NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
106 reportsClear category filter78,000 miles · Mar 30, 2016
Service Brakes
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. WHILE DRIVING 30 MPH, THE BRAKE PEDAL WAS DEPRESSED AND THE VEHICLE VIBRATED SEVERELY. A LOUD SQUEALING NOISE WAS HEARD FROM THE TWO FRONT WHEELS. THE FAILURE OCCURRED CONSTANTLY. IN ADDITION, FUMES OF SMOKE APPEARED FROM THE TWO FRONT WHEELS. THE DEALER CLAIMED THE BRAKES WERE COMPLETE…
Read full complaint
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. WHILE DRIVING 30 MPH, THE BRAKE PEDAL WAS DEPRESSED AND THE VEHICLE VIBRATED SEVERELY. A LOUD SQUEALING NOISE WAS HEARD FROM THE TWO FRONT WHEELS. THE FAILURE OCCURRED CONSTANTLY. IN ADDITION, FUMES OF SMOKE APPEARED FROM THE TWO FRONT WHEELS. THE DEALER CLAIMED THE BRAKES WERE COMPLETELY NEW. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ROTORS AND BRAKES FOR THE FRONT WHEELS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 78,000.
NHTSA ODI #10852421
70,000 miles · Mar 11, 2016
Electrical SystemEngineService Brakes
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. ON SEVERAL OCCASIONS, THE VEHICLE FAILED TO START. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V373000 (AIR BAGS, ELECTRICAL SYSTEM). THE CONTACT ALSO STATED THAT THE BRAKES WOULD WEAR EXCESSIVELY AFTER BEING REPLACED. THE CONTACT ALSO STATED THAT THE VEHICLE EXPERIENCED A H…
Read full complaint
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. ON SEVERAL OCCASIONS, THE VEHICLE FAILED TO START. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V373000 (AIR BAGS, ELECTRICAL SYSTEM). THE CONTACT ALSO STATED THAT THE BRAKES WOULD WEAR EXCESSIVELY AFTER BEING REPLACED. THE CONTACT ALSO STATED THAT THE VEHICLE EXPERIENCED A HEAD GASKET FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
NHTSA ODI #10846112
131,000 miles · Feb 2, 2016
Service Brakes
BRAKE ROTORS WARPED. TROUBLE STOPPING. STEERING WHEEL SHAKING WHEN BRAKES APPLIED.
NHTSA ODI #10823657
16,975 miles · Jan 23, 2016
Electronic Stability Control (esc)Service Brakes
WE BOUGHT THE CAR NEW IN APRIL OF 2009. IN AUGUST OF 2012 BRAKES STARTED ACTING 'STICKY AND JERKY'. TOOK IT BACK TO THE DEALERSHIP JUST BECAUSE OF THE BRAKES (HAD EXTENDED WARRANTY). WE HAD A STRONG FEELING IT HAD SOMETHING TO DO WITH THE ESP BAS SYSTEM. THEY DIDN'T EVEN LOOK AT IT BEFORE SAYING 'NO' IT WASN'T THE ESP BAS SY…
Read full complaint
WE BOUGHT THE CAR NEW IN APRIL OF 2009. IN AUGUST OF 2012 BRAKES STARTED ACTING 'STICKY AND JERKY'. TOOK IT BACK TO THE DEALERSHIP JUST BECAUSE OF THE BRAKES (HAD EXTENDED WARRANTY). WE HAD A STRONG FEELING IT HAD SOMETHING TO DO WITH THE ESP BAS SYSTEM. THEY DIDN'T EVEN LOOK AT IT BEFORE SAYING 'NO' IT WASN'T THE ESP BAS SYSTEM. THROUGH MULTIPLE DEALERSHIP SERVICE VISITS, OIL CHANGES AND SUCH; BRAKES STAYED CONSTANTLY JERKY. 2+ YEARS AGO I WENT INTO DEALERSHIP FOR TIRE ROTATION AND OIL CHANGE AND THEY TOLD ME I'D HAVE TO REPLACE MY BRAKES SOON. UNHAPPY WITH THE LONG WAIT AND COST OF SERVICE AT THE DEALERSHIP I'VE BEEN TAKING THE JOURNEY INTO ANOTHER SHOP WHERE I ASKED THEM TO CHECK MY BRAKES AND THEY SAID THEY WERE FINE. YESTERDAY WHILE DRIVING APPROX. 35MPH THE ESP BAS LIGHTS CAME ON AND ALL OF A SUDDEN THE BRAKES WEREN'T STICKY OR JERKY. THEY WORKED LIKE THEY WERE SUPPOSED TO IN THE FIRST PLACE. THE ESP BAS (YELLOW) LIGHTS WILL NOT TURN OFF. I KNOW SOONER OR LATER I'LL HAVE TO REPLACE THE BRAKES BECAUSE THEY PUT SUCH SHODDY ONES ON AT THE FACTORY, BUT THE PROBLEM WITH THE ESP BAS IS A COMPUTER PROBLEM THAT EFFECTED THE BRAKE SYSTEM AND IT SHOULD HAVE BEEN ADDRESSED BY THE DEALERSHIP. BETWEEN THE POOR DISMISSIVE WAY THE DEALERSHIP HANDLED THIS ESP BAS PROBLEM (DIDN'T EVEN TEST DRIVE) AND THE CHEAP BRAKES DODGE INSTALLED. I WILL NEVER BUY A VEHICLE FROM EITHER OF THEM AGAIN.
