NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,433 reports43,018 miles · Feb 27, 2014
Wheels
HAVE FACTORY ALUMINUM WHEELS. THE MANDATED "SAFETY" TIRE PRESSURE SENSORS FACTORY INSTALLED HAVE A STEEL SHAFT THROUGH THE RIMS. ROAD SALT REACTS WITH THE METAL PROPERTIES CAUSE ROTTING. IN MY CASE IT BROKE OFF WHEN THE MECHANIC TRIED TO TOP OFF AIR. JUST AS EASY WOULD BE A BUMP CAUSING ONE OR MORE TO BREAK ON THE ROAD. I …
Read full complaint
HAVE FACTORY ALUMINUM WHEELS. THE MANDATED "SAFETY" TIRE PRESSURE SENSORS FACTORY INSTALLED HAVE A STEEL SHAFT THROUGH THE RIMS. ROAD SALT REACTS WITH THE METAL PROPERTIES CAUSE ROTTING. IN MY CASE IT BROKE OFF WHEN THE MECHANIC TRIED TO TOP OFF AIR. JUST AS EASY WOULD BE A BUMP CAUSING ONE OR MORE TO BREAK ON THE ROAD. I COMPLAINED DIRECTLY TO DODGE, AFTER THINKING IT OVER FOR THREE WEEKS, THEY CALLED AND REPORTED THEY HAVE NO INTENTION OF REPAIRING THEIR FAULTY MATERIAL PROBLEM. THIS ATTITUDE TOWARDS A POTENTIALLY ACCIDENT CAUSING PROBLEM IS NOT AN ACCEPTABLE RESPONSE.
NHTSA ODI #10567206
125,000 miles · Feb 24, 2014
Electrical System
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. THE CONTACT STATED THAT THE DRIVER FRONT DOOR FAILED TO UNLOCK, THE WINDOW FAILED TO OPEN, AND THE MIRRORS WERE UNABLE TO BE CONTROLLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER W…
Read full complaint
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. THE CONTACT STATED THAT THE DRIVER FRONT DOOR FAILED TO UNLOCK, THE WINDOW FAILED TO OPEN, AND THE MIRRORS WERE UNABLE TO BE CONTROLLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 125,000.
NHTSA ODI #10565611
88,000 miles · Jan 30, 2014
Steering
POWER STEERING HOSES RUPTURING FROM COLD WEATHER. SECOND HOSE IN LESS THAN 1 MONTH TO BLOW OUT WHILE VEHICLE IS PARKED AND WARMING UP. MANY PEOPLE ONLINE WITH SAME COMPLAINT, WHEN IT GETS COLD THE JOURNEY STARTS BLOWING THE POWER STEERING HOSES. SEEMS TO HAVE BEEN A PROBLEM FROM THE START, BUT THE PROBLEM HASN'T BEEN FIXED AN…
Read full complaint
POWER STEERING HOSES RUPTURING FROM COLD WEATHER. SECOND HOSE IN LESS THAN 1 MONTH TO BLOW OUT WHILE VEHICLE IS PARKED AND WARMING UP. MANY PEOPLE ONLINE WITH SAME COMPLAINT, WHEN IT GETS COLD THE JOURNEY STARTS BLOWING THE POWER STEERING HOSES. SEEMS TO HAVE BEEN A PROBLEM FROM THE START, BUT THE PROBLEM HASN'T BEEN FIXED AND NEWER MODELS ARE STILL EXPERIENCING THIS PROBLEM. THE MECHANIC FEELS THIS IS DUE TO THE MATERIAL BEING USED IS NOT THE APPROPRIATE MATERIAL, IT IS TOO HARD AND BRITTLE. ONCE THE HOSE BLOWS OUT YOU LOSE THE POWER STEERING WHICH IS DANGEROUS AND IT STARTS TO GET SMOKE INSIDE THE VEHICLE AS THE POWER STEERING FLUID IS SMOKING IN THE ENGINE. *TR
NHTSA ODI #10562200
84,000 miles · Jan 28, 2014
Electrical System
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THE INTERIOR LIGHTS WOULD FAIL SPORADICALLY. THE BATTERY WAS REPLACED TWICE OVER A PERIOD OF TWO YEARS BUT THE FAILURE WAS RECURRING. THE VEHICLE WAS TAKEN TO …
Read full complaint
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THE INTERIOR LIGHTS WOULD FAIL SPORADICALLY. THE BATTERY WAS REPLACED TWICE OVER A PERIOD OF TWO YEARS BUT THE FAILURE WAS RECURRING. THE VEHICLE WAS TAKEN TO A DEALER AND DIAGNOSED THAT THE DRIVER'S SIDE DOOR SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER HAD NOT BEEN MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 84,000.
