IllustrationSTEERING PITMAN ARM AND IDLER ARM HAVE A LOT OF PLAY, FRONT BEARINGS LOOSE, FRONT ROTORS RUSTED AND WORN OUT REQUIRED REPLACEMENT. *AK
1996 Dodge RAM
Owner reports · Recalls · Investigations
More warning signs than most RAM years
Owner complaints for the 1996 Dodge RAM are substantially higher than the model-year median of 27.
About this comparison →How this year compares
Owner complaints by model year
Compare all RAM years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 18 of 625 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 170 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 135 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
72 crash reports23 fire reports34 injury reports
Service Brakes, Hydraulic complaints
170 reportsDOG ELECTROCUTED DUE TO POSSIBLE FAULTY WIRING HARNESS, NOTICE RECEIVED AFTER INCIDENT ABOUT POTENTIAL HAZARD. *MJS
WHEN APPLYING BRAKES VEHICLE WILL PULLS HARD TO LEFT . DEALER HAS RESURFACED FRONT BRAKES, AND FLUSHED MASTER CYLINDER AND ITS LINES, BUT DEFECT KEEPS REOCCURRING. *AK
TRANSMISSION WILL NOT SHIFT TO 2-3 GERAS NORMALY, ALSO, ABS BRAKE LIGHT COMES ON AT IDLE. *AK
BRACKET FOR THE EMERGENCY BRAKE CABLE HAS FALLEN OFF DUE TO NUTS ON THE BOLTS SECURING THE BRACKET BECOMING LOOSE AND BOTH FALLING OFF. NUTS ARE LOCATED BEHIND THE GAS TANK AND ARE NOT ACCESSABLE UNLESS THE GAS TANK IS REMOVED. EMERGENCY BRAKE NOT OPERATIONAL.
WHEN APPLYING THE BRAKES THE PEDAL GOES TO THE FLOOR, CAUSING EXTENDED STOPPING DISTANCE. REPLACED BRAKES FIVE TIMES WITHIN TWO YEARS. ALSO, THE ROTORS ARE PREMATURLEY WEARING. PLEASE GIVE ANY FURTHER DETAILS. *AK
WHEN THE BRAKES ARE APPLIED THE PEDAL GETS MUSHY AND GOES TO THE FLOOR CAUSING EXTENDED STOPPING DISTANCES RESULTING IN A COLLISION. THE DEALER HAS NOTIFIED. MJS
TRANSMISSION SHUDDERS AT 45 MPH, DOES NOT SHIFT AND SHAKES WHEN GOING INTO 3RD OR OVERDIRVE, AND JERKS AND SLIPS, DEALER HAS REPLACED THE VALVE BODY AND RECONDITIONED TRANSMISSION AND REPLACED CONVERTOR, TRANSMISSION CONTINUES TO LOCK UP AND JERK. DRIVER AND PASSENGER SIDE MIRRORS WERE BOTH REPLACED DUE TO BEING LOOSE. EMERGEN…
Read full complaint
TRANSMISSION SHUDDERS AT 45 MPH, DOES NOT SHIFT AND SHAKES WHEN GOING INTO 3RD OR OVERDIRVE, AND JERKS AND SLIPS, DEALER HAS REPLACED THE VALVE BODY AND RECONDITIONED TRANSMISSION AND REPLACED CONVERTOR, TRANSMISSION CONTINUES TO LOCK UP AND JERK. DRIVER AND PASSENGER SIDE MIRRORS WERE BOTH REPLACED DUE TO BEING LOOSE. EMERGENCY BRAKE HANDLE CAME OFF AND WAS REPLACED. FUEL GAUGE READ EMPTY WITH 12 GALLONS IN TANK, DEALER REPLACED FUEL PUMP MODULE. WIPER BLADES WEREN'T CLEANING WINDSHIELD, DEALER REPLACED BOTH WIPER BLADES, WINDSHIELD WASHER WAS INOPERABLE, DEALER REPLACED WASHER MOTOR. VEHICLE HAS EXPERIENCED MANY PROBLEMS WITH THE INTERIOR AND DOME LIGHTS FAILING, DOME LIGHT KEEPS BLOWING FUSE AND DEALER HAS REPLACED THE STRIP LIGHTING AND FUSE BOX DOOR AND REPAIRED THE OPEN CIRCUIT TO JUNCTION BLOCK. RADIATOR CAP WAS REPLACED DUE TO LOW COOLANT. THERE WAS A BRAKE FLUID LEAK, DEALER REPLACED CAPS FOR THE MASTER CYLINDER, THE BRAKE AND ABS LIGHT WERE ILLUMINATED, DEALER REPLACED REAR WHEEL SPEED SENSOR AND WIRING. PASSENGER SIDE VENT WINDOW WOULD NOT OPEN AND LEAKED AIR. VEHICLE ONLY GETS 13MPH ON HIGHWAY, CONSUMER STATES THIS IS POOR GAS MILEAGE. *SLC
