IllustrationVEHICLE WIPERS, WIPER FLUID, AND HORN OPERATE SEPARATELY AND INDEPENDENTLY FROM HUMAN OPERATOR INPUT WITH NO RESPONSE TO OPERATORS ATTEMPTS TO DISENGAGE THEIR OPERATIONS. INCIDENTS HAPPEN INTERMITTENTLY AT REST OR IN MOTION, SITUATIONS ARE NOT ABLE TO BE ANTICIPATED.
2008 Dodge Grand Caravan
Owner reports · Recalls · Investigations
More warning signs than most Grand Caravan years
Owner complaints for the 2008 Dodge Grand Caravan are substantially higher than the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1360–25K
13425–50K
15650–75K
17675–100K
172100–150K
54150K+
828 reports with mileage · 464 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 815 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 293 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 133 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports16 fire reports12 injury reports
Visibility/wiper complaints
42 reportsTL* THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. WHILE DRIVING VARIOUS SPEEDS, THE HORN STARTED TO HONK WITHOUT WARNING. IN ADDITION, THE WINDSHIELD WIPERS AND WASHER FLUID ACTIVATED INDEPENDENTLY, THE AIR CONDITIONING UNIT TURNED OFF INDEPENDENTLY, AND THE TRANSMISSION FAILED TO SHIFT AS INTENDED. THE CONTACT WAS ABLE TO TURN O…
Read full complaint
TL* THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. WHILE DRIVING VARIOUS SPEEDS, THE HORN STARTED TO HONK WITHOUT WARNING. IN ADDITION, THE WINDSHIELD WIPERS AND WASHER FLUID ACTIVATED INDEPENDENTLY, THE AIR CONDITIONING UNIT TURNED OFF INDEPENDENTLY, AND THE TRANSMISSION FAILED TO SHIFT AS INTENDED. THE CONTACT WAS ABLE TO TURN OFF AND RESTART THE VEHICLE. THE VEHICLE OPERATED AS INTENDED FOR APPROXIMATELY TEN MINUTES BEFORE THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED, BUT THE MECHANIC WAS UNABLE TO RETRIEVE A FAULT CODE OR DUPLICATE THE FAILURES. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 159,654.
WHILE PARKED IN DRIVEWAY, THE HORN STARTED BLOWING ERRATICALLY, HEADLIGHTS WERE ON, AND FRONT AND REAR WINDSHIELD WIPERS AND WASHERS OPERATING. DOOR LOCKS WOULD NOT RESPOND TO REMOTE. AFTER S SHORT PERIOD OF TRYING TO UNLOCK THE DOORS WITH THE REMOTE, THEY EITHER RESPONDED TO THE REMOTE OR UNLOCKED BY THEMSELVES. AT THAT POINT I…
Read full complaint
WHILE PARKED IN DRIVEWAY, THE HORN STARTED BLOWING ERRATICALLY, HEADLIGHTS WERE ON, AND FRONT AND REAR WINDSHIELD WIPERS AND WASHERS OPERATING. DOOR LOCKS WOULD NOT RESPOND TO REMOTE. AFTER S SHORT PERIOD OF TRYING TO UNLOCK THE DOORS WITH THE REMOTE, THEY EITHER RESPONDED TO THE REMOTE OR UNLOCKED BY THEMSELVES. AT THAT POINT I ATTEMPTED TO TURN THE IGNITION ON AND START THE VEHICLE. I STARTED IT AND THEN TURNED IT OFF BUT THAT DID NOT STOP THE HORN, WIPERS, ETC. A FEW SECONDS AFTER SHUTTING THE IGNITION OFF, EVERYTHING STOPPED. FRONT AND REAR WIPERS DID NOT RETURN TO PARK POSITION UNTIL I MANUALLY TURNED THEM ON AND OFF. I STARTED THE ENGINE AGAIN AND HAD A CHECK ENGINE LIGHT WITH ERROR CODES RELATED TO THE TCM, TRANSMISSION CONTROL MODULE. IN ADDITION, WHILE DRIVING, THE HEATER BLOWER MOTOR INTERMITTENTLY STOPS WORKING. ALL OF THIS APPEARS TO BE THE RESULT OF A FAULTY TIPM,TOTALLY INTEGRATED POWER MODULE. THIS HAS HAPPENED TWICE IN THE LAST TWO WEEKS. FIRST OCCURRENCE WAS 1/11/18 AND SECOND OCCURRENCE WAS 1/16/18. SEARCHING ONLINE REVEALED THAT MINE IS NOT AN ISOLATED PROBLEM AS THERE ARE MANY REPORTED INSTANCES OF TIPM FAILURES WITH SIMILAR SYMPTOMS.
