1998 Dodge RAM Van

SOME DODGE RAM VANS HAVE A LATENT DEFECT IN THE FRAME THAT IS VERY DANGEROUS. AS FAR AS I CAN TELL, THERE IS NO RECALL EVEN THOUGH THE INTERNET IS LITTERED WITH COMPLAINTS, INCIDENTS AND ACCIDENTS DUE TO FAILURE OF THE FRAME IN ONE SPOT. I BELIEVE THAT THE AC RUNOFF IS VENTED DIRECTLY INTO THE FRAME WHICH, OVER TIME RESULTS IN THE EVENTUAL FAILURE OF THE FRAME AT THE POINT WHERE THE SUSPENSION AND STEERING ARE LOCATED - THIS RESULTS IN LOSS OF CONTROL OF THE VEHICLE. THERE IS NO EASY WAY TO CORRECT THIS PROBLEM SHORT OF REPLACING THE WHOLE FRAME. DODGE DENIES THAT THIS IS A PROBLEM AND BLAMES THIS DEFECT ON ROAD SALT AND CONDITIONS. THIS WOULD BE A VALID ASSERTION IF THE REST OF THE VEHICLE HAD ROT PROBLEMS ELSEWHERE ON THE VEHICLE. INCLUDING THE MUCH MORE VOLATILE BODY PARTS, WHICH ARE IN SOME CASES, STILL SOLID AND IN GOOD CONDITION. THIS PROBLEM IS PREVALENT IN SEVERAL YEARS OF THIS MODEL TRUCK. THIS PROBLEM IS EASY TO CHECK FOR AND NEEDS TO BE ADDRESSED BY DODGE SIMPLY BECAUSE THE VANS ARE GETTING OLDER AND THIS PROBLEM WILL BE OCCURRING MORE FREQUENTLY. *TR

WHILE BACKING OUT OF MY PARKING SPACE AND TURNING THE STEERING WHEEL I HEARD A LOUD POP/THUMP. SUBSEQUENTLY WHILE DRIVING DOWN THE ROAD AT 15MPH THE STEERING WENT OUT AND THE VEHICLE WAS UNCONTROLLABLE. I HAD THE VEHICLE TOWED TO A REPAIR SHOP. THE CAUSE OF THE BREAK DOWN WAS THE FRONT PASSENGER SIDE FRAME HAD RUSTED AND CRACKED. THIS IS WHERE THE STEERING IS CONNECTED TO. NO REPAIR WAS POSSIBLE. I HAVE CONTACTED ALTERNATE REPAIR SOURCES OF DEALERS, BODY SHOPS, WELDERS AND METAL FABRICATORS WITHOUT ANY SUCCESS TO GET ANYONE WILLING OR ABLE TO REPAIR THE FRAME. THE VEHICLE IS CONSIDERED NON-DRIVABLE AND NON-FIXABLE.

THE VEHICLE IS A MOTOR HOME, BUILT INTO A 19-FOOT DODGE VAN 3500 BY THE HOME AND PARK COMPANY IN ONTARIO, CANADA (WWW.ROADTREK.COM). THEY CALL THEIR MOTOR HOME 'ROADTREK'. WE LIVE IN MICHIGAN AND HAD DRIVEN TO OKLAHOMA WHEN THE INCIDENT HAPPENED. WE WERE ON I-44 AT MILE 262 GOING WEST WHEN WE STOPPED TO SWITCH DRIVERS. THE NEW DRIVER, BEFORE SETTING OUT, FOUND THAT THE BRAKES WERE GONE: PEDAL ON THE FLOOR. INSPECTION REVEALED THAT ALL THE BRAKE FLUID WAS ON THE GROUND. THE VEHICLE WAS TOWED TO CLAREMORE OK FOR REPAIRS, WHERE THE RIGHT FRONT BRAKE LINE WAS FOUND TO BE RUPTURED DUE TO ABRASION. INSPECTION REVEALED THE FRONT BRAKE LINE ON THE LEFT SIDE WAS SIMILARLY ABRADED BUT NOT YET WORN THROUGH. BOTH LINES WERE REPLACED AND WE RESUMED TRAVEL. THE EXACT SAME THING HAPPENED TO US IN 2004, WHERE THE BRAKES FAILED AFTER WE HAD PARKED THE VEHICLE IN OUR ASSIGNED SITE IN A CAMPGROUND. IN THAT CASE ONLY THE RIGHT SIDE LINE WAS REPLACED. HAD THESE INCIDENTS OCCURRED IN FAST, HEAVY TRAFFIC OR ON A STEEP HILL WE WOULD NOT HAVE SURVIVED AND POSSIBLY CAUSED INJURY TO OTHERS. THE FIRST TIME IT HAPPENS YOU FIGURE IT'S A FLUKE. BUT AFTER A SECOND TIME, IT'S A DESIGN FLAW. I HAVE PHOTOS OF THE ABRADED BRAKE LINE ON THE LEFT FRONT SIDE OF THE VEHICLE AS WELL AS THE INVOICES OF THE WORK DONE. I CAN SEND THOSE IF DESIRED.