WHEN APPLYING THE BRAKES, VEHICLE HAS NO POWER. ALSO, THE POWER STEERING FAILED, CAUSING CONSUMER TO PUT VEHICLE INTO NEUTRAL, AND REV THE ENGINE. TOOK SIX MONTHS TO GET PART AFTER REPEATED CALLS. FRONT BRAKES WEARING OUT PREMATURELY BECAUSE REAR BRAKES ARE NOT SELF ADJUSTING. VERY UNSAFE WHEN BRAKING AT HIGHER SPEEDS. *YC T…
Read full complaint
WHEN APPLYING THE BRAKES, VEHICLE HAS NO POWER. ALSO, THE POWER STEERING FAILED, CAUSING CONSUMER TO PUT VEHICLE INTO NEUTRAL, AND REV THE ENGINE. TOOK SIX MONTHS TO GET PART AFTER REPEATED CALLS. FRONT BRAKES WEARING OUT PREMATURELY BECAUSE REAR BRAKES ARE NOT SELF ADJUSTING. VERY UNSAFE WHEN BRAKING AT HIGHER SPEEDS. *YC THE LEFT REAR AXLE SEAL WAS LEAKING. WATER COLLECTS NEAR THE PASSENGER DOOR UNDERNEATH THE CARPET. *YH
BRAKE PERFORMANCE DIMINISHED, TAKES HEAVY BRAKE PEDAL PRESSURE TO STOP. PARKING BRAKE DOES NOT HOLD VEHICLE, WITH PARKING BRAKE PUSHED ON HARD THE VEHICLE CAN STILL CREEP. FRONT BRAKE PADS WEARING VERY QUCIKLY, REAR BRAKE SHOES GLAZED. REAR BRAKE SHOES REPLACED THREE TIMES, A NEW SET OF "HEAVY DUTY" REAR WHEEL CYLINDERS WERE …
Read full complaint
BRAKE PERFORMANCE DIMINISHED, TAKES HEAVY BRAKE PEDAL PRESSURE TO STOP. PARKING BRAKE DOES NOT HOLD VEHICLE, WITH PARKING BRAKE PUSHED ON HARD THE VEHICLE CAN STILL CREEP. FRONT BRAKE PADS WEARING VERY QUCIKLY, REAR BRAKE SHOES GLAZED. REAR BRAKE SHOES REPLACED THREE TIMES, A NEW SET OF "HEAVY DUTY" REAR WHEEL CYLINDERS WERE INSTALLED BY THE DEALER. THE WHEEL CYLINDERS HELPED SOME BUT THE TRUCK HAS POOR BRAKING PERFORMANCE, ESPECIALLY WITH A LIGHT LOAD IN THE BED OR TOWING AN EMPTY 16' FLAT BED TRAILER. REPLACED FRONT BRAKE PADS AND THEY WERE WORN UNEVENLY. I DON'T KNOW IF A PROPORTINING VALVE WOULD CAUSE THIS KIND OF PROBLEM. THE DEALER HAS TRIED WHAT THEY THOUGHT WOULD FIX THE PROBLEM. THE TRUCK IS OUT OF WARRANTY NOW SINCE OCTOBER OF 1999.
Official recalls
1001V037000 · Vehicle Speed Control
Feb 12, 2001
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH DIESEL ENGINES. THE THROTTLE CABLE COULD UNRAVEL (FRAY) OR BREAK RESULTING IN LOSS OF THROTTLE CONTROL.
Consequence & remedy
Consequence: A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE THROTTLE CABLE AND UPPER BELL CRANK LEVER. OWNER NOTIFICATION BEGAN AUGUST 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
01V040000 · Latches/locks/linkages:hood:latch
Feb 12, 2001
ON CERTAIN PICKUP TRUCKS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING "SALT BELT" STATES: MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, AND MISSOURI. CORROSION OF THE RETURN SPRING ON THE HOOD SECONDARY LATCH COULD CAUSE THE MECHANISM TO BIND IN THE "RELEASE POSITION."
