CONSUMER STATES THAT THERE IS A PROBLEM WITH THE GENERATOR MAKING NOISES. DEALER WAS NOTIFIED. THE FUEL LINE WAS CRACKED. CONSUMER HAD TO CHANGE FUEL LINE TO THE COACH GENERATOR (110VAC-5.5 KVA) *MR THE CONSUMER STATES THAT THE FUEL LINE IS INSTALLED FROM OEM CHASIS CHEVROLET TO THE COACH GENERATOR BY FLEETWOOD AND HAS A MA…
Read full complaint
CONSUMER STATES THAT THERE IS A PROBLEM WITH THE GENERATOR MAKING NOISES. DEALER WAS NOTIFIED. THE FUEL LINE WAS CRACKED. CONSUMER HAD TO CHANGE FUEL LINE TO THE COACH GENERATOR (110VAC-5.5 KVA) *MR THE CONSUMER STATES THAT THE FUEL LINE IS INSTALLED FROM OEM CHASIS CHEVROLET TO THE COACH GENERATOR BY FLEETWOOD AND HAS A MATERIAL MANUFACTURING DEFECT WHICH RESULTS IN AN UNSAFE CONDITION ALLOWING HYDRO CARBONS TO VENT INTO THE ATMOSPHERE AND POTENTIALLY ALLOWING THE FUEL TO ESCAPE TO THE HOT SUFACES OF THE ONAN GENERATOR, WHICH CAN RESULT IN A FIRE/PERSONAL INJURY AND OR DEATH. *SCC
NHTSA ODI #8019625
Mileage unknown · Sep 16, 2002
Electrical SystemFuel System, Other
A REPAIR MAN CHANGING A FLAT TIRE DISCOVERED THE PROPANE LINE LOCATED IN FRONT OF THE WHEEL WAS BROKEN AND THE WIRE HARNESS ABOVE THE WHEEL WELL COVER WAS SPLIT, THE PROTECTIVE COVER OVER THE WHEEL WAS DESTROYED. THE MANUFACTURER REFUSED TO PAY THE DEALER TO LOOK AT THE DEFECT BECAUSE VEHICLE WAS OUT OF WARRANTY. CONSUMER WIL…
Read full complaint
A REPAIR MAN CHANGING A FLAT TIRE DISCOVERED THE PROPANE LINE LOCATED IN FRONT OF THE WHEEL WAS BROKEN AND THE WIRE HARNESS ABOVE THE WHEEL WELL COVER WAS SPLIT, THE PROTECTIVE COVER OVER THE WHEEL WAS DESTROYED. THE MANUFACTURER REFUSED TO PAY THE DEALER TO LOOK AT THE DEFECT BECAUSE VEHICLE WAS OUT OF WARRANTY. CONSUMER WILL SEEK LEGAL REIMBURSEMENT FOR MONIES PAID. *JG
NHTSA ODI #567457
Mileage unknown · Aug 21, 2002
Electrical SystemFuel System, GasolineTires
I WILL MAKE THIS SHORT. I OWN A RV MADE BY FLEETWOOD. GOING TO FLORIDA WITH FAMILY WE HAD A FLAT TIRE. THE TIRE TORE UP WHEEL WELL COVER AND THEN DESTROYED A MAIN WIRING HARNESS WITH BOTH AC/DC POWER. THE MAIN CONCERN WAS IT ALSO BROKE A GAS LINE, THAT COULD HAVE CAUSED AN EXPLOSION FROM THE SPARKING WIRES. THE MANUFACTURER…
Read full complaint
I WILL MAKE THIS SHORT. I OWN A RV MADE BY FLEETWOOD. GOING TO FLORIDA WITH FAMILY WE HAD A FLAT TIRE. THE TIRE TORE UP WHEEL WELL COVER AND THEN DESTROYED A MAIN WIRING HARNESS WITH BOTH AC/DC POWER. THE MAIN CONCERN WAS IT ALSO BROKE A GAS LINE, THAT COULD HAVE CAUSED AN EXPLOSION FROM THE SPARKING WIRES. THE MANUFACTURER HAS TOLD ME TO GO TO HELL, THAT THEY WOULD NOT PAY A DIME FOR REPAIR SINCE THE VEHICLE IS OUT OF WARRANTY. THIS IS WRONG AND NEEDS TO BE INVESTIGATED AS MY FAMILY AND I COULD HAVE BEEN INJURED OR EVEN KILLED FROM A GAS EXPLOSION.*AK
NHTSA ODI #765975
Mileage unknown · Dec 5, 1999
Electrical System
THE GENERATOR EXHAUST OUR 1998 BOUNDER 32K SEEPS BACK INTO THE MOTOHOME AND RAISES THE CO2 LEVELS TO UNSAFE LEVELS. THIS RESULTS IN THE CO2 DETECTOR BEING SET OFF. THIS HAS HAPPENED EVERY TIME WE HAVE USED OUR MOTORHOME.
