NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
106 reportsClear category filter149,000 miles · Jul 3, 2017
Air BagsSeat BeltsService BrakesCrash
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V047000 (SEAT BELTS, AIR BAGS). THE PARTS TO DO THE REPAIRS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE WAS TAKEN TO HOLT DODGE AND JEEP D…
Read full complaint
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V047000 (SEAT BELTS, AIR BAGS). THE PARTS TO DO THE REPAIRS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE WAS TAKEN TO HOLT DODGE AND JEEP DEALER TO GET THE RECALL REPAIRED. UPON TAKING APART THE VEHICLE, THE CONTACT NOTICED THAT THE PARTS WERE NOT THE CORRECT ONES. THE VEHICLE WAS REASSEMBLED AND THE PARTS WERE ORDERED. THE NEXT DAY, WHILE TRAVELING AT HIGHWAY SPEEDS, THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO STOP THE VEHICLE, WHICH RESULTED IN A FRONT END COLLISION. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 149,000. PARTS DISTRIBUTION DISCONNECT. UPDATED 09/01/17*LJ *CN
NHTSA ODI #11002853
Mileage unknown · Apr 4, 2017
Service Brakes
BOUGHT 2009 DODGE JOURNEY NEW. WITH ONLY 12,143 MILES (19.818 KM) I HAD TO HAVE ROTORS AND BRAKES REPLACED DUE TO THEM RUSTING OUT. THIS WAS DONE IN GERMANY BY A DODGE DEALER. A POLICY ADJUSTMENT WAS MADE. THEN WITH ONLY 27,000 MILES ON THE VEHICLE I HAD TO REPLACE THE BRAKE PADS AND THE ROTORS NEEDED TO BE TURNED. THEN WITH 4…
Read full complaint
BOUGHT 2009 DODGE JOURNEY NEW. WITH ONLY 12,143 MILES (19.818 KM) I HAD TO HAVE ROTORS AND BRAKES REPLACED DUE TO THEM RUSTING OUT. THIS WAS DONE IN GERMANY BY A DODGE DEALER. A POLICY ADJUSTMENT WAS MADE. THEN WITH ONLY 27,000 MILES ON THE VEHICLE I HAD TO REPLACE THE BRAKE PADS AND THE ROTORS NEEDED TO BE TURNED. THEN WITH 43,148 MILES I HAD TO ONCE AGAIN REPLACE ALL BRAKE PADS, FRONT ROTORS AND THE REAR ROTORS WERE ABLE TO BE MACHINED. THIS IS THE WORK I HAD DONE AT SAN DIEGO DODGE DEALER. WHEN I HAD THE WORK DONE IN MAY 2016 I TOOK THE VEHICLE BACK IN AUG 2016 DUE TO A SQUEAKING NOISE COMING WHEN BRAKES APPLIED. WAS TOLD IT WAS FROM NEW BRAKES AND I SHOULD JUST PUMP THEM AND IT SHOULD GO AWAY. I TRIED TO DO THIS BUT NOISE REMAINED SO I TOOK VEHICLE BACK IN NOV 2016 AND WAS TOLD THAT THE BRAKES WERE "DIRTY" AND THEY COULD CLEAN THEM FOR $134 OR I COULD ONCE AGAIN PUMP THEM AND IT SHOULD STOP. I TRIED AGAIN THEIR RECOMMENDATION AND THEN DECIDED TO TAKE FOR SECOND OPINION SO TOOK TO PERRY'S DODGE IN NATIONAL CITY, CA ON 3 APRIL 2017 AND WAS INFORMED THAT I THE VEHICLE NEEDED ALL FOUR BRAKES AND THE REAR ROTOR NEEDED REPLACED WITH THE FRONT ROTOR NEEDING MACHINED. I WOULD THINK THAT FOR A VEHICLE HAVING ONLY 53,000 MILES AND HAVING 4 BRAKE JOBS AND NOW NEEDING ANOTHER ONE THAT SOMETHING IS WRONG. I CONTACTED DODGE CUSTOMER SERVICE REP (ROYAL) WHO BASICALLY SAID THAT ACCORDING TO THE SAN DIEGO DODGE DEALERSHIP THAT THIS IS NORMAL WEAR AND TEAR BUT THEY DID OPEN EMAIL CASE NUMBER: 3336076 AND REFERENCE NUMBER: 29272328. I HAVE READ MANY REVIEWS THAT BASICALLY SAY THAT THE 2009 AND 2010 DODGE JOURNEY'S BRAKE SYSTEM WERE NOT MADE TO HOLD THE WEIGHT OF THE VEHICLE. DODGE WILL NOT CLAIM THIS ERROR AND SO US WHO BOUGHT THIS VEHICLE WHEN IT FIRST CAME OUT ARE STUCK WITH PERFORMING BRAKE JOBS EVERY 10,000 MILES.
