Illustration2008 DODGE CARAVAN BRAKES ARE DEFECTIVE OR UNDER ENGINEERED. HAD TO REPLACE FRONT BRAKES AND ROTORS @ 22K MILES AND AM NOW HAVING TO REPLACE FRONT AND REAR @ 35K MILES. VERY NERVOUS AS TO STOPPING ABILITY NOW. *TR
2008 Dodge Grand Caravan
Owner reports · Recalls · Investigations
More warning signs than most Grand Caravan years
Owner complaints for the 2008 Dodge Grand Caravan are substantially higher than the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1360–25K
13425–50K
15650–75K
17675–100K
172100–150K
54150K+
828 reports with mileage · 464 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 815 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 293 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 133 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports16 fire reports12 injury reports
Service Brakes, Hydraulic complaints
133 reports2008 DODGE GRAND CARAVAN. CONSUMER STATES THERE HAVE BEEN FIVE RECALLS FOR HER VEHICLE AND HAD PROBLEMS BEFORE THE RECALLS WERE ANNOUNCED. SHE WOULD LIKE TO TERMINATE HER LEASE EARLY. *KB IN JUNE 2009, THE VEHICLE NEEDED NEW FRONT BRAKE PADS AND ROTORS AT ONLY 15,000 AND AGAIN IN AUGUST 2010. IN THE SPRING, THE VEHICLE HAD NO …
Read full complaint
2008 DODGE GRAND CARAVAN. CONSUMER STATES THERE HAVE BEEN FIVE RECALLS FOR HER VEHICLE AND HAD PROBLEMS BEFORE THE RECALLS WERE ANNOUNCED. SHE WOULD LIKE TO TERMINATE HER LEASE EARLY. *KB IN JUNE 2009, THE VEHICLE NEEDED NEW FRONT BRAKE PADS AND ROTORS AT ONLY 15,000 AND AGAIN IN AUGUST 2010. IN THE SPRING, THE VEHICLE HAD NO AIR CONDITION. THE DEALER INFORMED THE CONSUMER THE PART WAS MANUFACTURED TOO SHORT AND FROZE DURING THE WINTER, WHICH CAUSED FLUID TO LEAK OUT. THE PROBLEM WAS RESOLVED AFTER 3 WEEKS. IN JUNE 2010, THE SAME HOSE RUPTURED AND AGAIN THE CONSUMER WAS LEFT WITH NO A/C. THE RADIATOR CAP HAD TO BE REPAIRED WHICH WAS WHY THE CONSUMER HAD TO KEEP ADDING COOLANT. THE WASHER FLUID SENSOR WAS NOT WORKING AND NEEDED TO BE REPLACED. IN AUGUST 2010, THE POWER SLIDING DOOR STOPPED FUNCTIONING FOR DAYS. WHEN THE CONSUMER TOOK THE VEHICLE TO THE DEALER, THEY WERE UNABLE TO FIND A PROBLEM. HOWEVER, TWO MONTHS LATER A RECALL WAS ISSUED. THE CONSUMER STATED SHE ALSO EXPERIENCED POWER FAILURES WITH THE VEHICLE. EACH TIME THE PROBLEM OCCURRED THE ENGINE WOULD RUN, BUT NOTHING ELSE IN THE VEHICLE WORKED, SUCH AS THE WINDOWS, LOCKS, WINDSHIELD WIPERS AND INTERIOR LIGHTS ETC. THE PROBLEM WAS SPORADIC AND EACH TIME THE CONSUMER WENT TO THE DEALER, THEY WERE UNABLE TO FIND ANY PROBLEMS. *JB
TL* THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN SE. THE CONTACT WAS APPLYING THE BRAKES WHEN THE BRAKE PEDAL BEGAN TO VIBRATE ABNORMALLY AND THE BRAKES WERE EXHIBITING AN UNUSUAL CHATTERING. THE DEALER WAS NOTIFIED WHO ADVISED THAT THE FAILURE WAS COMMON IN HIS YEAR, MAKE AMD MODEL VEHICLE BUT UNLESS THE MANUFACTURER WAS WILLING…
Read full complaint
TL* THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN SE. THE CONTACT WAS APPLYING THE BRAKES WHEN THE BRAKE PEDAL BEGAN TO VIBRATE ABNORMALLY AND THE BRAKES WERE EXHIBITING AN UNUSUAL CHATTERING. THE DEALER WAS NOTIFIED WHO ADVISED THAT THE FAILURE WAS COMMON IN HIS YEAR, MAKE AMD MODEL VEHICLE BUT UNLESS THE MANUFACTURER WAS WILLING TO ASSIST, THERE WAS NOT MUCH HE COULD DO TO ASSIST. THE CONTACT DID NOT INFORM THE MANUFACTURER OF THE FAILURE NOR WAS THE VEHICLE REPAIRED. THE CURRENT MILEAGE WAS 32,000 AND THE FAILURE MILEAGE WAS 12,000.