I WAS DRIVING ON A BUSY MAIN CITY ROAD AT NIGHT, TRAVELING AROUND 35 MPH WHEN MY VAN SHUT OFF AND THE WIPERS AND HORN WENT CRAZY. I LOST ALL POWER STEERING AND BRAKES. HEADLIGHTS ALSO CUT OUT. I STRUGGLED TO GET TO THE SIDE OF THE ROAD AND INTO A PARKING LOT. THE FRONT WIPERS STOPPED WHEN I TURNED THE KEY OFF, BUT THE BACK W…
Read full complaint
I WAS DRIVING ON A BUSY MAIN CITY ROAD AT NIGHT, TRAVELING AROUND 35 MPH WHEN MY VAN SHUT OFF AND THE WIPERS AND HORN WENT CRAZY. I LOST ALL POWER STEERING AND BRAKES. HEADLIGHTS ALSO CUT OUT. I STRUGGLED TO GET TO THE SIDE OF THE ROAD AND INTO A PARKING LOT. THE FRONT WIPERS STOPPED WHEN I TURNED THE KEY OFF, BUT THE BACK WIPER AND HORN CONTINUED FOR ABOUT 10 MIN. I DID NOT HAVE TOOLS TO DISCONNECT THE BATTERY. SUDDENLY THERE WAS A FLASH OF ALL THE LIGHTS IN THE CAR AND EVERYTHING SEEMED TO BE BACK TO NORMAL WITH THE EXCEPTION OF THE CHECK ENGINE LIGHT APPEARING ON THE DASH. I WAS ABLE TO RESTART THE VEHICLE AND DRIVE ANOTHER HALF MILE TO MY HOME. THIS IS THE FIRST TIME THIS HAS HAPPENED WHILE DRIVING, THAT I HAVE LOST ALL ENGINE POWER AND STEERING, IT IS NOT THE FIRST TIME THE VAN HAS ACTED OUT. WIPERS WILL SUDDENLY START MOVING WHEN I AM DRIVING OR THE HORN WITH SUDDENLY SOUND AND RADIO WILL CUT OUT. I HAVE ALSO HAD IT GO CRAZY WITH WINDSHIELD WIPERS MOVING, HORN HONKING, LOCKS MALFUNCTIONING AND FLUID SPRAYED ALL OVER THE CAR WHEN I UNLOCKED IT. MY WIFE ONCE HAD MY KIDS TRAPPED INSIDE OF THE CARE FOR 10 MINS UNTIL I COULD I DRIVE OVER AND DISCONNECTED THE BATTERY. I HAVE BEEN TOLD IT IS THE TIPM ACTING UP. IT HAS HAPPENED MORE THAN 10 TIMES. I DO NOT TRUST THE VEHICLE. I HAVE READ ABOUT MANY MORE INSTANCES ONLINE. THIS COULD CAUSE AN ACCIDENT IF IT WAS IN RUSH HOUR OR ON A BUSIER ROAD.
