motive power complaints in vehicles that had previously received Ford’s software-based remedy. Consumers reported that they did not receive warnings related to the 12V battery or the vehicle’s electrical system before the loss of power. On November 15, 2024, ODI opened Recall Query (RQ24014) to assess the effectiveness of the 24V-267 recall remedy. On January 19, 2025, Ford issued recall 25V-019 covering 272,817 MY 2021-2023 Bronco Sport and MY 2022-2023 Ford Maverick vehicles. The new recall addressed the same hazard as 24V-267 but required replacement of the existing 12V battery with an AGM battery as the remedy. Ford reported that following the opening of RQ24014, it evaluated several field-returned 12V batteries, and determined that EFBs produced by battery supplier Camel potentially contained internal manufacturing defects causing loss of motive power. Ford further concluded that the software updates provided in the 24V-267 recall remedy were unable to detect battery failures quickly enough to avoid loss of motive power. Vehicles previously within the scope of recall 24V-267, but outside of the scope of recall 25V-019, are equipped with EFBs produced by a different battery supplier (Clarios). When recall 25V-019 was issued, Ford had not identified any Clarios EFBs exhibiting the same failure mode as the Camel EFBs. In light of Ford’s recall action, ODI is closing this Recall Query. The agency will continue to monitor loss of motive power complaints in Bronco Sport vehicles equipped with Clarios EFBs and reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24008 · Underhood Fires Caused By Fuel Leak
Opened Apr 11, 2024 · Closed Oct 30, 2025
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:injectors
On April 11, 2024, NHTSA’s Office of Defects Investigation (“ODI”) opened this Recall Query (“RQ”) to investigate the adequacy of, including various safety concerns associated with, the remedy program in recalls 22V-859 (filed Nov. 18, 2022) and 24V-187 (filed Mar. 8, 2024). The vehicle population associated with these recalls includes certain MY 2020-2022 Ford Escape vehicles and MY 2021-2023 Ford Bronco Sport vehicles equipped with 1.5L engines. The safety defect in each recall involves high-pressure fuel injectors that are susceptible to cracking, allowing liquid fuel and fuel vapor to migrate onto hot surfaces within the engine compartment potentially resulting in underhood vehicle fires. The remedy programs described in recalls 22V-859 and 24V-187 are identical and involve both a software component and a hardware component. Specifically, Ford developed an updated engine control software designed to detect a pressure drop in the high-pressure fuel rail, provide instrument cluster messaging to the driver, invoke a strategy to disable the high-pressure fuel pump, derate the engine output, and lower the temperatures of possible ignition sources within the engine compartment. Additionally, Ford would install a tube into the engine’s cylinder head drain hole to shunt spilled liquid fuel past the various hot surfaces within the engine compartment and ultimately discard the spilled liquid fuel onto the roadway. ODI identified various safety concerns with this remedy program, which, among other things, notably did not include repairing or replacing the defective part and potentially did include the introduction of new safety defects (like fuel spilling near the spark plugs and fuel spilling onto the public roadway). NHTSA opened this investigation to evaluate these concerns with the remedy program, including whether the vehicles were still susceptible to underhood fires even post-remedy. As described in more detail in the Additional Summary posted simultaneously with this resume, ODI conducted a thorough investigation that included analyzing data and other materials received in response to two Information Requests, as well as inspections of post-remedy vehicles that experienced an underhood fire. ODI and Ford worked to identify and locate vehicles that experienced post-remedy fires and conduct joint vehicle inspections. ODI’s investigation also prompted Ford to initiate a more in-depth evaluation of the defect, including Ford’s conducting component level testing of high-pressure fuel injectors. ODI met with Ford on several occasions throughout this investigation to jointly conduct certain of these described tasks and to discuss test results. A collateral issue surfaced as a result of this investigation: in March 2025, Ford realized that despite relevant repairs having been recorded as successfully completed, approximately 33,576 vehicles subject to recalls 22V-859 and 24V-187 did not have the software component of the remedy program installed correctly. Thus, on March 27, 2025, Ford filed a new related recall (25V-165) for these vehicles, notifying NHTSA and the public that they were still at risk of experiencing an underhood vehicle fire due to cracked fuel injectors despite the consumer having had their vehicle remedied pursuant to one of the two earlier recalls. In June 2025, Ford committed to implementing a new remedy program to repair the vehicles. On July 11, 2025, Ford documented this commitment in a new recall filing (25V-467), which explains that Ford’s upcoming remedy program will involve proactive replacement of all high-pressure fuel injectors within the recall population. In view of the recall action taken by Ford, ODI is closing this Recall Query, which was opened given NHTSA’s concerns that the initial remedy programs of the software to detect the pressure drop plus installation of the drain tube did not constitute an adequate repair. The agency reserves the right to take additional action if warranted by future circumstances.