TL*THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT HEARD A CLUNKING NOISE AND BEGAN TO SMELL A BURNING ODOR. THE CONTACT PULLED OVER AND NOTICED THAT THE ODOR WAS COMING FROM THE REAR PASSENGER SIDE BRAKE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE REAR PASSENGE…
Read full complaint
TL*THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT HEARD A CLUNKING NOISE AND BEGAN TO SMELL A BURNING ODOR. THE CONTACT PULLED OVER AND NOTICED THAT THE ODOR WAS COMING FROM THE REAR PASSENGER SIDE BRAKE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE REAR PASSENGER SIDE BRAKE HAD LOCKED UP. THE BRAKES WERE REPLACED. THE FAILURE OCCURRED THREE ADDITIONAL TIMES. THE VEHICLE HAD BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 27,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 60,000. UPDATED 02/23/11 *BF UPDATED 02/28/11
WE PURCHASE OUR 2008 DODGE GRAND CARAVAN NEW ON 12/22/2008. WE HAVE HAD TO GET OUR FRONT PADS REPLACED AND FRONT ROTORS RESURFACED AT 20,306 MILES AND CHRYSLER SENT OUT A FRONT BRAKE LIMITED WARRANTY EXTENSION SO WE RECEIVED A REFUND BACK MINUS THE 50.00 DEDUCTIBLE FOR THIS REPAIR. HOWEVER NOW WE'VE HAD PROBLEMS WITH OUR REAR …
Read full complaint
WE PURCHASE OUR 2008 DODGE GRAND CARAVAN NEW ON 12/22/2008. WE HAVE HAD TO GET OUR FRONT PADS REPLACED AND FRONT ROTORS RESURFACED AT 20,306 MILES AND CHRYSLER SENT OUT A FRONT BRAKE LIMITED WARRANTY EXTENSION SO WE RECEIVED A REFUND BACK MINUS THE 50.00 DEDUCTIBLE FOR THIS REPAIR. HOWEVER NOW WE'VE HAD PROBLEMS WITH OUR REAR CALIPERS & REAR BRAKES WHICH WE WOULD LIKE TO HAVE OUR REPAIR REFUNDED OR A RECALL DONE ON THIS MATTER. HERE IS THE INFO: FIRST COMPLAINT:--THE REAR CALIPERS SEIZED WHICH CAUSED THE SECOND COMPLAINT-- THE PADS WORE OUT QUICKLY. THE REAR CALIPERS SEIZED AND THE REAR BRAKES FAILED AND BOTH HAD TO BE REPLACED. THE REAR ROTORS AND DRUMS HAD TO BE RESURFACED AT OUR EXPENSE($446.38 PARTS & LABOR, NOT INCLUDING TAX).
