Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 15 of 63 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Power Train. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Seat Belts. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
63 reports
160,000 miles · Mar 2, 2012
Power Train
TL* THE CONTACT OWNS A 1991 DODGE STEALTH. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE WHEELS SEIZED AND AS THE CONTACT ATTEMPTED TO SHIFT GEARS TO UNLOCK THE WHEELS, THE VEHICLE MADE A LOUD GRINDING NOISE FOLLOWED BY A LOUD EXPLOSION. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHERE A DIAGNOSTIC WAS PERFORMED, WHICH LOCAT…
Read full complaint
TL* THE CONTACT OWNS A 1991 DODGE STEALTH. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE WHEELS SEIZED AND AS THE CONTACT ATTEMPTED TO SHIFT GEARS TO UNLOCK THE WHEELS, THE VEHICLE MADE A LOUD GRINDING NOISE FOLLOWED BY A LOUD EXPLOSION. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHERE A DIAGNOSTIC WAS PERFORMED, WHICH LOCATED THE FAILURE AT THE TRANSMISSION TRANSFER CASE. THE MANUFACTURER ADVISED THE CONTACT THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER 02V143002 (POWER TRAIN: TRANSFER CASE: 4-WHEEL DRIVE), BUT DENIED ASSISTANCE WITH THE REPAIRS DUE TO THE AGE OF THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 160,000. UPDATED 04/10/12*LJ
NHTSA ODI #10450081
110,000 miles · Jan 7, 2010
Power Train
TL*THE CONTACT OWNS A 1991 DODGE STEALTH. RECALL# 02V143002, POWER TRAIN, TRANSFER CASE (4-WHEEL DRIVE) IS RELATED TO THE FAILURE THAT THE CONTACT HAS EXPERIENCED. THE OIL LEAKS FROM THE ALL-WHEEL DRIVE TRANSFER CASE WHICH CAUSED THE BEARINGS TO BE LOCK AND DAMAGE THE DRIVE TRAIN. WHILE DRIVING 35 MPH THE VEHICLE BECAME INOPERAB…
Read full complaint
TL*THE CONTACT OWNS A 1991 DODGE STEALTH. RECALL# 02V143002, POWER TRAIN, TRANSFER CASE (4-WHEEL DRIVE) IS RELATED TO THE FAILURE THAT THE CONTACT HAS EXPERIENCED. THE OIL LEAKS FROM THE ALL-WHEEL DRIVE TRANSFER CASE WHICH CAUSED THE BEARINGS TO BE LOCK AND DAMAGE THE DRIVE TRAIN. WHILE DRIVING 35 MPH THE VEHICLE BECAME INOPERABLE AND WAS TOWED TO HIS RESIDENCE. THE RECALL REPAIR WAS PERFORMED; HOWEVER, THE FAILURE RECURRED. THE CONTACT FILED A CLAIM WITH THE MANUFACTURER AND IT WAS DENIED STATING THAT HE HAD TO PAY FOR THE REPAIR OUT OF POCKET. THE FAILURE MILEAGE WAS 110,000.
