Electrical System. Review the 767 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 269 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 195 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

41 crash reports30 fire reports27 injury reports

Steering complaints

72 reports

Clear category filter

102,000 miles · Nov 22, 2014

Steering

Read full complaint

TURNING LEFT ONTO HIGHWAY, LOST ALL ABILITY TO STEER, BRAKE, ETC. CAR JUST FROZE UP. PUT ON FLASHERS, COASTED TO RIGHT SIDE OF ROAD (NO LEFT SHOULDER) ACROSS TRAFFIC. TURNED IGNITION OFF, RESTARTED IN 1 MINUTE, AND WAS ABLE TO DRIVE AWAY. THIS HAS BEEN HAPPENING WITH INCREASING FREQUENCY SINCE, NOW SEVERAL TIMES A WEEK USUALLY WITH TURNS RIGHT OR LEFT. TOOK TO DEALER "COULD NOT REPRODUCE", BUT SAID THE ABS BAD SO INSTALLED NEW ABS, INSTALLED RECALLED IGNITION SWITCH BUT ACTUALLY NOW HAPPENING MORE! TAKING TO DIFFERENT LOCAL DODGE DEALER TO ASSESS SINCE NOT SATISFIED WITH PRIMARY DEALER (PURCHASED VEHICLE) AND THEIR LACK OF FURTHER DIAGNOSTIC TESTING. *TR

NHTSA ODI #10660221

100,000 miles · Aug 8, 2014

Electrical SystemEngineSteering

Read full complaint

WHILE DRIVING ON THE FREEWAY @ ABOUT 70 MPH SUDDENLY THE STEERING LOCKED UP AND THERE WAS NO POWER. WHILE I WAS TRYING TO MERGE OVER TO THE SIDE OF THE FREEWAY( I HAD TO CROSS 3 LANE, I WAS ALMOST HIT BY MULTIPLE CARS. I HAD NO CONTROL OF THE CAR. I MANAGED TO GET OFF TO THE SIDE OFF THE FREEWAY AND HAPPENED TO LOOK DOWN TO SEE THE IGNITION KEY TURNED TO THE OFF POSITION. I DONT HAVE ANY OTHER KEYS ATTACHED TO IT BECAUSE I HAD JUST HAD THE STARTER REPLACED MAYBE 1 WEEK BEFORE & WAS ADVISED NOT TO. I STARTED THE CAR THINKING MAYBE IT WAS A FREAK THING AND IT WOULDNT HAPPEN AGAIN. IT DID 2 DAYS LATER. THIS TIME I WAS APPROACHING AN INTERSECTION TURNING LEFT ON A GREEN ARROW. JUST AS I STARTED TO TURN THE CAR TURNED OFF MAKING IT VERY DIFFICULT TO TURN AND BARELY MISSED A GROUP OF PEOPLE ON THE SIDEWALK WHERE MY CAR ENDED UP BEFORE STOPPING. I HAD THE CAR TOWED TO THE SERVICE CENTER THE DEALERSHIP I BOUGHT THE CAR FROM. THIS WAS NOT A DODGE, CHRYSLER, OR JEEP DEALERSHIP EITHER. I WAS TOLD THAT RWI MODULE HAD TO BE REPLACED AND IT WAS NOT COVERED UNDER MY WARRANTY AND DODGE WOULD NOT COVER IT EITHER. WHILE THE CAR WAS BEING REPAIRED I CAME ACROSS RECALL L25. BUT WAS TOLD MY VIN NUMBER WAS NOT INCLUDED IN THE RECALL. THE CAR WAS IN THE REPAIR SHOP FOR 5 DAYS. IT COST ME OVER $600. THE DAY I PICKED THE CAR UP I CAME ACROSS DOCUMENTATION OF THE EXPANSION TO THE L25. I WAS THEN AGAIN TOLD THE VIN WAS NOT PART OF THE RECALL & AN INVESTIGATION WAS BEING DONE AND EVENTUALLY THE VIN WOULD BE IN THE RECALL BUT I COULD NOT BE GIVEN A DATE AS TO WHEN THIS WOULD HAPPEN. I CALLED DODGE CORPORATE OFFICES AND WAS TOLD THE SAME THING. I FEEL LIKE I OWN A COFFIN ON WHEELS. . ALL IN ALL I HAVE HAD THIS CAR IN FOR REPAIR FOR THE KEY TURNING TO THE OFF POSITION 3 TIMES NOW. SOMETHING NEEDS TO BE DONE NOW BEFORE SOMEONE IS SERIOUSLY HURT OR KILLED IN A CRASH BECAUSE OF THIS DEFECTIVE PART. *TR