NHTSA ODI #10561887
Mileage unknown · Jan 23, 2014
Service Brakes
AT 19,000 MILE I HAD TO REPLACE THE BRAKES, THEN ANOTHER 41,000 REPLACE BRAKES, AT 66,000 REPLACE BRAKES, AND REAR BRAKES LOOKED UP AT THE COST OF 650.00. REPLACING BRAKES 90,000 AGAIN!! THIS HAS BEEN THE MOST EXPENSIVE "FAMILY CAR" I HAVE EVER OWNED. TIRES- I HAVE HAD 4 SETS OF TIRES!! THEY ONLY MADE ONE TIRE (KUMO) FOR A …
Read full complaint
AT 19,000 MILE I HAD TO REPLACE THE BRAKES, THEN ANOTHER 41,000 REPLACE BRAKES, AT 66,000 REPLACE BRAKES, AND REAR BRAKES LOOKED UP AT THE COST OF 650.00. REPLACING BRAKES 90,000 AGAIN!! THIS HAS BEEN THE MOST EXPENSIVE "FAMILY CAR" I HAVE EVER OWNED. TIRES- I HAVE HAD 4 SETS OF TIRES!! THEY ONLY MADE ONE TIRE (KUMO) FOR A 19" RIM AT A COSTLY EXPENSE. NOW GOODYEAR MAKES A TIRE THAT IS A BETTER GRADE. I HAVE HAD MORE MONEY IN THIS CAR THAN ITS WORTH. NEVER WILL BUY A DODGE AGAIN. THEY CUT A LOT OF COST BUILDING THIS CAR!! AS ADVERTISED AS A FAMILY VEHICLE!! WHAT A JOKE!! *TR
NHTSA ODI #10561200
54,390 miles · Jan 23, 2014
Service BrakesSteeringTires
WE BOUGHT THE DODGE JOURNEY IN DEC 2012 3 WEEKS OR SO LATER I RETURNED TO DEALERSHIP WITH A CLICKING SOUND WHEN I MOVED THE STEERING WHEEL THAT THE FRONT END WAS SHAKING AND THAT THERE WAS A LOAD ROAR LONG STORY SHORT EVERY 6 MONTHS ROTORS BRAKES TIRES ARE HAVING TO BE REPLACED AND I GUESS WHAT REALLY SET THINGS MORE IN MOTION W…
Read full complaint
WE BOUGHT THE DODGE JOURNEY IN DEC 2012 3 WEEKS OR SO LATER I RETURNED TO DEALERSHIP WITH A CLICKING SOUND WHEN I MOVED THE STEERING WHEEL THAT THE FRONT END WAS SHAKING AND THAT THERE WAS A LOAD ROAR LONG STORY SHORT EVERY 6 MONTHS ROTORS BRAKES TIRES ARE HAVING TO BE REPLACED AND I GUESS WHAT REALLY SET THINGS MORE IN MOTION WAS JAN 21 2014 WHILE TRAVELING DOWN THE INTERSTATE TO TAKE A SICK CHILD TO THE DR THE LEFT FRONT TIRE VALVE STEAM BLEW OUT MY HUSBAND GOT THE CAR OFF THE ROAD ONLY TO JACK IT UP TO CHANGE TIRE WHEN THE WEIGHT OF THE VEHICLE BENT THE JACK CAUSING IT TO FALL ALMOST ON MY HUSBANDS FOOT, WE BOUGHT THIS CAR BECAUSE IT WAS A V6 AND HAD THE ROOM WE NEED TO TRAVEL TO DR APPTS WITH OUR SPECIAL NEEDS CHILD BECAUSE WE HAVE TO TRAVEL SO FAR I HAVE HAD NOTHING BUT TROUBLE THE DEALERSHIP AFTER A FIGHT AGREED TO PUT NEW BRAKES THE MACHINED THE ROTORS AND SAID THE STEERING WAS A DODGE THING NOTHING TO WORRY ABOUT ONLY THE LOAD CLICKING WHEN PULLING IN OR OUT OF A PARKING SPACE AND THE ROAR IN THE FRONT THEY CLAIM IS THE RAOS AND THEY ALSO AT THIS TIME PUT 4 NEW TIRES ON THE CAR NOW MIND YOU THIS WAS ALL DONE 7/6/13 AND THEY DONE ALL OF THIS WHEN THEY PURCHASED THE CAR IN 11/20/12 AND WHEN I GO BACK IN TO THE CAR FAX EVERY 6 MONTHS THE BREAKS ROTORS AND TIRES HAVE TO BE REPLACED. NOW HERE IT