Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 12 of 22 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Steering. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports2 fire reports1 injury reports
What owners actually said
22 reports
Mileage unknown · Mar 22, 2018
Power Train
TL* THE CONTACT OWNS A 2011 RAM 5500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V821000 (POWER TRAIN) MONTHS AGO. THE MANUFACTURER HAD NOT SUPPLIED THE PART TO THE DEALER. THE DEALER (JEFF WYLER EASTGATE AUTO MALL, 513-752-3447) WAS CALLED AND COULD NOT DETERMINE WHEN THE PARTS WOULD BECOME AVAILABLE TO SCHED…
Read full complaint
TL* THE CONTACT OWNS A 2011 RAM 5500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V821000 (POWER TRAIN) MONTHS AGO. THE MANUFACTURER HAD NOT SUPPLIED THE PART TO THE DEALER. THE DEALER (JEFF WYLER EASTGATE AUTO MALL, 513-752-3447) WAS CALLED AND COULD NOT DETERMINE WHEN THE PARTS WOULD BECOME AVAILABLE TO SCHEDULE THE RECALL REPAIR. THE MANUFACTURER WAS CONTACTED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #11080830
Mileage unknown · Sep 29, 2017
Fuel/propulsion System
THE METAL STEM THAT IS CONNECTED TO THE PLASTIC HOUSING ACTS AS A GUIDE FOR THE SPRINGING ACTION OF THE SENDER. AS THE FUEL PUMP HEATED UP, INDICATED BY THE BLACK AREA ON THE FUEL SENDER, IT HEATED THE METAL TUBE AND BURNED A HOLE THROUGH THE TANK. THIS CAUSED A LEAK IN THE FUEL TANK AND A SPILL OF FUEL IN EXCESS OF 25 GALLONS …
Read full complaint
THE METAL STEM THAT IS CONNECTED TO THE PLASTIC HOUSING ACTS AS A GUIDE FOR THE SPRINGING ACTION OF THE SENDER. AS THE FUEL PUMP HEATED UP, INDICATED BY THE BLACK AREA ON THE FUEL SENDER, IT HEATED THE METAL TUBE AND BURNED A HOLE THROUGH THE TANK. THIS CAUSED A LEAK IN THE FUEL TANK AND A SPILL OF FUEL IN EXCESS OF 25 GALLONS AT A GAS STATION.
NHTSA ODI #11030505
77,093 miles · May 3, 2017
Engine
DIESEL EXHAUST FLUID (DEF) SYSTEM FAILURE. ENGINE LIGHT CAME ON WITH WARNING TO HAVE SERVICED OR VEHICLE WOULD NOT START AFTER XX MILES. WAS DEF SYSTEM, PIPE, INJECTOR, AND SENSORS.
NHTSA ODI #10983231
11,913 miles · Apr 12, 2016
Electrical SystemEngine
-CONTROL MODULES REQUIRE UPDATES (ECM AND TCM) WHICH YOU HAVE TO PAY $120.00 FOR THE UPDATES. IT MAY CAUSE DRIVABILITY ISSUES. -INTAKE TUBE CLAMPS NEED REPLACING WHICH YOU CAN'T BUY THE CLAMP YOU HAVE TO PURCHASE THE INTAKE HOSE FOR $379.92.