THIS VEHICLE BELONGS TO VERIZON COMMUNICATIONS. THE VAN HAD AN UNDERHOOD FIRE THAT ORIGINATED IN THE ABS MODULE AREA WHILE PARKED. CHRYSLER ISSUED SAFETY RECALL D20 IN 2004 TO ADDRESS THIS PROBLEM BUT THE RECALL REPAIR HAS NOT CORRECTED THE PROBLEM. VERIZON HAS HAD 33 UNDERHOOD FIRE INCIDENTS THAT OCCURRED AFTER THE RECALL WAS PERFORMED. THIS IS AN UNSAFE CONDITION THAT WARRANTS FURTHER INVESTIGATION AND ACTION BY NHTSA. *TR

THIS VEHICLE BELONGS TO VERIZON COMMUNICATIONS. THE VAN HAD AN UNDER HOOD FIRE THAT ORIGINATED IN THE ABS MODULE AREA WHILE PARKED. DAIMLERCHRYSLER ISSUED SAFETY RECALL D20 IN 2004 TO ADDRESS THIS PROBLEM BUT THE RECALL REPAIR HAS NOT CORRECTED THE PROBLEM. VERIZON HAS HAD 32 UNDER HOOD FIRE INCIDENTS THAT OCCURRED AFTER THE RECALL WAS PERFORMED. THIS IS AN UNSAFE CONDITION THAT WARRANTS FURTHER INVESTIGATION AND ACTION. *TR

TL*THE CONTACT OWNS A 1998 DODGE RAM VAN. WHILE PULLING INTO A PARKING SPACE AT AN UNKNOWN SPEED, THE CONTACT FELT A HARD VIBRATION AND HEARD A LOUD BANG. HE EXITED THE VEHICLE TO LOCATE THE ORIGIN OF THE SOUND, BUT WAS UNSUCCESSFUL. HE RE-ENTERED THE VEHICLE TO CONTINUE TO PARK WHEN ANOTHER LOUD SOUND OCCURRED. THE STEERING DID NOT RESPOND. HE EXITED THE VEHICLE AGAIN AND LOCATED A FAILURE WITH THE STEERING CONTROL ARM AND ITS COMPONENTS. THE CONTACT ALSO NOTICED THAT THE ENTIRE FRONT END WAS COMPLETELY RUSTED. HE CALLED A TOW TRUCK AND HAD THE VEHICLE TOWED TO A LOCAL DEALER. THE DEALER STATED THAT THERE BODY SHOP WOULD NOT REPAIR THE VEHICLE BECAUSE THEY DID NOT WANT TO BE RESPONSIBLE FOR ANY LIABILITY. THEY FURTHER STATED THAT THEY MAY BE ABLE TO LOCATE A COLLISION REPAIR SHOP TO PERFORM THE REPAIR WORK. THE CONTACT HAS NOT YET BEEN ABLE TO LOCATE A SHOP TO PERFORM THE NEEDED REPAIRS. THE VEHICLE IS CURRENTLY AT THE DEALER. THE FAILURE AND CURRENT MILEAGES WERE 140,000.

VEHICLE: 1998 DODGE B1500 RAM VAN PROBLEM: AT LESS THAN 40,000 MILES I WAS TOLD BY A TIRE DEALER THAT MY UPPER BALL JOINTS WERE SHOT AND THAT I SHOULD TAKE THE VEHICLE REPAIR SHOP TO HAVE THEM REPLACED BEFORE THE FRONT END COULD BE ALIGNED. AT 60,000 MILES I FINALLY DECIDE TO HAVE IT REPAIRED. NOT ONLY WAS THE BALL JOINTS BAD, BUT ONE SIDE HAD COME LOOSE IN THE UPPER CONTROL ARM, AND DESTROYED THE THREADS AND WAS FLOATING FREE IN THE CONTROL ARM. I CONSIDER THIS TO BE A SERIOUS SAFTEY HAZARD. I AM INTERESTED IF THIS IS A COMMON COMPLAINT WITH THIS VEHICLE OR NOT. BY DOING SOME RESEARCH ON THE INTERNET I SEE MULTIPLE COMPLAINT ON OTHER DODGE VEHICLES. THANK YOU FOR YOUR ATTENTION. JOSEPH SCHEIBENPFLUG

THE VERIZON VEHICLE HAD AN UNDERHOOD FIRE WHILE BEING DRIVEN. THE FIRE ORIGINATED IN THE ABS MODULE AREA. THE ABS MODULE AND WIRING CONNECTOR, TRUCK BATTERY, AND VARIOUS UNDERHODD COMPONENTS WERE BURNT. VERIZON HAS HAD SIMILAR FIRES IN THIS MODEL VAN AND FEELS THAT THIS IS AN UNSAFE CONDITION THAT WARRANTS FURTHER INVESTIGATION.

WHILE AT A DODGE DEALER FOR INSTRUMENT CLUSTER REPAIR THE VERIZON VEHICLE HAD AN UNDERHOOD FIRE WHICH ORIGINATED IN THE ABS MODULE AREA. THE ABS MODULE AND WIRING CONNECTOR, TRUCK BATTERY AND OTHER UNDERHOOD COMPONENTS WERE BURNT. VERIZON HAS HAD SIMILAR FIRES IN OTHER VANS OF THIS MODEL AND BELIEVES THIS IS A SAFETY ISSUE WHICH WARRANTS FURTHER INVESTIGATION.