NHTSA ODI #10621005

88,000 miles · Jan 30, 2014

Steering

Read full complaint

POWER STEERING HOSES RUPTURING FROM COLD WEATHER. SECOND HOSE IN LESS THAN 1 MONTH TO BLOW OUT WHILE VEHICLE IS PARKED AND WARMING UP. MANY PEOPLE ONLINE WITH SAME COMPLAINT, WHEN IT GETS COLD THE JOURNEY STARTS BLOWING THE POWER STEERING HOSES. SEEMS TO HAVE BEEN A PROBLEM FROM THE START, BUT THE PROBLEM HASN'T BEEN FIXED AND NEWER MODELS ARE STILL EXPERIENCING THIS PROBLEM. THE MECHANIC FEELS THIS IS DUE TO THE MATERIAL BEING USED IS NOT THE APPROPRIATE MATERIAL, IT IS TOO HARD AND BRITTLE. ONCE THE HOSE BLOWS OUT YOU LOSE THE POWER STEERING WHICH IS DANGEROUS AND IT STARTS TO GET SMOKE INSIDE THE VEHICLE AS THE POWER STEERING FLUID IS SMOKING IN THE ENGINE. *TR

NHTSA ODI #10562200

54,390 miles · Jan 23, 2014

Service BrakesSteeringTires

Read full complaint

WE BOUGHT THE DODGE JOURNEY IN DEC 2012 3 WEEKS OR SO LATER I RETURNED TO DEALERSHIP WITH A CLICKING SOUND WHEN I MOVED THE STEERING WHEEL THAT THE FRONT END WAS SHAKING AND THAT THERE WAS A LOAD ROAR LONG STORY SHORT EVERY 6 MONTHS ROTORS BRAKES TIRES ARE HAVING TO BE REPLACED AND I GUESS WHAT REALLY SET THINGS MORE IN MOTION WAS JAN 21 2014 WHILE TRAVELING DOWN THE INTERSTATE TO TAKE A SICK CHILD TO THE DR THE LEFT FRONT TIRE VALVE STEAM BLEW OUT MY HUSBAND GOT THE CAR OFF THE ROAD ONLY TO JACK IT UP TO CHANGE TIRE WHEN THE WEIGHT OF THE VEHICLE BENT THE JACK CAUSING IT TO FALL ALMOST ON MY HUSBANDS FOOT, WE BOUGHT THIS CAR BECAUSE IT WAS A V6 AND HAD THE ROOM WE NEED TO TRAVEL TO DR APPTS WITH OUR SPECIAL NEEDS CHILD BECAUSE WE HAVE TO TRAVEL SO FAR I HAVE HAD NOTHING BUT TROUBLE THE DEALERSHIP AFTER A FIGHT AGREED TO PUT NEW BRAKES THE MACHINED THE ROTORS AND SAID THE STEERING WAS A DODGE THING NOTHING TO WORRY ABOUT ONLY THE LOAD CLICKING WHEN PULLING IN OR OUT OF A PARKING SPACE AND THE ROAR IN THE FRONT THEY CLAIM IS THE RAOS AND THEY ALSO AT THIS TIME PUT 4 NEW TIRES ON THE CAR NOW MIND YOU THIS WAS ALL DONE 7/6/13 AND THEY DONE ALL OF THIS WHEN THEY PURCHASED THE CAR IN 11/20/12 AND WHEN I GO BACK IN TO THE CAR FAX EVERY 6 MONTHS THE BREAKS ROTORS AND TIRES HAVE TO BE REPLACED. NOW HERE IT IS 6 MONTHS LATER FOR US AND BLOW OUT ALSO WE JUST CHANGES THE ROTORS AND BRAKES ON THE 11 OF THIS MONTH SO SEE THE 6 MONTH DEAL WITH THIS CAR AND WHEN SEARCHING OTHER COMPLAINTS I AM FINDING THE SAME PROBLEM I HAVE CONTACTED CHRYSLER AND THEY SAY CALL MY DEALERSHIP I INFORMED [XXX] AT CHRYSLER IT WAS NOT THE DEALERSHIPS PROBLEM THEY DIDN'T MAKE THE CAR. IT IS A DEATH TRAP THERE ARE SO MANY MORE ISSUES WITH THIS CAR BUT THE DEADLY ONES ARE THE TIRES BLOWING OUT THE BRAKES CRUMBLING AND THE ROTORS WEARING OUT WITH IN 6 MONTHS THANK U AND I SO HOPE THAT SOMEONE CAN HELP US. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI #10561150