NHTSA ODI #10855080
103,782 miles · Feb 15, 2016
Fuel/propulsion SystemUnknown Or Other
WHILE DRIVING, AT RANDOM, A WARNING WILL DISPLAY STATING THE FOLLOWING: "SERVICE DEF SYSTEM. ENGINE WILL NOT START AT 200 MILES. SEE DEALER" THIS HAS HAPPENED 10 OR MORE TIMES SINCE WE PURCHASED THE TRUCK. WE HAVE THE SAME PROBLEM WITH ANOTHER 2011 DODGE RAM 5500 WHICH WE PURCHASED WITH THIS ONE. WHEN WE BRING IT TO THE DE…
Read full complaint
WHILE DRIVING, AT RANDOM, A WARNING WILL DISPLAY STATING THE FOLLOWING: "SERVICE DEF SYSTEM. ENGINE WILL NOT START AT 200 MILES. SEE DEALER" THIS HAS HAPPENED 10 OR MORE TIMES SINCE WE PURCHASED THE TRUCK. WE HAVE THE SAME PROBLEM WITH ANOTHER 2011 DODGE RAM 5500 WHICH WE PURCHASED WITH THIS ONE. WHEN WE BRING IT TO THE DEALER, THEY CANT GIVE AN EXACT REASON WHY THIS KEEPS OCCURRING. THEY ONCE TOLD ME "ITS BECAUSE THE VEHICLE WAS GOING 65 MPH ON THE HIGH WAY WHILE TOWING A VEHICLE." THE CHECK ENGINE LIGHT HAS BEEN ON IN THIS VEHICLE SINCE THE MONTH WE PURCHASED IT. THE DEALERSHIP HAS A HARD TIME SHUTTING IT OFF & KEEPING IT OFF. THIS SYSTEM LOCK-DOWN OF OUR RAM TOW TRUCK'S IS UNPREDICTABLE, AND A MAJOR PROBLEM FOR OUR BUSINESS & NEEDS TO BE PROPERLY ADDRESSED AND FIXED.
NHTSA ODI #10826107
Mileage unknown · Jan 5, 2016
Unknown Or Other
THIS VEHICLE IS ON THE BUY BACK PROGRAM. CHRYSLERS 3RD PARTY TOOK SEVERAL MONTHS TO FILE THE PAPERWORK WITH A PRELIMINARY OFFER OF 35 THOUSAND DOLLARS ON THE BUY BACK. AT THE TIME THEY GUARANTEED THAT PRICE AND THAT IT COULD NOT BE LOWERED. NOW THEY ARE COMING BACK AND OFFERING 24K FOR THE SAME VEHICLE AND ARE REFUSING TO SPE…
Read full complaint
THIS VEHICLE IS ON THE BUY BACK PROGRAM. CHRYSLERS 3RD PARTY TOOK SEVERAL MONTHS TO FILE THE PAPERWORK WITH A PRELIMINARY OFFER OF 35 THOUSAND DOLLARS ON THE BUY BACK. AT THE TIME THEY GUARANTEED THAT PRICE AND THAT IT COULD NOT BE LOWERED. NOW THEY ARE COMING BACK AND OFFERING 24K FOR THE SAME VEHICLE AND ARE REFUSING TO SPEAK TO US UNDER ANY CIRCUMSTANCES UNLESS WE DECLINE THE OFFER OR ACCEPT THE OFFER. FCA AND IMPARTIAL SERVICES IS REFUSING TO RE-PURCHASE OR REPAIR OUR VEHICLE THAT IS PART OF THE 13V-527 CAMPAIGN. WE HAVE BEEN FIGHTING WITH THEM NON STOP SINCE OCTOBER OF 2015 AND THEY ARE STILL REFUSING. THIS IS THE SECOND TIME I HAVE ATTEMPTED TO REACH NHTSA AND EVEN YOU GUYS ARE REFUSING TO ASSIST. SO WE STILL HAVE A BROKEN TRUCK IN OUR DRIVEWAY THAT FCA WILL NOT FIX!!!!!!!!..UPDATED 01/20/16 *BF
NHTSA ODI #10818262
Mileage unknown · Jun 1, 2015
Engine And Engine CoolingFuel System, DieselFire
2011 DODGE RAM 5500. ATTORNEY REPRESENTING CONSUMER WRITES IN REGARDS TO VEHICLE FIRE AND DIESEL FUEL HEATER ELECTRICAL CONNECTOR RECALL NOTICE. *SMD
NHTSA ODI #10720913
Mileage unknown · May 12, 2015
Electrical SystemEngineFire
TL* THE CONTACT OWNED A 2011 DODGE RAM 5500. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE UNDER THE FRONT OF THE VEHICLE NEAR THE ENGINE COMPARTMENT. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE. THE VEHICLE WAS DESTROYED. IT WAS UNKNOWN IF A POLICE AND A FIRE REPORT WERE FILED. THE VEHICLE WAS INCLUDED IN NHTSA CAM…
