IllustrationPURCHASED NEW=OCT.2004.......... 2005 FLEETWOOD TRAVEL TRAILER 25RKS......... MFG. INSTALLED INADEQUATE TIRES............ VEH.GVWR= 7250 LB.... TIRES MAX= 7280 LB LOAD C......... THREE TIRES POP SIDEWALLS WITHIN 1 YR......... VERY DANGEROUS HIGHWAY POTENTIALS........ MFG. SHOULD USE LOAD D FOR GVWR 7250 LB...
2005 Fleetwood Wilderness
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Wilderness years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 6 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Equipment. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports1 fire reports0 injury reports
What owners actually said
6 reportsVEHICLE CAUGHT FIRE DURING DELIVERY. UPON FURTHER INVESTIGATION, IT WAS FOUND THAT THE MAIN WIRING HARNESS WAS INCORRECTLY ROUTED / CLAMPED BETWEEN CHASSIS AND FLOORING. THIS CAUSED THE HARNESS WIRING TO SHORT OUT AND CAUSE A FIRE IN THE FLOORING / INSULATION. DAMAGE INCLUDED SMOKE, REROUTING / REPAIR OF BURNT HARNESS, REPAIR OF…
Read full complaint
VEHICLE CAUGHT FIRE DURING DELIVERY. UPON FURTHER INVESTIGATION, IT WAS FOUND THAT THE MAIN WIRING HARNESS WAS INCORRECTLY ROUTED / CLAMPED BETWEEN CHASSIS AND FLOORING. THIS CAUSED THE HARNESS WIRING TO SHORT OUT AND CAUSE A FIRE IN THE FLOORING / INSULATION. DAMAGE INCLUDED SMOKE, REROUTING / REPAIR OF BURNT HARNESS, REPAIR OF SLIDE SWITCH, SLIDE SWITCH HARNESS, SLIDE SWITCH CONNECTOR, SLIDE SWITCH MOTOR, SEVERAL FUSES, INCLUDING THOSE ON THE TOW VEHICLE. HARNESS HAS BEEN REROUTED AND REPAIRED. FUSES HAVE BEEN REPLACED AS WELL. REMAINING PARTS HAVE NOT BEEN REPLACED PENDING AVAILABILITY FROM FLEETWOOD. *TR
TL*THE CONTACT OWNS A 2005 FLEETWOOD WILDERNESS. SIX MONTHS AFTER PURCHASING THE VEHICLE, THE DOMETIC REFRIGERATOR FAILED AND ALMOST CAUSED A FIRE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 06E076000 (EQUIPMENT:RECREATIONAL VEHICLE). THE CURRENT AND FAILURE MILEAGES WERE 5,400. NO ADDITIONAL INFORMATION WAS AVAILA…
Read full complaint
TL*THE CONTACT OWNS A 2005 FLEETWOOD WILDERNESS. SIX MONTHS AFTER PURCHASING THE VEHICLE, THE DOMETIC REFRIGERATOR FAILED AND ALMOST CAUSED A FIRE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 06E076000 (EQUIPMENT:RECREATIONAL VEHICLE). THE CURRENT AND FAILURE MILEAGES WERE 5,400. NO ADDITIONAL INFORMATION WAS AVAILABLE FOR THE TRAILER.
TL*THE CONTACT OWNS A 2005 FLEETWOOD WILDERNESS. THE CONTACT STATED THAT THE BODY OF THE CAMPER WAS NOT LEVEL WITH THE BODY OF THE VEHICLE. HE NOTICED A CRACK ON THE C-CHANNEL FRAME, WHICH SHEARED THE BOLTS THAT HELD THE CAMPER. HE STATED THAT THE REAR LATCHES FOR THE REAR DOOR BENT AND HE BELIEVED THAT THE SHEARED BOLTS CAUS…
Read full complaint
TL*THE CONTACT OWNS A 2005 FLEETWOOD WILDERNESS. THE CONTACT STATED THAT THE BODY OF THE CAMPER WAS NOT LEVEL WITH THE BODY OF THE VEHICLE. HE NOTICED A CRACK ON THE C-CHANNEL FRAME, WHICH SHEARED THE BOLTS THAT HELD THE CAMPER. HE STATED THAT THE REAR LATCHES FOR THE REAR DOOR BENT AND HE BELIEVED THAT THE SHEARED BOLTS CAUSED THE FAILURE. AS OF SEPTEMBER 10, 2007, THE DEALER HAD NOT INSPECTED THE VEHICLE. THE MILEAGE AND ENGINE INFORMATION WERE NOT APPLICABLE.
