IllustrationAm smells as if wires are burning and vehicle turns off whilst driving causing me to nearly hit a pole in one instance. Car will shut off also whilst parked or when reversing to park. Emergency Brake light come on at random times during driving as well. Or the seatbelt light will come on whilst seatbelt is engaged.
2018 Dodge Grand Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2018 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
80–25K
3525–50K
3450–75K
1375–100K
7100–150K
2150K+
99 reports with mileage · 171 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 34 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports0 fire reports8 injury reports
Steering complaints
5 reportsMy Transmission failed. My odometer reading is 92901. Dealership said not manufactured coverage. No message on dash. Happened while driving with children. Mechanic said needed to be replaced. This is a expensive repair. I believe manufacture should have told drivers about problems with transmission.
9:45 PM I HAD JUST TAKEN THE EXIT FOR 781 OFF OFF I-81 IN JEFFERSON COUNTY, NY TO HEAD TO FORT DRUM. I WAS IN THE RIGHT HAND LANE. I SET THE CRUISE CONTROL TO 62, THE SPEED LIMIT IS 65. IT WAS ABOUT A MILE OR SO DOWN FROM THE ON RAMP WHEN THE VAN SHUT OFF BY ITSELF AT 62MPH. THERE WAS NO ELECTRICAL OR LIGHTS, NOT EVEN THE HEA…
Read full complaint
9:45 PM I HAD JUST TAKEN THE EXIT FOR 781 OFF OFF I-81 IN JEFFERSON COUNTY, NY TO HEAD TO FORT DRUM. I WAS IN THE RIGHT HAND LANE. I SET THE CRUISE CONTROL TO 62, THE SPEED LIMIT IS 65. IT WAS ABOUT A MILE OR SO DOWN FROM THE ON RAMP WHEN THE VAN SHUT OFF BY ITSELF AT 62MPH. THERE WAS NO ELECTRICAL OR LIGHTS, NOT EVEN THE HEADLIGHTS WORKED. THE STEERING WHEEL LOCKED, THE BRAKE PEDAL LOCKED AND WOULD NOT WORK. I HAD NO CONTROL. THERE IS NO ROAD LIGHTING IN THAT AREA AND NO OTHER CARS WERE AROUND SO I COULD NOT SEE THE ROAD OR ANYTHING AROUND ME. MY FIRST INSTINCT WAS THAT I NEEDED TO TRY TO GET OUT OF THE MIDDLE OF THE HIGHWAY BECAUSE NO OTHER CARS COULD SEE ME BUT THE VEHICLE WAS STILL MOVING. I TRIED THE HAZARD LIGHTS AND THEY WORKED SO I TRIED AS HARD AS I COULD TO PULL THE WHEEL TO THE RIGHT TO GET TO THE SHOULDER. I ENDED UP HITTING A GUARD RAIL AND THAT'S WHAT ULTIMATELY STOPPED THE VEHICLE. I WAS ABLE TO PUT IT IN PARK, AND THEN I CALLED 911. I TRIED TO RESTART THE VEHICLE AND IT WORKED FINE. IT TOOK ABOUT 15 MINUTES FOR THE POLICE OFFICER TO ARRIVE. SHE ASKED WHAT HAPPENED, LOOKED AT THE GUARD RAIL AND THE VEHICLE. I GAVE HER MY LICENSE, INSURANCE AND REGISTRATION AND SHE DID THE PAPERWORK. I LEFT THE SCENE IN THE VEHICLE AT 10:35PM. THERE IS DAMAGE TO THE RIGHT SIDE BUMPER AND WHEEL WELL AS WELL AS DAMAGE TO THE HUB CAP. THIS WAS TERRIFYING TO EXPERIENCE. I AM VERY, VERY LUCKY THAT I WAS ALONE ON A STRAIGHT, ONE WAY PIECE OF HIGHWAY. TOTAL LOSS OF CONTROL OF THE VEHICLE AT A HIGH RATE OF SPEED COULD HAVE RESULTED IN A CATASTROPHIC ACCIDENT HAD THE CIRCUMSTANCES BEEN DIFFERENT. I COULD HAVE GONE INTO ONCOMING TRAFFIC, I COULD HAVE BEEN REARENDED, MY CHILDREN COULD HAVE BEEN INJURED. THERE IS AN OPEN RECALL FOR THIS MODEL YEAR GRAND CARAVAN AND THE POWERTRAIN CONTROL MODULE, BUT IF I INPUT MY VIN IT SAYS THERE'S NO RECALLS FOR THAT VIN.