55,000 miles · Jul 22, 2013

Air BagsSteering

Read full complaint

I AM NOT REPORTING AN ACCIDENT ... YET. I WAS DRIVING ON RESIDENTIAL STREET ABOUT 35 MPH WHEN THE "AIRBAG WARNING LIGHT" CAME ON. THEREAFTER IT CAME ON EACH TIME I STARTED MY CAR AND STARTED TO DRIVE. CONTACTED NEAREST DEALER AND WAS TOLD THAT MY VEHICLE WAS NOT APART OF THE RECALL ( 09V118000), ALTHOUGH THE RECALL NAMED 2009 DODGE JOURNEYS. THEY WANTED ME TO PAY TO HAVE IT CHECKED! I THEN CALLED CHRYSLER CORP AND SPOKE WITH A REP WHO ALSO STATED THAT MY VEHICLE WAS NOT APART OF THE RECALL. IT APPEARS TO ME THAT IT SHOULD HAVE BEEN SINCE I NEVER HAD THIS TYPE OF ISSUE BEFORE WITH ANY OF THE APPROX. 7 VEHICLES I HAVE PURCHASED OVER THE LAST 50 YEARS. I DRIVE TO CALIFORNIA AT LEAST 3 TIMES EACH YEAR AND VARIOUS LOCATIONS WITHIN THE STATE OF ARIZONA. I WANT CHRYSLER TO CONTACT THE BILL-LUKE DEALERSHIP AND HAVE THEM CHECK MY ELECTRICAL SYSTEM AND FIX THE PROBLEM, AT CHRYSLER'S EXPENSE. I AM SURE I AM NOT THE ONLY OWNER WHO HAS THIS COMPLAINT. *TR

NHTSA ODI #10526150

53,600 miles · Apr 26, 2013

Service BrakesSteeringSuspension

Read full complaint

HAVE HAD THE RACK AND PINION FIXED 1 1/2 YEARS AGO AND IT IS LEAKING AGAIN. HAVE HAD TO PUT 3 SETS OF BRAKE PADS ON IN 3 YEARS. ALSO HAD TO PUT NEW ROTOR AND BRAKE CALIPER ON RIGHT FRONT DUE TO BRAKE LOCKING UP! THIS CAR ONLY HAS 53,600 MILES ON IT AND HAS BEEN ONE THING AFTER ANOTHER BREAKING DOWN ON IT. BEEN TOLD BY TWO DODGE MECHANICS THIS SHOULD NOT BE HAPPENING. WOULD LIKE FOR THE DEALER TO DO SOMETHING ABOUT IT. BEEN TOLD THERE WERE RECALLS ON THIS CAR AND WE HAVE NEVER GOTTEN ONE IN THE MAIL. HELP!! *TR

