NHTSA owner reports · September 18, 2026 snapshot.
Visibility complaints
10 reportsClear category filter92,000 miles · Sep 29, 2011
Exterior LightingStructureVisibility
TL* THE CONTACT OWNS 1999 DODGE STRATUS. THE CONTACT WAS DRIVING 55 MPH WHEN THE INTERIOR AND EXTERIOR LIGHTS FAILED TO ILLUMINATE. THE CONTACT ALSO STATED THE POWER WINDOWS AND DOOR LOCKS FAILED TO WORK PROPERLY. THE CONTACT STATED THE FAILURE WAS DUE TO THE WIRING HARNESS. THE VEHICLE WAS TAKEN TO THE DEALER, AND THE MANUFACTU…
Read full complaint
TL* THE CONTACT OWNS 1999 DODGE STRATUS. THE CONTACT WAS DRIVING 55 MPH WHEN THE INTERIOR AND EXTERIOR LIGHTS FAILED TO ILLUMINATE. THE CONTACT ALSO STATED THE POWER WINDOWS AND DOOR LOCKS FAILED TO WORK PROPERLY. THE CONTACT STATED THE FAILURE WAS DUE TO THE WIRING HARNESS. THE VEHICLE WAS TAKEN TO THE DEALER, AND THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 92,000 AND THE CURRENT MILEAGE WAS 92,100.
NHTSA ODI #10427858
127,182 miles · Mar 14, 2011
Exterior LightingPower TrainVisibility
WITH NO RYME OR RYTHEM, THE WINSHEILD WIPERS FAIL TO TURN ON, POWER LOCKS FAIL TO WORK AND TURN SYGNALS FAIL. ENGINE STALLS AND WILL NOT RESTART WHILE IN TRAFFIC FOR AT LEAST 30 SECONDS. THESE CONDITIONS HAPPEN WHILE ON THE ROADWAY AND WITH CHILDREN IN THE CAR , LOSS OF IGNITION, WINSHEILD WIPERS OR TURN SYGNALS CAN CAUSE AN ACC…
Read full complaint
WITH NO RYME OR RYTHEM, THE WINSHEILD WIPERS FAIL TO TURN ON, POWER LOCKS FAIL TO WORK AND TURN SYGNALS FAIL. ENGINE STALLS AND WILL NOT RESTART WHILE IN TRAFFIC FOR AT LEAST 30 SECONDS. THESE CONDITIONS HAPPEN WHILE ON THE ROADWAY AND WITH CHILDREN IN THE CAR , LOSS OF IGNITION, WINSHEILD WIPERS OR TURN SYGNALS CAN CAUSE AN ACCIDENT OR DEATH.
NHTSA ODI #10391528
Mileage unknown · Jul 22, 2009
Electrical SystemEquipmentVisibility
TL*THE CONTACT OWNS A 1999 DODGE STRATUS. WHEN IT RAINS, THE INSTRUMENT PANEL GAUGES, WINDSHIELD WIPERS, AND AIR CONDITIONER BECOME INOPERABLE. THE CONTACT STATED THAT THE VEHICLE WAS A LEMON BECAUSE IT HAS BEEN INCLUDED IN TWO RECALLS AND THE WINDOWS DID NOT WORK AT THE TIME OF PURCHASE. THE CONTACT BELIEVES THAT CHRYSLER SH…
Read full complaint
TL*THE CONTACT OWNS A 1999 DODGE STRATUS. WHEN IT RAINS, THE INSTRUMENT PANEL GAUGES, WINDSHIELD WIPERS, AND AIR CONDITIONER BECOME INOPERABLE. THE CONTACT STATED THAT THE VEHICLE WAS A LEMON BECAUSE IT HAS BEEN INCLUDED IN TWO RECALLS AND THE WINDOWS DID NOT WORK AT THE TIME OF PURCHASE. THE CONTACT BELIEVES THAT CHRYSLER SHOULD REPAIR THE VEHICLE SINCE THE FAILURES HAVE BEEN OCCURRING SINCE THE DAY IT WAS PURCHASED. THE VIN AND FAILURE MILEAGE WERE UNKNOWN. THE CURRENT MILEAGE WAS 5,000.