NHTSA ODI #10298560
Mileage unknown · Jun 29, 2007
Seat Belts
SEAT BELT MALFUNCTIONED SINCE I OWNED THE CAR. ON (MAY, 200) THE SEAT BELTS IN THE FRONT DID NOT RETRACT PROPERLY. UPON TALKING TO OTHER CAR OWNERS THEY HAD SIMILAR PROBLEMS. *AK
NHTSA ODI #10194929
150,000 miles · Apr 1, 2007
Seat Belts
I HAVE A 1991 DODGE STEALTH AND THE RETRACTOR FOR THE SEAT BELT NO LONGER WORKS. WHEN YOU PUT ON THE SEAT BELT IN MOST CASES THE SLACK IS NOT TAKEN UP. I HAVE NOT BEEN IN AN ACCIDENT AND I HOPE I'M NOT. *JB
NHTSA ODI #10186660
18,000 miles · Mar 21, 2007
Seat Belts
MY DRIVER'S SIDE SEATBELT DOES NOT WORK PROPERLY. WHEN I PULL IT OUT TO BUCKLE UP THE EXTRA SLACK DOES NOT GET TAKEN CARE OF. IT JUST REMAINS LOOSE AND I DON'T KNOW HOW WELL IT WOULD HOLD UP IN AN ACCIDENT. THIS SEEMS TO BE MOST OF THE TIME BUT ONCE IN A WHILE FOR SOME REASON IT WILL RETRACT THE EXTRA SLACK.*AK
NHTSA ODI #10185792
92,000 miles · Jan 15, 2007
Seat Belts
1. SEAT BELT WILL NOT RETRACT, AND REMOVE SLACK ONCE THE SEAT BELT IS LATCHED.--- 2. AFTER BUCKLING MY SEAT BELT, THE SEAT BELT WILL NOT RETRACT. IT WILL LEAVE A LARGE AMOUNT OF SLACK BETWEEN MY BODY AND THE SEAT. IN A WRECK, IF THERE IS SLACK IN THE SEAT BELT BETWEEN THE BODY AND THE SEAT, THE SEAT BELT WILL NOT BE ABLE TO PRO…
Read full complaint
1. SEAT BELT WILL NOT RETRACT, AND REMOVE SLACK ONCE THE SEAT BELT IS LATCHED.--- 2. AFTER BUCKLING MY SEAT BELT, THE SEAT BELT WILL NOT RETRACT. IT WILL LEAVE A LARGE AMOUNT OF SLACK BETWEEN MY BODY AND THE SEAT. IN A WRECK, IF THERE IS SLACK IN THE SEAT BELT BETWEEN THE BODY AND THE SEAT, THE SEAT BELT WILL NOT BE ABLE TO PROPERLY RESTRAIN THE BODY. RESULTING IN SERIOUS INJURY, TRAUMA, AND POSSIBLE EJECTION FROM THE CAR, INCLUDING THE POSSIBILITY OF PARALYSIS OR DEATH.--- 3.TRIED CLEANING THE SEAT BELT HANGER AND THE PLACE THE BELT GOES INTO THE CAR, BUT THIS DID NOT RESOLVE THE ISSUE.--- *THERE HAVE BEEN WELL OVER 250 FAILURES, I CAN NOT GIVE AN EXACT AMOUNT OF HOW MANY TIMES I GET IN AND OUT OF MY CAR OVER A COURSE OF TIME, SO THE NUMBER I PUT BELOW IS AN CONSERVATIVE ESTIMATE. I HAVE OWNED THE CAR FOR ALMOST 2 YEARS NOW, AND DRIVE THE CAR BACK AND FORTH TO WORK, AND ON ERRANDS. *JB
NHTSA ODI #10178728
119,500 miles · Dec 11, 2006
Seat Belts
SEAT BELT ON BOTH PASSENGER/DRIVER SIDES FAIL TO RETRACT. *NM
NHTSA ODI #10175794
40,000 miles · Jul 17, 2006
Seat Belts
SEAT BELT DOES NOT RETRACT, LEAVING SLACK WHILE DRIVING IN BOTH DRIVER AND PASSENGER BELTS. *JB
NHTSA ODI #10162586
126,000 miles · May 8, 2006
Seat Belts
SEAT BELTS DO NOT RETRACT ALL THE WAY CAUSING THEM TO POSSIBLY FAIL DURING AN ACCIDENT. *NM
NHTSA ODI #10157012
Mileage unknown · Apr 25, 2006
Seat Belts
THE SEAT BELT DO NOT FULLY RETRACT, LEAVING A LOT OF SLACK. THIS MAKES ME FEEL UNSAFE, SINCE IT IS NOT DOING ITS JOB. WITH THE SEAT BELT BEING LOOSE, IF I WERE TO BE INVOLVED IN AN ACCIDENT, IT WOULD NOT BELT ME IN, WITH ALL THAT EXTRA SLACK HANGING OUT. THIS HAS BEEN A BIG ISSUE FOR A LONG TIME. *NM
ON CERTAIN PASSENGER VEHICLES BUILT BY MITSUBISHI MOTOR CORPORATION FOR DAIMLERCHRYSLER, A CONDITION EXISTS THAT ALLOWS OIL TO LEAK FROM THE ALL-WHEEL DRIVE TRANSFER CASE.