IS 6 MONTHS LATER FOR US AND BLOW OUT ALSO WE JUST CHANGES THE ROTORS AND BRAKES ON THE 11 OF THIS MONTH SO SEE THE 6 MONTH DEAL WITH THIS CAR AND WHEN SEARCHING OTHER COMPLAINTS I AM FINDING THE SAME PROBLEM I HAVE CONTACTED CHRYSLER AND THEY SAY CALL MY DEALERSHIP I INFORMED [XXX] AT CHRYSLER IT WAS NOT THE DEALERSHIPS PROBLEM THEY DIDN'T MAKE THE CAR. IT IS A DEATH TRAP THERE ARE SO MANY MORE ISSUES WITH THIS CAR BUT THE DEADLY ONES ARE THE TIRES BLOWING OUT THE BRAKES CRUMBLING AND THE ROTORS WEARING OUT WITH IN 6 MONTHS THANK U AND I SO HOPE THAT SOMEONE CAN HELP US. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10561150
71,000 miles · Jan 18, 2014
Electrical System
SUDDENLY THE GAUGES ALL WENT TO ZERO, INCLUDING THE GAS. THE HEADLIGHTS CAME ON. THE WIPERS ALL CAME O. THE RADIO STOPPED WORKING. ALL OF THE BLINKERS MAKE NOISE. THIS OCCURS IF THE CAR IS STOPPED OR IF THE CAR IS IN MOTION. *TR
NHTSA ODI #10560510
22,000 miles · Jan 13, 2014
Service Brakes
THE BRAKES ON THIS VEHICLE DO NOT WORK. EVERY SINGLE YEAR, FOR THE PAST 4 YEARS, I HAVE HAD TO PURCHASE A NEW BRAKE SYSTEM FOR THIS CAR AT A COST OF HUNDREDS OF DOLLARS. DODGE AND THE DEALER ARE AWARE OF THE PROBLEMS BUT THEY REFUSE TO RECOGNIZE IT. THIS IS MY SON'S CAR AND I DON'T FEEL SAFE HAVING HIM DRIVE IT. I PURCHASED A LE…
Read full complaint
THE BRAKES ON THIS VEHICLE DO NOT WORK. EVERY SINGLE YEAR, FOR THE PAST 4 YEARS, I HAVE HAD TO PURCHASE A NEW BRAKE SYSTEM FOR THIS CAR AT A COST OF HUNDREDS OF DOLLARS. DODGE AND THE DEALER ARE AWARE OF THE PROBLEMS BUT THEY REFUSE TO RECOGNIZE IT. THIS IS MY SON'S CAR AND I DON'T FEEL SAFE HAVING HIM DRIVE IT. I PURCHASED A LEMON! *TR
NHTSA ODI #10559659
86,000 miles · Jan 10, 2014
Electrical System
WHILE DRIVING THE CAR STARTED TO SPUTTER WITH THE WIPERS GOING EXTREMELY FAST THEN STOPPING AND COMING BACK ON. DOOR LOCKS WOULDN'T WORK WITH KEY FOB OR DOOR BUTTONS, LEFT LOW BEAM AND RIGHT HIGH BEAM WOULDN'T WORK, NEITHER FRONT TURN SIGNAL WOULD WORK, AND TEMP GAUGE WAS OFF BY 30 OR 40 DEGREES. REPLACED THE BATTERY AND NONE OF…
Read full complaint
WHILE DRIVING THE CAR STARTED TO SPUTTER WITH THE WIPERS GOING EXTREMELY FAST THEN STOPPING AND COMING BACK ON. DOOR LOCKS WOULDN'T WORK WITH KEY FOB OR DOOR BUTTONS, LEFT LOW BEAM AND RIGHT HIGH BEAM WOULDN'T WORK, NEITHER FRONT TURN SIGNAL WOULD WORK, AND TEMP GAUGE WAS OFF BY 30 OR 40 DEGREES. REPLACED THE BATTERY AND NONE OF THE ISSUES WERE FIXED. HAD TO TAKE IT TO THE CLOSEST MECHANIC IT FINALLY SHUT DOWN COMPLETELY ON HIM WHILE RUNNING TESTS. HE CALLED THE LOCAL DODGE SERVICE CENTER AND THEY TOLD HIM IT IS A KNOWN ELECTRICAL ISSUE WITH JOURNEYS AND DURANGOS THAT THEY SEE ALL THE TIME. HE HAD TO ORDER A COMPLETE NEW INTEGRATED POWER MODULE