NHTSA ODI #10277924
30,000 miles · Jun 22, 2005
Electrical SystemLatches/locks/linkagesPower Train
DT: CONSUMER BOUGHT CAR IN 1999. TWO YEARS LATER TRANSMISSION FAILED, AND CONSUMER PAID $2,500 TO REPLACE IT. CONSUMER SAID THAT WHEN SHE GOT INTO VEHICLE AND SOMETIMES WHEN SHE LEFT VEHICLE THE DOORS DID NOT LOCK, AND SOMETIMES THE PASSENGER SIDE WINDOW WILL NOT ROLL DOWN. CONSUMER THOUGHT SHE HAD ALL THIS FIXED, BUT PRO…
Read full complaint
DT: CONSUMER BOUGHT CAR IN 1999. TWO YEARS LATER TRANSMISSION FAILED, AND CONSUMER PAID $2,500 TO REPLACE IT. CONSUMER SAID THAT WHEN SHE GOT INTO VEHICLE AND SOMETIMES WHEN SHE LEFT VEHICLE THE DOORS DID NOT LOCK, AND SOMETIMES THE PASSENGER SIDE WINDOW WILL NOT ROLL DOWN. CONSUMER THOUGHT SHE HAD ALL THIS FIXED, BUT PROBLEM RECURRED. DASHBOARD SHUT DOWN/GAUGES DID NOT WORK, AND TDASHBOARD ILLUMINATION MALFUNCTIONED. WHEN CONSUMER DROVE DASHBOARD CA ME ON AT ONCE/GAUGES WILL BEGAN WORKING, AND LIGHT CAME ON . CONSUMER HAD TO REPLACE WIRING AND SENSORS, BUT PROBLEM RECURRED. *AK
NHTSA ODI #10126234
Mileage unknown · Nov 15, 2004
Engine And Engine CoolingEquipmentPower Train
MULTIPLE FAILURES, CONTINUALLY STEERING PROBLEMS. ENGINE LEAKED OIL, NO A/C OR HEATED, ECT. *BF THE CONSUMER STATED THAT THE STEERING WHEEL WAS LOOSE. THE CONSUMER ATTEMPTED TO MAKE A LEFT TURN AND HIT THE CURB DUE TO THE LOOSE STEERING WHEEL. THE CONSUMER STATED THAT THERE MIGHT BE A PROBLEM WITH THE RIGHT SIDE AXLE. *TC
NHTSA ODI #10101681
Mileage unknown · Jun 3, 2003
Visibility
WASHER JETS AND HOSES FOR WINDSHIELD WIPERS ARE CLOGGING AND RESULT IN SYSTEM FAILURE TO OPERATE. THIS TOOK THREE SERVICE CALLS TO RESOLVE AND SHOULD BE COVERED AS A MANUFACTURE DEFECT. I WAS FORCED TO REPLACE MOTOR THAT OPERATES THE SPRAYERS LAST YEAR AND THE PROBLEM CONTINUED. PER DEALERSHIP, THIS PROBLEM IS KNOWN AND HAS NO…
Read full complaint
WASHER JETS AND HOSES FOR WINDSHIELD WIPERS ARE CLOGGING AND RESULT IN SYSTEM FAILURE TO OPERATE. THIS TOOK THREE SERVICE CALLS TO RESOLVE AND SHOULD BE COVERED AS A MANUFACTURE DEFECT. I WAS FORCED TO REPLACE MOTOR THAT OPERATES THE SPRAYERS LAST YEAR AND THE PROBLEM CONTINUED. PER DEALERSHIP, THIS PROBLEM IS KNOWN AND HAS NOT BEEN PUBLISHED WHICH MEANS OWNERS ARE BEING FORCED TO PAY FOR DEFECTIVE PARTS. *NLM
NHTSA ODI #10020952
Mileage unknown · Dec 3, 2002
Engine And Engine CoolingPower TrainSeat Belts
CONSUMER EXPERIENCED HEAD GASKET FAILURE. OTHER FAILURES INCLUDED REAR SEAT BELT PROBLEMS, NO POWER ON THE BACK WINDOWS, EGR VALVE FAILURE, TRANSMISSION SHIFTING PROBLEMS AND SPEED SENSOR FAILURE.*JB
NHTSA ODI #568461
Mileage unknown · Jan 23, 2002
Visibility