NHTSA ODI #10821872
Mileage unknown · Jan 12, 2016
Service BrakesVehicle Speed Control
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 70 MPH, THE VEHICLES POWER REDUCED WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THERE WAS AN ABNORMAL SOUND COMING FROM THE VEHICLE WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT …
Read full complaint
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 70 MPH, THE VEHICLES POWER REDUCED WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THERE WAS AN ABNORMAL SOUND COMING FROM THE VEHICLE WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V373000 (AIR BAGS , ELECTRICAL SYSTEM) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #10819634
Mileage unknown · Jan 11, 2016
Service Brakes
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. WHILE DRIVING AT VARIOUS SPEEDS, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN IT WAS DEPRESSED. THE ACCELERATOR PEDAL STIFFENED AND PREVENTED THE VEHICLE FROM ACCELERATING. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED TH…
Read full complaint
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. WHILE DRIVING AT VARIOUS SPEEDS, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN IT WAS DEPRESSED. THE ACCELERATOR PEDAL STIFFENED AND PREVENTED THE VEHICLE FROM ACCELERATING. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BRAKES, ROTORS, AND CALIPERS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10819427
110,000 miles · Dec 20, 2015
EngineService Brakes
CAR HAS OVERHEATED SEVERAL TIMES. I HAVE REPLACED HOSES AND COOLANT RESERVE TANK TWICE TEMP GOT SO HOT THAT IT MELTED HOLES IN IT, BRAKES ON FRONT HASH BEEN REPLACED 6 TIMES SINCE 2014 ALSO REPLACED ROTORS TWICE REPLACE BRAKES ON REAR TWICE. *DT
NHTSA ODI #10811351
Mileage unknown · Nov 27, 2015
Service Brakes
HAVE CHANGED BRAKES AND ROTORS 3 TIMES SINCE OWNING IT NEEDS,REPAIRED AGAIN, JUST REPAIRED IT LAST DECEMBER 2014
NHTSA ODI #10807232
104,350 miles · Nov 2, 2015
Electrical SystemService Brakes
WHILE DRIVING THE CAR WHEEL WILL LOCK UP AND CUT OFF. NO WARNING I HAVE TAKEN IT TO MECHANICS WHO SAID NOTHING IS WRONG. I HAVE BEEN DEALING THIS SINCE I PURCHASED THE CAR. ALSO FRONT BRAKES WHERE OUT I RECENTLY HAD TO CHANGE THE BRAKE CALIBER IN THE FRONT OF VEHICLE.
NHTSA ODI #10787597
100,000 miles · Oct 21, 2015
Electrical SystemService Brakes
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. WHILE PARKED, THE VEHICLE WOULD NOT START WITHOUT WARNING. THE CONTACT STATED THAT THE VEHICLE DROVE FINE, BUT IT WOULD NOT RESTART WHEN PARKED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE, BUT THE FAILURE RECURRED. THE CONTACT ALSO STATED THAT THE BRAKE PADS AND ROTORS WERE WEARING DOW…
Read full complaint
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. WHILE PARKED, THE VEHICLE WOULD NOT START WITHOUT WARNING. THE CONTACT STATED THAT THE VEHICLE DROVE FINE, BUT IT WOULD NOT RESTART WHEN PARKED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE, BUT THE FAILURE RECURRED. THE CONTACT ALSO STATED THAT THE BRAKE PADS AND ROTORS WERE WEARING DOWN FASTER THAN NORMAL. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT COULD NOT BE DIAGNOSED AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10785181
Official recalls
8May 6, 2016
Chrysler (FCA US LLC) is recalling certain model year 2009-2016 Dodge Journey vehicles manufactured July 31, 2007, to November 12, 2016. After exposure to cold temperatures, the power steering return hose may rupture at engine start-up causing a loss of power steering assist.
Consequence & remedy
Consequence: A loss of power steering assist may require extra steering effort, especially at lower speeds, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the power steering return hoses, steel tubes, and power steering oil cooler, free of charge. The recall began on May 24, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S08.