TL* THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE WAS EXPERIENCING AN INCREASE IN STOPPING DISTANCE WHEN BRAKING AT ANY SPEED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE BRAKES WERE REPLACED. THE FAILURE SINCE RECURRED TWICE. AFTER EACH FAILURE, THE BRAKES WOULD EITHER BE REPLA…
Read full complaint
TL* THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE WAS EXPERIENCING AN INCREASE IN STOPPING DISTANCE WHEN BRAKING AT ANY SPEED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE BRAKES WERE REPLACED. THE FAILURE SINCE RECURRED TWICE. AFTER EACH FAILURE, THE BRAKES WOULD EITHER BE REPLACED BY AN AUTHORIZED DEALER OR INDEPENDENT MECHANIC BUT TO NO AVAIL. THE FAILURE MILEAGE WAS 10,000 AND THE CURRENT MILEAGE WAS 50,000. UPDATED 02/09/11*LJ UPDATED 05/09/11
APPROXIMATELY 20,000 MILES FRONT BRAKE RECALL LETTER RECEIVED, TOOK TO LOCAL DEALER AND REPAIRS MADE. AT 23,000 MILE REAR LEFT LOCKED, TOTAL REPLACEMENT AT THE COST OF $299.29 TO REPAIR ONE BRAKE, ROTOR AND CALIPER. VERY DISAPPOINTED, WAS INFORMED BY DEALER REPAIRMAN THAT THERE SHOULD BE A RECALL FOR THE REARS SOON. TOLD TO…
Read full complaint
APPROXIMATELY 20,000 MILES FRONT BRAKE RECALL LETTER RECEIVED, TOOK TO LOCAL DEALER AND REPAIRS MADE. AT 23,000 MILE REAR LEFT LOCKED, TOTAL REPLACEMENT AT THE COST OF $299.29 TO REPAIR ONE BRAKE, ROTOR AND CALIPER. VERY DISAPPOINTED, WAS INFORMED BY DEALER REPAIRMAN THAT THERE SHOULD BE A RECALL FOR THE REARS SOON. TOLD TO KEEP RECEIPT FOR REIMBURSEMENT. *TR
TL*THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. THE CONTACT STATED THAT ON AUGUST 18, 2009 WHILE DRIVING APPROXIMATELY 45 MPH SOMEONE ADVISED HIM THAT HIS WHEEL WAS SMOKING. THE VEHICLE WAS TOWED TO THE DEALER WHO CONFIRMED THAT BOTH REAR CALIPERS WERE LOCKED THE DEALER REPLACED CALIPERS, ROTORS, AND REAR BRAKE PADS AT 14,768 M…
Read full complaint
TL*THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. THE CONTACT STATED THAT ON AUGUST 18, 2009 WHILE DRIVING APPROXIMATELY 45 MPH SOMEONE ADVISED HIM THAT HIS WHEEL WAS SMOKING. THE VEHICLE WAS TOWED TO THE DEALER WHO CONFIRMED THAT BOTH REAR CALIPERS WERE LOCKED THE DEALER REPLACED CALIPERS, ROTORS, AND REAR BRAKE PADS AT 14,768 MILES. ON OCTOBER 25, 2010 WHILE DRIVING HE SMELLED SMOKE AGAIN. THE VEHICLE WAS TOWED TO THE DEALER WHO STATED THAT THE RIGHT REAR CALIPER WAS FROZEN, THE LEFT REAR CALIPER WAS STICKING AND THE BRAKE PADS WERE OVERHEATED AND CRACKED. THE REAR CALIPERS, AND BRAKE PADS WERE REPLACED AT 29,979 MILES. THE MANUFACTURER PROVIDED A RENTAL VEHICLE WHEN THE FIRST FAILURE OCCURRED. THE FAILURE MILEAGE WAS 14,768. THE CURRENT MILEAGE WAS 29,979. UPDATED 01/18/11 *BF UPDATED 1/19/2010 *CN UPDATED 03/31/11 ACCORDING TO THE INVOICE, THE REAR CALIPERS WERE NOT RELEASING PROPERLY AND THE REAR ROTORS WERE DISCOLORED. UPDATED 06/01/11
2008 DODGE GRAND CARAVAN 32K MILES FRONT BRAKES WERE SQUEAKING SO WE TOOK IT TO LOCAL DODGE DEALER. SAID THE FRONT ROTORS AND PADS NEEDED TO BE REPLACED. THIS CAR IS NEW AND THE FIRST BRAKE JOB NEEDS ROTORS? WE PAID FOR IT AND LATER DODGE SENT OUT A REIMBURSEMENT LETTER IN THE SUMMER TO PAY HALF OF THE COSTS. I WONDER IF TH…
Read full complaint