NHTSA ODI #10509692

16,000 miles · May 15, 2012

Power TrainService BrakesSteering

Read full complaint

SINCE I BROUGHT MY JOURNEY I HAD TO GET MY BRAKES REPLACED SEVERAL TIME & ROTORS REPLACE, TRANSMISSION SEALANT LEAK AND RECENTLY WHEN I WAS DRIVING TO WORK MY TIRE PRESSURE LIGHT CAME ON AND WITHIN MINUTES MY TIRE WAS ALMOST FLAT. I WAS ABLE TO JUST MAKE IT TO A GAS STATION AND WENT TO FILL UP MY TIRE AND MY VALVE STEM WENT ALL THE WAY IN AND MY TIRE WENT TOTALLY FLAT AND LOST ALL PRESSURE. MY CAR HAD TO BE TOWED AND ENDED UP SPENDING $300 TO GET MY FRONT PASSENGER AND REAR PASSENGER SIDE VALVE STEMS REPLACED. THE SERVICE GUY AGREED THAT IT WAS UNSAFE AND I COULD OF EASILY SPUN OUT IF I LOST ALL TIRE PRESSURE RIGHT AWAY. I HAVE 2 KIDS AND I FEEL UNSAFE TO DRIVE WITH MY CHILDREN IN THE CAR. ON TOP OF THESE ISSUES MY STEERING WHEEL CONTINUE TO SHAKE BUT I HAD IT IN TO THE SERVICE DEPARTMENT A NUMBER OF TIMES AND THEY SAID EVERYTHING IS OK. ONE OF THE INSTANCES THEY SAID THE SHAKING WAS BECAUSE OF MY ROUTERS AND RESURFACED THEM TWICE. PLEASE HELP ME. I DON'T KNOW OF MY OPTIONS BUT I AM CONCERNED FOR ME AND MY FAMILY'S SAFETY WITH THIS CAR. SINCERELY, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #10458601

Mileage unknown · Jan 12, 2012

Engine And Engine CoolingSteeringVehicle Speed Control

WHILE PULLING THE CAR INTO MY DRIVEWAY THE CAR JUST SHUT DOWN/DIED. I HAD NO CONTROL OF THE STEERING. EXTREMELY FRIGHTENING AND THANKFULLY THIS DID NOT OCCUR WHILE AT AN INTERSECTION OR ON THE HIGHWAY. *TR

NHTSA ODI #10443611

Mileage unknown · Jan 5, 2012

Electrical SystemSteering

Read full complaint

WE PURCHASED THIS VEHICLE 2/2011 WITH 47,000 MILES AND RECENTLY IN 9/2011 AT OUR REGULAR OIL CHANGE WE WERE TOLD THE LEFT-FRONT TIE ROD WAS GOING TO NEED REPLACED. NOW THE STEERING IS LOOSE, AND ITS LOUD IN THE FRONT END WHILE DRIVING OVER BUMPS. WE DON'T FEEL LIKE WE SHOULD BE REPLACING TIE-ROD ENDS THIS SOON ON THIS VEHICLE THAT IS IN EXCELLENT SHAPE OTHERWISE. I KNOW THERE IS A DODGE RAM RECALL CAMPAIGN#10V65800 FOR THE SAME THING. COULD THIS BE SOMETHING ALSO RELATED TO THE 2009 DODGE JOURNEY? *TR