EVENTS: TOWED 27' FLEETWOOD TRAVEL TRAILER FROM HEWITT, TX TO RED RIVER, NM. FAILURE: STEEL FRAME WHICH HOLDS REAR BUMPER AND ALSO HOLDS SPARE TIRE BEGAN TEARING OFF FRAME OF TRAVEL TRAILER, EVENTUALLY IF NOT CAUGHT IN TIME BUMPER W/SPARE TIRE ATTACHED WOULD HAVE DETACHED FROM TRAILER. CORRECTIVE ACTION: TOOK TO DEALER, FLEETW…
Read full complaint
EVENTS: TOWED 27' FLEETWOOD TRAVEL TRAILER FROM HEWITT, TX TO RED RIVER, NM. FAILURE: STEEL FRAME WHICH HOLDS REAR BUMPER AND ALSO HOLDS SPARE TIRE BEGAN TEARING OFF FRAME OF TRAVEL TRAILER, EVENTUALLY IF NOT CAUGHT IN TIME BUMPER W/SPARE TIRE ATTACHED WOULD HAVE DETACHED FROM TRAILER. CORRECTIVE ACTION: TOOK TO DEALER, FLEETWOOD MOTOR HOMES CLAIMED IT WAS NOT A STRUCTURAL OR INSTALLATION DEFECT EVEN THOUGH ANCIRA DEALERSHIP ALSO AGREED THIS WAS FACTORY FLAW IN THE DESIGN/INSTALLATION. *NM
MY HUSBAND AND I PURCHASED A 2005 5TH WHEEL FLEETWOOD GEARBOX. WE FILLED OUR WATER TANK AND IT CAUSED THE HOLDING BRACKETS AND THE FLOOR TO BEND. WE TOOK IT BACK TO EARNHARTS SERVICE DEPT AND THEY SAID THEY WOULD NOT WARRANTY THE BRACKETS OR FLOOR. MY CONCERN IS IF THEY ARE GOING TO ALLOW YOU TO FILL YOU TANK TO 120 GALLONS AND …
Read full complaint
MY HUSBAND AND I PURCHASED A 2005 5TH WHEEL FLEETWOOD GEARBOX. WE FILLED OUR WATER TANK AND IT CAUSED THE HOLDING BRACKETS AND THE FLOOR TO BEND. WE TOOK IT BACK TO EARNHARTS SERVICE DEPT AND THEY SAID THEY WOULD NOT WARRANTY THE BRACKETS OR FLOOR. MY CONCERN IS IF THEY ARE GOING TO ALLOW YOU TO FILL YOU TANK TO 120 GALLONS AND THE BRACKETS BEND THEN THAT IS A MAJOR PROBLEM. I THANK GOD THE BRACKETS DIDN'T BRAKE AND THE WATER TANK DIDN'T FALL OUT WHILE DRIVING AND KILL SOMEONE. I BELIEVE THIS IS A MANUFACTURE DEFECT THAT NEEDS TO BE FIXED. MAKE STRONGER BRACKETS FOR THE HOLDING TANK BEFORE SOMEONE IS KILLED OR INJURED. IF THEY MAKE THE TANK TO HOLD THAT MUCH WATER THE BRACKETS SHOULD NOT BEND THEY TO SHOULD HOLD THAT MUCH WEIGHT. *NM
Official recalls
308V320000 · Equipment:recreational Vehicle/trailer
Jul 15, 2008
FLEETWOOD IS RECALLING 70,101 MY 2003-2007 SOUTHWIND, PACE ARROW, BOUNDER, FLAIR, STORM, FIESTA, TERRA GAS CLASS A MOTOR HOMES; BOUNDER, DISCOVERY, PROVIDENCE, EXCURSION, EXPEDITION, REVOLUTION, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION DIESEL CLASS A MOTOR HOMES; JAMBOREE TIOGA CLASS C MOTOR HOMES; AND PROWLER, WILDERNESS, TERRY, MALLARD, PIONEER, PRIDE AND TRIUMPH CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATORS MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence & remedy
Consequence: IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.