PE24002 · Loss Of Motive Power
Opened Jan 31, 2024 · Closed Aug 19, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
On January 31, 2024, the Office of Defects Investigation (ODI) opened PE24002 to investigate allegations of loss of motive power in model year (MY) 2021 Ford Bronco Sport vehicles. At that time, ODI had received 31 Vehicle Owner Questionnaires (VOQs), with consumers commonly reporting a loss of engine power accompanied by complete electrical system failure which occurred either while driving, or after coming to a stop. The investigation revealed that MY 2021-2024 Ford Bronco Sport and certain MY 2022-2023 Ford Maverick vehicles are equipped with a 12V enhanced flooded battery (EFB), which may experience an abrupt failure during a drive cycle. The failure is the result of an internal corrosion issue, which is influenced by long exposure to high under-hood temperatures. If the sudden loss of 12V battery voltage is not detected by the vehicle’s battery management sensor, the vehicle can experience a loss of power event without providing any warning to the driver. Following a loss of power due to battery failure, the vehicle may be without all 12V accessories including hazard lights and typically will not be able to be restarted. In its March 2024 response to ODI’s information request, Ford provided 367 customer complaints (including field reports, lawsuits, and legal claims) and 1005 warranty claims relating to the alleged defect. When combining ODI and manufacturer failure report data, there are 1,368 unique VINs represented across MY 2021-2023 Ford Bronco Sport vehicles. One of the VOQs submitted to NHTSA reported a minor rear-end collision resulting from a loss of power event. Included within Ford’s complaints were a reported single-vehicle collision and a vehicle fire which occurred following a loss of power event at a traffic light (fire cause and origin was not determined). Additionally, across ODI and manufacturer data, there were 12 allegations of either acid leaking from the 12V battery or smoke emitting from the battery area within the engine compartment. On April 12, 2024, Ford submitted recall 24V267 for MY 2021-2024 Ford Bronco Sport and certain MY 2022-2023 Ford Maverick vehicles (total population 456,565). The recall remedy provides updated calibrations to the body control module and powertrain control module. Ford indicated that the update will result in improved detection of 12V battery state of charge during drive cycles and will provide notification to the driver if the battery significantly degrades while driving. Additionally, Ford has replaced the EFB with an absorbed glass mat (AGM) battery as both a service component for the subject vehicles and as original equipment for Bronco Sport vehicles with production dates beginning in mid-March 2024. The warranty claim rate for peer vehicles equipped with an AGM battery is substantially lower than that for the subject vehicle population. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
On January 31, 2024, the Office of Defects Investigation (ODI) opened PE24002 to investigate allegations of loss of motive power in model year (MY) 2021 Ford Bronco Sport vehicles. At that time, ODI had received 31 Vehicle Owner Questionnaires (VOQs), with consumers commonly reporting a loss of engine power accompanied by complete electrical system failure which occurred either while driving, or after coming to a stop. The investigation revealed that MY 2021-2024 Ford Bronco Sport and certain MY 2022-2023 Ford Maverick vehicles are equipped with a 12V enhanced flooded battery (EFB), which may experience an abrupt failure during a drive cycle. The failure is the result of an internal corrosion issue, which is influenced by long exposure to high under-hood temperatures. If the sudden loss of 12V battery voltage is not detected by the vehicle’s battery management sensor, the vehicle can experience a loss of power event without providing any warning to the driver. Following a loss of power due to battery failure, the vehicle may be without all 12V accessories including hazard lights and typically will not be able to be restarted. In its March 2024 response to ODI’s information request, Ford provided 367 customer complaints (including field reports, lawsuits, and legal claims) and 1005 warranty claims relating to the alleged defect. When combining ODI and manufacturer failure report data, there