NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
149 reportsClear category filter120,000 miles · Jul 6, 2021
Electrical SystemEngine
The contact owns a 2009 Dodge Journey. The contact stated while his wife was driving at an undisclosed speed, the vehicle loss motive power and stalled. The driver restarted the vehicle and continued to drive; however, the failure recurred. The driver was unable to restart the vehicle. The contact had the vehicle towed back to t…
Read full complaint
The contact owns a 2009 Dodge Journey. The contact stated while his wife was driving at an undisclosed speed, the vehicle loss motive power and stalled. The driver restarted the vehicle and continued to drive; however, the failure recurred. The driver was unable to restart the vehicle. The contact had the vehicle towed back to the residence. An independent mechanic went to the residence to inspect the vehicle. The mechanic replaced the starter and installed a new battery however, the failure recurred. The mechanic was unable to determine the cause of the failure. The contact was concerned that the failure was related to the ignition switch and the engine. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 120,000.
NHTSA ODI #11423610
Mileage unknown · May 28, 2021
Electrical SystemEngine
Something in the engine is causes the alternator to die. I’ve gotten it changed 3 times within a year. The car has been having multiple issues since I purchased it. The file is to lengthy to upload
NHTSA ODI #11418861
19 miles · Mar 13, 2021
Air BagsElectrical SystemEngine
REPORTING COMMON PROBLEMS OF 2009 DODGE JOURNEY 2.0CRD 103KW 1.A CAR STARTED SHUTTING OFF WHENEVER IT DRIVES, RUNNING IN PARKING LOT, STOPPED AT RED LIGHT. 2.BATTERY FAILS SUDDENLY, WITHOUT ANY WARNING, JUMPING CABLES CAN'T HELP, BECAUSE A CAR JUST MAKING A CRANKING NOISE UNDER A HOOD. 3. WHEEL AIRBAG IS HAVING SHORT CIRCUIT…
Read full complaint
REPORTING COMMON PROBLEMS OF 2009 DODGE JOURNEY 2.0CRD 103KW 1.A CAR STARTED SHUTTING OFF WHENEVER IT DRIVES, RUNNING IN PARKING LOT, STOPPED AT RED LIGHT. 2.BATTERY FAILS SUDDENLY, WITHOUT ANY WARNING, JUMPING CABLES CAN'T HELP, BECAUSE A CAR JUST MAKING A CRANKING NOISE UNDER A HOOD. 3. WHEEL AIRBAG IS HAVING SHORT CIRCUITS, SO DUE TO IT SOMETIMES LIGHTS A WARNING IN DASHBOARD. 4. STEERING WHEEL RELAY SHOWS MISUNDERSTOOD DEGREES OF WHEEL ANGLE, SO IT COMES TO ESP BAS ERROR.
NHTSA ODI #11402721
130,000 miles · Sep 30, 2020
EngineService Brakes
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE AIR BAG, CHECK ENGINE, AND THE EPS TRACTION WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT INITIALLY TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO REPLACED THE BRAKE MODULE CONTROL SENSOR HOWEVER, THE FAILUR…
Read full complaint
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE AIR BAG, CHECK ENGINE, AND THE EPS TRACTION WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT INITIALLY TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO REPLACED THE BRAKE MODULE CONTROL SENSOR HOWEVER, THE FAILURE PERSISTED. THE MECHANIC REFERRED THE CONTACT TO AN AUTHORIZED DEALER FOR ASSISTANCE. THE CONTACT THEN TOOK THE VEHICLE TO LITHIA CHRYSLER DODGE JEEP RAM FIAT OF SANTA FE (7401 CERRILLOS RD, SANTA FE, NM 87507) WHERE THE DIAGNOSIS CONFIRMED THAT THE BRAKE MODULE CONTROL SENSOR WAS DEFECTIVE. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE PERSISTED. THE CONTACT BROUGHT THE VEHICLE BACK TO THE DEALER FOR A SECOND DIAGNOSTIC TEST TO BE PERFORMED. THE RESULTS WERE STILL PENDING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.
NHTSA ODI #11361992
170,000 miles · Aug 31, 2020
Electrical SystemEngine
CAR WON'T START , WHEN TRYING TO START , EVERYTHING WORKS(LIGHTS RADIO) EXCEPT THE ENGINE WON'T CRANK. IT HAS HAPPENED NUMEROUS TIMES. SOMETIMES I GET STALLED IN THE HIGHWAY, WHICH IS REALLY DANGEROUS.
NHTSA ODI #11352402
203,573 miles · Mar 3, 2020
EngineFuel/propulsion SystemFire
WHILE DRIVING THE ENGINE CAUGHT FIRE. DEALER SAYS IT IS NOT COVERED UNDER RECALL. EVEN THOUGH I SEE OTHER DODGE JOURNEY RECALLS OF SAME FIRE BEING RECALLED.
NHTSA ODI #11315783
61,226 miles · Feb 13, 2020
Engine
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. WHILE DRIVING THE ENTIRE BOARD FLASHED AND THEN VEHICLE ENGINE SEIZED AND THE VEHICLE STOPPED. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE ROD AND THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE HAD BEEN SERVICED EARLIER BY THE DEALER OURISMAN CHRYSLER DODGE JEEP RAM OF BOWI…
Read full complaint
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. WHILE DRIVING THE ENTIRE BOARD FLASHED AND THEN VEHICLE ENGINE SEIZED AND THE VEHICLE STOPPED. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE ROD AND THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE HAD BEEN SERVICED EARLIER BY THE DEALER OURISMAN CHRYSLER DODGE JEEP RAM OF BOWIE 2406 CRAIN HWY, BOWIE, MD 20716 (855) 822-3228. THE CONTACT SUSPECTED THE DEALER DID SUBPAR WORK THAT CAUSED THE ENGINE TO SHUT DOWN AND NEEDED REPLACEMENT THE CONTACT DID NOT GET HER VEHICLE BACK UNTIL THE END OF NOVEMBER 2019, THE VEHICLE ISSUE OF STOPPING OCCURRED IN 12/2019. THE MANUFACTURER GAVE THE CONTACT A CASE NUMBER BUT HAD NOT CALLED BACK WITH AN UPDATE. THE CONTACT WAS REFERRED TO THE FTC AND HER STATE'S ATTORNEY GENERAL'S OFFICE THE FAILURE MILEAGE WAS 61,226.
NHTSA ODI #11308989
Mileage unknown · Jan 8, 2020
Air BagsElectrical SystemEngine
THERE WAS A RECALL ON THE AIRBAGS & AIRBAG MODULE.. THEY SUPPOSEDLY REPLACED.. THE ELECTRICAL WIRE IS NOW MESSED UP BC THE AIRBAG LIGHT KEEPS COMING ON & OFF, THE DRIVERS SIDE FRONT DOOR CONTROL LOCK TO LOCK THE CAR WILL NOT WORK, NOW ENGINE LIGHT COMES ON & OFF AND THE TRANSMISSION WAS REPLACED, ALL NEW COMPONENTS, DRIVING TH…
Read full complaint
THERE WAS A RECALL ON THE AIRBAGS & AIRBAG MODULE.. THEY SUPPOSEDLY REPLACED.. THE ELECTRICAL WIRE IS NOW MESSED UP BC THE AIRBAG LIGHT KEEPS COMING ON & OFF, THE DRIVERS SIDE FRONT DOOR CONTROL LOCK TO LOCK THE CAR WILL NOT WORK, NOW ENGINE LIGHT COMES ON & OFF AND THE TRANSMISSION WAS REPLACED, ALL NEW COMPONENTS, DRIVING THE CAR ON JAN 4TH 2020 & THE ENGINE JUST STOPS ON ME AT TRAFFIC LIGHT.. THIS CAR HAS HAD NOTHING BUT PROBLEMS AFTER PROBLEMS FROM THE 1ST DAY I BOUGHT IT FROM THE SALES AGENT THAT LIED TO ME ABOUT EVERYTHING.. THERE ARE RECALLS ON MY CAR THAT STILL NEVER GOT REPLACED.. I AM THE NEW OWNER OF THIS 2009 DODGE JOURNEY SXT ON (2/16/2018).. I WAS TOLD I'M THE 2ND OWNER, I AM THE 4TH OWNER AND WAS LIED ABOUT IF THIS CAR WAS IN A ACCIDENT.. IT WAS IN A ACCIDENT TO DO WITH THE TRANSMISSION STOPPING AND THE PPL THAT HAD THIS CAR B4 ME THE REPORT SAYS IT WAS SIDE SWIPED PASSENGER SIDE ON (10/18/2017).. FOUND OUT MORE ABOUT THE CAR I BOUGHT WAS IN A MAJOR FLOOD SO SOMEONE DIDN'T TELL THE TRUTH & I WAS SOLD A CAR THAT HAS WATER DAMAGE & THEY COVERED IT UP AND I BEEN COMPLAINING SINCE I BOUGHT THIS CAR... SOMETHING ISN'T RIGHT WITH THIS CAR & I GOT RIPPED OFF, THIS CAR THE TRANSMISSION STOPPED ON ME AND I ALMOST GOT IN A BAD CAR ACCIDENT.. I'VE HAD A MECHANIC AT A DODGE DEALERSHIP TELL ME & MY DAD I WAS SOLD A CAR THAT HAS WATER DAMAGE ETC... I AM HAVING PROBLEMS WITH THE AIRBAG LIGHT ON & OFF AND THIS WAS A RECALL AND SHOULD BE REDONE, THE ENGINE LIGHT IS FAULTY AND THE STEERING WHEEL AND ELECTRICAL STILL, ALONG WITH THE FOB IGNITION SWITCH..
NHTSA ODI #11297834
Mileage unknown · Oct 4, 2019
Electrical SystemEngine
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. WHILE DRIVING, THE INSTRUMENT PANEL LIGHTING ILLUMINATED AND THE VEHICLE STOPPED IN THE MIDDLE OF THE ROAD. THE FAILURE ALMOST CAUSED A CRASH. THE VEHICLE WAS TAKEN TO MULTIPLE INDEPENDENT MECHANICS AND DEALERS. THE CONTACT RESEARCHED AND FOUND OTHER VEHICLE'S EXPERIENCING THE SAME FAIL…
Read full complaint
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. WHILE DRIVING, THE INSTRUMENT PANEL LIGHTING ILLUMINATED AND THE VEHICLE STOPPED IN THE MIDDLE OF THE ROAD. THE FAILURE ALMOST CAUSED A CRASH. THE VEHICLE WAS TAKEN TO MULTIPLE INDEPENDENT MECHANICS AND DEALERS. THE CONTACT RESEARCHED AND FOUND OTHER VEHICLE'S EXPERIENCING THE SAME FAILURE. THE VEHICLE WAS TAKEN TO GANLEY CHRYSLER DODGE JEEP RAM (310 BROADWAY AVE, BEDFORD, OH 44146, (440) 232-2121) WHERE IT WAS DETERMINED THAT THE ELECTRICAL AND COMPUTER SYSTEMS FAILED. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC FOR A SECOND OPINION, BUT THEY DID NOT HAVE THE EQUIPMENT TO CLEARLY DIAGNOSE THE VEHICLE. THE MANUFACTURER STATED THAT THEY WOULD DOCUMENT THE CONTACT'S FILE; HOWEVER, THE VEHICLE WAS NO LONGER UNDER WARRANTY AND THERE WERE NO CURRENT RECALLS. THE CONTACT STATED THAT THE FAILURES OCCURRED EVER SINCE THE VEHICLE WAS PURCHASED IN 2015. THE CONTACT WAS INFORMED TO CALL NHTSA. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #11266058
135,000 miles · Sep 27, 2019
EnginePower Train
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SHOOK AND JERKED BEFORE SHUTTING OFF. AFTER RESTARTING THE ENGINE, THE VEHICLE OPERATED NORMALLY. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE…
Read full complaint
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SHOOK AND JERKED BEFORE SHUTTING OFF. AFTER RESTARTING THE ENGINE, THE VEHICLE OPERATED NORMALLY. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 135,000.
NHTSA ODI #11258601
Official recalls
8May 6, 2016
Chrysler (FCA US LLC) is recalling certain model year 2009-2016 Dodge Journey vehicles manufactured July 31, 2007, to November 12, 2016. After exposure to cold temperatures, the power steering return hose may rupture at engine start-up causing a loss of power steering assist.
Consequence & remedy
Consequence: A loss of power steering assist may require extra steering effort, especially at lower speeds, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the power steering return hoses, steel tubes, and power steering oil cooler, free of charge. The recall began on May 24, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S08.
Jan 29, 2016
FCA US LLC (Chrysler) is recalling certain model year 2009 Dodge Journey vehicles manufactured December 31, 2007, to August 31, 2008, 2008-2009 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured June 18, 2007, to August 31, 2008. In the affected vehicles, the air bag control units may corrode and fail.
Consequence & remedy
Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began on December 6, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S07.