Consequence & remedy
Consequence: IF THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD OPEN UNEXPECTEDLY.
Remedy: DEALERS WILL REPLACE THE SECONDARY HOOD LATCH. OWNER NOTIFICATION BEGAN SEPTEMBER 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V135000 · Electrical System:ignition:switch
May 10, 2000
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE AFFECTED VEHICLES WERE BUILT WITH AN IGNITION SWITCH AND WIRING THAT COULD OVERHEAT. HIGH ELECTRICAL CURRENT LOADS PASS THROUGH THE SWITCH WHEN THE BLOWER MOTOR IS OPERATED ON HIGH FOR AN EXTENDED PERIODS OF TIME.
Consequence & remedy
Consequence: THIS COULD CAUSE THE IGNITION SWITCH AND WIRING TO OVERHEAT.
Remedy: DEALERS WILL INSTALL A RELAY AND OVERLAY HARNESS.
99V115000 · Power Train:clutch Assembly
May 6, 1999
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSION, V10 ENGINES AND FOUR-WHEEL-DRIVE TRANSFER CASES. UNDER SUSTAINED MAXIMUM RATED VEHICLE LOAD, WHILE DRIVING UP A STEEP GRADE IN FOUR-WHEEL-DRIVE LOW RANGE IN HOT AMBIENT CONDITIONS, THE LOCAL EXHAUST TEMPERATURE PROXIMATE TO THE HYDRAULIC CLUTCH LINE CAN GENERATE LINE TEMPERATURES THAT EXCEED THE TEMPERATURE LIMIT OF THE CLUTCH LINE MATERIAL. IF THIS CONDITION OCCURS AND THE CLUTCH IS DEPRESSED, THE LINE COULD RUPTURE.
Consequence & remedy
Consequence: THE FLUID COULD IGNITE ON THE HOT EXHAUST POSSIBLY RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL REPLACE THE HYDRAULIC CLUTCH ASSEMBLY.
99V023000 · Air Bags:frontal
Feb 5, 1999
VEHICLE DESCRIPTION: VAN AND WAGON MODEL PASSENGER VEHICLES. IF WATER/ROAD SALT GETS ON THE INTERIOR FLOOR OF THE VEHICLE IN THE PROXIMITY OF THE AIR BAG ELECTRONIC CONTROL MODULE (AECM), THE AECM CAN CORRODE. THE RESULTING CORROSION CAN CAUSE THE DRIVER SIDE AIR BAG TO DEPLOY INADVERTENTLY.
Consequence & remedy
Consequence: DEPLOYMENT OF THE AIR BAG WITHOUT WARNING COULD CAUSE A DRIVER TO LOSE VEHICLE CONTROL, INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WIL REPLACE THE AECM WITH AN AECM THAT IS SEALED FROM MOISTURE INTRUSION.
97V199000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Nov 13, 1997
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH GASOLINE ENGINES. THE FUEL TANK MOUNTED ROLLOVER VALVE CAN ALLOW LIQUID FUEL TO LEAK ONTO THE GROUND UNDER CERTAIN VEHICLE OPERATING CONDITIONS.
Consequence & remedy
Consequence: FUEL LEAKAGE COULD RESULT IN A FIRE IF AN IGNITION SOURCE WAS PRESENT.
Remedy: DEALERS WILL REPLACE THE FUEL TANK ROLLOVER VALVE WITH A FLOAT TYPE ROLLOVER VALVE.
97V084000 · Power Train:automatic Transmission:cooling Unit And Lines
May 5, 1997
UNDER CERTAIN HIGH LOAD OPERATING CONDITIONS, THE TRANSMISSION FLUID TEMPERATURE CAN EXCEED THE MELTING POINT OF THE MATERIAL USED IN THE CONNECTOR TO RETAIN THE FLUID LINE TO THE TRANSMISSION.
Consequence & remedy
Consequence: WHEN THESE TEMPERATURES OCCUR, THE FLUID LINE WILL NOT STAY CONNECTED WITH THE TRANSMISSION AND FLUID CAN SPRAY ONTO THE EXHAUST MANIFOLD, RESULTING IN SMOKE OR FIRE.
Remedy: DEALERS WILL REPLACE THE HIGH TEMPERATURE SIDE OF THE TRANSMISSION FLUID COOLER LINE CONNECTOR FITTINGS WITH CONNECTORS THAT INCORPORATE A STAINLESS STEEL RETAINER.
97V068000 · Service Brakes, Hydraulic:power Assist:vacuum:hoses, Lines/piping, And Fittings
Apr 28, 1997
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH DIESEL ENGINES. THE ENGINE DRIVEN VACUUM PUMP CAN ALLOW ENGINE OIL INTO THE VACUUM HOSES DUE TO THE ABSENCE OF AN INTERNAL CHECK VALVE. THE OIL CAN CAUSE THE HOSE TO DETERIORATE AND PARTIALLY COLLAPSE, REDUCING THE VACUUM SUPPLY TO THE BRAKE BOOSTER.
Consequence & remedy
Consequence: REDUCED POWER BRAKE ASSIST CAN RESULT INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A VACUUM PUMP CHECK VALVE TO THE VACUUM PUMP. IN ADDITION, THE VACUUM HOSE CONNECTED TO THE VACUUM PUMP WILL BE REPLACED WITH A HOSE THAT IS ENGINE OIL RESISTANT.
96V027000 · Equipment:other:labels
Feb 5, 1996
THE INVOLVED VEHICLES HAVE TIRE/WHEEL SPECIFICATION INFORMATION ON THE VEHICLE CERTIFICATION LABEL WHICH INDICATES A SMALLER SIZE TIRE THAN REQUIRED. THIS DOES NOT COMPLY WITH LABEL REQUIREMENTS OF FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE SMALLER TIRES WOULD NOT HAVE SUFFICIENT LOAD CAPACITY FOR THE VEHICLES SPECIFIED GROSS WEIGHT RATING, INCREASING THE POTENTIAL FOR A PREMATURE TIRE FAILURE AND AN ACCIDENT.
Remedy: OWNERS WILL BE MAILED AN OVERLAY LABEL WITH THE CORRECT TIRE/WHEEL CERTIFICATION INFORMATION AND INSTRUCTIONS FOR INSTALLING THE LABEL ON THEIR VEHICLES. IF OWNERS PREFER, THEIR DEALER CAN INSTALL THE LABEL FOR THEM.
95V237000 · Electrical System:alternator/generator/regulator
Dec 12, 1995
THE FASTENERS WHICH SECURE THE GENERATOR CARTRIDGE FUSE TO THE POWER DISTRIBUTION CENTER MAY HAVE AN IMPROPER CLAMP LOAD. IMPROPER CLAMPING CAN RESULT IN ARCING AT THE CONNECTION.
Consequence & remedy
Consequence: THIS CONDITION CAN POTENTIALLY CAUSE A FIRE IN THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL TIGHTEN THE GENERATOR CARTRIDGE FUSE FASTENERS PROPERLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9DP03006 · Seat Back Failure
Opened Sep 23, 2003 · Closed Apr 8, 2004
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Additional source detail variants (2)
Seats
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
RQ00012 · Hood Latch
Opened May 3, 2000 · Closed Apr 20, 2001
Status: closed (inferred from source dates) · Structure
ONMARCH 20, 1995, DAIMLERCHRYSLER FILED A DEFECT REPORT FOR 181,008 1994 AND 1995 DODGE RAM TRUCKS MANUFACTUREDC FROM JANUARY 21, 1994 - OCTOBER 25, 1994 AT THE DODGE CITY ASSEMBLY PLANT AND FROM MARCH 26, 1994 - DECEMBER 8, 1994 AT THE LAGO ALBERTO ASSEMBLY PLANT.THE SECONDARY HOOD LATCH ROD COULD BIND ON THE GUIDE BRACKET AND PREVENT ENGAGEMENT OF THE SECONDARY LATCH.IF THIS OCCURS WHEN THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD FLY UP WHEN THE VEHICLE IS BEING DRIVEN AND OBSTRUCT THE DRIER'S VISION INCREASING THE POTENTIAL FOR A CRASH.THE RECALL REMEDY WAS TO REPLACE THE SEDCONDARY HOOD LATCH.OWNERS WERE NOTIFIED IN AUGUST OF 1995.THIS RECALL RATE AS OF 2/97 WAS 68%
Additional source detail variants (2)
Structure
ONMARCH 20, 1995, DAIMLERCHRYSLER FILED A DEFECT REPORT FOR 181,008 1994 AND 1995 DODGE RAM TRUCKS MANUFACTUREDC FROM JANUARY 21, 1994 - OCTOBER 25, 1994 AT THE DODGE CITY ASSEMBLY PLANT AND FROM MARCH 26, 1994 - DECEMBER 8, 1994 AT THE LAGO ALBERTO ASSEMBLY PLANT.THE SECONDARY HOOD LATCH ROD COULD BIND ON THE GUIDE BRACKET AND PREVENT ENGAGEMENT OF THE SECONDARY LATCH.IF THIS OCCURS WHEN THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD FLY UP WHEN THE VEHICLE IS BEING DRIVEN AND OBSTRUCT THE DRIER'S VISION INCREASING THE POTENTIAL FOR A CRASH.THE RECALL REMEDY WAS TO REPLACE THE SEDCONDARY HOOD LATCH.OWNERS WERE NOTIFIED IN AUGUST OF 1995.THIS RECALL RATE AS OF 2/97 WAS 68%
Structure
ONMARCH 20, 1995, DAIMLERCHRYSLER FILED A DEFECT REPORT FOR 181,008 1994 AND 1995 DODGE RAM TRUCKS MANUFACTUREDC FROM JANUARY 21, 1994 - OCTOBER 25, 1994 AT THE DODGE CITY ASSEMBLY PLANT AND FROM MARCH 26, 1994 - DECEMBER 8, 1994 AT THE LAGO ALBERTO ASSEMBLY PLANT.THE SECONDARY HOOD LATCH ROD COULD BIND ON THE GUIDE BRACKET AND PREVENT ENGAGEMENT OF THE SECONDARY LATCH.IF THIS OCCURS WHEN THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD FLY UP WHEN THE VEHICLE IS BEING DRIVEN AND OBSTRUCT THE DRIER'S VISION INCREASING THE POTENTIAL FOR A CRASH.THE RECALL REMEDY WAS TO REPLACE THE SEDCONDARY HOOD LATCH.OWNERS WERE NOTIFIED IN AUGUST OF 1995.THIS RECALL RATE AS OF 2/97 WAS 68%
DP00002 · Steering Column Fire
Opened Jan 20, 2000 · Closed Apr 24, 2000
Status: closed (inferred from source dates) · Steering
ALLEGES THAT THE POOR DESIGN OF THE IGNITION SWITCH ASSEMBLY AND//OR THE KEY CYLINDER ASSEMBLY IN THE MODEL YEAR 1991-2000 VEHICLES MAY CAUSE THE STEERING COLUMN TO CATCH FIRE
EA99027 · Steering Column Fires
Opened Sep 10, 1999 · Closed May 30, 2000
Status: closed (inferred from source dates) · Power Train
ODI has received 33 complaints alleging excessive heat in the ignition switch and related circuitry in 1994-1996 Dodge Ram trucks.The root cause is an excessive current draw through the ignition switch result in fire, smoke, melting of surrounding plastics, stalling and the illumination of air bag and anti-lock brake system (ABS) warnig lights. DaimlerChrsler has been aware of the potential for this failure and implemented a design change to reduce the current draw through the switch.This design change involved the installation of a relay in the blower motor circuitry for all Ram trucks built after March 15,1996.DaimlerChrysler also made available an ignition switch repair package (PN 4874996) which includes the necessary components to upgrade vehicles built prior to the implementation date.DaimleChrysler also issued a correspondence to its zones instructing technicians to replace failed ignition switches in the subject population with the sevice kit only.An Engineering Analysis is necessary to determine if a safety defect trend exists.ODI will focus its investigation on fires in the steering column area as well as the effects of switch failure on the ABS and air bag system.
