Illustration1995 DODGE INTREPID. CONSUMER WRITES IN REGARDS VEHICLE STALLING WHILE DRIVING. *SMD THE CONSUMER STATED WHEN THE VEHICLE STALLED, THE POWER STEERING FAILED AND IT WAS DIFFICULT TO STEER THE VEHICLE. THE VEHICLE WAS TAKEN TO A REPAIR SHOP, WHERE THE IGNITION SWITCH WAS REPLACED. *JB
1995 Dodge Intrepid
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1995 Dodge Intrepid do not stand out strongly from the model-year median of 377.
About this comparison →How this year compares
Owner complaints by model year
Compare all Intrepid years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 46 of 589 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 142 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 105 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 103 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
48 crash reports27 fire reports30 injury reports
Electrical System complaints
43 reportsI WAS DRIVING DOWN THE ROAD WHEN MY CAR JUST DIED. I DIDN'T GET ANY FLASHING LIGHTS, CHECK ENGINE LIGHT OR ANYTHING. IT WAS AS IS SOMEONE HAD TURNED THE CAR OFF WITH OUT MOVING THE KEY FROM THE ON POSITION. ONCE I COME TO A STOP, I CAN SIT FOR A LITTLE BIT AND THEN THE CAR WILL START BACK UP AS IF NOTHING EVER HAPPENED. I HAVE R…
Read full complaint
I WAS DRIVING DOWN THE ROAD WHEN MY CAR JUST DIED. I DIDN'T GET ANY FLASHING LIGHTS, CHECK ENGINE LIGHT OR ANYTHING. IT WAS AS IS SOMEONE HAD TURNED THE CAR OFF WITH OUT MOVING THE KEY FROM THE ON POSITION. ONCE I COME TO A STOP, I CAN SIT FOR A LITTLE BIT AND THEN THE CAR WILL START BACK UP AS IF NOTHING EVER HAPPENED. I HAVE RECENTLY HAD A FEW ISSUES WITH SOME OTHER THINGS THAT WERE RESOLVED BY REPLACING THE IGNITION SWITCH BUT IT DIDN'T SEEM TO FIX THIS ISSUE. I TOOK THE CAR TO A REPAIR SHOP AND HAD THE DIAGNOSTICS RAN ON IT BUT IT DIDN'T COME BACK WITH ANY CODES. I OFTEN DRIVE WITH MY WIFE AND KIDS IN THE CAR SO NOW I FEAR THAT THIS MAY CAUSE US TO GET IN A WRECK. *TR
I HAVE A 1995 DODGE INTREPID. UNTIL 4 MONTHS AGO, IT NEVER HAD A PROBLEM, ONLY DID ROUTINE MAINTENANCE AND THAT WAS CONSTANTLY DONE. IT HAS A NEW TRANSMISSION AND RADIATOR (UNDER EXTENDED WARRANTY), AND NEW STARTER, ALTERNATOR, AND BATTERY. THE FUEL PUMP WAS REPLACED ABOUT 2-3 YEARS AGO. FOUR MONTHS AGO, THE CAR STARTED TO…
Read full complaint
I HAVE A 1995 DODGE INTREPID. UNTIL 4 MONTHS AGO, IT NEVER HAD A PROBLEM, ONLY DID ROUTINE MAINTENANCE AND THAT WAS CONSTANTLY DONE. IT HAS A NEW TRANSMISSION AND RADIATOR (UNDER EXTENDED WARRANTY), AND NEW STARTER, ALTERNATOR, AND BATTERY. THE FUEL PUMP WAS REPLACED ABOUT 2-3 YEARS AGO. FOUR MONTHS AGO, THE CAR STARTED TO ACT UP. FIRST, I NOTICED A "BURNT OIL OR ANTI-FREEZE" SMELL. I TOOK IT TO MY MECHANIC, WHO I HAVE HAD FOR MORE THAN 15 YEARS. HE COULDN'T FIND ANY LEAKS OR PROBLEMS AND REMINDED ME THAT ALL THE HOSES AND ACCESSORIES WERE REPLACE A YEAR BEFORE. HE SAID THAT HE SAW NOTHING DRIPPING OR BUILDING UP ANYWHERE. A WEEK LATER, I WOULD DRIVE IT SOMEWHERE, GET OUT AND DO WHATEVER IT WAS I NEEDED TO DO, GO BACK AND IT WOULDN'T START. EVERYTHING SOUNDS NORMAL, LIKE IT WANTS TO START, BUT DOESN'T. IF I WAIT 30-90 MINUTES AND TRY AGAIN, IT WILL START RIGHT UP AND A CHECK ENGINE LIGHT WOULD COME ON, BUT GO BACK OFF WITHIN A FEW MINUTES. A MONTH LATER THINGS GOT WORSE. IT STARTED TO DIE WHILE DRIVING. I WOULD BE IN THE CAR FOR LESS THAN 10 MILES AND ALL THE LIGHTS ON THE DASH WOULD "FLASH" AND THE CAR WOULD DIE. IT TAKES BETWEEN 2-3 HOURS BEFORE GETTING IT TO RESTART WHEN THIS HAPPENS. THIS PUTS ME IN SERIOUS DANGER AS THE CAR NO LONGER HAS POWER STEERING OR POWER BRAKES AND I LIVE ON A MOUNTAIN WITH NO WHERE I CAN GET OFF THE ROAD. I HAVE NEARLY BEEN HIT/KILLED WHEN THIS HAS HAPPENED. SINCE THEN, I CAN'T GO 1 MILE WITHOUT IT DYING OR NOT START AGAIN. AS A MATTER-OF-FACT, IF I LEAVE IT IDLING IN MY DRIVEWAY, IT WILL DIE WITH 2-4 MINUTES. I HAVE TAKEN IT TO MY SHOP 4 TIMES AND 2 OTHER ONES TRYING TO FIND OUT WHAT IS WRONG. THEY ALL SAY THAT SINCE THE "CHECK ENGINE" LIGHT ONLY FLASHES AND THEN GOES OFF, THE COMPUTER CAN'T CATCH THE PROBLEM. SOMETIMES THEY THINK IT IS THE FUEL PUMP OR FUEL LINES; SOMETIMES THEY THINK IT IS ELECTRICAL; MOST OF THE TIME THEY JUST HAVE NO IDEA WHAT IS WRONG! *TR
DT: THE CONTACT STATED WHILE DRIVING THE FRONT PASSENGER TIRE FELL OFF THE VEHICLE. HAD THE INNER AND OUTER TIE RODS REPLACED TWICE. DID ONE REPLACEMENT BEFORE THE TIRE FELL OFF. THE SECOND REPLACEMENT WAS DONE AFTER THE TIRE CAME OFF. THE REPLACEMENTS DID NOT REMEDY THE PROBLEM. WHILE DRIVING IT FELT AS THOUGH THE …
Read full complaint
DT: THE CONTACT STATED WHILE DRIVING THE FRONT PASSENGER TIRE FELL OFF THE VEHICLE. HAD THE INNER AND OUTER TIE RODS REPLACED TWICE. DID ONE REPLACEMENT BEFORE THE TIRE FELL OFF. THE SECOND REPLACEMENT WAS DONE AFTER THE TIRE CAME OFF. THE REPLACEMENTS DID NOT REMEDY THE PROBLEM. WHILE DRIVING IT FELT AS THOUGH THE WHEELS WERE FALLING OFF. WHEN HITTING A BUMP WHILE DRIVING THERE WAS A SNAPPING NOISE FROM UNDERNEATH THE VEHICLE. ANOTHER CONCERN WAS THE ELECTRICAL SYSTEM. ONLY ONE HEADLIGHT WILL WORK ON BRIGHT AND ONLY ONE WILL WORK ON DIM. THE CONTACT REPLACED BOTH BULBS IN THE HEADLIGHTS, BUT THIS DID NOT REMEDY THE PROBLEM. HE CHECKED THE FUSES, AND THERE WERE NO PROBLEMS WITH THEM. ALSO, THE HEADLIGHT SWITCH FELL OFF WITHOUT BEING HIT OR KNOCKED OFF. *AK
LOST ALL POWER WHILE ON FREEWAY. SAME THING HAPPEN ON JAN 05. HAD TO REPLACE A COMPUTER CHIP PN R4606240. MECHANIC STATED THIS WAS A PROBLEM OF LOCATION ON CAR (BACK UNDER EXHAUST. MY FAMILY WAS LUCKY THE WE WE ABLE TO MOVE TO SIDE OF ROAD HAVE THERE BEEN ANY OTHER COMPAINTS IN THIS REGARD …
Read full complaint
LOST ALL POWER WHILE ON FREEWAY. SAME THING HAPPEN ON JAN 05. HAD TO REPLACE A COMPUTER CHIP PN R4606240. MECHANIC STATED THIS WAS A PROBLEM OF LOCATION ON CAR (BACK UNDER EXHAUST. MY FAMILY WAS LUCKY THE WE WE ABLE TO MOVE TO SIDE OF ROAD HAVE THERE BEEN ANY OTHER COMPAINTS IN THIS REGARD THANK YOU
SINCE OWNING THE 1995 DODGE INTREPID WE PURCHASED BRAND NEW, THESE ARE THE PROBLEMS EXPERIENCED SINCE OWNING AND THE PROBLEMS BEING EXPERIENCED NOW. WE HAVE HAD STEERING PROBLEMS WHICH REQUIRED THE POWER STEERING PUMP TO BE REPLACED, ALSO SOME ARM HAD TO BE REPLACED DUE TO THE RIGHT FRONT WHEEL WOBBLING. OUR ELECTRIC LOCKS HAV…
Read full complaint
SINCE OWNING THE 1995 DODGE INTREPID WE PURCHASED BRAND NEW, THESE ARE THE PROBLEMS EXPERIENCED SINCE OWNING AND THE PROBLEMS BEING EXPERIENCED NOW. WE HAVE HAD STEERING PROBLEMS WHICH REQUIRED THE POWER STEERING PUMP TO BE REPLACED, ALSO SOME ARM HAD TO BE REPLACED DUE TO THE RIGHT FRONT WHEEL WOBBLING. OUR ELECTRIC LOCKS HAVE ENGAGED AS IF HOLDING THE SWITCH FOR A COUPLE OF SECONDS ON THE PASSENGER SIDE AND THE DRIVER SIDE. NEVER WAS FIXED DUE TO DEALER NOT DUPLICATING. OUR AC/HEAT ELECTRONIC CONTROLS STUCK AND WOULD NOT RESPOND TO ANY COMMANDS AND CONSTANTLY WAS BLOWING HOT AIR, PULLING FUSE WAS ONLY REMEDY. ELECTRONIC GAUGES WILL NOT ALWAYS SHOW CORRECT INFORMATION IE. FUEL LEVEL, TEMP, FUEL USED, COMPASS, ..ETC, TURNING CAR ON/OFF WILL USUALLY CORRECT IT. OUR FUEL RAILS HAS BEEN REPLACED UNDER WARRANTY RECALL, BUT I STILL WILL SMELL FUEL INSIDE. OUR PASSENGER SIDE AIR BAG IS WARPED. OUR HEADLIGHTS WILL NOT COME ON AT TIMES AND EVEN GO OUT WHILE DRIVING. FLASHING HIGH/LOW BEAM STEERING COLUMN SWITCH WILL USUALLY MAKE THEM COME ON. OUR MOST RECENT PROBLEM AND THE STATE OUR VEHICLE IS IN RIGHT NOW IS SMOKE IS COMING FROM THE STEERING COLUMN AND IT IS VERY HOT AND I BELIEVE A FIRE IS TRYING TO START. THE CAR IS PARKED AT THE LOCATION THIS STARTED AT AND IS NOT BEING DRIVEN. *JB
THE CONSUMER RECEIVED A RECALL LETTER INDICATING THAT THE TRANS AXLE FLOOR SHIFTER WAS DEFECTIVE. THE CONSUMER DROVE THE VEHICLE TO WORK IN THE MORNING. THE CONSUMER HAD GOTTEN INTO THE VEHICLE IN THE EVENING TO GO HOME FROM WORK AND THE VEHICLE WOULD NOT START. THE VEHICLE MADE A CLICKING NOISE AND ONLY CRANKED. THE CONSUME…
Read full complaint