Jan 29, 2016
FCA US LLC (Chrysler) is recalling certain model year 2009 Dodge Journey vehicles manufactured December 31, 2007, to August 31, 2008, 2008-2009 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured June 18, 2007, to August 31, 2008. In the affected vehicles, the air bag control units may corrode and fail.
Consequence & remedy
Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began on December 6, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S07.
Jun 26, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Dec 24, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2009 DODGE JOURNEY VEHICLES MANUFACTURER FROM NOVEMBER 1, 2007, THROUGH NOVEMBER 7, 2008. THE WIRES WITHIN THE FRONT DOOR WIRE HARNESSES MAY FATIGUE AND BREAK, WHICH CAN INTERRUPT THE CIRCUITS FOR THE SIDE IMPACT SENSOR(S), RESULTING IN AN AIRBAG WARNING LAMP ILLUMINATION AND LOSS OF SIDE CRASH SENSING CAPABILITY.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SIDE AIRBAG MAY NOT DEPLOY, REDUCING THE PROTECTION INTENDED FOR THE OCCUPANT AND INCREASING THE RISK OF INJURIES.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE LEFT AND RIGHT DOOR WIRING HARNESSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Apr 9, 2009
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (3)
Air Bags:frontal
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Electrical System:wiring
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Mar 12, 2009
CHRYSLER IS RECALLING 16,852 MY 2009 DODGE JOURNEY VEHICLES EQUIPPED WITHOUT OPTIONAL 115 VOLT AUXILIARY POWER OUTLET. AN UNUSED ELECTRICAL CONNECTOR FOR THE OPTIONAL 115 VOLT AUXILIARY POWER OUTLET OPTION MAY BECOME CORRODED AND COULD SHORT CIRCUIT.
Consequence & remedy
Consequence: IF THE FUSE FOR THIS CIRCUIT DOES NOT BLOW, THE CONNECTOR COULD OVERHEAT AND POTENTIALLY CATCH FIRE.
Remedy: DEALERS WILL RE-ROUTE AND STOW THE 115 VOLT AUXILIARY POWER OUTLET CONNECTOR AND PULL THE 25 AMP FUSE TO REMOVE POWER FROM THIS UNUSED CIRCUIT FREE OF CHARGE. THE RECALL BEGAN ON MARCH 30, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Oct 9, 2008
CHRYSLER IS RECALLING 712 MY 2009 SEBRING, DODGE CALIBER, AVENGER, JOURNEY, JEEP PATRIOT, AND COMPASS VEHICLES. A NEW ADHESIVE USED IN THE POWER TRAIN CONTROL MODULE (PCM) MANUFACTURING PROCESS CAN CAUSE THE PRINTED CIRCUIT BOARD TO BREAK.
Consequence & remedy
Consequence: THIS CAN CAUSE THE ENGINE TO STALL AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE PCM FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 10, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Jun 3, 2008
CHRYSLER IS RECALLING 6,692 MY 2009 DODGE JOURNEY VEHICLES EQUIPPED WITH A 3.5L ENGINE. THE ENGINE WIRING HARNESS MAY CONTACT THE LEFT TRANSAXLE MOUNT.
Consequence & remedy
Consequence: DAMAGE TO THE WIRING HARNESS COULD RESULT IN AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL INSPECT THE ENGINE WIRING HARNESS FOR DAMAGE. IF THE HARNESS IS DAMAGED, THE WIRING WILL BE REPAIRED AND A TIE WRAP INSTALLED TO SECURE THE HARNESS AWAY FROM THE LEFT TRANSAXLE MOUNT. IF NO DAMAGE IS FOUND, A TIE WRAP WILL BE INSTALLED TO SECURE THE HARNESS AWAY FROM THE LEFT TRANSAXLE MOUNT. THE RECALL BEGAN ON JULY 7, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA24003 · Vehicle Entrapment
Opened Aug 1, 2024 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages
The Office of Defects Investigation (ODI) opened PE23-008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During the investigation, ODI collected information from the manufacturer and involved parties to confirm or refute the defect allegation. ODI has determined that additional reports of vehicle entrapment exist for other model year Dodge Journey vehicles. ODI continues to explore the cause of the thermal event and its potential effect on the actuation of the door locks. ODI also continues to explore other potential causes for door lock malfunction. ODI has determined that an upgrade to an Engineering Analysis (EA) is necessary to continue the review of the investigative material and to assess the risk to motor vehicle safety . To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23008 · Vehicle Entrapment
Opened May 1, 2023 · Closed Aug 15, 2024
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Latches/locks/linkages:doors:lock; Latches/locks/linkages:electronic Lock/latch Actuator
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Latches/locks/linkages:doors:lock
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Latches/locks/linkages:electronic Lock/latch Actuator
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Illustration