NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,433 reports163,220 miles · Oct 26, 2016
Electrical System
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. IT TOOK THE CONTACT FIVE ATTEMPTS TO START THE VEHICLE. THE CONTACT HAD TO PLACE THE VEHICLE IN NEUTRAL AND REMOVE AND RE-INSERT THE KEY IN THE IGNITION IN ORDER FOR THE VEHICLE TO START. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE WIRELESS IGNITION MODULE, OCCUPAN…
Read full complaint
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. IT TOOK THE CONTACT FIVE ATTEMPTS TO START THE VEHICLE. THE CONTACT HAD TO PLACE THE VEHICLE IN NEUTRAL AND REMOVE AND RE-INSERT THE KEY IN THE IGNITION IN ORDER FOR THE VEHICLE TO START. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE WIRELESS IGNITION MODULE, OCCUPANT RESTRAINT CONTROL MODULE, AND IGNITION KEY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 163,220.
NHTSA ODI #10919000
53,000 miles · Oct 25, 2016
Air Bags
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. AFTER THE VEHICLE WAS STARTED, THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V047000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACT…
Read full complaint
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. AFTER THE VEHICLE WAS STARTED, THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V047000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 53,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #10918796
182,000 miles · Oct 25, 2016
Electrical System
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE DOOR WIRING HARNESS FAILED, THE WIRES PREMATURELY SHORTED, AND THE ELECTRICAL FUNCTION PANEL FAILED TO OPERATE. THE DEALER DIAGNOSED THAT THERE WERE LOOSE AND FRACTURED WIRES, AND THE FRONT DRIVER'S SIDE WIRES AND HARNESS NEEDED TO BE REPL…
Read full complaint
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE DOOR WIRING HARNESS FAILED, THE WIRES PREMATURELY SHORTED, AND THE ELECTRICAL FUNCTION PANEL FAILED TO OPERATE. THE DEALER DIAGNOSED THAT THERE WERE LOOSE AND FRACTURED WIRES, AND THE FRONT DRIVER'S SIDE WIRES AND HARNESS NEEDED TO BE REPLACED. THE DEALER AND MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED NHTSA CAMPAIGN NUMBER: 10V658000 (ELECTRICAL SYSTEM). THE MANUFACTURER PROVIDED NO SOLUTION. THE APPROXIMATE FAILURE MILEAGE WAS 182,000.
NHTSA ODI #10918717
100,000 miles · Oct 24, 2016
Air Bags
TAKATA RECALL
NHTSA ODI #10918632
83,000 miles · Oct 24, 2016
Power TrainFire
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. WHILE DRIVING 25 MPH, A LOUD ABNORMAL NOISE WAS HEARD AND SMOKE EMITTED FROM THE REAR OF THE VEHICLE. IN ADDITION, THE CONTACT INDEPENDENTLY NOTICED THAT THE TRANSAXLE WAS LEAKING FLUID. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE TRANSFER CASE AND TWO GEARS …
Read full complaint
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. WHILE DRIVING 25 MPH, A LOUD ABNORMAL NOISE WAS HEARD AND SMOKE EMITTED FROM THE REAR OF THE VEHICLE. IN ADDITION, THE CONTACT INDEPENDENTLY NOTICED THAT THE TRANSAXLE WAS LEAKING FLUID. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE TRANSFER CASE AND TWO GEARS IN THE TRANSFER CASE HAD FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 83,000. UPDATED 12/21/16*LJ UPDATED 7/9/18*JB
