IllustrationCRACKED HEAD GASKET AS OF 09/04/2002 PROBLEM WAS NOT DIAGNOSED UNTIL 10/08/2002. MR
1999 Dodge Stratus
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1999 Dodge Stratus do not stand out strongly from the model-year median of 168.
About this comparison →How this year compares
Owner complaints by model year
Compare all Stratus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
50–25K
1025–50K
2150–75K
1775–100K
33100–150K
12150K+
98 reports with mileage · 153 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports59 fire reports13 injury reports
Engine And Engine Cooling complaints
53 reportsWHILE DRIVING AND NO WARNING THE RPM IS RACING AND THE CONSUMER CANNOT GO OVER 35MPH. DEALER NOTIFIED
ROUTINE OIL CHANGE NOTED A SEVERE LEAK THAT THEY SUSPECTED WAS THE INFAMOUS "HEAD GASKET LEAK" THAT THE STRATUS ARE FAMOUS FOR. TOOK TO DEALER WHO AGREED AND REPAIRED UNDER MY EXTENDED WARRANTY. MR
VEHICLE HAD DEVELOPED A CONSTANT OIL LEAK. BEFORE TAKING TO DEALERSHIP FOR REVIEW, WE DID EXTENSIVE RESEARCH ON INTERNET & DETERMINED THAT HEAD GASKET ISSUES WERE HIGHLY EVIDENT IN THE STRATUS. NUMEROUS RECORDS ALSO INDICATED THAT CHRYSLER WAS WELL AWARE OF ISSUE, ALTHOUGH NO FORMAL RECALL HAD BEEN DONE. UPON TAKING TO DEALER…
Read full complaint
VEHICLE HAD DEVELOPED A CONSTANT OIL LEAK. BEFORE TAKING TO DEALERSHIP FOR REVIEW, WE DID EXTENSIVE RESEARCH ON INTERNET & DETERMINED THAT HEAD GASKET ISSUES WERE HIGHLY EVIDENT IN THE STRATUS. NUMEROUS RECORDS ALSO INDICATED THAT CHRYSLER WAS WELL AWARE OF ISSUE, ALTHOUGH NO FORMAL RECALL HAD BEEN DONE. UPON TAKING TO DEALER, DIAGNOSTIC CONFIRMED HEAD GASKET NEEDED REPLACEMENT. TOTAL COST WAS APPROX. $700 & WE HAD TO PAY $511 OF IT. PRIOR TO PAYING, MADE SEVERAL CALLS TO CHRYSLER TRYING TO SOLICIT A HIGHER LEVEL OF ASSISTANCE ON IT. CSR REPS GAVE INDICATION THAT MY REQUEST WAS PLAUSIBLE, BUT DEALER SERVICE MGR. CONTINUED TO ONLY APPROVE ORIG. $200 OF ASSISTANCE WHICH SUPPOSEDLY CHRYSLER DIST. MGR. BACKED UP. I HAVE NOT BEEN GIVEN ANY SATISFACTION ON TRYING TO CONTACT THE DIST. MGR. ONGOING HIGH LEVEL OF COMPLAINTS ON THIS SAME ISSUE SHOULD WARRANT RECALL AND CHRYSLER BACKING FULL COST OF REPAIR. I'M CONTINUING WITH SEVERAL CONSUMER AGENCIES TO RECOUP MY $500, INCLUDING LOOKING INTO SMALL CLAIMS COURT.*AK
ONGOING PROBLEM WITH 3.8L V6 ENGINE OVERHEATING. DEALER AND MANUFACTURER HAVE BEEN NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
ENGINE HEAD GASKET WAS REPLACED BY THE DEALER ON TWO OCCASIONS WITHIN 10 MONTHS, AND CURRENTLY PROBLEM WITH COOLANT LEAKING IS REOCCURRING. DEALER CONTACTED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
VEHICLE WAS GOING 55MPH ON THE EXPRESSWAY WHEN TEMPERATURE GAUGE DROPPED TO RED. VEHICLE WAS PULLED OVER DUE TO OIL LEAKING ON THE GROUND. NO OTHER SIGNS INDICATIONS THAT VEHICLE WAS HAVING A PROBLEM. VEHICLE WAS DIAGNOSED AS HAVING A BLOWN HEAD GASKET. DEALER WAS NOTIFIED. PLEASE PROVIDE MORE INFORMATION.*AK