SEVERAL TIMES THE HORN BEGAN SOUNDING A LONG BLARE, THE WINDSHIELD WIPERS CAME ON, THE WASHER FLUID STARTED SPRAYING, THE DOORS LOCKED, AND THE HEADLIGHTS AND REAR LIGHTS BEGAN FLASHING, ALL LASTING SEVERAL MINUTES. IT BEGAN WHILE DRIVING AND CONTINUED AFTER I STOPPED THE CAR, TURNED IT OFF, AND REMOVED THE KEY. THE SYMPTOMS WOR…
Read full complaint
SEVERAL TIMES THE HORN BEGAN SOUNDING A LONG BLARE, THE WINDSHIELD WIPERS CAME ON, THE WASHER FLUID STARTED SPRAYING, THE DOORS LOCKED, AND THE HEADLIGHTS AND REAR LIGHTS BEGAN FLASHING, ALL LASTING SEVERAL MINUTES. IT BEGAN WHILE DRIVING AND CONTINUED AFTER I STOPPED THE CAR, TURNED IT OFF, AND REMOVED THE KEY. THE SYMPTOMS WORSENED ABOUT A WEEK LATER WHEN ALL OF THE ABOVE HAPPENED AS WELL AS THE GEAR SHIFT INDICATOR LIGHTS BEGAN FLASHING, THE STABILITY CONTROL LIGHT CAME ON, THE CHECK ENGINE LIGHT CAME ON, THE BAS LIGHT CAME ON, AND THEN THE CAR SHIFTED ITSELF INTO NEUTRAL. THIS HAS HAPPENED SEVERAL TIMES AND HAS BECOME MORE FREQUENT.
VEHICAL'S HORN WILL SOUND, WINDCHILL WIPERS GO OFF AND SPRAY WASHER FLUID, AND DOORS WILL LOCK THEMSELVES. THIS WILL HAPPEN WHETHER THE VAN IS RUNNING OR NOT. STARTED 1 AND HALF YEARS AGO. TAKEN IT TO DEALERSHIP TWICE AND THEY CANT FIND ANYTHING WRONG WITH IT.
MY VAN WAS ONE YEAR OLD (2009) WHEN IT FIRST ACTIVATED THE HORN (OFF AND ON MAKING A WEIRD WARBLING HALF HONK SOUND) AND WIPERS/SPRAY WHILE DRIVING DOWN THE HIGHWAY ON A HIGHWAY SWITCH RAMP AT 65 MPH. IT LASTED ABOUT A MINUTE AND THEN STOPPED. WE WERE ON A TRIP SO WE ASKED WHEN WE GOT BACK TO THE ARKANSAS DEALERSHIP. THEY TOLD U…
Read full complaint
MY VAN WAS ONE YEAR OLD (2009) WHEN IT FIRST ACTIVATED THE HORN (OFF AND ON MAKING A WEIRD WARBLING HALF HONK SOUND) AND WIPERS/SPRAY WHILE DRIVING DOWN THE HIGHWAY ON A HIGHWAY SWITCH RAMP AT 65 MPH. IT LASTED ABOUT A MINUTE AND THEN STOPPED. WE WERE ON A TRIP SO WE ASKED WHEN WE GOT BACK TO THE ARKANSAS DEALERSHIP. THEY TOLD US IT WAS LIKELY CORROSION (ON A BRAND NEW CAR THAT WAS DRIVEN IN NORMAL CIRCUMSTANCES). THEY SAID IT WASN'T COVERED UNDER WARRANTY AND WE DIDN'T HAVE PROOF. IT REPEATED ABOUT ONCE EVERY 6 MONTHS OR MORE. NOW (ABOUT ONCE A MONTH)THE BATTERY DIES RANDOMLY AND THE HORN/WIPERS/ETC GO OFF RANDOMLY WHILE IT'S JUST SITTING THERE AND DRIVING DOWN THE ROAD. I'VE HAD TO JUMP IT 5 TIMES WITHOUT ANY WARNING. I'VE DOUBLE VERIFIED THAT THE ALTERNATOR/BATTERY ARE IN GREAT SHAPE. REALLY DODGE ! A BRAND NEW CAR AND YOU COULDN'T HELP US! *TR
BOUGHT THIS VAN IN AUG. 2009 LOVED IT AT FIRST..THEN THINGS STARTED HAPPENING. WOULD HESITATE WHILE DRIVING, NEVER DIE ON ME BUT STILL FEELS LIKE IT WILL SOMETIMES.. STEERING WHEEL HAS LOCKED ON ME SEVERAL TIMES. DIFFERENT PANEL LIGHTS COME ON AND GO OFF SINCE DAY ONE. HAVE CHANGED BRAKES WAY MORE THAN SHOULD OF BEEN NECE…
