Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 25 of 318 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 106 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
28 crash reports13 fire reports19 injury reports
What owners actually said
318 reports
98,000 miles · Mar 6, 2005
Air BagsPower Train
I AM FILING THIS COMPLAINT WITH RESPECT TO A 1995 DODGE STRATUS. THE DODGE STRATUS IS EQUIPPED WITH A DEVICE WHICH I ASSUME IS TIED IN WITH THE CAR'S ELECTRONICS OR COMPUTER. THE PURPOSE OF THIS SPECIFIC DEVICE IS TO MONITOR THE OPERATION OF THE CAR'S TRANSMISSION SO THAT WHENEVER THE TRANSMISSION IS UNDER STRESS OR IS NOT OPE…
Read full complaint
I AM FILING THIS COMPLAINT WITH RESPECT TO A 1995 DODGE STRATUS. THE DODGE STRATUS IS EQUIPPED WITH A DEVICE WHICH I ASSUME IS TIED IN WITH THE CAR'S ELECTRONICS OR COMPUTER. THE PURPOSE OF THIS SPECIFIC DEVICE IS TO MONITOR THE OPERATION OF THE CAR'S TRANSMISSION SO THAT WHENEVER THE TRANSMISSION IS UNDER STRESS OR IS NOT OPERATING AS DESIGNED OR INTENDED (OR AT LEAST THE THE COMPUTER SURMISES THAT THE TRANSMISSION IS NOT OPERATING NORMALLY OR UP TO STANDARD), THE COMPUTER WHENEVER THAT OCCURS AUTOMATICALLY DOWNSHIFTS THE DODGE STRATUS TO 2ND GEAR WITHOUT ANY PRIOR WARNING OR NOTICE WHATSOEVER TO THE DRIVER AND THE DODGE REMAINS IN 2ND GEAR UNTIL SUCH TIME AS THE DODGE IS BROUGHT TO A COMPLETE STOP AND UNTIL THE ENGINE IS COMPLETELY TURNED OFF. IF YOU THEN ALLOW THE DODGE ENGINE TO REMAIN OFF FOR 3 OR 4 MINUTES AND THEN TURN THE ENGINE BACK ON AGAIN, THE CAR WILL PERFORM NORMALLY AGAIN AND WITHOUT INCIDENT AT SPEEDS UP TO 40 OR 50 OR 60 MILES PER HOUR UNTIL SUCH TIME AS THE COMPUTER, ONCE AGAIN, SUCCUMBS TO THE URGE TO DOWNSHIFT TO 2ND GEAR. AT THAT POINT, THE DRIVER FINDS HIMSELF IN 2ND GEAR AND WITH NO VIABLE ALTERNATIVE BUT TO PULL OFF THE ROAD AND TURN OFF THE ENGINE ONCE AGAIN. TO COMPREHEND WHAT THAT PREDICAMENT IS LIKE FROM THE DRIVER?S POINT OF VIEW, ONE HAS ONLY TO ENVISION YOURSELF ON THE NEW JERSEY TURNPIKE OR THE LONG ISLAND EXPRESSWAY IN RUSH HOUR TRAFFIC WITH DOZENS AND DOZENS OF 18 WHEELER TRUCKS ALL GOING 55AND 65 MILES AN HOUR WHEN, OUT OF THE BLUE, THE COMPUTER ON THE DODGE STRATUS DECIDES TO DOWNSHIFT TO 20 MILES AN HOUR AND THE NEAREST 18 WHEELER TRUCK IS ONLY 10 FEET BEHIND YOU AND DOING 60 MILES AN HOUR. IN THAT SCENARIO, THE POSSIBILITIES FOR A HORRIBLE AND CATASTROPHIC ACCIDENT COSTING DOZENS OF LIVES IS APPARENT---ALL BECAUSE THE ONBOARD COMPUTER ON THE DODGE STRATUS DECIDED ON ITS OWN TO DOWNSHIFT TO 2ND GEAR. *AK
NHTSA ODI #10112615
145,500 miles · Jan 6, 2005
Power Train
TRANSMISSION FAILED, 145,000 MILES WITH NO INDICATION OR CHECK ENGINE LIGHT. THE TRANSMISSION WAS RUNNING FINE THEN FAILED AND LEAKED A QUART AND A HALF OF FLUID FROM THE RIP IN THE PAN. *AK
NHTSA ODI #10105903
97,000 miles · Aug 31, 2004
Electrical SystemFire
AFTER PARKING THE VEHICLE, WENT INTO THE HOUSE, AND A FRIEND CAME TO NOTIFY CONSUMER THAT THE VEHICLE WAS ON FIRE. CONSUMER STATED THAT THE PERMANENT REGISTRATION ON THE VEHICLE HAD NOT BEEN RECEIVED. *AK
NHTSA ODI #10090134
64,295 miles · Aug 9, 2004