Jun 26, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Dec 24, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2009 DODGE JOURNEY VEHICLES MANUFACTURER FROM NOVEMBER 1, 2007, THROUGH NOVEMBER 7, 2008. THE WIRES WITHIN THE FRONT DOOR WIRE HARNESSES MAY FATIGUE AND BREAK, WHICH CAN INTERRUPT THE CIRCUITS FOR THE SIDE IMPACT SENSOR(S), RESULTING IN AN AIRBAG WARNING LAMP ILLUMINATION AND LOSS OF SIDE CRASH SENSING CAPABILITY.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SIDE AIRBAG MAY NOT DEPLOY, REDUCING THE PROTECTION INTENDED FOR THE OCCUPANT AND INCREASING THE RISK OF INJURIES.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE LEFT AND RIGHT DOOR WIRING HARNESSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Apr 9, 2009
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (3)
Air Bags:frontal
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Electrical System:wiring
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Mar 12, 2009
CHRYSLER IS RECALLING 16,852 MY 2009 DODGE JOURNEY VEHICLES EQUIPPED WITHOUT OPTIONAL 115 VOLT AUXILIARY POWER OUTLET. AN UNUSED ELECTRICAL CONNECTOR FOR THE OPTIONAL 115 VOLT AUXILIARY POWER OUTLET OPTION MAY BECOME CORRODED AND COULD SHORT CIRCUIT.
Consequence & remedy
Consequence: IF THE FUSE FOR THIS CIRCUIT DOES NOT BLOW, THE CONNECTOR COULD OVERHEAT AND POTENTIALLY CATCH FIRE.
Remedy: DEALERS WILL RE-ROUTE AND STOW THE 115 VOLT AUXILIARY POWER OUTLET CONNECTOR AND PULL THE 25 AMP FUSE TO REMOVE POWER FROM THIS UNUSED CIRCUIT FREE OF CHARGE. THE RECALL BEGAN ON MARCH 30, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Oct 9, 2008
CHRYSLER IS RECALLING 712 MY 2009 SEBRING, DODGE CALIBER, AVENGER, JOURNEY, JEEP PATRIOT, AND COMPASS VEHICLES. A NEW ADHESIVE USED IN THE POWER TRAIN CONTROL MODULE (PCM) MANUFACTURING PROCESS CAN CAUSE THE PRINTED CIRCUIT BOARD TO BREAK.
Consequence & remedy
Consequence: THIS CAN CAUSE THE ENGINE TO STALL AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE PCM FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 10, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Jun 3, 2008
CHRYSLER IS RECALLING 6,692 MY 2009 DODGE JOURNEY VEHICLES EQUIPPED WITH A 3.5L ENGINE. THE ENGINE WIRING HARNESS MAY CONTACT THE LEFT TRANSAXLE MOUNT.
Consequence & remedy
Consequence: DAMAGE TO THE WIRING HARNESS COULD RESULT IN AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL INSPECT THE ENGINE WIRING HARNESS FOR DAMAGE. IF THE HARNESS IS DAMAGED, THE WIRING WILL BE REPAIRED AND A TIE WRAP INSTALLED TO SECURE THE HARNESS AWAY FROM THE LEFT TRANSAXLE MOUNT. IF NO DAMAGE IS FOUND, A TIE WRAP WILL BE INSTALLED TO SECURE THE HARNESS AWAY FROM THE LEFT TRANSAXLE MOUNT. THE RECALL BEGAN ON JULY 7, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA24003 · Vehicle Entrapment
Opened Aug 1, 2024 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages
The Office of Defects Investigation (ODI) opened PE23-008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During the investigation, ODI collected information from the manufacturer and involved parties to confirm or refute the defect allegation. ODI has determined that additional reports of vehicle entrapment exist for other model year Dodge Journey vehicles. ODI continues to explore the cause of the thermal event and its potential effect on the actuation of the door locks. ODI also continues to explore other potential causes for door lock malfunction. ODI has determined that an upgrade to an Engineering Analysis (EA) is necessary to continue the review of the investigative material and to assess the risk to motor vehicle safety . To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23008 · Vehicle Entrapment
Opened May 1, 2023 · Closed Aug 15, 2024
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Latches/locks/linkages:doors:lock; Latches/locks/linkages:electronic Lock/latch Actuator
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Latches/locks/linkages:doors:lock
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Latches/locks/linkages:electronic Lock/latch Actuator
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Illustration