NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,433 reports57,400 miles · Jun 2, 2011
Structure
TL*THE CONTACT OWNS A 2009 DODGE JOURNEY. WHILE THE VEHICLE WAS PARKED THE CONTACT NOTICED THE FLOOR BETWEEN THE FRONT DRIVERS SIDE SEAT AND THE REAR DRIVERS SIDE SEAT WERE WET. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THERE WAS A COMPARTMENT ON THE FLOOR IN BACK OF THE FRONT DRIVERS SIDE SEAT WHICH WAS FILLED WITH APPROXIM…
Read full complaint
TL*THE CONTACT OWNS A 2009 DODGE JOURNEY. WHILE THE VEHICLE WAS PARKED THE CONTACT NOTICED THE FLOOR BETWEEN THE FRONT DRIVERS SIDE SEAT AND THE REAR DRIVERS SIDE SEAT WERE WET. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THERE WAS A COMPARTMENT ON THE FLOOR IN BACK OF THE FRONT DRIVERS SIDE SEAT WHICH WAS FILLED WITH APPROXIMATELY 5 INCHES OF WATER. THE CONTACT EMPTIED OUT THE WATER AND STATED THE COMPARTMENT CONTINUED TO FILL WITH WATER. THE CONTACT STATED SHE WAS CONCERNED OF RUST AND THAT SHE COULD NOT TELL WHERE THE WATER WAS COMING FROM. THE DEALER STATED THERE MIGHT BE A SEAL LEAK AND ADVISED THAT THE VEHICLE BE TAKEN INTO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 57,400. UPDATED 07/20/11*LJ UPDATED 12/05/11
NHTSA ODI #10404222
14,600 miles · Jun 1, 2011
Service Brakes, Hydraulic
COMPLETE BREAK DOWN OF BRAKE COMPONENTS FOR 2009 DODGE JOURNEY. BRAKES, ROTORS, AND CALIPERS ALL REPLACED AT 14,600 MILES DUE TO DEFECTS. NOT COVERED BY FULL WARRANTY. *TR
NHTSA ODI #10403958
22,000 miles · May 28, 2011
StructureTires
AFTER RAINING THE PASSENGER SIDE REAR DOOR FILLS WITH WATER. WHEN I CLOSE THE DOOR I HEAR THE WATER SWISH AROUND INSIDE AND THEN I SEE IT DRAIN OUT OF THE BOTTOM OF THE DOOR. THIS IS THE 4TH TIME THAT I HAVE SEEN THIS HAPPEN IN AS MANY WEEKS. MY WIFE HAS ALSO NOTICED THE EXACT SAME THING BEFORE I DID. THE DOOR FILLS WITH WATER P…
Read full complaint
AFTER RAINING THE PASSENGER SIDE REAR DOOR FILLS WITH WATER. WHEN I CLOSE THE DOOR I HEAR THE WATER SWISH AROUND INSIDE AND THEN I SEE IT DRAIN OUT OF THE BOTTOM OF THE DOOR. THIS IS THE 4TH TIME THAT I HAVE SEEN THIS HAPPEN IN AS MANY WEEKS. MY WIFE HAS ALSO NOTICED THE EXACT SAME THING BEFORE I DID. THE DOOR FILLS WITH WATER PRETTY MUCH EVERY TIME IT RAINS. IT SEEMS LIKE IT IS AT LEAST FILLING UP WITH SEVERAL CUPS OF WATER. I AM CONCERNED WITH MOLD GETTING INTO THE CAR AND ALSO THE PROBABILITY OF AN ELECTRICAL SHORT. THIS HAPPENS EVERY SINGLE TIME IT RAINS. IN ADDITION TO THE DOOR FILLING WITH WATER THE LOW TIRE PRESSURE LIGHT KEEPS COMING ON AND THE REAR LEFT TIRE WILL SLOWLY DEFLATE. I HAVE ALREADY HAD THE TIRE REPLACED ONCE AND THE SAME THING HAPPENED AGAIN IN A MATTER OF WEEKS. OUTSIDE AIR TEMPERATURE SEEMS TO HAVE NO EFFECT ON WHEN THIS OCCURS BECAUSE IT HAPPEN DURING THE COLD AND WHEN IT IS HOT OUT. USUALLY THE LOW TIRE PRESSURE WARNING WILL COME ON WITHIN ONE WEEK OF FILLING THE TIRE. *TR