NHTSA ODI #10442541

Mileage unknown · Oct 2, 2011

Electrical SystemSteeringVehicle Speed Control

Read full complaint

NHTSA IT ALL STARTED WHEN I BOUGHT MY JOURNEY: NICE LOOKING BUT VERY, VERY BAD EXPERIENCE 1.TRANSMISSION, IT CHANGE SPEED BY ITSELF. IT CHANGE SPEED FROM 80 MPH TO 40, THEN 70 MPH TO 30 MPH.. I WAS DRIVING IN THE EXPRESSWAY AND THIS CHANGE OF SPEED HAPPEN TO ME SEVERAL TIMES. I TOOK IT TO THE DEALER AND THEY SAID THAT THEY COULD NOT FOUND THE PROBLEM, AFTER SO MANY INCIDENTS I GOT MAD TO THE DEALER AND TOLD THEM THAT MY LIFE IS AT RISK BECAUSE THE CAR CHANGE SPEED BY ITSELF THAT THEY HAVE TO DO SOMETHING ABOUT IT. THEY FINALLY FIX THE CAR. 2.BRAKES, I HAVE PROBLEMS WITH THE BRAKES TOO. THEY RUN FAST AND HAVE TO KEEP CHANGING THEM. 3.BATTERY, I HAVE PROBLEMS WITH THE BATTERY TOO. I HAVE TOLD THEM NUMEROUS TIMES TOO CHECK THE BATTERY, BECAUSE THE CAR DOES NOT WANT TO START AND THEY KEEP TELLING ME THAT THERE IS NOTHING WRONG WITH THE BATTERY. SO MY QUESTION TO THEM IS THE FOLLOWING IF THE BATTERY IS GOOD., WHAT IS THE PROBLEM? I HAVE TO TURN ON THE SWITCH SEVERAL TIMES UNTIL THE CAR START. THEY SAID THAT THEY CANNOT FIND THE PROBLEM. AND NOW THE LATEST PROBLEM!!!!!!!! 4.STEERING, EVERY TIME I TURN THE WHEELS THE CAR MAKE A WEAR SOUND LIKE AN OLD CAR 5.CAR DOES NOT TURN OFF. NOW MY CAR DOES NOT WANT TO TURN OFF THE DEALER SAID THAT I BOUGHT THE CAR AND THAT NOW THE CAR IS MINE AND I HAVE TO TAKE CARE OF IT. YEAH RIGHT!!! SO MY QUESTION IS THE FOLLOWING WHAT IS NHTSA GOING TO DO ABOUT IT WHILE CHRYSLER IGNORE THEIR CUSTOMERS COMPLAINTS AND NOT TAKING RESPONSIBILITY. IN THE MEAN TIME WE THE CONSUMERS HAVE TO PAY FOR CHRYSLER POOR PERFORMANCE, ETC. DODGE JOURNEY SHOULD BE REMOVE FROM THE MARKET. AND WE AS CONSUMERS SHOULD BE REIMBURSE OR AT LEAST CHRYSLER SHOULD RECALL ALL CARS. *TR

NHTSA ODI #10428218

Official recalls

16V273000 · Steering:hydraulic Power Assist:hose, Piping, And Connections

May 6, 2016

Chrysler (FCA US LLC) is recalling certain model year 2009-2016 Dodge Journey vehicles manufactured July 31, 2007, to November 12, 2016. After exposure to cold temperatures, the power steering return hose may rupture at engine start-up causing a loss of power steering assist.

Consequence & remedy

Consequence: A loss of power steering assist may require extra steering effort, especially at lower speeds, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the power steering return hoses, steel tubes, and power steering oil cooler, free of charge. The recall began on May 24, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S08.

16V047000 · Air Bags:frontal

Jan 29, 2016

FCA US LLC (Chrysler) is recalling certain model year 2009 Dodge Journey vehicles manufactured December 31, 2007, to August 31, 2008, 2008-2009 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured June 18, 2007, to August 31, 2008. In the affected vehicles, the air bag control units may corrode and fail.

Consequence & remedy

Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began on December 6, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S07.

14V373000 · Air Bags; Electrical System:ignition:switch

Jun 26, 2014

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Consequence & remedy

Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.

Additional source detail variants (2)

Air Bags

Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.

Electrical System:ignition:switch

10V658000 · Electrical System:wiring

Dec 24, 2010

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2009 DODGE JOURNEY VEHICLES MANUFACTURER FROM NOVEMBER 1, 2007, THROUGH NOVEMBER 7, 2008. THE WIRES WITHIN THE FRONT DOOR WIRE HARNESSES MAY FATIGUE AND BREAK, WHICH CAN INTERRUPT THE CIRCUITS FOR THE SIDE IMPACT SENSOR(S), RESULTING IN AN AIRBAG WARNING LAMP ILLUMINATION AND LOSS OF SIDE CRASH SENSING CAPABILITY.

Consequence & remedy

Consequence: IN THE EVENT OF A CRASH, THE SIDE AIRBAG MAY NOT DEPLOY, REDUCING THE PROTECTION INTENDED FOR THE OCCUPANT AND INCREASING THE RISK OF INJURIES.

Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE LEFT AND RIGHT DOOR WIRING HARNESSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

09V118000 · Air Bags; Air Bags:frontal; Electrical System:wiring

Apr 9, 2009

CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.

Consequence & remedy

Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.

Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Additional source detail variants (3)

Air Bags:frontal

Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.

Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Air Bags

Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.

Electrical System:wiring

Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.

