2016 Fiat 500X

I am submitting this complaint to report a failure related to an emissions recall repair. The vehicle identified by VIN [XXX] was fully operable, properly maintained, and in excellent condition prior to an emissions recall repair performed by an authorized dealership. Immediately after the recall “fix” was completed, the vehicle began experiencing serious operational problems and became undrivable. The servicing dealership towed the vehicle and attempted an additional repair. After the vehicle was returned, it failed again on its first use and is now completely inoperable. Despite the fact that this failure occurred only after the recall repair, the dealership and manufacturer are refusing to assume responsibility for towing and correction unless the owner pays to have the vehicle towed more than 75 miles to another location. We do not believe it is appropriate for the owner to bear the cost of correcting a defect that arose directly from recall work. Another authorized dealership has advised that responsibility remains with the dealer that performed the recall repair. The original servicing dealer has now stated they are “not responsible,” despite having performed the recall work. This situation has left the vehicle undrivable and created a significant hardship, and we believe it represents a recall remedy failure. I spoke with the service manager at the dealership and he said it is up to me to prove that they did the damage to the car. The vehicle was operable before the recall repair The vehicle became inoperable immediately after the recall repair The recall is still showing as open The dealer already acknowledged a problem by towing it once and attempting a second repair That establishes prima facie responsibility. In plain English: 👉 Cause-and-effect is already evident. We are requesting that NHTSA document this issue and review the manufacturer’s handling of this recall repair. Thank you for your attention to this matter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (F

I am writing to you in regard to my 2016 FIAT 500X about multiple concerns. 1. There has been an open recall on the Emissions system since 2022. I immediately followed up and was put on a waitlist as I was told that the parts were on back order. I was told I was 27 on the waitlist. I followed up every 3-6 months for an update on getting the recall repaired but was told they have no update on the parts. It is now 2025 and my registration and inspection are expired. I was informed by FIAT service mechanic that the open recall should not impact my inspection. Upon bringing it in for inspection, I needed to get the thermostat replaced, which was one of the first recalls that was rectified upon purchasing the car in 2017. My car failed inspection. I followed up with FIAT corporate and was assigned a case manager who followed up as well unable to rectify the situation. Now my car is unsafe to drive, I have gotten a ticket for expired inspection . I told the officer that there is an open recall and that I am at the mercy of FIAT. Secondly since I purchased the car I have brought it back multiple times, expressing concern that the car lags when you press the gas. If I am merging on the the highway and I am going 30mph the RPM will struggle to go over 3 in order for the car to accelerate and then it falls to 1-2 RPM. Attached are numerous photos of my constant communication of presenting issues. The entire electrical system will turn on and off on its own. Error I have gotten speeding tickets always when trying to switch lanes or am preparing for the exist because I have to compensate for the lag otherwise I will get smashed by another car. When driving 25-40 mph the engine will make a humming sound as if it is stuck in a gear. So my options are 50+ or 25 or less. Living in NY this is very difficult. I have even advocated that I believe my car is apart of the 2016 transmission recall on my particular make and model. My car is unsafe to drive and I need some guidance

The Fiat 500X has a defective part, which is the Fiat Ambient Air Temperature Sensor. The dealer here claims that they replace this part at least once a month, and there are barely any Fiats on the road here. I called their customer satisfaction center and they said they are "sorry for the inconvenience" and cannot provide any assistance in the matter. The inconvenience, specifically, is: that this part is a known problem, that the entire mirror needs replaced and the door will need be disassembled to complete that work, that the mirror isn't provided in the color of the car so there is also painting involved, and the total cost is around $2,000. The part itself is just a little $10 bit, but because of the ridiculousness involved in this faulty part, the cost is bombastically high. So, that leaves me waiting for a part that is in short supply because they need replaced constantly, and having to drive in extreme heat until it's fixed. No one should have to pay thousands of dollars or die of heat stroke because of a faulty, tiny, $10 sensor.

The drivers door is defective and will not open from the outside. Upon request the inspection has a cost of upwards of $1000 and customers who drive Fiat 500x models across the US have reported this as an issue. This becomes a safety problem as if there were to be a major accident, I would not be able to be rescued through the door unless I open it through the inside. This is particularly a problem if I were to have a medical emergency. There were no warnings that appeared until this door suddenly would just not open. Additionally, this is a commonly reported issue, as was confirmed to me in person at the dealership, through online forums, and through a customer support chat attached below.

April 2023 - While driving at ~ 35mph multiple warning light on the dashboard came on, (including traction control, AWD needs service, drive mode unavailable, emergency brake and several others) the speedometer stopped working (both the digital and analog) and a sluggish sensation was immediate (like the brakes were applied rapidly.) The car was stopped and further investigation showed that the rear brake lights were on, seemingly indicating that the brakes were engaged while the car was in park, with no one in the vehicle. The car would not shut off. The car was taken to the dealership where over 30 codes were reported. 2 sensors were replaced (one brake sensor and the traction sensor) and the dealership reported that multiple updates were performed in the 2 weeks that they had the car. Five weeks after getting the car back from the dealership the SAME condition occurred on the highway at 55mph, in a construction zone with no ability to pull off. After reaching an area where it was safe to pull off, a restart of the car (by disconnecting the battery) had all of the lights going off and the brakes functioning normally. The car was driven straight to the dealership where the issues happened again. The car now has 43 codes. They replaced the HCU/ABS module, which did not fix the issue. The car has been in the service department for 3 weeks without discovering the cause of the lights, lack of speedometer and deceleration.

My Radio in my car went the system air bags , ESC lights up and my car while I’m driving goes into neautral so I have to shift to P to Gear for my car to drive so i went the next day told them and they had to make an appointment and told them to might as well do the recall while it was there for Dec 7 th didn’t pick my car up til the next day evening when picked up my car it was doing the same thing after I was so angry until this day I’m still dealing with this almost smashed a few times thru the back because my car goes into neautral out of no where and have to put it all the way on P to Drive again it keeps happening constant and most of the time my son is with me this a real Dangerous Safety Issue and nobody seems to be listening this car is too new to be going thru this and the history I see which is the same problem I’m going thru is either the Powertrain module or transmission module that causes and the Fiat I drive seemed to be a Dangerous i included pictures of what my radio which is the harness head unit says and the issues since radio and my car when my car goes into neautral randomly and it happens 4 to 5 times depending how long I be on the road what is says Supposedly Powertrain recall was done on the 7