NHTSA ODI #10970569
Mileage unknown · Dec 6, 2016
Electrical SystemService Brakes
MY 2009 DODGE SE JOURNEY HAS HAD SEVERAL PROBLEMS INCLUDING SOME UNDER OPEN RECALL,ELECTRICAL RECALL. HOWEVER MY BRAKES ARE VERY BAD,ABS LIGHT AND BRAKE LIGHT FREQUENTLY COME ON AND OFF. THE BRAKES ACT AS IF I HAVE NO BRAKES OR PRESSURE, UNTIL THEY ARE HALF WAY DOWN THEN THEY OVER ENGAGE CAUSING THE VEHICLE TO SUDDENLY STOP OR S…
Read full complaint
MY 2009 DODGE SE JOURNEY HAS HAD SEVERAL PROBLEMS INCLUDING SOME UNDER OPEN RECALL,ELECTRICAL RECALL. HOWEVER MY BRAKES ARE VERY BAD,ABS LIGHT AND BRAKE LIGHT FREQUENTLY COME ON AND OFF. THE BRAKES ACT AS IF I HAVE NO BRAKES OR PRESSURE, UNTIL THEY ARE HALF WAY DOWN THEN THEY OVER ENGAGE CAUSING THE VEHICLE TO SUDDENLY STOP OR SIGNIFICANTLY SLOW AT UNSAFE PACE. I HAVE CONTACTED CHRYSLER THERE IS NO RECALL AT THIS TIME. THIS IS AN UNSAFE VEHICLE ALL AROUND AND COMPLETE RECALL SHOULD BE IN EFFECT. THIS PROBLEM HAS OCCURRED SINCE WE PURCHASED THE VEHICLE AND HAS NOT STOPPED.
NHTSA ODI #10930204
160,000 miles · Nov 2, 2016
Service BrakesSuspensionUnknown Or Other
SUSPENSION PARTS FAILING CONSTANTLY, FRONT TIE RODS, SWAY BARS, STRUTS, BALL JOINTS, BUSHINGS WEAR AFTER 10,000 A 15,000 MILES. AS A RESULT ALIGNMENT IS OFF AND CAUSE UNUSUAL WEAR ON THE TIRES RESULTING IN ROUGH UNCOMFORTABLE RIDE. BRAKES GET HOT AND WEAR/ SQUEAK AFTER 10K MILES, SOMETIMES SOONER RESULTING IN HUB CAP DUST AND PA…
Read full complaint
SUSPENSION PARTS FAILING CONSTANTLY, FRONT TIE RODS, SWAY BARS, STRUTS, BALL JOINTS, BUSHINGS WEAR AFTER 10,000 A 15,000 MILES. AS A RESULT ALIGNMENT IS OFF AND CAUSE UNUSUAL WEAR ON THE TIRES RESULTING IN ROUGH UNCOMFORTABLE RIDE. BRAKES GET HOT AND WEAR/ SQUEAK AFTER 10K MILES, SOMETIMES SOONER RESULTING IN HUB CAP DUST AND PAINT CHIPPING. REAR TIE RODS GO BAD RESULTING IN REAR CAMBER BEING OFFSET AND INSIDE OF TIRES WEAR REAL QUICK. RIGHT SIDE DOOR LOCKS HAVE TO BE MANUALLY LOCKED/ UNLOCKED. INTERMITTENT NOT STARTING PROBLEMS, WIN MODULE ALREADY REPLACED ONCE DUE TO RECALL. DRIVER SIDE WINDOW UP AND DOWN BUTTONS BROKE OFF. FRONT DASH RATTLES BAD WHEN TAKING OFF/ GOING OVER BUMPS. REAR LEFT SIDE DOOR HINGE GOT LOOSE RESULTING IN SPRING POPPING OFF, NOW DOOR WON'T STAY OPEN AND CLOSES BY ITSELF, THAT'S THE DOOR THAT'S LEAST USED.