PE99031 · Ignition Switch
Opened May 5, 1999 · Closed Sep 10, 1999
Status: closed (inferred from source dates) · Power Train
COMPLAINANTS ALLEGE FIRES, MELTING, SMOKE OR EXCESSIVE HEAT IN THE VICINITY OF THE IGNITION SWITCH
RQ98002 · Transmission Quick Connectors
Opened Mar 10, 1998 · No close date supplied
Status: open (inferred from source dates) · Power Train:automatic Transmission:cooling Unit And Lines
ON APRIL 17, 1997, THE CHRYSLER CORPORATION FILED A DEFECT INFORMATION REPORT CONCERNING APPROXIMATELY 800,000 1994 THROUGH 1997 DODGE RAM PICKUPS EQUIPPED WITH V6 OR V8 ENGINES AND AUTOMATIC TRANSMISSIONS, 1995 THROUGH 1997DODGE RAM PICKUPS EQUIPPED WITH THE V10 ENGINE AND AUTOMATIC TRANSMISSION, AND THE 1995 AND 1996 DODGE RAM VAN/WAGON EQUIPPED WITH AUTOMATIC TRANSMISSION.ODI HAS RECEIVED ELEVEN REPORTS CONCERNING TRANSMISSION LEAKAGES FROM THE QUICK CONNECTOR JOINTS RESULTING IN EIGHT FIRES.THE REPORTED VEHICLES INCLUDED ARE THE 1994 AND 1995 JEEP WRANGLER, 1995 AND 1996 CHEROKEE, 1993 THROUGH 1996 GRAND CHEROKEE, AND 1994 AND 1995 DODGE DAKOTA.THE PURPOSE OF THIS INVESTIGATION IS TO EXAMINE THE SCOPE OF RECALL 97V-084.CLOSING SUMMARY: FURTHER INVESTIGATION OF CONSUMER REPORTS REVEALED THAT SOME OF THE TRANSMISSION LEAKAGE WAS DUE TO OTHER CONNECTIONS ALONG THE COOLING LINES.IN THE FIRE INCIDENTS, THERE WERE INDICATIONS THAT SOME OF THESE VEHICLES WERE EITHER USED BEYOND THE VEHICLE'S TOWING CAPABILITY OR HAD IMPROPER TRANSMISSION REPAIR.IN ADDITION, THE RECALLED RAM PICKUP TRUCKS, 98V-084, HAVE AN EXHAUST MANIFOLD NEAR THE PLASTIC QUICK CONNECTOR JOINTS WHICH EFFECTIVELY PRESENTS A HEAT SOURCE TO IGNITE THE HOT TRANSMISSION FLUID IN THE EVENT OF A LEAKAGE.THE SUBJECT VEHICLES' QUICK CONNECTOR JOINTS ARE EITHER TOO FAR, OR POSITIONED COMPLETELY AWAY, FROM A HEAT SOURCE OR EXHAUST COMPONENTS.CONSEQUENTLY, THE FIRE REPORTS OF THE SUBJECT VEHICLES ARE SIGNIFICANTLY LESS THAN THOSE OF THE DODGE RAM PICKUP TRUCKS.BASED ON THE AVAILABLE INFORMATION, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY FUTURE CIRCUMSTANCES.
EA98005 · Clutch Hydraulic Line
Opened Feb 27, 1998 · Closed May 24, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
ALLEGED PLASTIC CLUTCH TUBE MAY FAIL FROM EXPOSURE TO EXHAUST HEAT, RESULTING IN LOSS OF CLUTCH FUNCTION AND POSSIBLE VEHICLE FIRE.
PE97043 · Clutch Hydraulic Line Failure
Opened Oct 20, 1997 · Closed Feb 27, 1998
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
ALLEGED CLUTCH LINE MAY MELT AND LEAK HYDRAULIC FLUID IN THE VICINITY OF THE EXHAUST MANIFOLD.LEAKED HYDRAULIC FLUID COULD IGNITE AND CAUSE A VEHICLE FIRE.
PE96070 · Transmission Fluid Fires
Opened Nov 26, 1996 · Closed May 15, 1997
Status: closed (inferred from source dates) · Power Train
TRANSMISSION FLUID LEAKAGE AT COOLER TUBE DISCONNECTS IS ALLEGED TO HAVE RESULTED IN VEHICLE FIRES.(this resume was revises on 12/3/96 to include the 1996 model year truck equipped with the subject equipment)
Additional source detail variants (2)
Power Train
TRANSMISSION FLUID LEAKAGE AT COOLER TUBE DISCONNECTS IS ALLEGED TO HAVE RESULTED IN VEHICLE FIRES.(this resume was revises on 12/3/96 to include the 1996 model year truck equipped with the subject equipment)
Power Train
TRANSMISSION FLUID LEAKAGE AT COOLER TUBE DISCONNECTS IS ALLEGED TO HAVE RESULTED IN VEHICLE FIRES.(this resume was revises on 12/3/96 to include the 1996 model year truck equipped with the subject equipment)