THE FIRST TIME THIS HAPPENED I WAS (JUNE 22, 2020) ON MY WAY HOME FROM THE DEALERSHIP WHERE I HAD JUST PURCHASED THE VEHICLE. I PURCHASED IT FROM OUT OF STATE SO IT WAS ABOUT A 400 MILE DRIVE HOME. I WAS COMING TO A STOP LIGHT AND THE BRAKES STIFFENED AND DIDN'T WORK. ALSO THE POWER STEERING WAS GONE. LUCKILY, I WAS ABLE TO PULL…
Read full complaint
THE FIRST TIME THIS HAPPENED I WAS (JUNE 22, 2020) ON MY WAY HOME FROM THE DEALERSHIP WHERE I HAD JUST PURCHASED THE VEHICLE. I PURCHASED IT FROM OUT OF STATE SO IT WAS ABOUT A 400 MILE DRIVE HOME. I WAS COMING TO A STOP LIGHT AND THE BRAKES STIFFENED AND DIDN'T WORK. ALSO THE POWER STEERING WAS GONE. LUCKILY, I WAS ABLE TO PULL OVER AND TURN THE CAR OFF AND THEN TURN IT BACK ON AGAIN. A BRAKE LIGHT WAS FLASHING ON THE DASH SO, I PRESSED THE PARKING BRAKE RELEASE TWICE AND RESTARTED IT AGAIN. AFTER I DID THIS THE CAR SEEMED FINE. I DROVE HOME VERY CAREFULLY AND CALLED THE DEALER. THEY SAID TO TAKE IT TO THE CLOSEST DEALER TO MY HOUSE. I DID THE NEXT DAY (JUNE 23, 2020). THE ONLY PROBLEM CODE THEY FOUND WAS IN THE BRAKES SO THEY REPLACED THOSE PARTS. I WENT HOME THINKING THAT ALL WAS FIXED. I DROVE THE VEHICLE ANOTHER 500+ MILES IN THE NEXT WEEK WITHOUT ANY PROBLEMS. THEN ON JULY 4TH IT HAPPENED AGAIN, NO BRAKES OR POWER STEERING. I WAS LUCKY AGAIN IN THAT I COULD PULL OVER AND RESTART THE CAR. I TOOK IT IN TO THE DEALER WHEN THEY OPENED ON JULY 6TH. THEY FOUND NO PROBLEM CODE AND SAID UNTIL THEY HAD IT HAPPEN WHILE THEY WERE DRIVING IT, THERE WAS NOTHING THEY COULD DO. THE FIRST TIME THIS HAPPENED I WAS DRIVING DOWNHILL SLOWING DOWN TO A STOPLIGHT. THE SECOND TIME I WAS DRIVING DOWNHILL AND SLOWING FOR TRAFFIC WHEN I NOTICED IT. I WAS LUCKY THAT I WAS NOT ON FAST HIGHWAYS WHEN THIS HAPPENED.
THE TIE ROD ON THE RIGHT, PASSENGER SIDE, TIRE OF THIS VEHICLE BROKE WHILE DRIVING. THIS WAS A RENTAL CAR.
Official recalls
425V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:
Dec 17, 2025
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.
20V278000 · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:storage:tank Assembly
May 15, 2020
Vantage Mobility International, LLC (Vantage) is recalling certain Vantage-modified 2016-2019 Dodge Grand Caravan vehicles. The fuel pump gasket may deteriorate, allowing fuel to leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Vantage will notify owners, and will provide parts and reimbursement to owners for repair facilities to replace the fuel tank gasket, free of charge. The recall began May 19, 2020. Owners may contact Vantage customer service at 1-800-488-9082.
Additional source detail variants (2)
Fuel System, Gasoline:delivery:fuel Pump
Vantage Mobility International, LLC (Vantage) is recalling certain Vantage-modified 2016-2019 Dodge Grand Caravan vehicles. The fuel pump gasket may deteriorate, allowing fuel to leak.
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Vantage will notify owners, and will provide parts and reimbursement to owners for repair facilities to replace the fuel tank gasket, free of charge. The recall began May 19, 2020. Owners may contact Vantage customer service at 1-800-488-9082.
Fuel System, Gasoline:storage:tank Assembly
Vantage Mobility International, LLC (Vantage) is recalling certain Vantage-modified 2016-2019 Dodge Grand Caravan vehicles. The fuel pump gasket may deteriorate, allowing fuel to leak.
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Vantage will notify owners, and will provide parts and reimbursement to owners for repair facilities to replace the fuel tank gasket, free of charge. The recall began May 19, 2020. Owners may contact Vantage customer service at 1-800-488-9082.
18V523000 · Service Brakes, Hydraulic:foundation Components:disc:caliper
Aug 9, 2018
Chrysler (FCA US LLC) is recalling certain 2018-2019 Dodge Grand Caravan and Jeep Compass, 2018 Dodge Journey, and 2019 Jeep Cherokee vehicles. The rear brake caliper pistons on these vehicles may have an insufficient coating causing gas pockets to form, potentially reducing rear brake performance.
Consequence & remedy
Consequence: A reduction of braking performance can increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will bleed the vehicle's brake system, free of charge. The recall began September 29, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U86.
18V524000 · Electrical System:wiring:front Underhood
Aug 9, 2018
Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.
Consequence & remedy
Consequence: A vehicle stall can increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.