WINDSHIELD WASHER/ WIPER SYSTEM FAILURE - VEHICLE TO DEALER SEVERAL TIMES IN LAST THREE YEARS - DEALER CUT THE WASHER FLUID LINE TO ALLOW COMPRESSED AIR TO BLOW OUT SYSTEM - WORKS FOR SEVERAL DAYS THEN PLUGS UP AGAIN - IT BECOMES A SFETY HAZARD WHEN YOU ACTIVEATE THE WINDSHIRLD WASHER SYSTEM AT HIGHWAY SPEEDS AND NO FLUID IS DIS…
Read full complaint
WINDSHIELD WASHER/ WIPER SYSTEM FAILURE - VEHICLE TO DEALER SEVERAL TIMES IN LAST THREE YEARS - DEALER CUT THE WASHER FLUID LINE TO ALLOW COMPRESSED AIR TO BLOW OUT SYSTEM - WORKS FOR SEVERAL DAYS THEN PLUGS UP AGAIN - IT BECOMES A SFETY HAZARD WHEN YOU ACTIVEATE THE WINDSHIRLD WASHER SYSTEM AT HIGHWAY SPEEDS AND NO FLUID IS DISPENSED - BUT THE WINDSHIELD WIPERS ACTIVATE SMEARING WHATEVER IS ON THE WINDSHIELD, CAUSING VERY LIMITED VISIBILITY.*AK
NHTSA ODI #757230
Mileage unknown · Oct 10, 2001
Power TrainService Brakes, HydraulicSteering
WHILE TRAVELING, TRANSMISSION WOULD NOT SHIFT INTO NEXT GEAR CORRECTLY. WOULD SUDDENLY SLAM INTO GEAR, AND CAUSE VEHICLE TO JERK FORWARD. *AK REAR BRAKES MAKE NOISE. CONSUMER STATES STEERING WHEEL LOCK UP. WINDSHIELD WASHER IS NOT WORKING. REAR BUMPER IS COMING LOOSE. THE VEHICLE ALSO HAS NOISY A SUSPENSION. *YH
NHTSA ODI #897576
Mileage unknown · Dec 16, 1999
Visibility
BOTH REAR VIEW MIRRORS ARE POWER AND WILL NOT GO DOWNWARD WITH POWER BUTTON. *AK
NHTSA ODI #716135
NHTSA investigations
5EA05019 · Power Steering Fluid Fires
Opened Nov 7, 2005 · Closed Jan 12, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Steering:hydraulic Power Assist:hose, Piping, And Connections
ODI HAS RECEIVED 29 REPORTS OF ENGINE COMPARTMENT FIRES THAT APPEAR TO BE RELATED TO POWER STEERING HOSE LEAKAGE IN MODEL YEAR (MY) 1999 AND 2000 CHRYSLER CIRRUS, DODGE STRATUS AND PLYMOUTH BREEZE VEHICLES (JA-CARS) EQUIPPED WITH 2.4L ENGINES.THESE REPORTS INDICATE THAT THE FIRE RESULTED FROM A POWER STEERING HOSE LEAK OR THAT IT OCCURRED AFTER AN EXTENDED DRIVE AND SHORTLY AFTER BEING PARKED - CONDITIONS CONSISTENT WITH IGNITION OF POWER STEERING FLUID ON A HOT ENGINE OR EXHAUST SURFACE DURING THE VEHICLE HOT SOAK PERIOD. ON JANUARY 6, 2006, DAIMLERCHRYSLER CORPORATION (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 1999 AND 2000 JA-CARS BUILT FROM JULY 1, 1998 TO JULY 31, 2000 AND EQUIPPED WITH 2.4L ENGINES (RECALL 06V-001).THE NOTIFICATION STATED THAT ?THE HIGH PRESSURE POWER STEERING HOSE MAY PREMATURELY HEAT, AGE AND DEVELOP A LEAK. POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN AN UNDER HOOD FIRE.DCC INDICATED THAT IT WAS AWARE OF 94 COMPLAINTS AND FIELD REPORTS THAT MAY BE RELATED TO THIS CONDITION WHEN IT MADE THE DEFECT DETERMINATION.TO REMEDY THE DEFECT CONDITION, DCC WILL REPLACE THE HIGH PRESSURE POWER STEERING HOSE ON THE AFFECTED VEHICLES WITH A NEW PART MADE FROM A HOSE MATERIAL WITH INCREASED HEAT RESISTANCE CAPABILITY. CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (2)