Read full complaint
BOUGHT THIS VAN IN AUG. 2009 LOVED IT AT FIRST..THEN THINGS STARTED HAPPENING. WOULD HESITATE WHILE DRIVING, NEVER DIE ON ME BUT STILL FEELS LIKE IT WILL SOMETIMES.. STEERING WHEEL HAS LOCKED ON ME SEVERAL TIMES. DIFFERENT PANEL LIGHTS COME ON AND GO OFF SINCE DAY ONE. HAVE CHANGED BRAKES WAY MORE THAN SHOULD OF BEEN NECESSARY..OTHER REPAIR TO BRAKE SYSTEM. HAD POWER STEERING LINE CHANGED. ABOUT 6 MONTHS AGO, PANEL LIGHTS STARTED COMING ON MORE OFTEN, THEN THE GAUGES WOULDN'T WORK, WIPERS COME ON AND WON'T STOP. HEADLIGHT FLASH ON AND OFF OR DON'T WORK AT ALL; TURN SIGNALS WORK ON AND OFF, POWER LOCKS COME ON AND OFF, CAN'T ROLL WINDOWS DOWN OR UP FROM DRIVERS SIDE OR LOCK OR UNLOCK DOORS.EVERYDAY IT GETS WORSE. TOOK IT TO DODGE DEALER 11/2016 COST ABOUT $100.00 TO TELL ME , ITS NOT A CALL BACK AND NOT RELATED TO THE IGNITION PROBLEM, AND IN MY PASSED COMPLAINS THEY HAD DIDN'T HAVE ANY OF THESE PROBLEMS LISTED, EVEN THO I HAD TOLD THEM ABOUT THEM BEFORE. SO BECAUSE CONTROL LIGHTS HAD WENT OFF AT THAT TIME THEY COULDN'T DO ANYTHING. IT WAS PROBABLY AN ELECTRICAL PROBLEM AND THE LAST TIME THEY DID ONE IT TOO ABOUT 10 HR.TO FIND THE PROBLEM. ($128.00 AN HR) I CAN'T AFFORD THAT AND I THINK CHRYSLER SHOULD STAND BEHIND THEIR CARS. NOW FOR THE LAST 2 WEEKS ALL OF THESE THINGS STAY ON AND CONTINUE TO DO IT ALL. LOW MILEAGE 81000 ALWAYS TAKEN CARE OF, NOW I'M 70 YRS OLD AND HAVE A VAN THAT I'M AFRAID TO DRIVE...THIS HAPPENS WHILE DRIVING AND SITTING STILL. *TR
FREQUENTLY WILL NOT START-HAVE TO RAISE HOOD & SMACK TOP OF BLACK BOX & THEN IT WILL START, WILL GO "CRAZY" WHILE PARKED WITH NO KEYS IN IGNITION-HORN HONKS, LIGHTS FLASH ON & OFF, WIPERS GO & FLUID SPRAYS-AGAIN HAVE TO SMACK BOX TO MAKE IT STOP. BETWEEN 5/2/16 & 5/18/16, WHILE DRIVING DOWN THE ROAD, FOUR TIMES THE MOTOR HAS S…
Read full complaint
FREQUENTLY WILL NOT START-HAVE TO RAISE HOOD & SMACK TOP OF BLACK BOX & THEN IT WILL START, WILL GO "CRAZY" WHILE PARKED WITH NO KEYS IN IGNITION-HORN HONKS, LIGHTS FLASH ON & OFF, WIPERS GO & FLUID SPRAYS-AGAIN HAVE TO SMACK BOX TO MAKE IT STOP. BETWEEN 5/2/16 & 5/18/16, WHILE DRIVING DOWN THE ROAD, FOUR TIMES THE MOTOR HAS SHUT ITSELF OFF, HORN HAS BEGUN HONKING, WIPERS GO, FLUID SPRAYS, RUNNING LIGHTS GO OFF. ***DID IT TWICE ON 5/18/16! THANK GOD, WAS GOING SLOWLY DOWN A SIDE STREET-AGAIN HAD TO RAISE HOOD, SMACK ON TOP OF THAT BLACK BOX-FUSES AND SENSORS MUST BE IN THERE-AND IT STOPPED ACTING CRAZY AND RESTARTED. MY HUSBAND HAS BEEN DRIVING IT AS I REFUSE TO!! VERY SURPRISED AND CONCERNED THAT THERE HAS NOT BEEN RECALL AS THIS SEEMS TO BE A VERY FREQUENT ISSUE WITH THESE VANS-WISH I HAD NEVER BOUGHT MINE!