NHTSA ODI #10403623
12,000 miles · May 27, 2011
EquipmentService Brakes, HydraulicCrash
I HAVE AN 09 DODGE JOURNEY THAT HAS ISSUES FROM DAY ONE. 1ST THE A/C BROKE. THEY FIXED IT THAT WAS ONLY 2 WEEKS AFTER I BOUGHT THE CAR. THE CAR WAS NEW AND BOUGHT IN 01/2009. AT A LITTLE OVER 12000 MILES MY BRAKES WERE GONE. I HAD TO ROTATE ROTORS AND PUT NEW BRAKE PADS. EVER SINCE THEN I HAVE HAD TO CHANGE THE PADS (2 TIME…
Read full complaint
I HAVE AN 09 DODGE JOURNEY THAT HAS ISSUES FROM DAY ONE. 1ST THE A/C BROKE. THEY FIXED IT THAT WAS ONLY 2 WEEKS AFTER I BOUGHT THE CAR. THE CAR WAS NEW AND BOUGHT IN 01/2009. AT A LITTLE OVER 12000 MILES MY BRAKES WERE GONE. I HAD TO ROTATE ROTORS AND PUT NEW BRAKE PADS. EVER SINCE THEN I HAVE HAD TO CHANGE THE PADS (2 TIMES THE ROTORS COMPLETELY ALL OTHER TIMES ROTATING THE ROTORS)5 MORE TIMES. I HAVE CALLED CHRYSLER AND ALL THEY HAVE DONE IS MADE THE WARRANTY TO 36000 MILES BUT THAT IS NOT FIXING A PROBLEM. I HAVE GOTTEN ONLINE AND RESEARCHED. I AM NOT THE ONLY ONE HAVING THIS PROBLEM . THERE ARE THOUSANDS OF OTHERS AND THERE ARE ACTUALLY LAWSUITS OUT THERE FOR THIS REASON. I WAS IN A FENDERBENDER IN DEC. 2010 AND I CAN NOT HELP BUT WONDER IF I WOULD HAVE HAD BRAKES THERE WERE 100% IF IT COULD HAVE BEEN AVOIDED.WITH ALL THE COMPLAINTS I AM WONDERING HOW MUCH IT WILL TAKE FOR A RECALL OR SOMETHING TO BE PUT INTO EFFECT. I HOPE IT DOES NOT TAKE PEOPLE GETTING KILLED FOR THIS TO BE CORRECTED. *TR
NHTSA ODI #10402967
Mileage unknown · May 26, 2011
Electrical System
2009 DODGE JOURNEY. CONSUMER WRITES IN REGARDS TO NOT RECEIVING RECALL SERVICE *TGW THE DEALER INFORMED THE CONSUMER, THE REPLACEMENT PART WAS NOT AVAILABLE. *JB
NHTSA ODI #10403453
18,000 miles · May 24, 2011
Service Brakes, Hydraulic
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. THE CONTACT STATED THAT WHEN APPLYING THE BRAKES, THERE WAS A LOUD GRINDING THAT CAUSED THE BRAKES TO WEAR PREMATURELY. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE ROTORS AND BRAKE PADS AT A COST OF $50 AND OFFERED AN EXTENDED THE WARRANTY. THE MANUFACTURER WAS CONTACTED AND A …
Read full complaint
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. THE CONTACT STATED THAT WHEN APPLYING THE BRAKES, THERE WAS A LOUD GRINDING THAT CAUSED THE BRAKES TO WEAR PREMATURELY. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE ROTORS AND BRAKE PADS AT A COST OF $50 AND OFFERED AN EXTENDED THE WARRANTY. THE MANUFACTURER WAS CONTACTED AND A CLAIM WAS FILE. THE MANUFACTURER ADVISED THAT THE CLAIM WOULD BE ESCALATED AND THE CONTACT SHOULD EXPECT A RETURN CALL AT A LATER DATE. THE FAILURE MILEAGE WAS 18,000.
