FUEL INJECTION PUMP FAILURE DUE TO INADEQUATE FUEL DELIVERY. THIS PUMP IS A BOSCH VP44 PUMP AND ACCORDING TO THE CUMMINS BLOG WEBSITES AND THE FACTORY AUTHORIZED DEALER, THIS PART HAS A 100% FAILURE RATE. WHEN THE PUMP FAILS THE ENGINE SHUTS OFF AND DOESN'T RESTART. MY VEHICLE IS A 25000 POUND MOTOR HOME, AND WHEN IT DIES OUT…
Read full complaint
FUEL INJECTION PUMP FAILURE DUE TO INADEQUATE FUEL DELIVERY. THIS PUMP IS A BOSCH VP44 PUMP AND ACCORDING TO THE CUMMINS BLOG WEBSITES AND THE FACTORY AUTHORIZED DEALER, THIS PART HAS A 100% FAILURE RATE. WHEN THE PUMP FAILS THE ENGINE SHUTS OFF AND DOESN'T RESTART. MY VEHICLE IS A 25000 POUND MOTOR HOME, AND WHEN IT DIES OUT AT FREEWAY SPEEDS CAN BE VERY DANGEROUS. BOSCH AND CUMMINS KNOW ABOUT THE PROBLEM, BUT ARE UNWILLING TO ASSIST THE CUSTOMER IN ANY WAY EVEN THOUGH THEY ADMIT THAT IT IS A DESIGN FAULT. IN THEIR WORDS "WE ADMIT THAT IT WASN'T OUR BEST DESIGN". ACCORDING TO THE BLOGS THIS IS THE ISSUE: THE MOST COMMON MECHANICAL FAILURE OF THE VP44 PUMP IS RUPTURING OF THE DIAPHRAGM IN THE FRONT OF THE INJECTION PUMP. THE DIAPHRAGM RUPTURES ALLOWING THE TIMING PISTON TO VIBRATE AND DAMAGE THE FRONT COVER UNTIL FUEL BYPASSES. THIS WILL CAUSE THE DREADED CHECK ENGINE TROUBLE CODE P0216. WHEN THIS OCCURS YOUR BOSCH VP44 INJECTION PUMP MUST BE REPLACED. THE RUPTURING OF THE DIAPHRAGM IS CAUSED BY A POORLY DESIGNED LIFT PUMP. WHEN THE LIFT PUMP DOES NOT SUPPLY THE INJECTION PUMP WITH THE CORRECT AMOUNT OF FUEL PRESSURE (A MINIMUM OF 5PSI UNDER LOAD AT WIDE OPEN THROTTLE) THE DIAPHRAGM THEN DOESN'T HAVE ENOUGH POSITIVE PRESSURE AND RUPTURES. DODGE HAS RECOGNIZED THIS PROBLEM AS THEY WILL NO LONGER EVEN SELL THE LIFT PUMP THAT GOES ON THE SIDE OF THE BLOCK, THEY REPLACE IT WITH A UNIT THAT IS NOW MOUNTED IN THE TANK. I HAVE ASKED FOR ASSISTANCE BUT WAS OFFERED NOTHING. THE COST TO CHANGE THIS PART IS OVER $3000.00 DOLLARS, BUT EVEN MORE IMPORTANT IS THE FACT THAT THEY HAVE A DESIGN WHICH IS INHERENTLY DANGEROUS. HAD THIS HAPPENED 10 MILES LATER, I WOULD HAVE BEEN HALF WAY UP A MOUNTAIN ROAD. ON A DIESEL MOTOR HOME WHEN THE ENGINE DIES, YOU LOOSE BRAKES, POWER EVERYTHING.
NHTSA ODI #10465001
46,385 miles · Mar 22, 2006
Engine And Engine CoolingFuel System, Gasoline
DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS THE VEHICLE SLOWS DOWN AS IF IT IS LOOSING POWER. THE DEALER WAS ALERTED. THEY HAVE REPLACED THE FUEL PUMP TWICE HOWEVER THIS DID NOT CORRECT THE PROBLEM. THE MANUFACTURER WAS ALERTED. *AK THE ENGINE STALLED. UPDATED 04/06/06
NHTSA ODI #10153429
Mileage unknown · Jun 21, 2001
Engine And Engine Cooling
THE PROBLEM OF FAILED HEATER HOSE CLAMPS ON THE 6.8 L ENGINE WAS WELL KNOWN TO THE FORD AGENCY WHICH REPAIRED IT UNDER WARRANTY. THE PROBLEM HAS ALSO BEEN DISCUSSED IN THE TECHNICAL COLUMNS OF RV MAGAZINES. THE FAILED CLAMP WAS REPLACED BY ONE OF SIMILAR DESIGN AND OTHERS REMAIN ON THE ENGINE. OBVIOUS DANGEROUS SITUATIONS CAN AR…
Read full complaint
THE PROBLEM OF FAILED HEATER HOSE CLAMPS ON THE 6.8 L ENGINE WAS WELL KNOWN TO THE FORD AGENCY WHICH REPAIRED IT UNDER WARRANTY. THE PROBLEM HAS ALSO BEEN DISCUSSED IN THE TECHNICAL COLUMNS OF RV MAGAZINES. THE FAILED CLAMP WAS REPLACED BY ONE OF SIMILAR DESIGN AND OTHERS REMAIN ON THE ENGINE. OBVIOUS DANGEROUS SITUATIONS CAN ARISE WITH FAILED HOSE CLAMPS.
NHTSA ODI #747210
Mileage unknown · Oct 19, 2000
Engine And Engine Cooling
CONSUMER HAS ONLY FILLED TANK 3 TIMES SINCE OWNING IT. EVERY TIME HAS NOTICED GAS LEAKING. FLEETWOOD DEALER REPAIRED THE OVERFLO TUBE.*AK
CERTAIN MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence & remedy
Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy: FLEETWOOD WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.
ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.
Consequence & remedy
Consequence: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.
Remedy: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR FLEETWOOD AT 1-800-629-8454.
CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.
Consequence & remedy
Consequence: IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.
Remedy: DEALERS WILL REPAIR THESE VEHICLES. OWNER NOTIFICATION BEGAN APRIL 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FLEETWOOD AT 1-800-445-3307.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2000 Fleetwood Bounder Problems, Complaints & Recalls | Skip That Year
Illustration