THE CONSUMER RECEIVED A RECALL LETTER INDICATING THAT THE TRANS AXLE FLOOR SHIFTER WAS DEFECTIVE. THE CONSUMER DROVE THE VEHICLE TO WORK IN THE MORNING. THE CONSUMER HAD GOTTEN INTO THE VEHICLE IN THE EVENING TO GO HOME FROM WORK AND THE VEHICLE WOULD NOT START. THE VEHICLE MADE A CLICKING NOISE AND ONLY CRANKED. THE CONSUMER HAD NO WAY TO GET OUT OF THE VEHICLE TO A DEALER TO HAVE RECALL REPAIRS DONE. THE CONSUMER WILL HAVE A MECHANIC LOOK AT THE VEHICLE LATER. *AK *SC
ELECTRICAL SYSTEM PROBLEM WHEREIN AT STARTUP VEHICLE EITHER ONLY CLICKS OR STARTS WITH NO GAUGES WORKING FOR SEVERAL MINUTES. WHEN THIS OCCURS THE VEHICLE WILL NOT ACCELERATE TO MORE THAN 30 MPH. DEALER STATES THAT STARTER NEEDS REPLACEMENT, BUT VEHICLE HAS BEEN INTERMITTENT WITH THIS PROBLEM FOR LONGER THAN A STARTER ON THE B…
Read full complaint
ELECTRICAL SYSTEM PROBLEM WHEREIN AT STARTUP VEHICLE EITHER ONLY CLICKS OR STARTS WITH NO GAUGES WORKING FOR SEVERAL MINUTES. WHEN THIS OCCURS THE VEHICLE WILL NOT ACCELERATE TO MORE THAN 30 MPH. DEALER STATES THAT STARTER NEEDS REPLACEMENT, BUT VEHICLE HAS BEEN INTERMITTENT WITH THIS PROBLEM FOR LONGER THAN A STARTER ON THE BRINK WOULD LAST. APPARENT ELECTRICAL PROBLEM THAT COMPUTER DIAGNOSTIC DOES NOT CONFIRM. ONLY CODE INVOLVES THE AT MODULE NOT PROVIDING SIGNAL. ALL SUCH COMPONENTS ARE CONTROLLED BY THE PCM (POWER CONTROL MODULE). PLEASE INVESTIGATE. *JB
RECASLL 04V021000 CONCERNING FLOOR SHIFT IGNITION PARK INTERLOCK. CONSUMER STATED THAT ONE MONTH PRIOR TO THIS RECALL HAD THIS WORK DONE AT AN AFTERMARKET REPAIR SHOP BECAUSE THE PRICE THAT DEALERSHIP CHARGED WAS TOO EXPENSIVE. CONSUMER SENT THE MANUFACTURER COPIES OF THE RECIEPT, AND WAS DENIED REIMBURSEMENT. *AK *TC
VEHICLE WAS PARKED IN THE DRIVEWAY WHEN THE HORN STARTED GOING OFF. CONSUMER WENT OUTSIDE TO INVESTIGATE THE VEHICLE, AND NOTICED THAT THE DASHBOARD WAS ON FIRE. CONSUMER WAS ABLE TO PUT THE FLAMES OUT WITH A WATER HOSE. *AK
Official recalls
304V021000 · Power Train:automatic Transmission:lever And Linkage:floor Shift
Jan 13, 2004
ON CERTAIN PASSENGER VEHICLES, THE FLOOR SHIFTER IGNITION-PARK INTERLOCK MAY FAIL AND ALLOW THE SHIFTER TO BE MOVED OUT OF THE PARK POSITION WITH THE KEY REMOVED. AN INOPERATIVE INTERLOCK MAY ALSO ALLOW THE KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: EITHER CIRCUMSTANCE MAY RESULT IN THE VEHICLE ROLLING AWAY WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER OF THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN ON JUNE 14, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
99V215000 · Suspension:front:control Arm:lower Arm
Aug 9, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LOWER CONTROL ARM ATTACHING BRACKETS CAN CRACK DUE TO FATIGUE AND SEPARATE FROM THE ENGINE CRADLE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE TRANSMISSION HALF-SHAFT COULD PULL OUT OF THE TRANSAXLE AND RESULT IN LOSS OF POWER.