MOTOR MOUNT BRACKET BROKE WHILE DRIVING. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE ADDITIOANL INFORMATION.*AK
THE VEHICLE CAUGHT FIRE WHILE THE IGNITION WAS TURNED OFF. *YH
CONSUMER STATED VEHICLE LEAKS OIL DUE TO BLOWN HEAD GASKET. DEALER CONTACTED. NLM *YH
Official recalls
306V001000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Jan 5, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4 LITER ENGINES, THE HIGH PRESSURE POWER STEERING HOSE MAY PREMATURELY HEAT AGE AND DEVELOP A LEAK.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL REPLACE THE HIGH PRESSURE POWER STEERING HOSE FREE OF CHARGE. THE THE RECALL BEGAN ON APRIL 10, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
04V021000 · Power Train:automatic Transmission:lever And Linkage:floor Shift
Jan 13, 2004
ON CERTAIN PASSENGER VEHICLES, THE FLOOR SHIFTER IGNITION-PARK INTERLOCK MAY FAIL AND ALLOW THE SHIFTER TO BE MOVED OUT OF THE PARK POSITION WITH THE KEY REMOVED. AN INOPERATIVE INTERLOCK MAY ALSO ALLOW THE KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: EITHER CIRCUMSTANCE MAY RESULT IN THE VEHICLE ROLLING AWAY WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER OF THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN ON JUNE 14, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
99V244000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Sep 15, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE RIGHT REAR BRAKE TUBE CAN CONTACT THE EXHAUST SYSTEM CLAMP AND WEAR A HOLE IN IT.
Consequence & remedy
Consequence: DAIMLERCHRYSLER RECALL NO. 843. IF THIS HAPPENS, THE TUBE COULD LEAK, REDUCING THE EFFECTIVENESS OF ONE-HALF OF THE DIAGONALLY SPLIT BRAKING SYSTEM, AND RESULTING IN LONGER STOPPING DISTANCES.
Remedy: DEALERS WILL INSPECT THE BRAKE TUBES FOR VISIBLE EVIDENCE OF CONTACT WITH THE EXHAUST SYSTEM CLAMP. IF THE TUBE SHOWS EVIDENCE OF CONTACT, IT WILL BE REPLACED. IF NO EVIDENCE OF CONTACT EXISTS, THE TUBE WILL BE FASTENED WITH A CLIP.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA05019 · Power Steering Fluid Fires
Opened Nov 7, 2005 · Closed Jan 12, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Steering:hydraulic Power Assist:hose, Piping, And Connections
ODI HAS RECEIVED 29 REPORTS OF ENGINE COMPARTMENT FIRES THAT APPEAR TO BE RELATED TO POWER STEERING HOSE LEAKAGE IN MODEL YEAR (MY) 1999 AND 2000 CHRYSLER CIRRUS, DODGE STRATUS AND PLYMOUTH BREEZE VEHICLES (JA-CARS) EQUIPPED WITH 2.4L ENGINES.THESE REPORTS INDICATE THAT THE FIRE RESULTED FROM A POWER STEERING HOSE LEAK OR THAT IT OCCURRED AFTER AN EXTENDED DRIVE AND SHORTLY AFTER BEING PARKED - CONDITIONS CONSISTENT WITH IGNITION OF POWER STEERING FLUID ON A HOT ENGINE OR EXHAUST SURFACE DURING THE VEHICLE HOT SOAK PERIOD. ON JANUARY 6, 2006, DAIMLERCHRYSLER CORPORATION (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 1999 AND 2000 JA-CARS BUILT FROM JULY 1, 1998 TO JULY 31, 2000 AND EQUIPPED WITH 2.4L ENGINES (RECALL 06V-001).THE NOTIFICATION