Remedy: FLEETWOOD IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.
05V433000 · Equipment:recreational Vehicle/trailer:lpg Systems:lines And Fittings
Sep 27, 2005
ON CERTAIN FIFTH WHEEL TRAILERS, THE PROPANE GAS LINES THAT RUN THROUGH THE FLOOR OF THE SLIDE OUT ROOM PENETRATE THE FLOOR TOO FAR FROM THE OUTSIDE WALL CAUSING THE POTENTIAL FOR PINCHED LINES DURING SLIDE OUT ROOM OPERATION.
Consequence & remedy
Consequence: THIS COULD LEAD TO A PROPANE GAS LEAK AND THE POTENTIAL FOR AN EXPLOSION AND/OR FIRE.
Remedy: DEALERS WILL INSPECT AND, AS NECESSARY, REROUTE THE PROPANE GAS LINE. THIS RECALL BEGAN ON OCTOBER 24, 2005. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
05V289000 · Structure
Jun 21, 2005
CERTAIN FIFTH WHEEL TRAVEL TRAILERS HAVE MISSING WELDS ON THE CHASSIS CROSS-MEMBERS.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE CROSS-MEMBER TO BECOME DISLODGED, CREATING A ROAD HAZARD IF THE FIFTH WHEEL TRAVEL TRAILER IS IN MOTION, WHICH COULD RESULT IN A CRASH.
Remedy: LIPPERT COMPONENTS, IN CONJUNCTION WITH FLEETWOOD, WILL INSPECT THE CROSS-MEMBERS FOR MISSING WELDS, REPAIR THE WELDS IF NECESSARY, AND ADD ADDITIONAL SUPPORT TO THE AFFECTED AREA. OWNERS MAY CONTACT LIPPERT DIRECTLY AT 1-866-524-7821 TO MAKE ARRANGEMENTS TO HAVE THIS INSPECTION AND REPAIR PERFORMED. THE RECALL BEGAN ON AUGUST 4, 2005.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE06005 · Inadvertent SLIDE-OUT Extension Movement
Opened Jan 20, 2006 · Closed May 2, 2006
Status: closed (inferred from source dates) · Equipment:recreational Vehicle/trailer
THIS INVESTIGATION WAS OPENED BASED ON ODI'S RECEIPT OF A CONGRESSIONAL LETTER ON BEHALF OF A CONSTITUENT.THE CONSTITUENT REPORTED INCIDENTS WHERE THE SLIDE OUT ROOM OF HIS MOTOR HOME WOULD INADVERTENTLY MOVE (EXTEND) DURING HIGHWAY USE.ODI WAS CONCERNED THAT A FULLY EXTENDED SLIDE OUT WOULD DEGRADE THE VEHICLE'S DYNAMIC HANDLING CHARACTERISTICS AND/OR POSSIBLY IMPACT AN OBJECT OR ANOTHER VEHICLE, RESULTING IN A CRASH.ODI CONTACTED FLEETWOOD AND DISCOVERED THAT SLIDE OUT ROOMS WERE INSTALLED IN MOTOR HOMES, TRAVEL TRAILERS AND FOLDING TRAILERS. AS PART OF THE INVESTIGATION ODI VISITED A RV SHOW AND THE FLEETWOOD PAXINOS PLANT TO EXAMINE SLIDE OUTS IN VARIOUS NEW MAKE AND MODEL VEHICLES AND GAIN AN UNDERSTANDING OF HOW THE SYSTEMS WORK.DURING THE INVESTIGATION ODI LEARNED THAT THERE ARE TWO METHODS USED TO EXTEND SLIDE OUT ROOMS.SOME MANUFACTURERS USE HYDRAULIC SYSTEMS AND OTHERS, SUCH AS FLEETWOOD, USE AN ELECTRIC MOTOR. (CONTINUED ON PAGE 2)