NHTSA ODI #10402613
52,191 miles · May 22, 2011
Tires
I HAVE A 2009 DODGE JOURNEY AND THE TIRE (WHILE NOT IN MOTION) TIRE WENT FLAT. FOUND OUT THE SENSOR FOR THE AIR PRESSURE IS THE ISSUE. THIS IS A HAZARDOUS TO EVERY OWNER. WHAT IF THIS WOULD HAVE HAPPEN W/ OTHER PASSENGERS IN THE VEHICLE ESPECIALLY MY BABY. THIS COULD HAVE RESULTED IN A HORRIFIC ACCIDENT. THIS VEHICLE …
Read full complaint
I HAVE A 2009 DODGE JOURNEY AND THE TIRE (WHILE NOT IN MOTION) TIRE WENT FLAT. FOUND OUT THE SENSOR FOR THE AIR PRESSURE IS THE ISSUE. THIS IS A HAZARDOUS TO EVERY OWNER. WHAT IF THIS WOULD HAVE HAPPEN W/ OTHER PASSENGERS IN THE VEHICLE ESPECIALLY MY BABY. THIS COULD HAVE RESULTED IN A HORRIFIC ACCIDENT. THIS VEHICLE SHOULD BE RECALL W/ SOME OTHER ALTERNATIVE MEASURES FOR THE SENSORS. I UNDERSTAND ALL FOUR TIRES HAVE SENSORS AND THIS CAN HAPPEN AT ANY TIME. *TR
NHTSA ODI #10402319
35,000 miles · May 21, 2011
Electrical System
BOUGHT 2009 JOURNEY WITH 47,000 KM'S ON IT ABOUT 3 MONTHS AGO FROM DODGE DEALER. HAVE HAD TO HAVE THE CAR TOWED TWICE NOW BECAUSE IT WOULD NOT START. DEALER SEEMS TO BE IN THE DARK ABOUT HOW TO FIX PROBLEM. POOR, POOR, EXAMPLE OF CUSTOMER SERVICE AND CAR QUALITY. *TR
NHTSA ODI #10402269
21,000 miles · May 18, 2011
Tires
TL*THE CONTACT OWNS A 2009 DODGE JOURNEY. THE VEHICLE HAD KUMHO TIRES, LINE SOLUS, TIRE SIZE 225/55/R19 ON THE VEHICLE. THE DOT WAS NOT AVAILABLE. THE CONTACT STATED AFTER TAKING THE VEHICLE IN FOR A FRONT END ALIGNMENT, THEY ADVISED HER THAT ALL FOUR TIRES WERE SEPARATING. THE VEHICLE WAS NOT REPAIRED SINCE THE TIRES WERE ON BA…
Read full complaint
TL*THE CONTACT OWNS A 2009 DODGE JOURNEY. THE VEHICLE HAD KUMHO TIRES, LINE SOLUS, TIRE SIZE 225/55/R19 ON THE VEHICLE. THE DOT WAS NOT AVAILABLE. THE CONTACT STATED AFTER TAKING THE VEHICLE IN FOR A FRONT END ALIGNMENT, THEY ADVISED HER THAT ALL FOUR TIRES WERE SEPARATING. THE VEHICLE WAS NOT REPAIRED SINCE THE TIRES WERE ON BACK-ORDER. THE MANUFACTURER WAS CONTACTED AND ADVISED HER THAT THERE WERE NO RECALLS. THE FAILURE MILEAGE WAS APPROXIMATELY 21,000.
NHTSA ODI #10401514
Mileage unknown · May 8, 2011
EquipmentService Brakes, Hydraulic
INAUG 2010, I HAD THE BRAKE PADS CHANGED BARELY A YEAR AFTER BUYING THE CAR. THE NEXT MONTH I HAD TO HAVE NEW ROTORS BECAUSE THEY WARPED. A MONTH LATER THEY WERE WARPED AGAIN, COULDN'T GET THEM CHANGED UNTIL MAR 7, 2011. EXACTLY 30 DAYS LATER THEY WERE WARPED AGAIN. JUST HAD THEM AND THE BRAKE PADS REPLACED ON MAY 8, 2011. …
Read full complaint
INAUG 2010, I HAD THE BRAKE PADS CHANGED BARELY A YEAR AFTER BUYING THE CAR. THE NEXT MONTH I HAD TO HAVE NEW ROTORS BECAUSE THEY WARPED. A MONTH LATER THEY WERE WARPED AGAIN, COULDN'T GET THEM CHANGED UNTIL MAR 7, 2011. EXACTLY 30 DAYS LATER THEY WERE WARPED AGAIN. JUST HAD THEM AND THE BRAKE PADS REPLACED ON MAY 8, 2011. *TR
NHTSA ODI #10399492
Official recalls
8May 6, 2016
Chrysler (FCA US LLC) is recalling certain model year 2009-2016 Dodge Journey vehicles manufactured July 31, 2007, to November 12, 2016. After exposure to cold temperatures, the power steering return hose may rupture at engine start-up causing a loss of power steering assist.
Consequence & remedy
Consequence: A loss of power steering assist may require extra steering effort, especially at lower speeds, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the power steering return hoses, steel tubes, and power steering oil cooler, free of charge. The recall began on May 24, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S08.
Jan 29, 2016
FCA US LLC (Chrysler) is recalling certain model year 2009 Dodge Journey vehicles manufactured December 31, 2007, to August 31, 2008, 2008-2009 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured June 18, 2007, to August 31, 2008. In the affected vehicles, the air bag control units may corrode and fail.