2008 DODGE GRAND CARAVAN 32K MILES FRONT BRAKES WERE SQUEAKING SO WE TOOK IT TO LOCAL DODGE DEALER. SAID THE FRONT ROTORS AND PADS NEEDED TO BE REPLACED. THIS CAR IS NEW AND THE FIRST BRAKE JOB NEEDS ROTORS? WE PAID FOR IT AND LATER DODGE SENT OUT A REIMBURSEMENT LETTER IN THE SUMMER TO PAY HALF OF THE COSTS. I WONDER IF THEY PUT THE SAME JUNK ROTORS BACK ON? NOW, 6K MILES LATER THE FRONT RIGHT BRAKE SQUEALS LIKE THE PAD IS LOW BUT THE DEALER SAID IT IS OK AND THAT IS "NORMAL". IT IS NOT NORMAL TO HEAR A GRINDING PAD ON ROTOR SOUND WHEN THE PAD IS GOOD! THE ONLY THING HE SAID THEY COULD DO WOULD BE TO RESURFACE THE ROTOR AND PUT STOP SQUEAL ON THE PAD. IT WOULD COST AROUND 120.00 BUCKS. POOR PARTS ARE OBVIOUSLY ON THIS CAR...I WILL NOT BUY ANOTHER DODGE OR SUGGEST ANYONE DO SO. OTHER PROBLEMS WITH THIS NEW CAR SO FAR ARE: 1. WHEN FIRST BOUGHT, TRANS FLUID LEAK, WARRANTY FIXED THAT. 2. ROTORS AND PADS ON FRONT (AS DESCRIBED ABOVE), REIMBURSED FOR HALF 3. NOW AT 38K MILES, THE FRONT LEFT WHEEL BEARING IS BAD, HAVE TO REPLACE, 220.00 DOLLARS, I AM TALKING TO CHRYSLER TO SEE IF THEY WILL PAY FOR OR NOT. TWO DEALERS AND TWO REPAIR SHOPS CANNOT GET THIS PART FOR A WEEK TO A MONTH, THEY ARE ON BACKORDER. *TR
IN JULY2010, I HAD THE FRONT BRAKES REPLACE AFTER ONLY 30000 M ILES. ALSO A FRONT CALIPER WAS REPLACED DUE TO IT NOT RELEASING AFTER APPLYING THE BRAKES. IN AUG, 2010 ON A RETURN TRIP FROM FLORIDA, THE REAR BRAKE CALIPERS FROZE , WOULD NOT RELEASE, CAUSING THE REAR BRAKES TO OVERHEAT, CAUSING REAR BRAKE FAILURE. REPAIR OF THE RE…
Read full complaint
IN JULY2010, I HAD THE FRONT BRAKES REPLACE AFTER ONLY 30000 M ILES. ALSO A FRONT CALIPER WAS REPLACED DUE TO IT NOT RELEASING AFTER APPLYING THE BRAKES. IN AUG, 2010 ON A RETURN TRIP FROM FLORIDA, THE REAR BRAKE CALIPERS FROZE , WOULD NOT RELEASE, CAUSING THE REAR BRAKES TO OVERHEAT, CAUSING REAR BRAKE FAILURE. REPAIR OF THE REAR BRAKES COST APROX.$ 580.00. A COMPLAINT TO CHRYSLER CORP. WAS INITIATED, AND THEY REIMBURSED A TOTAL OF$280.00. I WAS TOLD BY 2 DEALERS THAT THERE HAS BEEN AN ABNORMAL AMOUNT OF PROBLEMS WITH THE BRAKE CALIPERS ON THE CHRYSLER/DODGE VANS. SINCE WE WERE TRANSPORTING OXYGEN THAT MY WIFE NEEDS FOR MEDICAL PURPOSES A FIRE OR OTHER FAILURE OF THE REAR BRAKES, IE FIRE, SEIZING OF THE BRAKES CAUSING A WRECK, OR BEING DISABLED ON THE HIGHWAY, MILES FROM A REPAIR FACILITY COULD HAVE HAD SERIOUS RESULTS. AT THE PRESENT TIME THE ONLY REMAINING CALIPER HAS FAILED, FROZE TO THE ROTOR, AND IS IN NEED OF REPAIR WHICH HAS BEEN SCHEDULED AT A NON DEALER SHOP. THE COST HAS BEEN ESTIMATED AT $100.00. CHRYSLER CORP HAS NOT GIVEN ANY ACKNOWLEDGMENT AS TO THE CAUSE OR WHY THIS IS OCCURRING, ONLY THE $280.00 REIMBURSEMENT. THE QUESTION IS: WILL THIS HAPPEN IF I PURCHASE ANOTHER CHRYSLER VAN AND HAS THE BRAKE CALIPER BEEN ACKNOWLEDGED AND FIXED? 4280.00 REIMBURSEMENT. *TR
Official recalls
820V396000 · Air Bags:frontal:driver Side:inflator Module; Steering: Steering Wheel/handle Bar
Jul 7, 2020
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence & remedy
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Steering: Steering Wheel/handle Bar
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
16V047000 · Air Bags:frontal
Jan 29, 2016
FCA US LLC (Chrysler) is recalling certain model year 2009 Dodge Journey vehicles manufactured December 31, 2007, to August 31, 2008, 2008-2009 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured June 18, 2007, to August 31, 2008. In the affected vehicles, the air bag control units may corrode and fail.