NHTSA ODI #10918570
159,000 miles · Oct 17, 2016
Engine
VEHICLE INTERMITTENTLY WON'T START AT ANY GIVEN TIME WHEN TURNING THE IGNITION ON IT WILL JUST CLICK. IT MAY START UP AFTER 10 MIN 2HRS MAYBE NOT UNTIL THE NEXT DAY. MY WIFE AND I HAVE BEEN GOING THROUGH THIS SINCE WE BROUGHT THIS 2009 DODGE JOURNEY NEW. WE TOOK IT BACK TO THE DEALER TROY MOTOR MALL THEY COULD NOT PINPOINT THE…
Read full complaint
VEHICLE INTERMITTENTLY WON'T START AT ANY GIVEN TIME WHEN TURNING THE IGNITION ON IT WILL JUST CLICK. IT MAY START UP AFTER 10 MIN 2HRS MAYBE NOT UNTIL THE NEXT DAY. MY WIFE AND I HAVE BEEN GOING THROUGH THIS SINCE WE BROUGHT THIS 2009 DODGE JOURNEY NEW. WE TOOK IT BACK TO THE DEALER TROY MOTOR MALL THEY COULD NOT PINPOINT THE PROBLEM AND THEY CHARGED US. SAME PROBLEM LATER NOTHING CHANGED. DID NOT START RECENTLY FIRST WEEK IN OCTOBER AAA TOW TRUCK CAME AND THE DRIVER HEARD THE CLICKING SOUND AND INDICATED THAT IT WAS THE STARTER. I TOOK THE CAR IN FOR REPAIR THAT NEXT WEEK AND HAD THE STARTER REPLACED AND IN A FEW DAYS IT WAS NOT STARTING AGAIN. I WENT TO THE DODGE DEALER TODAY AND I EXPLAINED TO THEM WHAT I HAD BEEN GOING THROUGH ALL OF THIS TIME AND HE STILL INDICATED THAT IT WOULD BE A $100.00 TO DIAGNOSE THE PROBLEM. I LOOKED UP THIS ISSUE ON CARCOMPLAINTS.COM AND A PERSON WITH THE SAME ISSUE INDICATED THAT THEIR MECHANIC FOUND IT TO BE A FAULTY RANGE SENSOR ATTACHED TO THE TRANSMISSION COMPLAINT #143 UNDER 2009 DODGE JOURNEY WON'T TURN OVER, ENGINE WON'T START. THERE WERE QUITE A FEW OTHER COMPLAINTS CONCERNING THIS SAME ISSUE THAT'S WHY IT'S HARD FOR ME TO UNDERSTAND WHY THERE IS NO RECALL CONCERNING THIS MATTER. WHEN EVER I GET IT FIXED I'D LIKE TO BE REIMBURSED BY CHRYSLER DODGE.
NHTSA ODI #10916682
131,000 miles · Oct 14, 2016
Service Brakes
THIS IS 3RD TIME MY JOURNEY'S BRAKES NEED REPLACING. THIS TIME MY COST 1683.00---IM ON SSDI---LOW INCOME---REALLY PUNCHED ME,. HORRIBLE PREDICAMENT TO BE IN--PLEASE CONTACT ME IF ANY COSTS ARE REIMBURSED BY CHRYSLER-DODGE. HELP!!
NHTSA ODI #10916204
40,000 miles · Sep 29, 2016
Electrical System
THE PROBLEM BEGAN AROUND 2 YEARS AGO, THE VEHICLE WONT START WHEN THE IGNITION KEY IS ENGAGED. THERE AREN'T ANY CLICKS OR CRANKING JUST SILENCE. AFTER 10, 15 OR 20 MINUTES THE VEHICLE STARTS AFTER THE ATTEMPT. THIS PROBLEM PROBABLY WON'T OCCUR IN THE NEXT NUMBER OF STARTING BUT SUDDENLY THE SAME PROBLEM, IT WON'T START. I LIVE I…
Read full complaint
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
NHTSA ODI #10910660
148,883 miles · Sep 20, 2016
Electrical System
AFTER THE RECALL WORK WAS COMPLETED AND WE RECEIVED NEW KEY FOBS THE CAR WILL RANDOMLY NOT START. WE HAVE TAKEN IT TO OUR MECHANIC REPEATEDLY AND HE HAS NOT BEEN ABLE TO FIND THE ISSUE. HE HAS JUMPSTARTED IT THINKING BATTERY WAS DOWN, APPLIED DIELECTRIC GREASE TO CONNECTIONS, CHECKED IT WITH THE COMPUTER AND COULD FIND NOTHING…