Power Train
CONSUMER RECEIVED A RECALL LETTER. CALLED A DEALER, AND WAS TOLD TO BRING THE VEHICLE IN. AFTER WAITING SHE WAS TOLD THERE WERE NO PARTS. CONSUMER MADE ANOTHER APPOINTMENT, AFTER ARRIVING AND WAITING FOR TWO HOURS THE PART WAS NOT IN, AND SHE WAS TOLD IT WOULD BE ONE MONTH. THE RECALL WAS ON SHIFT INTERLOCK.*AK
NHTSA ODI #10087448
181,075 miles · Jul 23, 2004
Electrical SystemEngine And Engine CoolingPower Train
REQUEST FOR REFUND FOR ALL REPAIRS MADE TO TRANSMISSION THAT WAS IN THE RECALL .*MR THE CONSUMER'S TRANSMISSION FAILED PRIOR TO RECALL NOTIFICATION. THE CONSUMER REQUEST REIMBURSEMENT FOR THE COST OF THE REPAIR. THE RADIATOR WAS REPLACED. THE ENGINE MOUNT ASSEMBLY WAS REPLACED. THE IGNITION WAS REPLACED. *NM
NHTSA ODI #10083763
79,000 miles · Jul 18, 2004
Power Train
CAR WILL KICK OUT OF GEAR WHILE DRIVING DOWN THE ROAD OR WON'T GO PAST FIRST GEAR WHEN STARTING IT. I'VE REPLACED ABOUT EVERYTHING EXCEPT THE TRANSMISSION AND THE ENGINE.
NHTSA ODI #10081286
56,000 miles · Feb 9, 2004
Power Train
WHILE DRIVING AT ANY SPEED TRANSMISSION WOULD NOT GO PAST FIRST GEAR. VEHICLE WAS TAKEN TO THE DEALER, WHO REBUILT THE ENGINE. CURRENTLY, TRANSMISSION WAS DOING THE EXACT SAME THING AGAIN. *AK
NHTSA ODI #10057754
Mileage unknown · Dec 15, 2003
Engine And Engine Cooling
VEHICLE DYING OUT AND WAS REPAIRED THREE TIMES WITH NO RESULT. *LA THE VEHICLE HAS STALLED SEVERAL TIME WHILE DRIVING UNDER NO CERTAIN CIRCUMSTANCES. THE DEALER HAS REPLACED THE EGR VALVE, CATALYTIC CONVERTER AND POWER DISTRIBUTION UNIT BUT THE VEHICLE CONTINUED TO STALL. THE VEHICLE HAS BEEN AT THE SERVICE SHOP FOR SEVEN WEE…
Read full complaint
VEHICLE DYING OUT AND WAS REPAIRED THREE TIMES WITH NO RESULT. *LA THE VEHICLE HAS STALLED SEVERAL TIME WHILE DRIVING UNDER NO CERTAIN CIRCUMSTANCES. THE DEALER HAS REPLACED THE EGR VALVE, CATALYTIC CONVERTER AND POWER DISTRIBUTION UNIT BUT THE VEHICLE CONTINUED TO STALL. THE VEHICLE HAS BEEN AT THE SERVICE SHOP FOR SEVEN WEEKS. *NM
NHTSA ODI #10051716
Mileage unknown · Oct 21, 2003
Engine And Engine Cooling
WE HAVE HAD OUR 1995 DODGE STRATUS AT SERRAMONTE AUTO PLAZA'S DODGE SERVICE FOR OVER 7 WEEKS NOW. THERE IS A PROBLEM WITH THE CAR DYING OUT. IT DIES AT ANY TIME AND UNDER NO SPECIFIC CONDITION. WHEN IT DIES, AS IF ALL POWER FAILS, WHICH IT DOES EVENTUALLY, AND IS OUT OF GAS. THERE HAS BEEN A TOTAL OF 2 SERVICE PROVIDES AND NOW A…
Read full complaint
WE HAVE HAD OUR 1995 DODGE STRATUS AT SERRAMONTE AUTO PLAZA'S DODGE SERVICE FOR OVER 7 WEEKS NOW. THERE IS A PROBLEM WITH THE CAR DYING OUT. IT DIES AT ANY TIME AND UNDER NO SPECIFIC CONDITION. WHEN IT DIES, AS IF ALL POWER FAILS, WHICH IT DOES EVENTUALLY, AND IS OUT OF GAS. THERE HAS BEEN A TOTAL OF 2 SERVICE PROVIDES AND NOW A THIRD TO FIGURE THIS PROBLEM OUT. MY REAL ISSUE IS WITH THE CERTIFIED EXPERT DEALER SERVICE WHO 1) REPLACED AN ERG VALVE - IT DID NOT FIX THE DYING OUT PROBLEM, THEN AFTER MORE THAN 15 SERVICE HOURS LATER THEY SAID IT WAS THE CATALYTIC CONVERTER $750 MORE AND THAT DID NOT FIX NOR WAS THE PROBLEM. PRIOR TO GOING TO THE DODGE DEALER, I HAD