OR FUSE AND CIRCUIT BOARD FOR $860 PART ONLY. WHEN HE ORDERED THE PART OUT OF CHICAGO THEY ONLY HAD 1 IN STOCK AS THE GUY STATED THEY CAN'T KEEP THESE IN DUE TO SO MANY ISSUES. CAR IS RUNNING NOW BUT IT IS AT THE DEALER SERVICE CENTER BECAUSE ONLY THEY CAN RESET THE COMPUTER SO EVERYTHING WORKS AS NORMAL. SO, ANOTHER $100+ FOR THAT AS WELL. THIS NEEDS TO PLACED IN A RECALL STATUS BEFORE SOMEONE IS SERIOUSLY INJURED WHEN THEIR CAR SHUTS DOWN WHILE DRIVING. I WILL BE SUBMITTING A REIMBURSEMENT REQUEST. *TR
NHTSA ODI #10559335
80,000 miles · Jan 5, 2014
TiresWheels
WHILE DRIVING HOME FROM LOCAL GROCERY STORE, REAR DRIVERS SIDE TIRE SUDDENLY BECAME FLAT. I WAS ABLE PULL OVER TO THE SIDE OF THE ROAD. WHEN MY HUSBAND ARRIVED TO HELP, HE ATTEMPTED TO PUT IN SOME "FIX A FLAT" TO GET ME TO THE TIRE STORE LESS THAN 2 MILES AWAY AND THE VALVE STEM WENT COMPLETELY INSIDE AND ALL AIR WAS RELEASED F…
Read full complaint
WHILE DRIVING HOME FROM LOCAL GROCERY STORE, REAR DRIVERS SIDE TIRE SUDDENLY BECAME FLAT. I WAS ABLE PULL OVER TO THE SIDE OF THE ROAD. WHEN MY HUSBAND ARRIVED TO HELP, HE ATTEMPTED TO PUT IN SOME "FIX A FLAT" TO GET ME TO THE TIRE STORE LESS THAN 2 MILES AWAY AND THE VALVE STEM WENT COMPLETELY INSIDE AND ALL AIR WAS RELEASED FROM TIRE. HE PUT ON THE SPARE AND WE TOOK THE TIRE TO THE TIRE STORE AND HAD TO PURCHASE A NEW VALVE STEM WITH SENSOR IN IT. AGAIN, DODGE IS PUTTING FAULTY EQUIPMENT INTO THEIR CARS AND NOT ACKNOWLEDGING OBVIOUS FLAWS IN THEIR VEHICLES. THIS IS ANOTHER EXAMPLE OF A SAFETY RECALL THAT DODGE SHOULD BE FORCED TO PUT IN PLACE. *TR
NHTSA ODI #10558537
Official recalls
8May 6, 2016
Chrysler (FCA US LLC) is recalling certain model year 2009-2016 Dodge Journey vehicles manufactured July 31, 2007, to November 12, 2016. After exposure to cold temperatures, the power steering return hose may rupture at engine start-up causing a loss of power steering assist.
Consequence & remedy
Consequence: A loss of power steering assist may require extra steering effort, especially at lower speeds, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the power steering return hoses, steel tubes, and power steering oil cooler, free of charge. The recall began on May 24, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S08.
Jan 29, 2016
FCA US LLC (Chrysler) is recalling certain model year 2009 Dodge Journey vehicles manufactured December 31, 2007, to August 31, 2008, 2008-2009 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured June 18, 2007, to August 31, 2008. In the affected vehicles, the air bag control units may corrode and fail.
Consequence & remedy
Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began on December 6, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S07.