NHTSA ODI #10923909
131,000 miles · Oct 14, 2016
Service Brakes
THIS IS 3RD TIME MY JOURNEY'S BRAKES NEED REPLACING. THIS TIME MY COST 1683.00---IM ON SSDI---LOW INCOME---REALLY PUNCHED ME,. HORRIBLE PREDICAMENT TO BE IN--PLEASE CONTACT ME IF ANY COSTS ARE REIMBURSED BY CHRYSLER-DODGE. HELP!!
NHTSA ODI #10916204
168,924 miles · Aug 9, 2016
Electrical SystemService BrakesFire
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. WHILE DRIVING AT ANY SPEED, THE ESP AND ABS LIGHTS ILLUMINATED AND THE VEHICLE LOST POWER. AFTERWARDS, ALL FOUR BRAKES LOCKED UP AND SMOKE APPEARED. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD. THE FIRE DEPARTMENT WAS CALLED AND DIAGNOSED THAT THE TWO FRONT BRAKES HAD LOCKED UP…
Read full complaint
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. WHILE DRIVING AT ANY SPEED, THE ESP AND ABS LIGHTS ILLUMINATED AND THE VEHICLE LOST POWER. AFTERWARDS, ALL FOUR BRAKES LOCKED UP AND SMOKE APPEARED. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD. THE FIRE DEPARTMENT WAS CALLED AND DIAGNOSED THAT THE TWO FRONT BRAKES HAD LOCKED UP. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND WAS LATER DRIVEN TO THE DEALER. THE DEALER DIAGNOSED THAT THE FAILURE OCCURRED DUE TO WEAR AND TEAR. THE MASTER CYLINDER, ROTORS, BRAKE CALIBER, AND ALL FOUR BRAKES WERE REPLACED; HOWEVER, THE FAILURE RECURRED NUMEROUS TIMES. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 168,924.
NHTSA ODI #10894374
98,000 miles · Jul 6, 2016
EngineService BrakesVehicle Speed ControlCrashInjury
WHILE DRIVING AT A SPEED OF 45 MPH ON A ROAD THAT IS RATED FOR 55 MPH, THE LEFT DRIVER SIDE TIRE SEPARATED FROM THE CAR. WHILE TRYING TO CONTROL THE CAR BY HITTING THE BRAKES THE CAR SPEED BEGAN TO INCREASED.
