IllustrationSee attached document for complaint.
2005 Dodge Sprinter 2500
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sprinter 2500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 18 of 21 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports2 fire reports1 injury reports
Engine And Engine Cooling complaints
6 reportsSPRINTER VAN STALLS DURING DECELERATION 2005 SPRINTER VAN WITH DUAL A/C STALLS WHEN BOTH A/C ARE ON AND DECELERATING. HAPPENS DURING SUMMER MONTHS DODGE HAS A FIX WITH A SERVICE BULLETIN BUT ONLY IF UNDER WARRANTY. *TR
TURBO RESONATOR CHAMBER FAILURE. RESULTING IN LOSS OF BOOST AND POWER. *TR
TL*THE CONTACT OWNS A 2005 DODGE SPRINTER 3500. WHILE DRIVING APPROXIMATELY 70 MPH THE TURBO RESONATOR CAUSED THE VEHICLE TO DECELERATE. THERE WERE NO PRIOR WARNING SIGNS WHICH AS A CONSEQUENCE INCREASED THE RISK OF A SERIOUS CRASH AND INJURY. THE DEALER REPLACED THE TURBO RESONATOR FOUR TIMES. ALL ATTEMPTS TO REPAIR THE FAIL…
Read full complaint
TL*THE CONTACT OWNS A 2005 DODGE SPRINTER 3500. WHILE DRIVING APPROXIMATELY 70 MPH THE TURBO RESONATOR CAUSED THE VEHICLE TO DECELERATE. THERE WERE NO PRIOR WARNING SIGNS WHICH AS A CONSEQUENCE INCREASED THE RISK OF A SERIOUS CRASH AND INJURY. THE DEALER REPLACED THE TURBO RESONATOR FOUR TIMES. ALL ATTEMPTS TO REPAIR THE FAILURE HAVE BEEN UNSUCCESSFUL. A TECHNICIAN SPECULATED THT POOR QUALITY AND EXCESSIVE HEAT EXPOSURE CAUSED THE COMPONENT TO FAIL. THE FAILURE MILEAGE WAS 2,336 AND THE CURRENT MILEAGE WAS 25,000.UPDATED 5/6/09 *CN UPDATED 05/08/09.*JB
TL*- THE CONTACT STATED VEHICLE LOST THE ABILITY TO ACCELERATE ON 05/22/06. THE CONTACT STATED THAT THIS WAS A CLEAR DAY AND THE ROAD CONDITIONS WERE GOOD. WAS DRIVING AT 70 MPH ON THE HIGHWAY ANDTHE VEHICLE STARTED LOSING SPEED. THE VEHICLE'S SPEED WENT DOWN TO 30-35 MPH, AND THE CHECK ENGINE LIGHT TURNED ON. THE CONTA…
Read full complaint
TL*- THE CONTACT STATED VEHICLE LOST THE ABILITY TO ACCELERATE ON 05/22/06. THE CONTACT STATED THAT THIS WAS A CLEAR DAY AND THE ROAD CONDITIONS WERE GOOD. WAS DRIVING AT 70 MPH ON THE HIGHWAY ANDTHE VEHICLE STARTED LOSING SPEED. THE VEHICLE'S SPEED WENT DOWN TO 30-35 MPH, AND THE CHECK ENGINE LIGHT TURNED ON. THE CONTACT S PULLED OVER TO THE SIDE OF THE ROAD AND TURNED THE VEHICLE OFF, AND STARTED IT BACK UP. THE VEHICLE WENT BACK TO 70-75 MPH FOR ABOUT 3 MILES AND STARTED LOSING POWER AGAIN. THIS HAPPENED FOR ABOUT 100 MILES, THE VEHICLE WOULD LOOSE SPEED, HE' PULLED TO SIDE OF ROAD AND THE CHECK ENGINE LIGHT WOULD COME ON, AND HE RESTARTED THE VEHICLE WHICH WOULD GO 70 MPH AGAIN. THE CONTACT STATED THAT THE REPAIR ORDER SITED THE TURBO RESONATOR AS THE CAUSE OF THE FAILURE.*AK UPDATED 1/29/2007 - (TURBO RESONATOR # 05137154AA) *NM
DT*: THE CONTACT STATED WHILE DRIVING 70 MPH IN HEAVY TRAFFIC, THE VEHICLE LOST POWER. THE VEHICLE WENT INTO LIMP HOME MODE AND WAS LATER DRIVEN TO THE DEALER WHO REPLACED THE RESONATOR IN THE TURBO. *AK UPDATED 09/15/06. *JB
Official recalls
316V833000 · Electrical System: Instrument Cluster/panel; Service Brakes, Hydraulic
Nov 17, 2016
Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2003-2006 Dodge and Freightliner Sprinter 2500 and 3500 vans manufactured June 30, 2003, to August 31, 2006. The instrument cluster on the affected vehicles fails to illuminate the BRAKE warning lamp in the instrument cluster during the vehicle start up bulb-function check. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 105, "Hydraulic and Electric Brake Systems."