09V082000 · Electrical System

Mar 12, 2009

CHRYSLER IS RECALLING 16,852 MY 2009 DODGE JOURNEY VEHICLES EQUIPPED WITHOUT OPTIONAL 115 VOLT AUXILIARY POWER OUTLET. AN UNUSED ELECTRICAL CONNECTOR FOR THE OPTIONAL 115 VOLT AUXILIARY POWER OUTLET OPTION MAY BECOME CORRODED AND COULD SHORT CIRCUIT.

Consequence & remedy

Consequence: IF THE FUSE FOR THIS CIRCUIT DOES NOT BLOW, THE CONNECTOR COULD OVERHEAT AND POTENTIALLY CATCH FIRE.

Remedy: DEALERS WILL RE-ROUTE AND STOW THE 115 VOLT AUXILIARY POWER OUTLET CONNECTOR AND PULL THE 25 AMP FUSE TO REMOVE POWER FROM THIS UNUSED CIRCUIT FREE OF CHARGE. THE RECALL BEGAN ON MARCH 30, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

08V528000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Oct 9, 2008

CHRYSLER IS RECALLING 712 MY 2009 SEBRING, DODGE CALIBER, AVENGER, JOURNEY, JEEP PATRIOT, AND COMPASS VEHICLES. A NEW ADHESIVE USED IN THE POWER TRAIN CONTROL MODULE (PCM) MANUFACTURING PROCESS CAN CAUSE THE PRINTED CIRCUIT BOARD TO BREAK.

Consequence & remedy

Consequence: THIS CAN CAUSE THE ENGINE TO STALL AND CAUSE A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL REPLACE THE PCM FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 10, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

08V247000 · Electrical System:wiring

Jun 3, 2008

CHRYSLER IS RECALLING 6,692 MY 2009 DODGE JOURNEY VEHICLES EQUIPPED WITH A 3.5L ENGINE. THE ENGINE WIRING HARNESS MAY CONTACT THE LEFT TRANSAXLE MOUNT.

Consequence & remedy

Consequence: DAMAGE TO THE WIRING HARNESS COULD RESULT IN AN ENGINE COMPARTMENT FIRE.

Remedy: DEALERS WILL INSPECT THE ENGINE WIRING HARNESS FOR DAMAGE. IF THE HARNESS IS DAMAGED, THE WIRING WILL BE REPAIRED AND A TIE WRAP INSTALLED TO SECURE THE HARNESS AWAY FROM THE LEFT TRANSAXLE MOUNT. IF NO DAMAGE IS FOUND, A TIE WRAP WILL BE INSTALLED TO SECURE THE HARNESS AWAY FROM THE LEFT TRANSAXLE MOUNT. THE RECALL BEGAN ON JULY 7, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA24003 · Vehicle Entrapment

Opened Aug 1, 2024 · No close date supplied

Status: open (inferred from source dates) · Latches/locks/linkages

The Office of Defects Investigation (ODI) opened PE23-008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During the investigation, ODI collected information from the manufacturer and involved parties to confirm or refute the defect allegation. ODI has determined that additional reports of vehicle entrapment exist for other model year Dodge Journey vehicles. ODI continues to explore the cause of the thermal event and its potential effect on the actuation of the door locks. ODI also continues to explore other potential causes for door lock malfunction. ODI has determined that an upgrade to an Engineering Analysis (EA) is necessary to continue the review of the investigative material and to assess the risk to motor vehicle safety . To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

PE23008 · Vehicle Entrapment

Opened May 1, 2023 · Closed Aug 15, 2024

Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Latches/locks/linkages:doors:lock; Latches/locks/linkages:electronic Lock/latch Actuator

The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (3)

Latches/locks/linkages:doors:latch

Latches/locks/linkages:doors:lock

Latches/locks/linkages:electronic Lock/latch Actuator

DP14004 · Totally Integrated Power Module Failure

Opened Sep 25, 2014 · Closed Jul 24, 2015

Status: closed (inferred from source dates) · Electrical System

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den

RQ14002 · Air Bag Non-Deployment/Engine Stall

Opened Jun 16, 2014 · Closed Mar 2, 2015

Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module

In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972

Additional source detail variants (2)

Air Bags

Electrical System:ignition:module