are 1,368 unique VINs represented across MY 2021-2023 Ford Bronco Sport vehicles. One of the VOQs submitted to NHTSA reported a minor rear-end collision resulting from a loss of power event. Included within Ford’s complaints were a reported single-vehicle collision and a vehicle fire which occurred following a loss of power event at a traffic light (fire cause and origin was not determined). Additionally, across ODI and manufacturer data, there were 12 allegations of either acid leaking from the 12V battery or smoke emitting from the battery area within the engine compartment. On April 12, 2024, Ford submitted recall 24V267 for MY 2021-2024 Ford Bronco Sport and certain MY 2022-2023 Ford Maverick vehicles (total population 456,565). The recall remedy provides updated calibrations to the body control module and powertrain control module. Ford indicated that the update will result in improved detection of 12V battery state of charge during drive cycles and will provide notification to the driver if the battery significantly degrades while driving. Additionally, Ford has replaced the EFB with an absorbed glass mat (AGM) battery as both a service component for the subject vehicles and as original equipment for Bronco Sport vehicles with production dates beginning in mid-March 2024. The warranty claim rate for peer vehicles equipped with an AGM battery is substantially lower than that for the subject vehicle population. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical SYSTEM:12V/24V/48V Battery
On January 31, 2024, the Office of Defects Investigation (ODI) opened PE24002 to investigate allegations of loss of motive power in model year (MY) 2021 Ford Bronco Sport vehicles. At that time, ODI had received 31 Vehicle Owner Questionnaires (VOQs), with consumers commonly reporting a loss of engine power accompanied by complete electrical system failure which occurred either while driving, or after coming to a stop. The investigation revealed that MY 2021-2024 Ford Bronco Sport and certain MY 2022-2023 Ford Maverick vehicles are equipped with a 12V enhanced flooded battery (EFB), which may experience an abrupt failure during a drive cycle. The failure is the result of an internal corrosion issue, which is influenced by long exposure to high under-hood temperatures. If the sudden loss of 12V battery voltage is not detected by the vehicle’s battery management sensor, the vehicle can experience a loss of power event without providing any warning to the driver. Following a loss of power due to battery failure, the vehicle may be without all 12V accessories including hazard lights and typically will not be able to be restarted. In its March 2024 response to ODI’s information request, Ford provided 367 customer complaints (including field reports, lawsuits, and legal claims) and 1005 warranty claims relating to the alleged defect. When combining ODI and manufacturer failure report data, there are 1,368 unique VINs represented across MY 2021-2023 Ford Bronco Sport vehicles. One of the VOQs submitted to NHTSA reported a minor rear-end collision resulting from a loss of power event. Included within Ford’s complaints were a reported single-vehicle collision and a vehicle fire which occurred following a loss of power event at a traffic light (fire cause and origin was not determined). Additionally, across ODI and manufacturer data, there were 12 allegations of either acid leaking from the 12V battery or smoke emitting from the battery area within the engine compartment. On April 12, 2024, Ford submitted recall 24V267 for MY 2021-2024 Ford Bronco Sport and certain MY 2022-2023 Ford Maverick vehicles (total population 456,565). The recall remedy provides updated calibrations to the body control module and powertrain control module. Ford indicated that the update will result in improved detection of 12V battery state of charge during drive cycles and will provide notification to the driver if the battery significantly degrades while driving. Additionally, Ford has replaced the EFB with an absorbed glass mat (AGM) battery as both a service component for the subject vehicles and as original equipment for Bronco Sport vehicles with production dates beginning in mid-March 2024. The warranty claim rate for peer vehicles equipped with an AGM battery is substantially lower than that for the subject vehicle population. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration