1996 Dodge RAM 2500

THE DASH IS A BIG PILE OF JUNK! HARD PLASTIC WITH A VIBRATING DIESEL? TURNS TO PIECES AND FALLS INTO DEFROSTER DUCTS, FLOOR, ALL IN CAB OF TRUCK! THIS IS WHY YOU DON'T BUY DODGE OR YOU BUY IT FOR ONLY CUMMINS DIESEL POWER! THATS ONE OF THE ONLY THINGS THAT SELDOM BREAKS AND NEEDS FIXING! TAKE THE POWER TRAIN AWAY AND YOU WOULD NOT SELL ANOTHER! BOOO! NO GOOD DASH! *TR

SEVERAL YEARS BACK IGNITION SWITCH WAS RECALLED FOR BURNING UP. AT THAT TIME HAD REPLACED IGNITION SWITCH TWICE PREVIOUSLY. DODGE PAID FOR THE SWITCHES AND LABOR AND REPLACED IGNITION SWITCH WITH NEW AND IMPROVED IGNITION SWITCH. NOW APPROX. 5 TO 7 YEARS LATER IGNITION SWITCH BURNING UP AGAIN TAKING OUT DOOR LOCK, WINDOWS, AIR BAG, AND ABB LIGHTS ARE ALL ON AND YOU CANNOT OPERATE EITHER WINDOW OR DOOR LOCK. TOOK INTO SHOP IN SPRING, TEXAS CALLED RILEYS OF RAYFORD ROAD IN SPRING, TEXAS WHERE THEY INFORMED ME THAT THE IGNITION SWITCH CAUSING ALL OF THESE PROBLEMS AND NEEDS REPLACED AGAIN! CALLED DEMONTRON DODGE IN CONROE, TEXAS TO SEE ABOUT SWITCH REPLACEMENT. NOTHING YET! *TR

NUMEROUS HEADLIGHT SWITCHES REPLACED DUE TO THEM BURNING UP TO INCLUDE SEVERAL INCHES OF THE EXISTING WIRING HARNESS TO SWITCH. I CANNOT BELIEVE THAT THIS TYPE OF SAFETY ISSUE IS NOT BEING ADDRESSED. YOU DAM SURE HAVE KNOWLEDGE OF THE PROBLEM SINCE THE AFTERMARKET AUTO PARTS O REILYS ETC. CARRY THE SWITCH OR SWITCH WITH WIRING HARNESS AS AN OPTION. AFTER READING HERE ALL SWITCHES GO OUT ABOUT THE SAME... THE HEADLIGHTS START GOING ON AND OFF THEN LOOK FOR SMOKE COMING FROM AROUND DASH WHERE SWITCH MOUNTED. YOU CAN FEEL THE HEAT FROM UNDER WHEN SWITCH IS BURNING UP. NEED A SIMPLE RELAY TO STOP THIS SHOW HOW MUCH DODGE LOVES ITS CUSTOMERS! *TR

AFTER OPERATING VEHICLE UNDER HEAVY LOAD (SNOWPLOWING), THE HYDRAULIC CLUTCH LINE RUPTURED WHEN THE CLUTCH WAS DEPRESSED AND THE HYDRAULIC FLUID IGNITED ON THE HOT EXHAUST SYSTEM. NOTE: THERE WAS A RECALL (NHTSA CAMPAIGN ID NUMBER : 99V115000 ) ISSUED FOR THE EXACT SAME PROBLEM WITH THIS MAKE/MODEL/YEAR TRUCK WITH A V10 ENGINE VERSES THE V8. THE HEAT FROM THE NEARBY EXHAUST PIPE EXCEEDED THE TEMPERATURE RATING OF THE HYDRAULIC CLUTCH LINE MATERIAL CAUSING IT TO RUPTURE. *TR