SEPT 2015-MY ENGINE SHUT OFF WHILE DRIVING AT 25MPH AND THE HORN AND WIPERS WENT CRAZY. I WAS ABLE TO PULL CAR TO SIDE OF ROAD SAFELY. FEB 2016- TOOK VAN IN FOR RECALL FOR NEW KEY FAB. THE FOLLOWING WEEK THE CAR WENT CRAZY WHEN I PUSHED UNLOCK BUTTON TO GET INTO THE VEHICLE USING THE NEW KEY FAB. HORN WENT OFF, WIPERS SQUIRTIN…
Read full complaint
SEPT 2015-MY ENGINE SHUT OFF WHILE DRIVING AT 25MPH AND THE HORN AND WIPERS WENT CRAZY. I WAS ABLE TO PULL CAR TO SIDE OF ROAD SAFELY. FEB 2016- TOOK VAN IN FOR RECALL FOR NEW KEY FAB. THE FOLLOWING WEEK THE CAR WENT CRAZY WHEN I PUSHED UNLOCK BUTTON TO GET INTO THE VEHICLE USING THE NEW KEY FAB. HORN WENT OFF, WIPERS SQUIRTING FLUID AND DOORS LOCKED ON ME EXCEPT FOR THE REAR HATCH. TOOK INTO DEALER THEY CHANGED THE CLOCK SPRING. MARCH 2016- VEHICLE WENT CRAZY AGAIN (HORN, WIPERS, DOORS) I GOT INTO VEHICLE THROUGH REAR HATCH, UNLOCKED HOOD, TURNED KEY TO START TO SEE IF I COULD UNLOCK, CAR STARTED. I TRIED TO TURN OFF AND ENGINE KEPT GOING WITHOUT KEY IN IGNITION. I GOT OUT DISCONNECTED BATTERY CABLE AND THE VEHICLE. WAS STILL GOING CRAZY AND THE ENGINE WAS STILL RUNNING FOR ABOUT 10 MINUTES. I TOOK VEHICLE INTO DEALER THEY FIRST STATED IT NEEDED NEW BATTERY CABLES.. I TOLD THEM THAT WILL NOT FIX THE ISSUE.. IT IS MORE THAN THAT. KEEP THE VEHICLE UNTIL YOU FIND THE REAL SOLUTION. NOW THE DEALERSHIP IS TELLING ME IT IS THE INTEGRATED POWER MODULE ($950) ON TOP ON THE CLOCK SPRING THAT THEY REPLACED FOR ($550). I FEEL LIKE THE DEALERSHIP IS JUST REACHING FOR SOLUTIONS AND ION THE MEANTIME I HAVE TO KEEP PAYING FOR THEIR TESTING.
Official recalls
820V396000 · Air Bags:frontal:driver Side:inflator Module; Steering: Steering Wheel/handle Bar
Jul 7, 2020
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence & remedy
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Steering: Steering Wheel/handle Bar
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
16V047000 · Air Bags:frontal
Jan 29, 2016
FCA US LLC (Chrysler) is recalling certain model year 2009 Dodge Journey vehicles manufactured December 31, 2007, to August 31, 2008, 2008-2009 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured June 18, 2007, to August 31, 2008. In the affected vehicles, the air bag control units may corrode and fail.
