2024 Dodge Hornet

Approximately one month after purchasing this vehicle new, I began experiencing a recurring loss-of-propulsion defect. Since XXX, the vehicle has repeatedly lost the ability to accelerate ("limp mode" / "turtle mode") without warning, and later experienced a complete no-start/shutdown failure caused by a PIM/IDCM power electronics failure (repaired ~XXX at approximately 15,650 miles). The vehicle has been in for repair 6 times, totaling approximately 120 days out of service. As of late XXX new (lesser) electrical issues have recurred and have not yet caused a full failure, but I have no confidence they will not recur at highway speed or in an isolated area. I drive an hour each way to work at night through rural, isolated southeast [XXX] with little to no cell service. A sudden loss of propulsion in this environment puts me at serious risk of being stranded in an unsafe location, or of a rear-end collision if the loss of power occurs in traffic. On XXX, the servicing dealership (Mitchell Chrysler Dodge Jeep Ram, Enterprise, AL) told me the vehicle was "operating as expected" and to continue driving it until the problem occurs again — despite the documented recurring defect. I have an active NCDS arbitration claim open with Stellantis regarding this same defect (Case #Dodge XXX), and have requested repurchase/replacement under Alabama's Lemon Law. I am filing this report separately to ensure NHTSA has a record of the safety risk for other Hornet owners. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I went to have an oil change and was told I had a coolant leak. Took to dealership and they told me they don’t see an issue. Two days later the same problem persists. I go under the hood and the coolant container is empty. Coolant was added and there is still an issue. I bring it back for a second time and dealership can not find the problem but clearly there is a problem.

The contact owns a 2024 Dodge Hornet. The contact stated that while the vehicle was parked and refueling, the fuel started to overflow. The vehicle was taken to the dealer; however, the failure was not duplicated. In addition, the contact stated that the instrument cluster displayed a black screen, and the engine seized. Upon the manufacturer's request, the vehicle was taken to another dealer for an emissions test. The contact was informed by the dealer, while performing the emissions test that the contact was informed that the instrument cluster displayed a black screen and the engine had seized. The vehicle was not repaired. The contact was advised to take the vehicle back to the original dealer for further diagnostic testing. In addition, the contact received notification of NHTSA Campaign Number: 25V246000 (Back Over Prevention); however, the contact was informed that the repair appointment needed to be scheduled at the original dealer. The manufacturer was made aware of the failure, and the contact requested that the manufacturer offer a buy-back; however, the manufacturer declined. The failure mileage was approximately 10,000.

Our 2024 Dodge Hornet broke down on [XXX] in Baltimore Maryland on [XXX} 8496 miles on it. It was towed to Ourisman Chrysler Dodge 124 north point Blvd 21224. It needed a new engine. Engine replaced October 2024. The new engine needs replacement parts vehicle still not fixed. Today is 180 days without a loaner or rental car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The car operates as if the start stop function is on when it has been turned off. The car idles erratically it launches when driving. The car pulls back while driving and putters. I have been scared to drive the car due to the way it erratically drives. The check engine light has come on twice. The coolant hose repaired, and now engine needs replacing due to piston, pin scoring cylinder walls, and spark plugs fouled. On both occasions, there was no oil found on inspection on the dipstick. No engine overheat warning, no low oil fuel or need for oil light ever comes on. Only indicator was initially performance how hot the car stayed afterwards the smells and the black soot coming out the back tail pipe before the engine light pops on while driving . I felt I was going to break down while driving. And this was after taking it out of the shop after two weeks. It was out of oil again. I happen to check it because I was scared and sure enough no oil. I have taken it back to the shop and I’ve been told now it needs a new engine. I could not make it to the break-in period of 7500 miles to perform an oil consumption test. But it is obvious the car was defective with a bad engine as can happen what I want now is a new car and a buyback from Dodge.