Read full complaint
AFTER THE RECALL WORK WAS COMPLETED AND WE RECEIVED NEW KEY FOBS THE CAR WILL RANDOMLY NOT START. WE HAVE TAKEN IT TO OUR MECHANIC REPEATEDLY AND HE HAS NOT BEEN ABLE TO FIND THE ISSUE. HE HAS JUMPSTARTED IT THINKING BATTERY WAS DOWN, APPLIED DIELECTRIC GREASE TO CONNECTIONS, CHECKED IT WITH THE COMPUTER AND COULD FIND NOTHING WRONG. PROBLEM KEEPS RECURRING WITH THE TIME AND NUMBER OF ATTEMPTS INCREASING UNTIL, WE HAVE TO KEEP CAR RUNNING ON SHORT ERRANDS AND PLAN FOR ALTERNATE TRANSPORTATION WHEN WE HAVE TO GO SOMEWHERE DISTANT, IN CASE IT DOES NOT START FOR SEVERAL HOURS. IN ADDITION THE DOOR LOCKS, RANDOMLY FAIL TO LOCK OR UNLOCK WHEN USING KEY FOB, AND ALSO LOCK AND UNLOCK AUTOMATICALLY WHEN DRIVING; WARNING LIGHTS RANDOMLY COME ON AND GO OFF, FOR THINGS LIKE LOW TIRE AND CHECK ENGINE LIGHT BUT WHEN CHECKED OR PUT ON DIAGNOSTIC COMPUTER THERE IS NOTHING WRONG. WARNING LIGHTS COME ON WHEN DRIVING AND STAY ON EVEN AFTER CAR IS PUT ON COMPUTER THEN SHUT OFF ON THEIR OWN SOMETIMES AFTER A FEW HOURS OR DAYS. ALL THESE STARTED AFTER RECALL AND AFTER REACHING 100K MILES, JUST GOT CAR BACK FROM MECHANIC AFTER REPLACING BATTERY LAST WEEK. HE IS NOT SURE WHAT ISSUES IS BUT IS GOING TO REPLACE A CONNECTION WIRE TO SEE IF IT HELPS, BECAUSE COMPUTER SAYS ITS GOOD. I SEE SIMILAR COMPLAINTS SAYING CAR WILL START IN NEUTRAL SOMETIMES AND I WAS TOLD TO TRY IT. IF IT STARTS HE SAID IT MAY BE A SAFETY MODULE, BUT CANNOT GUARANTEE IT IS OR WILL WORK. THIS HAS BEEN HAPPENING FOR NEARLY 2 YEARS WITH NO RESOLUTION. CAR IS OUR ONLY VEHICLE, AND WE FOLLOW ALL MAINTENANCE DIRECTIONS.
NHTSA ODI #10908145
68,000 miles · Sep 19, 2016
Engine
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. THE CONTACT STATED THAT IT TOOK SEVERAL ATTEMPTS TO START THE VEHICLE. THE GEAR HAD TO BE IN NEUTRAL IN ORDER FOR THE VEHICLE TO START. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 68,000.
NHTSA ODI #10907953
Official recalls
8May 6, 2016
Chrysler (FCA US LLC) is recalling certain model year 2009-2016 Dodge Journey vehicles manufactured July 31, 2007, to November 12, 2016. After exposure to cold temperatures, the power steering return hose may rupture at engine start-up causing a loss of power steering assist.
Consequence & remedy
Consequence: A loss of power steering assist may require extra steering effort, especially at lower speeds, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the power steering return hoses, steel tubes, and power steering oil cooler, free of charge. The recall began on May 24, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S08.
Jan 29, 2016
FCA US LLC (Chrysler) is recalling certain model year 2009 Dodge Journey vehicles manufactured December 31, 2007, to August 31, 2008, 2008-2009 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured June 18, 2007, to August 31, 2008. In the affected vehicles, the air bag control units may corrode and fail.
Consequence & remedy
Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began on December 6, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S07.