Read full complaint
TL* THE CONTACT OWNED A 2011 DODGE RAM 5500. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE UNDER THE FRONT OF THE VEHICLE NEAR THE ENGINE COMPARTMENT. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE. THE VEHICLE WAS DESTROYED. IT WAS UNKNOWN IF A POLICE AND A FIRE REPORT WERE FILED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBERS: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL) AND 13V527000 (STEERING); HOWEVER, THE RECALL NOTICES WERE RECEIVED AFTER THE VEHICLE WAS DESTROYED DUE TO THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #10715922
Mileage unknown · Apr 30, 2015
EngineFuel/propulsion SystemSteering
TL* THE CONTACT OWNS A 2011 DODGE RAM 5500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL) AND 13V527000(STEERING); HOWEVER, THE PARTS NEEDED TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FO…
Read full complaint
TL* THE CONTACT OWNS A 2011 DODGE RAM 5500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL) AND 13V527000(STEERING); HOWEVER, THE PARTS NEEDED TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10713922
Mileage unknown · Apr 20, 2015
Fuel/propulsion SystemSteeringUnknown Or Other
RECEIVED SAFETY RECALLS #P65/NHTSA 14V-635 AND #N63/NHTSA 13V-527 CHRYSLER STATES IN THEIR NOTICE THAT THE PARTS ARE NOT AVAILABLE BUT THEY WOULD SEND A LETTER TO THE VEHICLE OWNER WHEN THEY ARE. HAVE CONTACTED THE DEALER SEVERAL TIMES TO CHECK ON THE PARTS. AS OF THIS DATE NOTHING HAS BEEN RECEIVED FROM CHRYSLER AND THE DEA…
Read full complaint
RECEIVED SAFETY RECALLS #P65/NHTSA 14V-635 AND #N63/NHTSA 13V-527 CHRYSLER STATES IN THEIR NOTICE THAT THE PARTS ARE NOT AVAILABLE BUT THEY WOULD SEND A LETTER TO THE VEHICLE OWNER WHEN THEY ARE. HAVE CONTACTED THE DEALER SEVERAL TIMES TO CHECK ON THE PARTS. AS OF THIS DATE NOTHING HAS BEEN RECEIVED FROM CHRYSLER AND THE DEALER HASN'T AN ANSWER. THIS VEHICLE IS A FIRE DEPT EMERGENCY RESPONSE VEHICLE. WOULD LIKE AN UPDATE FROM CHRYSLER. THE FIRE DEPT JUST RECEIVED ANOTHER SAFETY RECALL ON THIS VEHICLE #P27. *TR
Chrysler (FCA US LLC) is recalling certain 2016-2017 Ram 3500 Cab Chassis with a Gross Vehicle Weight Rating (GVWR) of less than 10,000 lbs, 2011-2017 Ram 3500, 4500 and 5500 Cab Chassis vehicles, 2009-2017 Ram 1500 and 2010-2017 Ram 2500 and 3500 pickup trucks, all equipped with a column shifter. Pushing the brake pedal for prolonged periods when the vehicle is running and in PARK may cause the Brake Transmission Shift Interlock (BTSI) pin to stick in the open position. With the pin in the open position, the transmission can be shifted out of PARK into any gear without pushing the brake pedal or having the key in the ignition.
Consequence & remedy
Consequence: Being able to shift the transmission without pushing the brake pedal and/or without a key in the ignition can increase the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Chrysler will notify owners, and dealers will update the vehicle software, inspect the BTSI, and, as necessary, replace it, free of charge. The recall began February 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T79.