NHTSA ODI #10883144
100,000 miles · Jun 23, 2016
Service Brakes
WHILE DRIVING THIS VEHICLE, WHEN YOU GO TO USE THE BRAKES THEY BECOME 'MUSHY'. YOU HAVE TO PUSH ON THE BRAKES ALL THE WAY TO THE FLOOR BEFORE THE VEHICLE WILL EVEN TRY TO STOP. WE HAVE REPLACED THE BRAKES ALREADY SINCE PURCHASING THE VEHICLE AND NOW NOT SURE WHAT TO DO. YESTERDAY WHILE I WAS DRIVING DOWN THE HIGHWAY, TRAFFIC C…
Read full complaint
WHILE DRIVING THIS VEHICLE, WHEN YOU GO TO USE THE BRAKES THEY BECOME 'MUSHY'. YOU HAVE TO PUSH ON THE BRAKES ALL THE WAY TO THE FLOOR BEFORE THE VEHICLE WILL EVEN TRY TO STOP. WE HAVE REPLACED THE BRAKES ALREADY SINCE PURCHASING THE VEHICLE AND NOW NOT SURE WHAT TO DO. YESTERDAY WHILE I WAS DRIVING DOWN THE HIGHWAY, TRAFFIC CAME TO A COMPLETE STOP. I HAD TO PUSH ON THE BRAKES VERY HARD. THE TIRES ACTUALLY SQUEALED, THE CAR JERKED, AND YOU COULD FEEL THE BRAKE GIVE A JERKING FEELING BELOW MY FOOT. FORTUNATELY, I DID NOT HAVE MY BABIES WITH ME THIS TIME. ANOTHER INCIDENT THAT HAS HAPPENED THIS WEEK IS WHEN THE TIRES SQUEALED WHEN I WAS TRYING TO TURN RIGHT AT A LIGHT AND COULD NOT GET THE VEHICLE TO SLOW DOWN ENOUGH ON A DECLINE. THIS IS VERY SCARY AND I HOPE THIS IS FIXED VERY SOON. I HAVE LOOKED AT OTHER SITES AND NOTICE THAT THERE ARE A LOT OF BRAKE ISSUES WITH THIS PARTICULAR VEHICLE.
NHTSA ODI #10876230
132,000 miles · Jun 3, 2016
Service BrakesUnknown Or Other
WE HAVE HAD TO EVERY FEW WEEKS CHANGE EITHER THE ROTORS OR THE HUB. EVER SINCE WE GOT THE CAR IN JANUARY ITS BEEN WITH THE ABS LIGHTS ON CONSTINTLY AND SQUELLING COMING FROM THE RIGHT PASSENGER SIDE ONLY. IT EVEN WILL AT TIMES SHAKE LIKE ITS NOT GOING TO BRAKE AT ALL.
NHTSA ODI #10872336
Mileage unknown · May 20, 2016
Electrical SystemService BrakesUnknown Or Other
I' GOT THIS CAR AND THE REPAIRS NEVER STOPPED COMING. I'VE REPLACED THE BRAKES & ROTORS 4 TIMES IN 3 YEARS. I HAD TO PAY TO HAVE THE CAR RE-WIRED DUE TO ELECTRICAL PROBLEMS & ADD A STARTER, REPLACED HOSES. SHOCKS AND BALL JOINTS. THIS HAS TO BE THE WORST VEHICLE EVER.
NHTSA ODI #10869972
Official recalls
8May 6, 2016
Chrysler (FCA US LLC) is recalling certain model year 2009-2016 Dodge Journey vehicles manufactured July 31, 2007, to November 12, 2016. After exposure to cold temperatures, the power steering return hose may rupture at engine start-up causing a loss of power steering assist.
Consequence & remedy
Consequence: A loss of power steering assist may require extra steering effort, especially at lower speeds, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the power steering return hoses, steel tubes, and power steering oil cooler, free of charge. The recall began on May 24, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S08.
Jan 29, 2016
FCA US LLC (Chrysler) is recalling certain model year 2009 Dodge Journey vehicles manufactured December 31, 2007, to August 31, 2008, 2008-2009 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured June 18, 2007, to August 31, 2008. In the affected vehicles, the air bag control units may corrode and fail.
Consequence & remedy
Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began on December 6, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S07.