STATED THAT ?THE HIGH PRESSURE POWER STEERING HOSE MAY PREMATURELY HEAT, AGE AND DEVELOP A LEAK. POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN AN UNDER HOOD FIRE.DCC INDICATED THAT IT WAS AWARE OF 94 COMPLAINTS AND FIELD REPORTS THAT MAY BE RELATED TO THIS CONDITION WHEN IT MADE THE DEFECT DETERMINATION.TO REMEDY THE DEFECT CONDITION, DCC WILL REPLACE THE HIGH PRESSURE POWER STEERING HOSE ON THE AFFECTED VEHICLES WITH A NEW PART MADE FROM A HOSE MATERIAL WITH INCREASED HEAT RESISTANCE CAPABILITY. CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (2)
Engine And Engine Cooling
ODI HAS RECEIVED 29 REPORTS OF ENGINE COMPARTMENT FIRES THAT APPEAR TO BE RELATED TO POWER STEERING HOSE LEAKAGE IN MODEL YEAR (MY) 1999 AND 2000 CHRYSLER CIRRUS, DODGE STRATUS AND PLYMOUTH BREEZE VEHICLES (JA-CARS) EQUIPPED WITH 2.4L ENGINES.THESE REPORTS INDICATE THAT THE FIRE RESULTED FROM A POWER STEERING HOSE LEAK OR THAT IT OCCURRED AFTER AN EXTENDED DRIVE AND SHORTLY AFTER BEING PARKED - CONDITIONS CONSISTENT WITH IGNITION OF POWER STEERING FLUID ON A HOT ENGINE OR EXHAUST SURFACE DURING THE VEHICLE HOT SOAK PERIOD. ON JANUARY 6, 2006, DAIMLERCHRYSLER CORPORATION (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 1999 AND 2000 JA-CARS BUILT FROM JULY 1, 1998 TO JULY 31, 2000 AND EQUIPPED WITH 2.4L ENGINES (RECALL 06V-001).THE NOTIFICATION STATED THAT ?THE HIGH PRESSURE POWER STEERING HOSE MAY PREMATURELY HEAT, AGE AND DEVELOP A LEAK. POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN AN UNDER HOOD FIRE.DCC INDICATED THAT IT WAS AWARE OF 94 COMPLAINTS AND FIELD REPORTS THAT MAY BE RELATED TO THIS CONDITION WHEN IT MADE THE DEFECT DETERMINATION.TO REMEDY THE DEFECT CONDITION, DCC WILL REPLACE THE HIGH PRESSURE POWER STEERING HOSE ON THE AFFECTED VEHICLES WITH A NEW PART MADE FROM A HOSE MATERIAL WITH INCREASED HEAT RESISTANCE CAPABILITY. CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Steering:hydraulic Power Assist:hose, Piping, And Connections
ODI HAS RECEIVED 29 REPORTS OF ENGINE COMPARTMENT FIRES THAT APPEAR TO BE RELATED TO POWER STEERING HOSE LEAKAGE IN MODEL YEAR (MY) 1999 AND 2000 CHRYSLER CIRRUS, DODGE STRATUS AND PLYMOUTH BREEZE VEHICLES (JA-CARS) EQUIPPED WITH 2.4L ENGINES.THESE REPORTS INDICATE THAT THE FIRE RESULTED FROM A POWER STEERING HOSE LEAK OR THAT IT OCCURRED AFTER AN EXTENDED DRIVE AND SHORTLY AFTER BEING PARKED - CONDITIONS CONSISTENT WITH IGNITION OF POWER STEERING FLUID ON A HOT ENGINE OR EXHAUST SURFACE DURING THE VEHICLE HOT SOAK PERIOD. ON JANUARY 6, 2006, DAIMLERCHRYSLER CORPORATION (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 1999 AND 2000 JA-CARS BUILT FROM JULY 1, 1998 TO JULY 31, 2000 AND EQUIPPED WITH 2.4L ENGINES (RECALL 06V-001).THE NOTIFICATION STATED THAT ?THE HIGH PRESSURE POWER STEERING HOSE MAY PREMATURELY HEAT, AGE AND DEVELOP A LEAK. POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN AN UNDER HOOD FIRE.DCC INDICATED THAT IT WAS AWARE OF 94 COMPLAINTS AND FIELD REPORTS THAT MAY BE RELATED TO THIS CONDITION WHEN IT MADE THE DEFECT DETERMINATION.TO REMEDY THE DEFECT CONDITION, DCC WILL REPLACE THE HIGH PRESSURE POWER STEERING HOSE ON THE AFFECTED VEHICLES WITH A NEW PART MADE FROM A HOSE MATERIAL WITH INCREASED HEAT RESISTANCE CAPABILITY. CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