THIS REPORT IS REGARDING THE FAILURE OF A GOODYEAR WRANGLER ATS TIRE, LOAD RANGE D, SIZE 305/70R16. FOR SEVERAL MONTHS THE VEHICLE HAS HAD A MILD TO MODERATE TIRE SHAKE OR IN-BALANCE. A GOODYEAR DEALER RE-BALANCED THE TIRES, BUT THERE WAS NO CHANGE IN THE SHAKE. WE RETURNED THE VEHICLE TO THE SAME DEALER WHO THEN STATED THE TIRES WERE OUT OF ROUND AND COULDN'T BE BALANCED. THEY DID NOT ADVISE US TO REPLACE THE TIRES OR TO STOP USING THE VEHICLE. TWO MONTHS LATER, AFTER AN HOUR AT HIGHWAY SPEED, THE TIRE SUDDENLY DELAMINATED. THE VEHICLE SUSTAINED OVER $3,000 IN DAMAGE FROM THE TIRE EXPLOSION. CONTROL WAS NOT LOST. LOOKING AT THE TIRE, IT'S VERY OBVIOUS THIS WAS THE RESULT OF A MANUFACTURING DEFECT. HALF OF THE STEEL BELTS ARE COVERED WITH A LAYER OF BONDED RUBBER. THE OTHER HALF OF THE BELTS ARE EXPOSED. THE SEPARATING LINE IS RIGHT DOWN THE CENTER OF THE TIRE. THE SMALL PORTION OF TREAD THAT REMAINS IS SEPARATED FROM THE BELTS, BUT IS STILL BONDED ON THE OTHER SIDE. IT APPEARS TWO STRIPS OF RUBBER WERE PLACED LATERALLY ON THE FACE OF THE TIRE AND ONE OF THEM DID NOT BOND PROPERLY. I DON'T SEE ANY SIGNS OF PATCHES. ALTHOUGH NOW RUSTED, THE STEEL BELTS WERE BRIGHT WHEN THE TIRE FIRST SEPARATED. *TR

PULLING LOADED CARGO TRAILER ON A HOT DAY IN HEAVY TRAFFIC KIN SAN ANTONIO, TX. ALL A SUDDEN TRUCK STARTED SLOWING DOWN AND SMOKE STARTED COMING OUT FROM UNDER THE TRUCK. STOPPED AND LOOKED UNDER AND TRANSMISSION FLUID WAS COMING OUT OF TRANSMISSION ON TO HOT EXHAUST. THE HOT TRANSMISSION FLUID MELTED THE PLASTIC/NYLON MATERIAL AT THE FLUID LINE OF THE TRANSMISSION AND CAUSED FLUID TO SPRAY ALL OVER THE EXHAUST AND UNDER SIDE OF TRUCK AND ONTO THE PAYMENT. TRANSMISSION AND LINES HAD TO BE REPLACED. I WAS NOT AWARE OF THIS RECALL AS I HAD NEVER BEEN CONTACTED. I WISH I HAD, I WOULD HAVE SAVED ABOUT $4000.00!!!!

DODGE RAM 2500 PICK UP TRUCK: DASHBOARD HAS BEEN SLOWLY DISINTEGRATING TO THE POINT WHERE CERTAINLY ELEMENTS ARE HOLDING ONLY BY ONE SCREW ' AIR-CONDITION VENTS ARE FALLING OUT. TOP OF DASHBOARD IS 50% GONE, BROKEN IN TO SMALL PIECES AND EXPOSING ELECTRICAL WIRES TO THE HARSH SUNLIGHT. SOME CONTROLS SUCH AS DRIVER SEAT ELECTRICAL WINDOW IS NO LONGER OPENING, RPM METER IS ONLY WORKING INTERMITTENTLY. THE UNDERSIDE, EXPOSING ALL WIRES AND CONTROLS IS MISSING COVER (DISINTEGRATED). DODGE IS NO LONGER SELLING THE DASHBOARD REPLACEMENT ' WOULD BE WILLING TO PURCHASE AT ALMOST ANY PRICE. THE RIST CARKS SHOWEDUP ABOUT 3 YEARS AGO - SO FAR THERE HAS NOT BEEN AN INCIDENT, BUT I AM AFRAID,ONE DAY THE ENTIRE DASHBOARD WILL FALL DOWN, WHILE DRIVING - WHICH WILL BE VERY SERIOUS. *TR

ON THE MORNING OF 12/7/09 I STARTED MY TRUCK TO WARM IT UP WITH THE HEATING FAN ON HIGH WHEN AT SOME POINT, SOMEWHERE IN THE WIRING HARNESS UNDER THE DASH OVERHEATED AND STARTED THE INTERIOR ON FIRE. DESTROYING MY VEHICLE. THE WINDSHIELD AND DRIVER DOOR WINDOWS WERE BROKEN FROM THE HEAT BUT LUCKILY REMAINED INTACT AND NOT LETTING AIR INSIDE TO FUEL THE FIRE AND IT EVENTUALLY EXTINGUISHED ITSELF. *TR