Engine And Engine Cooling
ODI HAS RECEIVED 29 REPORTS OF ENGINE COMPARTMENT FIRES THAT APPEAR TO BE RELATED TO POWER STEERING HOSE LEAKAGE IN MODEL YEAR (MY) 1999 AND 2000 CHRYSLER CIRRUS, DODGE STRATUS AND PLYMOUTH BREEZE VEHICLES (JA-CARS) EQUIPPED WITH 2.4L ENGINES.THESE REPORTS INDICATE THAT THE FIRE RESULTED FROM A POWER STEERING HOSE LEAK OR THAT IT OCCURRED AFTER AN EXTENDED DRIVE AND SHORTLY AFTER BEING PARKED - CONDITIONS CONSISTENT WITH IGNITION OF POWER STEERING FLUID ON A HOT ENGINE OR EXHAUST SURFACE DURING THE VEHICLE HOT SOAK PERIOD. ON JANUARY 6, 2006, DAIMLERCHRYSLER CORPORATION (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 1999 AND 2000 JA-CARS BUILT FROM JULY 1, 1998 TO JULY 31, 2000 AND EQUIPPED WITH 2.4L ENGINES (RECALL 06V-001).THE NOTIFICATION STATED THAT ?THE HIGH PRESSURE POWER STEERING HOSE MAY PREMATURELY HEAT, AGE AND DEVELOP A LEAK. POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN AN UNDER HOOD FIRE.DCC INDICATED THAT IT WAS AWARE OF 94 COMPLAINTS AND FIELD REPORTS THAT MAY BE RELATED TO THIS CONDITION WHEN IT MADE THE DEFECT DETERMINATION.TO REMEDY THE DEFECT CONDITION, DCC WILL REPLACE THE HIGH PRESSURE POWER STEERING HOSE ON THE AFFECTED VEHICLES WITH A NEW PART MADE FROM A HOSE MATERIAL WITH INCREASED HEAT RESISTANCE CAPABILITY. CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Steering:hydraulic Power Assist:hose, Piping, And Connections
ODI HAS RECEIVED 29 REPORTS OF ENGINE COMPARTMENT FIRES THAT APPEAR TO BE RELATED TO POWER STEERING HOSE LEAKAGE IN MODEL YEAR (MY) 1999 AND 2000 CHRYSLER CIRRUS, DODGE STRATUS AND PLYMOUTH BREEZE VEHICLES (JA-CARS) EQUIPPED WITH 2.4L ENGINES.THESE REPORTS INDICATE THAT THE FIRE RESULTED FROM A POWER STEERING HOSE LEAK OR THAT IT OCCURRED AFTER AN EXTENDED DRIVE AND SHORTLY AFTER BEING PARKED - CONDITIONS CONSISTENT WITH IGNITION OF POWER STEERING FLUID ON A HOT ENGINE OR EXHAUST SURFACE DURING THE VEHICLE HOT SOAK PERIOD. ON JANUARY 6, 2006, DAIMLERCHRYSLER CORPORATION (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 1999 AND 2000 JA-CARS BUILT FROM JULY 1, 1998 TO JULY 31, 2000 AND EQUIPPED WITH 2.4L ENGINES (RECALL 06V-001).THE NOTIFICATION STATED THAT ?THE HIGH PRESSURE POWER STEERING HOSE MAY PREMATURELY HEAT, AGE AND DEVELOP A LEAK. POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN AN UNDER HOOD FIRE.DCC INDICATED THAT IT WAS AWARE OF 94 COMPLAINTS AND FIELD REPORTS THAT MAY BE RELATED TO THIS CONDITION WHEN IT MADE THE DEFECT DETERMINATION.TO REMEDY THE DEFECT CONDITION, DCC WILL REPLACE THE HIGH PRESSURE POWER STEERING HOSE ON THE AFFECTED VEHICLES WITH A NEW PART MADE FROM A HOSE MATERIAL WITH INCREASED HEAT RESISTANCE CAPABILITY. CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