Jun 26, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Dec 24, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2009 DODGE JOURNEY VEHICLES MANUFACTURER FROM NOVEMBER 1, 2007, THROUGH NOVEMBER 7, 2008. THE WIRES WITHIN THE FRONT DOOR WIRE HARNESSES MAY FATIGUE AND BREAK, WHICH CAN INTERRUPT THE CIRCUITS FOR THE SIDE IMPACT SENSOR(S), RESULTING IN AN AIRBAG WARNING LAMP ILLUMINATION AND LOSS OF SIDE CRASH SENSING CAPABILITY.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SIDE AIRBAG MAY NOT DEPLOY, REDUCING THE PROTECTION INTENDED FOR THE OCCUPANT AND INCREASING THE RISK OF INJURIES.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE LEFT AND RIGHT DOOR WIRING HARNESSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Apr 9, 2009
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (3)
Air Bags:frontal
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Electrical System:wiring
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Mar 12, 2009
CHRYSLER IS RECALLING 16,852 MY 2009 DODGE JOURNEY VEHICLES EQUIPPED WITHOUT OPTIONAL 115 VOLT AUXILIARY POWER OUTLET. AN UNUSED ELECTRICAL CONNECTOR FOR THE OPTIONAL 115 VOLT AUXILIARY POWER OUTLET OPTION MAY BECOME CORRODED AND COULD SHORT CIRCUIT.
Consequence & remedy
Consequence: IF THE FUSE FOR THIS CIRCUIT DOES NOT BLOW, THE CONNECTOR COULD OVERHEAT AND POTENTIALLY CATCH FIRE.
Remedy: DEALERS WILL RE-ROUTE AND STOW THE 115 VOLT AUXILIARY POWER OUTLET CONNECTOR AND PULL THE 25 AMP FUSE TO REMOVE POWER FROM THIS UNUSED CIRCUIT FREE OF CHARGE. THE RECALL BEGAN ON MARCH 30, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Oct 9, 2008
CHRYSLER IS RECALLING 712 MY 2009 SEBRING, DODGE CALIBER, AVENGER, JOURNEY, JEEP PATRIOT, AND COMPASS VEHICLES. A NEW ADHESIVE USED IN THE POWER TRAIN CONTROL MODULE (PCM) MANUFACTURING PROCESS CAN CAUSE THE PRINTED CIRCUIT BOARD TO BREAK.
Consequence & remedy
Consequence: THIS CAN CAUSE THE ENGINE TO STALL AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE PCM FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 10, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Jun 3, 2008
CHRYSLER IS RECALLING 6,692 MY 2009 DODGE JOURNEY VEHICLES EQUIPPED WITH A 3.5L ENGINE. THE ENGINE WIRING HARNESS MAY CONTACT THE LEFT TRANSAXLE MOUNT.
Consequence & remedy
Consequence: DAMAGE TO THE WIRING HARNESS COULD RESULT IN AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL INSPECT THE ENGINE WIRING HARNESS FOR DAMAGE. IF THE HARNESS IS DAMAGED, THE WIRING WILL BE REPAIRED AND A TIE WRAP INSTALLED TO SECURE THE HARNESS AWAY FROM THE LEFT TRANSAXLE MOUNT. IF NO DAMAGE IS FOUND, A TIE WRAP WILL BE INSTALLED TO SECURE THE HARNESS AWAY FROM THE LEFT TRANSAXLE MOUNT. THE RECALL BEGAN ON JULY 7, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA24003 · Vehicle Entrapment
Opened Aug 1, 2024 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages
The Office of Defects Investigation (ODI) opened PE23-008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During the investigation, ODI collected information from the manufacturer and involved parties to confirm or refute the defect allegation. ODI has determined that additional reports of vehicle entrapment exist for other model year Dodge Journey vehicles. ODI continues to explore the cause of the thermal event and its potential effect on the actuation of the door locks. ODI also continues to explore other potential causes for door lock malfunction. ODI has determined that an upgrade to an Engineering Analysis (EA) is necessary to continue the review of the investigative material and to assess the risk to motor vehicle safety . To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23008 · Vehicle Entrapment
Opened May 1, 2023 · Closed Aug 15, 2024
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Latches/locks/linkages:doors:lock; Latches/locks/linkages:electronic Lock/latch Actuator
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Latches/locks/linkages:doors:lock
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Latches/locks/linkages:electronic Lock/latch Actuator
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Illustration