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Charger Police vehicles, 2007-2013 RAM 3500 Cab Chassis, 2008-2013 RAM 4500 and 5500 Cab Chassis, and 2013 RAM 2500 and 3500 vehicles. The affected vehicles have a 220 amp alternator that may suddenly fail.
Consequence & remedy
Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash. There is also the possibility that the alternator may short circuit, increasing the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will replace the alternator with a revised alternator, free of charge. The recall began on December 23, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S68.
Chrysler Group LLC (Chrysler) is recalling certain model year 2010-2014 Ram 2500, 3500, 4500, and 5500 trucks manufactured March 27, 2009, to September 5, 2013. In the affected vehicles, the electrical connectors of the diesel fuel heater may overheat.
Consequence & remedy
Consequence: If the connectors overheat, the fuel heater may leak fuel, increasing the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will replace the harness side connector with a silver plated beryllium copper terminal service kit, and inspect the fuel heater for leaks, replacing it as necessary, free of charge. Chrysler issued interim notification to owners on December 8, 2014. The recall began on April 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P65.
Additional source detail variants (2)
Fuel System, Diesel
Chrysler Group LLC (Chrysler) is recalling certain model year 2010-2014 Ram 2500, 3500, 4500, and 5500 trucks manufactured March 27, 2009, to September 5, 2013. In the affected vehicles, the electrical connectors of the diesel fuel heater may overheat.
Consequence: If the connectors overheat, the fuel heater may leak fuel, increasing the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will replace the harness side connector with a silver plated beryllium copper terminal service kit, and inspect the fuel heater for leaks, replacing it as necessary, free of charge. Chrysler issued interim notification to owners on December 8, 2014. The recall began on April 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P65.
Engine And Engine Cooling:engine:diesel
Chrysler Group LLC (Chrysler) is recalling certain model year 2010-2014 Ram 2500, 3500, 4500, and 5500 trucks manufactured March 27, 2009, to September 5, 2013. In the affected vehicles, the electrical connectors of the diesel fuel heater may overheat.
Consequence: If the connectors overheat, the fuel heater may leak fuel, increasing the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will replace the harness side connector with a silver plated beryllium copper terminal service kit, and inspect the fuel heater for leaks, replacing it as necessary, free of charge. Chrysler issued interim notification to owners on December 8, 2014. The recall began on April 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P65.
Chrysler Group LLC (Chrysler) is recalling certain model year 2008-2012 RAM 4500 and 5500 trucks manufactured February 20, 2007, through December 22, 2012. The left tie rod assembly may break.
Consequence & remedy
Consequence: A failure of the tie rod assembly may result in a loss of steering control, increasing the risk of a crash.
