Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 6 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Power Train. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Wheels. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports0 fire reports1 injury reports
What owners actually said
6 reports
75,857 miles · Aug 22, 2005
Suspension
COIL SPRING ON DRIVERS SIDE BROKE AND WAS SITTING ON TIRE, DEALERSHIP TOWED VAN AND CHARGED ME $415 PLUS TAX, THE VAN IS A LITTLE OVER 850 MILES OVER ITS EXTENDED WARRANTY. I WAS TOLD THAT THIS WAS NOT A SAFETY ISSUE AND NO RECALL FOR THE YEAR 2000. I WAS FORTUNATE THAT THE SPRING BROKE IN MY DRIVE AND NOT GOING DOWN THE THE EXP…
Read full complaint
COIL SPRING ON DRIVERS SIDE BROKE AND WAS SITTING ON TIRE, DEALERSHIP TOWED VAN AND CHARGED ME $415 PLUS TAX, THE VAN IS A LITTLE OVER 850 MILES OVER ITS EXTENDED WARRANTY. I WAS TOLD THAT THIS WAS NOT A SAFETY ISSUE AND NO RECALL FOR THE YEAR 2000. I WAS FORTUNATE THAT THE SPRING BROKE IN MY DRIVE AND NOT GOING DOWN THE THE EXPRESSWAY AT 70 MILES AN HOUR, OR WHEN MY DAUGHTER, WHOM JUST RECIEVED HER DRIVERS PERMIT WAS DRIVING. I WOULD ALSO LIKE TO MENTION THAT I HAD MY VAN IN FOR SERVICE ON 7/01/05 FOR NOISES IN THE FRONT END AND VIBRATIONS WHILE DRIVING. DEALER REPLACED SWAY BAR, AND BALANCED TIRES. (VAN WAS STILL UNDER WARRANTY) THIS TOOK CARE OF SOME OF THE PROBLEM. I HAVE HAD ONGOING PROBLEMS WITH THE FRONT END OF THIS VAN. THE TIE RODS HAVE BEEN REPLACED A NUMBER OF TIMES. I WAS TOLD THAT THIS WAS A PROBLEM WITH THE FORD TIE RODS AND ONCE MY WARRANTY WAS UP I SHOULD HAVE AFTER MARKET TIE RODS INSTALLED. SEEMS TO ME THAT THIS IS A PROBLEM THAT FORD MOTOR COMPANY SHOULD BE REQUIRED TO FIX.
NHTSA ODI #10133757
Mileage unknown · Nov 3, 2004
Service Brakes, Hydraulic
CONSUMER APPLIED THE BRAKES AND PEDAL WENT TO THE FLOOR. THE BRAKES HAD LESS BRAKING POWER. CONSUMER TOOK THE VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT BRAKES PADS AND ROTORS NEEDED TO BE REPLACED. *AK *TC
NHTSA ODI #10095303
20,321 miles · Jan 15, 2004
Power TrainTiresWheels
4R100 TRANSMISSION HAD PROBLEMS SINCE 33602 MILES HARD SHIFTING INTO 3-4 AND WAS TOLD EVERY THING WAS NORMAL.STARTED TO HAVE MORE PROBLEMS AT 83521 AND WAS TOLD DRIVE IT AND SEE IF IT GETS WORSE AT 85953 TOOK IT TO FORD AND LEFT IT AND THEY SAID I NEED A TRANS. BUT FORD CHARGED ME $437.27 . I WAS TOLD I GOT MORE OUT OF THE TRAN…
Read full complaint
4R100 TRANSMISSION HAD PROBLEMS SINCE 33602 MILES HARD SHIFTING INTO 3-4 AND WAS TOLD EVERY THING WAS NORMAL.STARTED TO HAVE MORE PROBLEMS AT 83521 AND WAS TOLD DRIVE IT AND SEE IF IT GETS WORSE AT 85953 TOOK IT TO FORD AND LEFT IT AND THEY SAID I NEED A TRANS. BUT FORD CHARGED ME $437.27 . I WAS TOLD I GOT MORE OUT OF THE TRANS THAN MOST GET. THIS TRANS HAS A 90% PREMATURE FAILURE.FORD REFUSES TO HELP IN ANY WAY TO REPLACE THE TRANS.
NHTSA ODI #10070512
Mileage unknown · Jan 15, 2004
Wheels
REAR WHEEL BEARINGS
NHTSA ODI #10069590
60,005 miles · Jan 15, 2004
Air BagsEngine And Engine CoolingEquipmentCrashInjury
ACCELERATOR STUCK, CAR CONTINUED TO THROTTLE EVEN AFTER BRAKE WAS HEAVILY APPLIED. UPON FRONT IMPACT INTO TREE AND ROLLOVER TO DRIVER'S SIDE, NO AIR BAGS DEPLOYED. CAR WAS TOTALLED OUT DUE TO CRASH DAMAGE - NO ATTEMPT TO REPAIR.
NHTSA ODI #10068933
Mileage unknown · Oct 24, 2001
Power TrainCrash
THIS WAS SECOND TIME THAT VEHICLE TOOK OFF FORWARD WHILE SHIFT LEVER WAS IN REVERSE. ONCE VEHICLE TOOK OFF, CONSUMER LOST CONTROL AND WENT THROUGH SOME BUSHES, AND ALMOST WENT INTO A BUILDING. CONSUMER FELT SOMEONE COULD HAVE BEEN KILLED.*AK
NHTSA ODI #898114
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2000 Ford Aerostar Problems, Complaints & Recalls | Skip That Year
Illustration