Jun 26, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Dec 24, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2009 DODGE JOURNEY VEHICLES MANUFACTURER FROM NOVEMBER 1, 2007, THROUGH NOVEMBER 7, 2008. THE WIRES WITHIN THE FRONT DOOR WIRE HARNESSES MAY FATIGUE AND BREAK, WHICH CAN INTERRUPT THE CIRCUITS FOR THE SIDE IMPACT SENSOR(S), RESULTING IN AN AIRBAG WARNING LAMP ILLUMINATION AND LOSS OF SIDE CRASH SENSING CAPABILITY.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SIDE AIRBAG MAY NOT DEPLOY, REDUCING THE PROTECTION INTENDED FOR THE OCCUPANT AND INCREASING THE RISK OF INJURIES.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE LEFT AND RIGHT DOOR WIRING HARNESSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Apr 9, 2009
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (3)
Air Bags:frontal
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Electrical System:wiring
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Mar 12, 2009
CHRYSLER IS RECALLING 16,852 MY 2009 DODGE JOURNEY VEHICLES EQUIPPED WITHOUT OPTIONAL 115 VOLT AUXILIARY POWER OUTLET. AN UNUSED ELECTRICAL CONNECTOR FOR THE OPTIONAL 115 VOLT AUXILIARY POWER OUTLET OPTION MAY BECOME CORRODED AND COULD SHORT CIRCUIT.
Consequence & remedy
Consequence: IF THE FUSE FOR THIS CIRCUIT DOES NOT BLOW, THE CONNECTOR COULD OVERHEAT AND POTENTIALLY CATCH FIRE.
Remedy: DEALERS WILL RE-ROUTE AND STOW THE 115 VOLT AUXILIARY POWER OUTLET CONNECTOR AND PULL THE 25 AMP FUSE TO REMOVE POWER FROM THIS UNUSED CIRCUIT FREE OF CHARGE. THE RECALL BEGAN ON MARCH 30, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Oct 9, 2008
CHRYSLER IS RECALLING 712 MY 2009 SEBRING, DODGE CALIBER, AVENGER, JOURNEY, JEEP PATRIOT, AND COMPASS VEHICLES. A NEW ADHESIVE USED IN THE POWER TRAIN CONTROL MODULE (PCM) MANUFACTURING PROCESS CAN CAUSE THE PRINTED CIRCUIT BOARD TO BREAK.
Consequence & remedy
Consequence: THIS CAN CAUSE THE ENGINE TO STALL AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE PCM FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 10, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Jun 3, 2008
CHRYSLER IS RECALLING 6,692 MY 2009 DODGE JOURNEY VEHICLES EQUIPPED WITH A 3.5L ENGINE. THE ENGINE WIRING HARNESS MAY CONTACT THE LEFT TRANSAXLE MOUNT.
Consequence & remedy
Consequence: DAMAGE TO THE WIRING HARNESS COULD RESULT IN AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL INSPECT THE ENGINE WIRING HARNESS FOR DAMAGE. IF THE HARNESS IS DAMAGED, THE WIRING WILL BE REPAIRED AND A TIE WRAP INSTALLED TO SECURE THE HARNESS AWAY FROM THE LEFT TRANSAXLE MOUNT. IF NO DAMAGE IS FOUND, A TIE WRAP WILL BE INSTALLED TO SECURE THE HARNESS AWAY FROM THE LEFT TRANSAXLE MOUNT. THE RECALL BEGAN ON JULY 7, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA24003 · Vehicle Entrapment
Opened Aug 1, 2024 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages
The Office of Defects Investigation (ODI) opened PE23-008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During the investigation, ODI collected information from the manufacturer and involved parties to confirm or refute the defect allegation. ODI has determined that additional reports of vehicle entrapment exist for other model year Dodge Journey vehicles. ODI continues to explore the cause of the thermal event and its potential effect on the actuation of the door locks. ODI also continues to explore other potential causes for door lock malfunction. ODI has determined that an upgrade to an Engineering Analysis (EA) is necessary to continue the review of the investigative material and to assess the risk to motor vehicle safety . To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23008 · Vehicle Entrapment
Opened May 1, 2023 · Closed Aug 15, 2024
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Latches/locks/linkages:doors:lock; Latches/locks/linkages:electronic Lock/latch Actuator
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Latches/locks/linkages:doors:lock
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Latches/locks/linkages:electronic Lock/latch Actuator
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Illustration