Jun 26, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Dec 24, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2009 DODGE JOURNEY VEHICLES MANUFACTURER FROM NOVEMBER 1, 2007, THROUGH NOVEMBER 7, 2008. THE WIRES WITHIN THE FRONT DOOR WIRE HARNESSES MAY FATIGUE AND BREAK, WHICH CAN INTERRUPT THE CIRCUITS FOR THE SIDE IMPACT SENSOR(S), RESULTING IN AN AIRBAG WARNING LAMP ILLUMINATION AND LOSS OF SIDE CRASH SENSING CAPABILITY.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SIDE AIRBAG MAY NOT DEPLOY, REDUCING THE PROTECTION INTENDED FOR THE OCCUPANT AND INCREASING THE RISK OF INJURIES.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE LEFT AND RIGHT DOOR WIRING HARNESSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Apr 9, 2009
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (3)
Air Bags:frontal
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Electrical System:wiring
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Mar 12, 2009
CHRYSLER IS RECALLING 16,852 MY 2009 DODGE JOURNEY VEHICLES EQUIPPED WITHOUT OPTIONAL 115 VOLT AUXILIARY POWER OUTLET. AN UNUSED ELECTRICAL CONNECTOR FOR THE OPTIONAL 115 VOLT AUXILIARY POWER OUTLET OPTION MAY BECOME CORRODED AND COULD SHORT CIRCUIT.
Consequence & remedy
Consequence: IF THE FUSE FOR THIS CIRCUIT DOES NOT BLOW, THE CONNECTOR COULD OVERHEAT AND POTENTIALLY CATCH FIRE.
Remedy: DEALERS WILL RE-ROUTE AND STOW THE 115 VOLT AUXILIARY POWER OUTLET CONNECTOR AND PULL THE 25 AMP FUSE TO REMOVE POWER FROM THIS UNUSED CIRCUIT FREE OF CHARGE. THE RECALL BEGAN ON MARCH 30, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Oct 9, 2008
CHRYSLER IS RECALLING 712 MY 2009 SEBRING, DODGE CALIBER, AVENGER, JOURNEY, JEEP PATRIOT, AND COMPASS VEHICLES. A NEW ADHESIVE USED IN THE POWER TRAIN CONTROL MODULE (PCM) MANUFACTURING PROCESS CAN CAUSE THE PRINTED CIRCUIT BOARD TO BREAK.
Consequence & remedy
Consequence: THIS CAN CAUSE THE ENGINE TO STALL AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE PCM FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 10, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Jun 3, 2008
CHRYSLER IS RECALLING 6,692 MY 2009 DODGE JOURNEY VEHICLES EQUIPPED WITH A 3.5L ENGINE. THE ENGINE WIRING HARNESS MAY CONTACT THE LEFT TRANSAXLE MOUNT.
Consequence & remedy
Consequence: DAMAGE TO THE WIRING HARNESS COULD RESULT IN AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL INSPECT THE ENGINE WIRING HARNESS FOR DAMAGE. IF THE HARNESS IS DAMAGED, THE WIRING WILL BE REPAIRED AND A TIE WRAP INSTALLED TO SECURE THE HARNESS AWAY FROM THE LEFT TRANSAXLE MOUNT. IF NO DAMAGE IS FOUND, A TIE WRAP WILL BE INSTALLED TO SECURE THE HARNESS AWAY FROM THE LEFT TRANSAXLE MOUNT. THE RECALL BEGAN ON JULY 7, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA24003 · Vehicle Entrapment
Opened Aug 1, 2024 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages
The Office of Defects Investigation (ODI) opened PE23-008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During the investigation, ODI collected information from the manufacturer and involved parties to confirm or refute the defect allegation. ODI has determined that additional reports of vehicle entrapment exist for other model year Dodge Journey vehicles. ODI continues to explore the cause of the thermal event and its potential effect on the actuation of the door locks. ODI also continues to explore other potential causes for door lock malfunction. ODI has determined that an upgrade to an Engineering Analysis (EA) is necessary to continue the review of the investigative material and to assess the risk to motor vehicle safety . To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23008 · Vehicle Entrapment
Opened May 1, 2023 · Closed Aug 15, 2024
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Latches/locks/linkages:doors:lock; Latches/locks/linkages:electronic Lock/latch Actuator
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Latches/locks/linkages:doors:lock
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Latches/locks/linkages:electronic Lock/latch Actuator
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Illustration