Consequence & remedy
Consequence: LOW OIL LEVELS IN THE TRANSFER CASE COULD CAUSE BEARING DAMAGE AND RESULT IN DRIVE TRAIN LOCKUP, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE TRANSFER CASE FOR INDICATIONS OF OIL LEAKAGE. VEHICLES THAT HAVE NO OIL LEAKAGE WILL HAVE THE TRANSFER CASE OIL CHANGED. VEHICLES THAT HAVE OIL LEAKAGE WILL HAVE THE TRANSFER CASE RESEALED OR REPLACED IF NECESSARY. OWNER NOTIFICATION IS EXPECTED TO BEGIN DECEMBER 2, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
UNDER CONDITIONS OF FULL LOCK STEERING AND FULL SUSPENSION TRAVEL, THE LEFT OR RIGHT FRONT WHEEL-SIDE BRAKE HOSE CAN CRACK, RESULTING IN BRAKE FLUID LEAKAGE.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE WILL CAUSE ILLUMINATION OF THE BRAKE WARNING LAMP AND REDUCTION IN BRAKING EFFECTIVENESS INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT WHEEL-SIDE BRAKE HOSES WITH REVISED HOSE ASSEMBLIES.
THE FRONT SAFETY BELT BUCKLE RELEASE BUTTONS CAN BREAK. THESE RED PLASTIC RELEASE BUTTONS ARE MARKED "PRESS." IF A BUTTON BREAKS, PIECES CAN FALL INTO THE BUCKLE ASSEMBLY CAUSING THE BUCKLE TO OPERATE IMPROPERLY.
Consequence & remedy
Consequence: THE SAFETY BELTS WOULD NOT PROVIDE ADEQUATE PROTECTION TO AN OCCUPANT IN A VEHICLE CRASH.
Remedy: OWNERS SHOULD PROMPTLY CHECK THE CONDITION AND OPERATION OF BOTH FRONT SAFETY BELT BUCKLES AND CAREFULLY INSPECT THE RED RELEASE BUTTON FOR ANY BREAKS OR CRACKS. THEY SHOULD ENSURE THAT BOTH BUCKLES ARE OPERATING PROPERLY BY INSERTING EACH LATCH PLATE INTO ITS BUCKLE, TUGGING ON THE BELT TO MAKE SURE THE LATCH IS SECURELY LOCKED, AND THEN PRESSING THE RELEASE BUTTON. THE LATCH PLATE SHOULD POP OUT OF THE BUCKLE WHEN THE BUTTON IS PRESSED. IF EITHER RELEASE BUTTON SHOWS A SIGN OF BREAKING OR CRACKING OR IF EITHER BUCKLE FAILS TO OPERATE PROPERLY, OWNERS SHOULD PROMPTLY CONTACT THEIR AUTHORIZED DEALER TO SCHEDULE AN APPOINTMENT TO HAVE THE BUCKLE REPLACED OR REPAIRED, FREE OF CHARGE. THE MANUFACTURER IS DEVELOPING A REMEDY DESIGNED TO PREVENT FAILURE OF THE BUTTONS THAT ARE NOT CURRENTLY BROKEN.
A CONDITION EXISTS THAT ALLOWS OIL TO LEAK FROM THE ALL WHEEL DRIVE TRANSFER CASE. LOW OIL LEVELS IN THE TRANSFER CASE CAN CAUSE BEARING DAMAGE AND FAILURE.
Consequence & remedy
Consequence: BEARING FAILURE IN THE TRANSFER CASE RESULTS INPOWER TRAIN LOCKUP WITHOUT PRIOR WARNING, WHILE THE VEHICLE IS AT HIGHWAY SPEED.THIS COULD CAUSE IN A LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Remedy: INSTALL A C-RING TO TRANSFER CASE TO PREVENT OIL LEAKAGE, OR REPLACE TRANSFER CASE TO MAINTAIN SUFFICIENT OIL LEVELS IN THE TRANSFER CASE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA92004 · Transfer Case Lockup
Opened Jan 23, 1992 · Closed Mar 26, 1993
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
Additional source detail variants (2)
Power Train
There is no summary currently available
Power Train
There is no summary currently available
1991 Dodge Stealth Problems, Complaints & Recalls | Skip That Year
Illustration