PE05036 · Engine Compartment Fires
Opened Jun 29, 2005 · Closed Nov 7, 2005
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline
ON JUNE 29, 2005, ODI OPENED PRELIMINARY EVALUATION PE05-036 TO INVESTIGATE COMPLAINTS OF ENGINE COMPARTMENT FIRES IN MODEL YEAR (MY) 1999-2000 CHRYSLER CIRRUS, DODGE STRATUS AND PLYMOUTH BREEZE PASSENGER CARS (JA CARS). THE JA CARS WERE INTRODUCED IN MY 1995 AND ENDED WITH MY 2000.THEY WERE PRODUCED WITH 2.0L, 2.4L AND 2.5L ENGINES.THE INCIDENT DATA IN THE FAILURE REPORT SUMMARY OF THIS RESUME ARE FOR SUBJECT VEHICLE ENGINE COMPARTMENT FIRES FOR ALL CAUSES. ACCORDING TO DAIMLERCHRYSLER, EVIDENCE COLLECTED FROM FIELD INSPECTIONS OF FIRE INCIDENT VEHICLES INDICATE THAT FLUID LEAKAGE FROM THE HIGH PRESSURE POWER STEERING HOSE IS THE MOST LIKELY CAUSE OF THE FIRES IN THE SUBJECT VEHICLES.THE SUBJECT HIGH PRESSURE POWER STEERING HOSE IS USED IN JA CARS WITH BOTH THE 2.4L AND 2.0L ENGINES IN MY 1995 THROUGH 2000.THE FIRE INCIDENT RATE IN THE MY 1999 THROUGH 2000 JA VEHICLES WITH 2.4L ENGINES IS SIGNIFICANTLY HIGHER THAN IN THE PRIOR MODEL YEAR VEHICLES USING THAT ENGINE AND IN ANY OF THE VEHICLES WITH THE 2.0L OR 2.5L ENGINES.DAIMLERCHRYSLER IS CONTINUING ITS INVESTIGATION OF THE ISSUE AND HAS PROVIDED PERIODIC UPDATES TO ODI. AN ENGINEERING ANALYSIS (EA05-019) HAS BEEN OPENED TO FURTHER ASSESS THE SCOPE AND FREQUENCY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
RQ03005 · Auto Trans IGNITION-PARK Interlock
Opened Apr 8, 2003 · Closed Jul 16, 2003
Status: closed (inferred from source dates) · Power Train:automatic Transmission:lever And Linkage:floor Shift
THREE OF THE MANFACTURER COMPLAINTS AND TWO OF THE MANUFACTURER CRASHES REPORTED ABOVE WERE DUPLICATES OF ODI REPORTS.THE MAJORITY OF CRASHES OCCURRED AFTER OPERATORS PARKED THE VEHICLE WITHOUT ENGAGING PARK GEAR POSITION; A NON-FUNCTIONAL IGNITION-PARK INTERLOCK SYSTEM SUBSEQUENTLY FAILED TO PREVENT KEY REMOVAL BEFORE THE OPERATORS EXITED THE VEHICLE.MOST OF THE CRASHES WERE MINOR AND INVOLVED MINOR PROPERTY DAMAGE.FOUR OF THE INJURY INCIDENTS OCCURRED WHEN UNATTENDED CHILDREN MOVED THE GEARSHIFT FROM THE PARK POSITION CAUSING THE VEHICLE TO ROLL AWAY, ONE INJURY OCCURRED WHEN THE OPERATOR WAS STRUCK BY A ROLL-AWAY VEHICLE AFTER PARKING AND EXITING.ALL INJURIES WERE RELATIVELY MINOR.A SIGNIFICANT NUMBER OF INTERLOCK SYSTEM FAILURES APPEAR TO BE RELATED TO DISENGAGEMENT OF THE INTERLOCK PIN THAT RIDES IN THE INTERLOCK LEVER SLOT WITHIN THE SHIFT MECHANISM.AN ENGINEERING ANALYSIS WILL BE OPENED TO FURTHER STUDY INTERLOCK SYSTEM FAILURES.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
Illustration