Consequence & remedy
Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began on December 6, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S07.
14V373000 · Air Bags; Electrical System:ignition:switch
Jun 26, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
14V055000 · SUSPENSION:REAR:AXLE:NON-POWERED Axle Assembly
Feb 11, 2014
Freedom Motors Inc., (Freedom Motors) of Savaria Vehicle Group (formerly The Liberty Motor Company) is recalling one model year 2009 Volkswagen Routan and certain model year 2008-2010 Dodge Grand Caravan and Chrysler Town & Country wheelchair accessible vehicles modified by The Liberty Motor Company from February 2008 through January 2011. Over time and with use, the vehicle's rear axle may develop cracks which could lead to axle failure.
Consequence & remedy
Consequence: Failure of the rear axle may increase the risk of a crash.
Remedy: Freedom Motors will notify owners, and dealers will replace the affected axles, free of charge. The recall began on April 1, 2014. Owners can contact Freedom Motors at 1-800-561-9600. Freedom Motors' number for this recall is ENGF0216-3.
11V394000 · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Equipment:appliance:air Conditioner
Aug 3, 2011
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence & remedy
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (3)
Equipment:appliance:air Conditioner
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags:frontal:sensor/control MODULE-INACTIVE
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags:frontal
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
10V611000 · Equipment:appliance:air Conditioner
Dec 8, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES. THESE VEHICLES MAY EXPERIENCE A WATER LEAK At THE HEATING AND AIR CONDITIONER (HVAC) DRAIN GROMMET WHICH CAN LEAD TO ILLUMINATION OF AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT.
Consequence & remedy
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE HVAC DRAIN GROMMET FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
10V235000 · Electrical System:wiring
Jun 3, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY PASSENGER VEHICLES MANUFACTURED FROM FEBRUARY 2007 THROUGH SEPTEMBER 2009. SOME OF THE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPERLY ROUTED WIRE HARNESS THAT MAY HAVE A CONDITION WHERE THE LOWER SLIDING DOOR HINGE BRACKET CAN MAKE CONTACT AND WEAR THROUGH THE WIRE INSULATION.
Consequence & remedy
Consequence: A SHORT CIRCUIT COULD OCCUR INSIDE THE SLIDING DOOR, OVERHEATING THE LATCH, POSSIBLY RESULTING IN A FIRE.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT CHRYSLER TOLL-FREE AT 1-800-853-1403.
09V351000 · Service Brakes, Hydraulic
Sep 11, 2009
ELDORADO NATIONAL IS RECALLING MODEL YEAR 2008-2009 AMERIVAN MOBILITY VEHICLES BUILT ON CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN PLATFORMS VEHICLES. THE REAR BRAKE LINES MAY HAVE BEEN IMPROPERLY ROUTED AND NOT SECURED PROPERLY DURING THE ALTERATION. IF NOT ROUTED AND SECURED PROPERLY, THE BRAKE LINES COULD RUB AGAINST THE VEHICLE CAUSING A BRAKE FLUID LEAK.
Consequence & remedy
Consequence: A BRAKE FLUID LEAK COULD RESULT IN A LOSS OF BRAKING ABILITY, POSSIBLY CAUSING A CRASH.
Remedy: ELDORADO NATIONAL AMERIVAN DEALERS WILL INSPECT THE VEHICLES AND IF THE BRAKE LINES WERE IMPROPERLY ROUTED THEY WILL BE CORRECTLY REINSTALLED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 13, 2009. OWNERS MAY CONTACT ELDORADO NATIONAL AT 1-800-955-9086. THESE MINIVANS HAVE BEEN ALTERED INTO WHEELCHAIR ACCESSIBLE VEHICLES BY ELDORADO. THIS RECALL IS NOT BEING CONDUCTED BY CHRYSLER GROUP LLC AND WILL NOT BE PERFORMED AT NO COST BY DODGE OR CHRYSLER DEALERS UNLESS THEY ARE ALSO AN ELDORADO NATIONAL DEALER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972