NHTSA ODI #715665
Mileage unknown · Jul 19, 1999
Electrical SystemEquipmentLatches/locks/linkages
SLIDE OUT WOULD GO IN AND OUT WITHOUT THE KEY IN CONTROL. MJS
NHTSA ODI #547370
Mileage unknown · Jun 6, 1998
Electrical System
WHILE CAMPING SMELLED SOMETHING BURNING. FOUND WIRES WERE TOO CLOSELY TOGETHER, THEY SHORTED OUT AND BURNED .
CERTAIN MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence & remedy
Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy: FLEETWOOD WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.
VEHICLE DESCRIPTION: CLASS A MOTOR HOMES. THESE MOTOR HOMES, WHEN FULLY EQUIPPED AND LOADED WITH TYPICAL CARGO, WILL EXPERIENCE AN OVERLOADED CONDITION ON THE REAR AXLE.
Consequence & remedy
Consequence: THIS COULD CAUSE THE REAR AXLE COMPONENTS TO FAIL PREMATURELY RESULTING IN LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE WITH A NEW HIGHER CAPACITY REAR AXLE.
VEHICLE DESCRIPTION: CLASS A MOTOR HOMES. THE HYDRAULIC HOSES WHICH OPERATE THE LEVELING JACK SYSTEM IS ROUTED TOO CLOSE TO THE ENGINE EXHAUST MANIFOLD CAUSING THE HOSE TO MELT, RELEASING HYDRAULIC FLUID.
Consequence & remedy
Consequence: THIS HYDRAULIC FLUID CAN IGNITE IN THE ENGINE COMPARTMENT CAUSING A FIRE.
Remedy: DEALERS WILL INSPECT, REPLACE ANY DAMAGED HOSES, AND RELOCATE THE AFFECTED HYDRAULIC LINES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE07055 · Gasoline Supply Line To Gen'r Seepage
Opened Nov 14, 2007 · Closed Mar 14, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI'S INVESTIGATION HAS FOUND THAT THE 1/4 INSIDE DIAMETER FUEL HOSE THAT PROVIDES GASOLINE TO THE VEHICLE'S ON-BOARD GENERATOR CAN CRACK AND SEEP FUEL. COMPLAINT SUMMARIES INDICATE THAT OWNERS HAVE TYPICALLY DETECTED A SEEPING FUEL LINE THROUGH (1) THE ODOR OF RAW GASOLINE FUMES AND/OR (2) ERRATIC OR NON-START GENERATOR PERFORMANCE.ODI HAS FOUND THAT THE FUEL IN THE GENERATOR FUEL SUPPLY HOSE IS PULLED INTO THE GENERATOR BY SUCTION SO THE GENERATOR IS LIKELY TO PULL AIR INTO THE FUEL LINE THROUGH MINOR CRACKS IN THE FUEL LINE CAUSING ERRATIC GENERATOR PERFORMANCE WELL BEFORE THE CRACKS WILL INCREASE IN SIZE SUFFICIENTLY TO SEEP SIGNIFICANT AMOUNTS OF GASOLINE.RISK OF FIRE IS NEGLIGIBLE SINCE THE VOLUME OF FUEL SEEPAGE IS SMALL AND THE SEEPAGE IS UNLIKELY TO SPRAY BECAUSE THE FUEL LINE IS NOT PRESSURIZED.ALSO, THE FUEL TANK , GENERATOR, AND FUEL LINES ARE MOUNTED AT THE REAR OF THE VEHICLE DISTANT FROM HOT ENGINE PARTS AND/OR ANY OTHER LIKELY SOURCES OF IGNITION. FLEETWOOD HAS INFORMED ODI THAT THEY INTEND TO PROVIDE ANOTIFICATION TO AFFECTED OWNERS THAT (1) ADVISES THAT THE GENERATOR FUEL LINE SHOULD BE INSPECTED FREQUENTLY AND (2) DESCRIBES THE SYMPTOMS OF A DETERIORATING FUEL LINE SO THAT AFFECTED OWNERS WILL RECOGNIZE THE SYMPTOMS INDICATING A FUEL LINE LEAK OR SEEP HAS, OR IS ABOUT TO OCCUR, SO THE OWNERS MAY APPROPRIATELY DIAGNOSE AND RESPOND BY CORRECTING THE PROBLEM.