Consequence & remedy
Consequence: Without the BRAKE lamp illuminating during the vehicle start up bulb-function check, the driver has no confirmation that the lamp is working and therefore may not know whether or not the lamp will illuminate if the brake fluid level is low. If the operator is unaware that the vehicle has low brake fluid, there would be an increased risk of a crash.
Remedy: DVUSA will notify owners, and DVUSA and Dodge dealers will correct the instrument cluster software, as necessary, free of charge. An interim notification was sent to owners on January 6, 2017. A second notice will be mailed to owners once the remedy becomes available. The recall began on July 27, 2017. Owners may contact DVUSA customer service at 1-770-705-2070.
Additional source detail variants (2)
Electrical System: Instrument Cluster/panel
Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2003-2006 Dodge and Freightliner Sprinter 2500 and 3500 vans manufactured June 30, 2003, to August 31, 2006. The instrument cluster on the affected vehicles fails to illuminate the BRAKE warning lamp in the instrument cluster during the vehicle start up bulb-function check. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 105, "Hydraulic and Electric Brake Systems."
Consequence: Without the BRAKE lamp illuminating during the vehicle start up bulb-function check, the driver has no confirmation that the lamp is working and therefore may not know whether or not the lamp will illuminate if the brake fluid level is low. If the operator is unaware that the vehicle has low brake fluid, there would be an increased risk of a crash.
Remedy: DVUSA will notify owners, and DVUSA and Dodge dealers will correct the instrument cluster software, as necessary, free of charge. An interim notification was sent to owners on January 6, 2017. A second notice will be mailed to owners once the remedy becomes available. The recall began on July 27, 2017. Owners may contact DVUSA customer service at 1-770-705-2070.
Service Brakes, Hydraulic
Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2003-2006 Dodge and Freightliner Sprinter 2500 and 3500 vans manufactured June 30, 2003, to August 31, 2006. The instrument cluster on the affected vehicles fails to illuminate the BRAKE warning lamp in the instrument cluster during the vehicle start up bulb-function check. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 105, "Hydraulic and Electric Brake Systems."
Consequence: Without the BRAKE lamp illuminating during the vehicle start up bulb-function check, the driver has no confirmation that the lamp is working and therefore may not know whether or not the lamp will illuminate if the brake fluid level is low. If the operator is unaware that the vehicle has low brake fluid, there would be an increased risk of a crash.
Remedy: DVUSA will notify owners, and DVUSA and Dodge dealers will correct the instrument cluster software, as necessary, free of charge. An interim notification was sent to owners on January 6, 2017. A second notice will be mailed to owners once the remedy becomes available. The recall began on July 27, 2017. Owners may contact DVUSA customer service at 1-770-705-2070.
08V339000 · Steering:column
Jul 24, 2008
SPRINTER IS RECALLING 10 MY 2001-2006 DODGE AND FREIGHTLINER 2500 AND 3500 VEHICLES. THE WELDING SEAM BETWEEN THE BRACKET AND STEERING COLUMN OF AFFECTED SPARE PARTS DOES NOT MEET DESIGN SPECIFICATIONS. THE RESULT OF AN OUT OF SPECIFICATION WELDING SEAM IS THAT THE STEERING COLUMN MAY DETACH FROM ITS INTERIOR VEHICLE MOUNTING BRACKET.
Consequence & remedy
Consequence: THE OPERATOR MAY LOSE STEERING ABILITY OF THE VEHICLE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE STEERING COLUMNS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 16, 2009. OWNERS MAY CONTACT SPRINTER AT 843-695-5057.
07V299000 · Interior Lighting
Jul 13, 2007
ON CERTAIN TRUCKS EQUIPPED WITH REAR AIR CONDITIONING SYSTEM, THE INTERIOR LAMP IS EQUIPPED WITH AN 18W LAMP AND A SCATTERING LENS. IN EXTREMELY HOT AND HUMID CONDITIONS, THE COMBINATION OF HEAT AND HUMIDITY, AND THE HEAT FROM THE LAMP DUE TO EXTREME LONG TERM OPERATION, CAN DISTORT THE SCATTERING LENS.
Consequence & remedy
Consequence: THE SWITCHING CONTACTS OF THE LAMP MAY CAUSE A SHORT CIRCUIT OF THE REAR LAMP INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL REPLACE THE REAR INTERIOR LAMPS FREE OF CHARGE WITH A MODIFIED VERSION WHICH IS NOT SUBJECT TO THE IMPACTS OF HEAT AND HUMIDITY. THE RECALL BEGAN ON DECEMBER 17, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER MANUFACTURING INTERNATIONAL AT 1-843-695-5041.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.