Consequence & remedy
Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began on December 6, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S07.
14V373000 · Air Bags; Electrical System:ignition:switch
Jun 26, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
14V055000 · SUSPENSION:REAR:AXLE:NON-POWERED Axle Assembly
Feb 11, 2014
Freedom Motors Inc., (Freedom Motors) of Savaria Vehicle Group (formerly The Liberty Motor Company) is recalling one model year 2009 Volkswagen Routan and certain model year 2008-2010 Dodge Grand Caravan and Chrysler Town & Country wheelchair accessible vehicles modified by The Liberty Motor Company from February 2008 through January 2011. Over time and with use, the vehicle's rear axle may develop cracks which could lead to axle failure.
Consequence & remedy
Consequence: Failure of the rear axle may increase the risk of a crash.
Remedy: Freedom Motors will notify owners, and dealers will replace the affected axles, free of charge. The recall began on April 1, 2014. Owners can contact Freedom Motors at 1-800-561-9600. Freedom Motors' number for this recall is ENGF0216-3.
11V394000 · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Equipment:appliance:air Conditioner
Aug 3, 2011
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence & remedy
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (3)
Equipment:appliance:air Conditioner
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags:frontal:sensor/control MODULE-INACTIVE
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags:frontal
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
10V611000 · Equipment:appliance:air Conditioner
Dec 8, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES. THESE VEHICLES MAY EXPERIENCE A WATER LEAK At THE HEATING AND AIR CONDITIONER (HVAC) DRAIN GROMMET WHICH CAN LEAD TO ILLUMINATION OF AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT.
Consequence & remedy
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE HVAC DRAIN GROMMET FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
10V235000 · Electrical System:wiring
Jun 3, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY PASSENGER VEHICLES MANUFACTURED FROM FEBRUARY 2007 THROUGH SEPTEMBER 2009. SOME OF THE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPERLY ROUTED WIRE HARNESS THAT MAY HAVE A CONDITION WHERE THE LOWER SLIDING DOOR HINGE BRACKET CAN MAKE CONTACT AND WEAR THROUGH THE WIRE INSULATION.
Consequence & remedy
Consequence: A SHORT CIRCUIT COULD OCCUR INSIDE THE SLIDING DOOR, OVERHEATING THE LATCH, POSSIBLY RESULTING IN A FIRE.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT CHRYSLER TOLL-FREE AT 1-800-853-1403.
09V351000 · Service Brakes, Hydraulic
Sep 11, 2009
ELDORADO NATIONAL IS RECALLING MODEL YEAR 2008-2009 AMERIVAN MOBILITY VEHICLES BUILT ON CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN PLATFORMS VEHICLES. THE REAR BRAKE LINES MAY HAVE BEEN IMPROPERLY ROUTED AND NOT SECURED PROPERLY DURING THE ALTERATION. IF NOT ROUTED AND SECURED PROPERLY, THE BRAKE LINES COULD RUB AGAINST THE VEHICLE CAUSING A BRAKE FLUID LEAK.
Consequence & remedy
Consequence: A BRAKE FLUID LEAK COULD RESULT IN A LOSS OF BRAKING ABILITY, POSSIBLY CAUSING A CRASH.
Remedy: ELDORADO NATIONAL AMERIVAN DEALERS WILL INSPECT THE VEHICLES AND IF THE BRAKE LINES WERE IMPROPERLY ROUTED THEY WILL BE CORRECTLY REINSTALLED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 13, 2009. OWNERS MAY CONTACT ELDORADO NATIONAL AT 1-800-955-9086. THESE MINIVANS HAVE BEEN ALTERED INTO WHEELCHAIR ACCESSIBLE VEHICLES BY ELDORADO. THIS RECALL IS NOT BEING CONDUCTED BY CHRYSLER GROUP LLC AND WILL NOT BE PERFORMED AT NO COST BY DODGE OR CHRYSLER DEALERS UNLESS THEY ARE ALSO AN ELDORADO NATIONAL DEALER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972