PE05036 · Engine Compartment Fires
Opened Jun 29, 2005 · Closed Nov 7, 2005
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline
ON JUNE 29, 2005, ODI OPENED PRELIMINARY EVALUATION PE05-036 TO INVESTIGATE COMPLAINTS OF ENGINE COMPARTMENT FIRES IN MODEL YEAR (MY) 1999-2000 CHRYSLER CIRRUS, DODGE STRATUS AND PLYMOUTH BREEZE PASSENGER CARS (JA CARS). THE JA CARS WERE INTRODUCED IN MY 1995 AND ENDED WITH MY 2000.THEY WERE PRODUCED WITH 2.0L, 2.4L AND 2.5L ENGINES.THE INCIDENT DATA IN THE FAILURE REPORT SUMMARY OF THIS RESUME ARE FOR SUBJECT VEHICLE ENGINE COMPARTMENT FIRES FOR ALL CAUSES. ACCORDING TO DAIMLERCHRYSLER, EVIDENCE COLLECTED FROM FIELD INSPECTIONS OF FIRE INCIDENT VEHICLES INDICATE THAT FLUID LEAKAGE FROM THE HIGH PRESSURE POWER STEERING HOSE IS THE MOST LIKELY CAUSE OF THE FIRES IN THE SUBJECT VEHICLES.THE SUBJECT HIGH PRESSURE POWER STEERING HOSE IS USED IN JA CARS WITH BOTH THE 2.4L AND 2.0L ENGINES IN MY 1995 THROUGH 2000.THE FIRE INCIDENT RATE IN THE MY 1999 THROUGH 2000 JA VEHICLES WITH 2.4L ENGINES IS SIGNIFICANTLY HIGHER THAN IN THE PRIOR MODEL YEAR VEHICLES USING THAT ENGINE AND IN ANY OF THE VEHICLES WITH THE 2.0L OR 2.5L ENGINES.DAIMLERCHRYSLER IS CONTINUING ITS INVESTIGATION OF THE ISSUE AND HAS PROVIDED PERIODIC UPDATES TO ODI. AN ENGINEERING ANALYSIS (EA05-019) HAS BEEN OPENED TO FURTHER ASSESS THE SCOPE AND FREQUENCY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
RQ03005 · Auto Trans IGNITION-PARK Interlock
Opened Apr 8, 2003 · Closed Jul 16, 2003
Status: closed (inferred from source dates) · Power Train:automatic Transmission:lever And Linkage:floor Shift
THREE OF THE MANFACTURER COMPLAINTS AND TWO OF THE MANUFACTURER CRASHES REPORTED ABOVE WERE DUPLICATES OF ODI REPORTS.THE MAJORITY OF CRASHES OCCURRED AFTER OPERATORS PARKED THE VEHICLE WITHOUT ENGAGING PARK GEAR POSITION; A NON-FUNCTIONAL IGNITION-PARK INTERLOCK SYSTEM SUBSEQUENTLY FAILED TO PREVENT KEY REMOVAL BEFORE THE OPERATORS EXITED THE VEHICLE.MOST OF THE CRASHES WERE MINOR AND INVOLVED MINOR PROPERTY DAMAGE.FOUR OF THE INJURY INCIDENTS OCCURRED WHEN UNATTENDED CHILDREN MOVED THE GEARSHIFT FROM THE PARK POSITION CAUSING THE VEHICLE TO ROLL AWAY, ONE INJURY OCCURRED WHEN THE OPERATOR WAS STRUCK BY A ROLL-AWAY VEHICLE AFTER PARKING AND EXITING.ALL INJURIES WERE RELATIVELY MINOR.A SIGNIFICANT NUMBER OF INTERLOCK SYSTEM FAILURES APPEAR TO BE RELATED TO DISENGAGEMENT OF THE INTERLOCK PIN THAT RIDES IN THE INTERLOCK LEVER SLOT WITHIN THE SHIFT MECHANISM.AN ENGINEERING ANALYSIS WILL BE OPENED TO FURTHER STUDY INTERLOCK SYSTEM FAILURES.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.