Remedy: On May 19, 2015 Chrysler notified owners that dealers would replace the tie rod assembly, free of charge. In July 2015, and under a consent order with NHTSA, the company agreed to offer owners three options for remedying their vehicles: perform the original remedy, offer to repurchase the vehicle at the fair market value plus 10%, or offer an additional incentive offer towards the purchase of a new Dodge, Jeep, Chrysler, or Fiat vehicle. Chrysler will notify owners of the new recall options in a letter expected to be mailed on August 31, 2015. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is R16.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA19001 · Electrical Overstress
Opened Apr 19, 2019 · Closed Sep 19, 2024
Status: closed (inferred from source dates) · Air Bags: Air Bag/restraint Control Module
The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect. During the investigation a complex failure was studied that can result in non-deployment of subject vehicle air bags and other restraint system devices in severe crash events. The subject vehicles may be equipped with an airbag control unit (ACU) for the supplemental restraint system (SRS) Electronic Control Unit (ECU) manufactured by ZF-TRW. The ECU receives signals from crash sensors mounted in the vehicle and deploys the vehicle air bags and seat belt pretensioners in accordance with manufacturer design specifications. The ECU in the subject vehicles contains a model DS84 application-specific integrated circuit (ASIC) which controls the communication of the crash sensor signal, firing commands (i.e., when to deploy the airbag(s) and/or pretensioners), and fault information (e.g., diagnostic trouble codes). In September 2016, FCA announced recall 16V-668 for certain model year (MY) 2010 to 2014 Chrysler, Dodge and Jeep products manufactured with the subject ZF-TRW ACU. In this recall, FCA discussed an EOS condition that resulted in a failure of the subject DS84 ASIC, which caused air bag non-deployment. FCA noted that the defect condition had only been observed in vehicles equipped with sensor harnessing routed across the front of the vehicle. Other FCA vehicles that also used the subject ACU, but were not equipped with cross-car harnessing, had not experienced EOS failures, despite similar time in service. During the course of this investigation, ODI sent two separate Information Request (IR) letters to six vehicle manufactures (including FCA, Hyundai, Honda, Kia, Mitsubishi, and Toyota) and one IR letter to ZF-TRW. These IR letters resulted in ODI receiving comprehensive data from these manufacturers and suppliers. Studies of this data found that the DS84 ASIC does not have sufficient protection against negative electrical transients or electrical overstress (“EOS”) that can be generated in certain severe crashes. An electrical transient occurs when the electrical power supplied to a circuit changes momentarily over a short duration of time. In these severe crash cases, the crash sensors and other powered wiring can be damaged and short circuited so as to create a negative electrical transient of sufficient intensity and duration (that are outside the vehicle manufacturer's specification) to damage the ASIC before the restraint device deployment signal is received by the SRS ECU. This damaged signal can lead to incomplete or nondeployment of the air bags and/or pretensioners. Airbag non-deployment and/or lack of pretensioner operation can increase the risk or severity of injury in a crash.A total of 8 fatalities and 14 injuries were associated with known EOS events. The common element in all investigated manufacturers vehicles is the SRS ECU containing a DS84 ASIC manufactured by ZF-TRW. The risk associated with the ASIC is equally shared among all OEMS involved in the investigation. The actual real-world risk can be mitigated by other factors which were assessed by ODI during this investigation. The first mitigating factor involves protections built into the ACU design which protect the DS84 ASIC from damage. There are multiple strategies and levels of protection employed by different OEMs that provide effective EOS mitigation. The two most common strategies at the ACU level are circuit protection diodes on the remote senor signal lines, and current limiting resistors that protect critical components. The second mitigating factor is found at the vehicle level and involves the location and routing of the wires leading from the crash sensors to the SRS ECU. If the wires are well protected in a crash and are not routed with other power wires carrying large currents, the risk for an EOS event is significantly reduced or eliminated. These design specific factors combine to produce a spectrum of risk for the vehicles equipped with ACUs using the DS84 ASIC. Given the many of years of field exposure, it is possible to divide the subject population into two groups; vehicles which have experienced EOS events, and vehicles which have not experienced EOS field events. Four of the six OEMs involved in this investigation have experienced EOS field events on at least one of their models equipped with a DS84 ASIC. All vehicle models (including the Toyota models identified in the Failure Report Summary of the opening resume for this investigation) with field events have been recalled. In an abundance of caution, ODI kept this investigation open five years to monitor field performance and did not identify any field events on vehicles not included in existing safety recalls. Given the spectrum of risk identified in this investigation and that all vehicles with a demonstrated unreasonable risk have been recalled, ODI is closing this investigation. ODI is closing this investigation with the following manufacturer safety recalls: 16V-668, 18E-043, 18V-137, 18V-363, and 20V-024. With the recall actions taken by the subject vehicle and equipment manufacturers, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exists on other model or model year vehicles outside of the recall scopes. The agency reserves the right to take further action if warranted by the circumstances.
2011 Dodge RAM 5500 Problems, Complaints & Recalls | Skip That Year
Illustration