Remedy: DEALERS WILL REINFORCE THE ENGINE CRADLE AT THE POINT WHERE THE LOWER CONTROL ARM ATTACHES TO IT.
98V184000 · Fuel System, Gasoline:fuel Injection System
Aug 6, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT WITH 3.5L ENGINES. THE FUEL INJECTION DELIVERY SYSTEM CAN LEAK FUEL FROM SOME OF THE SEALING O-RINGS OR FROM HAIR LINE CRACKS IN THE THERMOSET FUEL INJECTION RAIL.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL RAIL O-RINGS AND REINFORCE THE OUTLET (PASSENGER) SIDE FUEL RAIL. VEHICLES SHOWING FUEL LEAKAGE ON THE OUTLET FUEL RAIL MUST HAVE THE OUTLET RAIL REPLACED WHICH INCLUDES CHANGING THE UPPER AND LOWER INJECTOR O-RINGS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS OR FROM A CRACKED FUEL LINE, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9DP04007 · Fuel Rail, Brake Fluid, Chassis
Opened Oct 13, 2004 · Closed Oct 27, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail; Service Brakes, Hydraulic:fluid; Structure:frame And Members
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
Additional source detail variants (3)
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
Service Brakes, Hydraulic:fluid
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
Structure:frame And Members
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
EA99031 · Steering System Rack And Pinion
Opened Oct 29, 1999 · Closed Sep 13, 2001
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE99044 · Steering System Rack And Pinion
Opened Jun 28, 1999 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Steering
SINCE OPENING THE PRELIMINARY EVALUATION (PE), ODI HAS RECEIVED 6 ADDITIONAL COMPLAINTS.DURING THE PE IT WAS DETERMINED MULTIPLE FAILURE MODES ARE INVOLVED IN THIS MATTER.THE WARRANTY CLAIM RATE IS HIGH FOR A STEERING SYSTEM CONCERN.THE ISSUES REPORTED INVOLVE PREMATURE WEAR OUT AT THE RACK AND PINION INTERFACE WITH THE INNER TIE ROD END(S), BINDING AND STICKING OF THE STEERING GEAR, CRACKED OR BROKEN TIE ROD ENDS, SHEARED RACK AND PINION ASSEMBLY BOLTS, AND WEAR OUT OF THE RACK AND PINION MOUNT BUSHINGS.MANY OF THE COMPLAINANTS MENTION STEERING WONDER AND LOOSE STEERING.THREE OF THE MOST RECENT COMPLAINTS ALLEGE A COMPLETE LOSS OF STEERING DUE TO SHEARED BOLTS.ODI IS UPGRADING THIS PE IN ORDER TO PERFORM A THOROUGH TECHNICAL ANALYSIS OF THE VARIOUS SYSTEM FAILURE ALLEGATIONS AND TO QUANTIFY THE EFFECT THAT THESE FAILURES HAVE ON VEHICLE CONTROL.
RQ98018 · Fuel Injection Delivery System Fuel Leak
Opened Oct 7, 1998 · Closed Jul 8, 2002
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System
No summary supplied.