Additional source detail variants (2)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI'S INVESTIGATION HAS FOUND THAT THE 1/4 INSIDE DIAMETER FUEL HOSE THAT PROVIDES GASOLINE TO THE VEHICLE'S ON-BOARD GENERATOR CAN CRACK AND SEEP FUEL. COMPLAINT SUMMARIES INDICATE THAT OWNERS HAVE TYPICALLY DETECTED A SEEPING FUEL LINE THROUGH (1) THE ODOR OF RAW GASOLINE FUMES AND/OR (2) ERRATIC OR NON-START GENERATOR PERFORMANCE.ODI HAS FOUND THAT THE FUEL IN THE GENERATOR FUEL SUPPLY HOSE IS PULLED INTO THE GENERATOR BY SUCTION SO THE GENERATOR IS LIKELY TO PULL AIR INTO THE FUEL LINE THROUGH MINOR CRACKS IN THE FUEL LINE CAUSING ERRATIC GENERATOR PERFORMANCE WELL BEFORE THE CRACKS WILL INCREASE IN SIZE SUFFICIENTLY TO SEEP SIGNIFICANT AMOUNTS OF GASOLINE.RISK OF FIRE IS NEGLIGIBLE SINCE THE VOLUME OF FUEL SEEPAGE IS SMALL AND THE SEEPAGE IS UNLIKELY TO SPRAY BECAUSE THE FUEL LINE IS NOT PRESSURIZED.ALSO, THE FUEL TANK , GENERATOR, AND FUEL LINES ARE MOUNTED AT THE REAR OF THE VEHICLE DISTANT FROM HOT ENGINE PARTS AND/OR ANY OTHER LIKELY SOURCES OF IGNITION. FLEETWOOD HAS INFORMED ODI THAT THEY INTEND TO PROVIDE ANOTIFICATION TO AFFECTED OWNERS THAT (1) ADVISES THAT THE GENERATOR FUEL LINE SHOULD BE INSPECTED FREQUENTLY AND (2) DESCRIBES THE SYMPTOMS OF A DETERIORATING FUEL LINE SO THAT AFFECTED OWNERS WILL RECOGNIZE THE SYMPTOMS INDICATING A FUEL LINE LEAK OR SEEP HAS, OR IS ABOUT TO OCCUR, SO THE OWNERS MAY APPROPRIATELY DIAGNOSE AND RESPOND BY CORRECTING THE PROBLEM.
Fuel System, Gasoline
ODI'S INVESTIGATION HAS FOUND THAT THE 1/4 INSIDE DIAMETER FUEL HOSE THAT PROVIDES GASOLINE TO THE VEHICLE'S ON-BOARD GENERATOR CAN CRACK AND SEEP FUEL. COMPLAINT SUMMARIES INDICATE THAT OWNERS HAVE TYPICALLY DETECTED A SEEPING FUEL LINE THROUGH (1) THE ODOR OF RAW GASOLINE FUMES AND/OR (2) ERRATIC OR NON-START GENERATOR PERFORMANCE.ODI HAS FOUND THAT THE FUEL IN THE GENERATOR FUEL SUPPLY HOSE IS PULLED INTO THE GENERATOR BY SUCTION SO THE GENERATOR IS LIKELY TO PULL AIR INTO THE FUEL LINE THROUGH MINOR CRACKS IN THE FUEL LINE CAUSING ERRATIC GENERATOR PERFORMANCE WELL BEFORE THE CRACKS WILL INCREASE IN SIZE SUFFICIENTLY TO SEEP SIGNIFICANT AMOUNTS OF GASOLINE.RISK OF FIRE IS NEGLIGIBLE SINCE THE VOLUME OF FUEL SEEPAGE IS SMALL AND THE SEEPAGE IS UNLIKELY TO SPRAY BECAUSE THE FUEL LINE IS NOT PRESSURIZED.ALSO, THE FUEL TANK , GENERATOR, AND FUEL LINES ARE MOUNTED AT THE REAR OF THE VEHICLE DISTANT FROM HOT ENGINE PARTS AND/OR ANY OTHER LIKELY SOURCES OF IGNITION. FLEETWOOD HAS INFORMED ODI THAT THEY INTEND TO PROVIDE ANOTIFICATION TO AFFECTED OWNERS THAT (1) ADVISES THAT THE GENERATOR FUEL LINE SHOULD BE INSPECTED FREQUENTLY AND (2) DESCRIBES THE SYMPTOMS OF A DETERIORATING FUEL LINE SO THAT AFFECTED OWNERS WILL RECOGNIZE THE SYMPTOMS INDICATING A FUEL LINE LEAK OR SEEP HAS, OR IS ABOUT TO OCCUR, SO THE OWNERS MAY APPROPRIATELY DIAGNOSE AND RESPOND BY CORRECTING THE PROBLEM.
1998 Fleetwood Bounder Problems, Complaints & Recalls | Skip That Year
Illustration