THE CAR AT VISITATION AUTO SERVICE IN SF WHO INFORMED US THAT THE PROBLEM WAS WITH THE POWER DISTRIBUTION UNIT $1000 TO REPLACE INCLUDING PARTS (NEVER SAW THE OLD UNIT- WAS TOLD THAT IT HAD TO GO TO THE MANUFACTURER), NOR ARE WE SURE THAT ANY OF THESE REPAIRS AND PARTS WERE JUSTIFIED - NEEDED, BECAUSE THERE HAS BEEN NO IMPROVEMENT AT ALL, THE CAR STILL DIES WHEN EVER IT FEELS LIKE IT, AND IT DIES ON THE FREEWAY, DRIVE WAY, CITY STREET, AND WILL ONLY START AGAIN AFTER A REST PERIOD OF SAY 15 MINUTES. AND THEN YOU JUST NEVER KNOW WHEN IT WILL KILL AGAIN. BEING THAT THE STRATUS HAS POWER WINDOWS, CASSETTE, 51,000 MILES, AND IS VERY GOOD CONDITION WITH NO ACCIDENTS AND EXCELLENT MAINTENANCE RECORD THE CAR'S VALUE IS $3500-$4000 BUT BECAUSE THE DEALER KNOWS OF THE ISSUE OF DYING OUT AND THEIR OWN REPAIR SHOP CAN NOT FIX IT, INFORMED US OF IT BEING WORTH $1000 - $1500, THIS IS LESS THAN THE AMOUNT WE INVESTED TO REPAIR IT, AND THEY WILL NOT OFFER US ANOTHER THATS EQUAL IN MILEAGE, CONDITION AND VALUE. SO ARE WE AT A MAJOR LOSS BECAUSE DODGE CAN NOT REPAIR THIS PROBLEM WITH THEIR VEHICLE? *LA
NHTSA ODI #10043276
Mileage unknown · Jun 26, 2003
Engine And Engine Cooling
WHILE TRAVELING ON THE HIGHWAY VEHICLE IS LEAKING OIL AND SMOKING. *AK
ON CERTAIN PASSENGER VEHICLES, THE FLOOR SHIFTER IGNITION-PARK INTERLOCK MAY FAIL AND ALLOW THE SHIFTER TO BE MOVED OUT OF THE PARK POSITION WITH THE KEY REMOVED. AN INOPERATIVE INTERLOCK MAY ALSO ALLOW THE KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: EITHER CIRCUMSTANCE MAY RESULT IN THE VEHICLE ROLLING AWAY WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER OF THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN ON JUNE 14, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. THE ADJUSTMENT OF THE CABLE CONNECTING THE CONSOLE SHIFTER MECHANISM TO THE IGNITION KEY CAN CAUSE A TRAPPED KEY CONDITION WHICH CAN RESULT IN A LOW FORCE REQUIRED TO DEPRESS THE SHIFT BUTTON. A COMBINATION OF APPLYING A MIS-ADJUSTED RELEASE BUTTON WITH A LOW FORCE ATTEMPT TO SHIFT OUT OF PARK WITH THE KEY IN THE LOCKED POSITION, CAN BREAK THE CONNECTING PIN IN THE SHIFTER.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE "IGNITION-PARK" INTERLOCK SYSTEM WILL BE NONFUNCTIONAL.
Remedy: DEALERS WILL INSPECT FOR PROPER OPERATION OF THE SYSTEM. ANY VEHICLES THAT ARE NOT FUNCTIONAL AFTER THE INSPECTION WILL HAVE THE SHIFT MECHANISM AND CABLE REPLACED WITH A "SELF-ADJUSTING" DESIGN.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR SEAT BELT ANCHOR DOES NOT ACHIEVE THE LOADING REQUIRED BY FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES."
Consequence & remedy
Consequence: FAILURE OF A SEAT BELT ANCHOR CAN RESULT IN THE LOSS OF SEAT BELT PROTECTION, WHICH COULD LEAD TO SERIOUS INJURY OR DEATH IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SEAT BELT OUTBOARD ANCHOR FLOOR ATTACHMENTS FOR PROPER POSITIONING. IF THE ANCHOR WAS IMPROPERLY ORIENTED, THE ORIENTATION WILL BE CORRECTED.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LOWER CONTROL ARM BALL JOINT CAN SEPARATE DUE TO LOSS OF LUBRICATION.