Consequence & remedy
Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began on December 6, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S07.
Jun 26, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Dec 24, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2009 DODGE JOURNEY VEHICLES MANUFACTURER FROM NOVEMBER 1, 2007, THROUGH NOVEMBER 7, 2008. THE WIRES WITHIN THE FRONT DOOR WIRE HARNESSES MAY FATIGUE AND BREAK, WHICH CAN INTERRUPT THE CIRCUITS FOR THE SIDE IMPACT SENSOR(S), RESULTING IN AN AIRBAG WARNING LAMP ILLUMINATION AND LOSS OF SIDE CRASH SENSING CAPABILITY.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SIDE AIRBAG MAY NOT DEPLOY, REDUCING THE PROTECTION INTENDED FOR THE OCCUPANT AND INCREASING THE RISK OF INJURIES.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE LEFT AND RIGHT DOOR WIRING HARNESSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Apr 9, 2009
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (3)
Air Bags:frontal
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Electrical System:wiring
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Mar 12, 2009
CHRYSLER IS RECALLING 16,852 MY 2009 DODGE JOURNEY VEHICLES EQUIPPED WITHOUT OPTIONAL 115 VOLT AUXILIARY POWER OUTLET. AN UNUSED ELECTRICAL CONNECTOR FOR THE OPTIONAL 115 VOLT AUXILIARY POWER OUTLET OPTION MAY BECOME CORRODED AND COULD SHORT CIRCUIT.
Consequence & remedy
Consequence: IF THE FUSE FOR THIS CIRCUIT DOES NOT BLOW, THE CONNECTOR COULD OVERHEAT AND POTENTIALLY CATCH FIRE.
Remedy: DEALERS WILL RE-ROUTE AND STOW THE 115 VOLT AUXILIARY POWER OUTLET CONNECTOR AND PULL THE 25 AMP FUSE TO REMOVE POWER FROM THIS UNUSED CIRCUIT FREE OF CHARGE. THE RECALL BEGAN ON MARCH 30, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Oct 9, 2008
CHRYSLER IS RECALLING 712 MY 2009 SEBRING, DODGE CALIBER, AVENGER, JOURNEY, JEEP PATRIOT, AND COMPASS VEHICLES. A NEW ADHESIVE USED IN THE POWER TRAIN CONTROL MODULE (PCM) MANUFACTURING PROCESS CAN CAUSE THE PRINTED CIRCUIT BOARD TO BREAK.
Consequence & remedy
Consequence: THIS CAN CAUSE THE ENGINE TO STALL AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE PCM FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 10, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Jun 3, 2008
CHRYSLER IS RECALLING 6,692 MY 2009 DODGE JOURNEY VEHICLES EQUIPPED WITH A 3.5L ENGINE. THE ENGINE WIRING HARNESS MAY CONTACT THE LEFT TRANSAXLE MOUNT.
Consequence & remedy
Consequence: DAMAGE TO THE WIRING HARNESS COULD RESULT IN AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL INSPECT THE ENGINE WIRING HARNESS FOR DAMAGE. IF THE HARNESS IS DAMAGED, THE WIRING WILL BE REPAIRED AND A TIE WRAP INSTALLED TO SECURE THE HARNESS AWAY FROM THE LEFT TRANSAXLE MOUNT. IF NO DAMAGE IS FOUND, A TIE WRAP WILL BE INSTALLED TO SECURE THE HARNESS AWAY FROM THE LEFT TRANSAXLE MOUNT. THE RECALL BEGAN ON JULY 7, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA24003 · Vehicle Entrapment
Opened Aug 1, 2024 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages
The Office of Defects Investigation (ODI) opened PE23-008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During the investigation, ODI collected information from the manufacturer and involved parties to confirm or refute the defect allegation. ODI has determined that additional reports of vehicle entrapment exist for other model year Dodge Journey vehicles. ODI continues to explore the cause of the thermal event and its potential effect on the actuation of the door locks. ODI also continues to explore other potential causes for door lock malfunction. ODI has determined that an upgrade to an Engineering Analysis (EA) is necessary to continue the review of the investigative material and to assess the risk to motor vehicle safety . To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23008 · Vehicle Entrapment
Opened May 1, 2023 · Closed Aug 15, 2024
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Latches/locks/linkages:doors:lock; Latches/locks/linkages:electronic Lock/latch Actuator
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Latches/locks/linkages:doors:lock
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Latches/locks/linkages:electronic Lock/latch Actuator
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Illustration