EA98007 · Fuel Injector Assembly Leakage
Opened Mar 10, 1998 · Closed Feb 1, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:fuel Injection System; Fuel System, Gasoline:fuel Injection System:fuel Rail
NITRILE RUBBER SEALS USED IN THE FUEL RAIL ASSEMBLIES OF THE SUBJECT VEHICLES AT THE SUPPLY, RETURN, AND CROSSOVER TUBE FITTINGS, AND AT THE PRESSURE REGULATOR FAIL, RESULTING IN FUEL LEAKAGE IN THE ENGINE COMPARTMENT.ALSO, THE OUTLET (RIGHT) FUEL RAIL MAY LEAK FROM CRACKS AT CERTAIN MOLD GATES IN THE THERMOSET RAIL MATERIAL.CHRYSLER WILL RECALL THE SUBJECT VEHICLES AND STATED THAT IT INTENDS TO REPLACE THE O-RINGS WITH FLUOROCARBON O-RING HAVING GREATER HEAT RESISTANCE CAPABILITY AND ATTACH REINFORCEMENTS TO THE RAIL IN THE AREAS WHERE THE CRACKING CONCERN HAS BEEN KNOWN TO OCCUR MOST FREQUENTLY.RAILS THAT ARE ALREADY CRACKED WILL BE REPLACED BY NEW, REINFORCED RAILS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
NITRILE RUBBER SEALS USED IN THE FUEL RAIL ASSEMBLIES OF THE SUBJECT VEHICLES AT THE SUPPLY, RETURN, AND CROSSOVER TUBE FITTINGS, AND AT THE PRESSURE REGULATOR FAIL, RESULTING IN FUEL LEAKAGE IN THE ENGINE COMPARTMENT.ALSO, THE OUTLET (RIGHT) FUEL RAIL MAY LEAK FROM CRACKS AT CERTAIN MOLD GATES IN THE THERMOSET RAIL MATERIAL.CHRYSLER WILL RECALL THE SUBJECT VEHICLES AND STATED THAT IT INTENDS TO REPLACE THE O-RINGS WITH FLUOROCARBON O-RING HAVING GREATER HEAT RESISTANCE CAPABILITY AND ATTACH REINFORCEMENTS TO THE RAIL IN THE AREAS WHERE THE CRACKING CONCERN HAS BEEN KNOWN TO OCCUR MOST FREQUENTLY.RAILS THAT ARE ALREADY CRACKED WILL BE REPLACED BY NEW, REINFORCED RAILS.
Fuel System, Gasoline:fuel Injection System
NITRILE RUBBER SEALS USED IN THE FUEL RAIL ASSEMBLIES OF THE SUBJECT VEHICLES AT THE SUPPLY, RETURN, AND CROSSOVER TUBE FITTINGS, AND AT THE PRESSURE REGULATOR FAIL, RESULTING IN FUEL LEAKAGE IN THE ENGINE COMPARTMENT.ALSO, THE OUTLET (RIGHT) FUEL RAIL MAY LEAK FROM CRACKS AT CERTAIN MOLD GATES IN THE THERMOSET RAIL MATERIAL.CHRYSLER WILL RECALL THE SUBJECT VEHICLES AND STATED THAT IT INTENDS TO REPLACE THE O-RINGS WITH FLUOROCARBON O-RING HAVING GREATER HEAT RESISTANCE CAPABILITY AND ATTACH REINFORCEMENTS TO THE RAIL IN THE AREAS WHERE THE CRACKING CONCERN HAS BEEN KNOWN TO OCCUR MOST FREQUENTLY.RAILS THAT ARE ALREADY CRACKED WILL BE REPLACED BY NEW, REINFORCED RAILS.
Fuel System, Gasoline:fuel Injection System:fuel Rail
NITRILE RUBBER SEALS USED IN THE FUEL RAIL ASSEMBLIES OF THE SUBJECT VEHICLES AT THE SUPPLY, RETURN, AND CROSSOVER TUBE FITTINGS, AND AT THE PRESSURE REGULATOR FAIL, RESULTING IN FUEL LEAKAGE IN THE ENGINE COMPARTMENT.ALSO, THE OUTLET (RIGHT) FUEL RAIL MAY LEAK FROM CRACKS AT CERTAIN MOLD GATES IN THE THERMOSET RAIL MATERIAL.CHRYSLER WILL RECALL THE SUBJECT VEHICLES AND STATED THAT IT INTENDS TO REPLACE THE O-RINGS WITH FLUOROCARBON O-RING HAVING GREATER HEAT RESISTANCE CAPABILITY AND ATTACH REINFORCEMENTS TO THE RAIL IN THE AREAS WHERE THE CRACKING CONCERN HAS BEEN KNOWN TO OCCUR MOST FREQUENTLY.RAILS THAT ARE ALREADY CRACKED WILL BE REPLACED BY NEW, REINFORCED RAILS.
EA95028 · Underhood Fuel Leaks
Opened Sep 22, 1995 · Closed Feb 24, 1997
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WAARRANTED BY THE CIRCUMSTANCES.AN ENGINEERING ANALYSIS CLOSSING REPORT IS INCLUDED IN THE PUBLIC FILE.
EA95023 · Water In Defroster System
Opened Aug 31, 1995 · Closed Dec 31, 1996
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE THE ENGINEERING ANALYSIS CLOSING REPORT (EA95-023)