Consequence & remedy
Consequence: SEPARATION OF THE BALL JOINT COULD CAUSE A LOSS OF STEERING CONTROL INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE BALL JOINT END HOUSING COVER SEAL FOR LEAKAGE WITH A HIGH PRESSURE AIR TESTER AND THE RUBBER BOOT WILL BE VISUALLY INSPECTED FOR DAMAGE. IF THE COVER SEAL LEAKS OR THE BOOT IS DAMAGED, THE LOWER CONTROL ARM WILL BE REPLACED.
THE BRAKE MASTER CYLINDER CAN LEAK BRAKE FLUID DUE TO A DAMAGED DOUBLE LIP REAR PISTON SEAL.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE CAN RESULT IN DIMINISHED EFFECTIVENESS OF ONE HALF OF THE SPLIT BRAKE SYSTEM. THE INSTRUMENT PANEL WARNING LIGHT(S) WILL SIGNAL SYSTEM IMPAIRMENT PRIOR TO PARTIAL BRAKE SYSTEM LOSS.
Remedy: DEALERS WILL REPLACE THE REAR BRAKE MASTER CYLINDR PISTON ASSEMBLY.
IN CERTAIN VEHICLES, THE ENGINE CYLINDER HEAD OIL GALLEY PLUG DOES NOT SEAL PROPERLY AND ENGINE CYLINDER HEAD OIL IS NOT ADEQUATELY RETAINED.
Consequence & remedy
Consequence: INADEQUATE SEALING AND RETENTION OF THE PLUG CAN RESULT IN OIL LEAKAGE WHICH COULD CAUSE A FIRE IN THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL INSTALL AN EXPANSION PLUG AND RETAINING BRACKET OVER THE CYLINDER HEAD OIL GALLEY PLUG.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
EA97016 · Lower Control Arm Ball Joint Failure
Opened Sep 29, 1997 · Closed Nov 20, 1997
Status: closed (inferred from source dates) · Suspension
BY LETTER DATED NOVEMBER 6, 1997, THE MANUFACTURER ADVISED THIS AGENCY OF ITS DECISION TO INITIATE A SAFETY RECALL CAMPAIGN OF THE SUBJECT VEHICLES TO CORRECT THE DEFECT IDENTIFIED IN THIS EA.THE RECALL WILL ALSO COVER 1996 AND 1997 CHRYSLER CIRRUS/DODGE STRATUS VEHICLES, AS WELL AS 1995 THROUGH 1997 CHRYSLER SEBRING CONVERTIBLE AND PLYMOUTH BREEZE VEHICLES EQUIPPED WITH IDENTICAL LOWER CONTROL ARM BALL JOINTS.AN ESTIMATED TOTAL OF 599,00VEHICLES ARE AFFECTED BY THIS RECALL.THE MANUFACTURER'S INVESTIGATION DISCLOSED THAT PROCESS VARIABILITY, TOGETHER WITH THE BALL JOINT HOUSING COVER CRIMPING OPERATION, CAN RESULT IN AN INEFFECTIVE SEAL THAT PERMITS A LOSS OF LUBRICATION AND ACCELERTED WEAR OF THE BALL JOINT ASSEMBLY.THIS CONDITION CAN LEAD TO FAILURE AND SEPARTION OF THE LOWER CONTROL ARM BALL JOINT.THE RECALL IS IDENTIFIED AS NHTSA 97V-201 AND A COPY OF CHRYSLER'S LETTER TO NHTSA IS ATTACHED HERETO.
PE97009 · Lower Control Arm Ball Joint Failure
Opened Mar 13, 1997 · Closed Sep 29, 1997
Status: closed (inferred from source dates) · Suspension
THE MANUFACTURER IDENTIFED VEHICLE OWNER COMPLAINTS OF THE SUBJECT BALL JOINT FAILURES AS TABULATED ABOVE.IN ADDITION, A TOTAL OF 72 WARRANTY REPORTS WERE IDENTIFIED FOR REPLACEMENT OF BROKEN OR CRACKED BALL JOINT ASSEMBLIES IN THE SUBJECT VEHICLES.CHRYSLER ALSO REPORTED THAT 1996 AND 1997 MODELS ARE EQUIPPED WITH IDENTICAL BALL JOINT ASSEMBLIES AS THE SUBJECT 1995 MODEL YEAR VEHICLES.A PARTIAL RESPONSE TO NHTSA'S INFORMATION REQUEST INDICATED THAT THE MANUFACTURER'S ANALYSES AND EVALUATIONS OF THE CONDITION WERE CONTINUING.IN ORDER TO CONTINUE NHTSA'S COMPLETE ASSESSMENT OF THE NATURE AND SCOPE OF THIS MATTER, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
1995 Dodge Stratus Problems, Complaints & Recalls | Skip That Year
Illustration