IllustrationDRIVING DOWN THE HIGHWAY, ENGINE STALLED, HORN WAS BLARING WITH NO WAY TO TURN IT OFF, WIPERS AT FULL SPEED AND COULDN'T STOP THEM, CAR WOULDN'T START BACK UP. ENGINE LIGHT AND GAS LIGHT(NOT EMPTY) ARE NOW ON.
2008 Dodge Grand Caravan
Owner reports · Recalls · Investigations
More warning signs than most Grand Caravan years
Owner complaints for the 2008 Dodge Grand Caravan are substantially higher than the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1360–25K
13425–50K
15650–75K
17675–100K
172100–150K
54150K+
828 reports with mileage · 464 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 815 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 293 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 133 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports16 fire reports12 injury reports
Electronic Stability Control (esc) complaints
39 reportsA NEED A RECALL ON TIPM PART WHICH CONTROLS THE ENGINE WHICH TURNS IT ON AND OFF. NOW A RECALL IS DUE>BECAUASE IT IS THE ISSUE WITH VEHICLE BECAUSE NOW THE EALERSHIPS ARE SAYING IT IS THE ISSUE OR WHAT IS CAUSING IT TO TURN OFF.AS A DODGE OWNER OF A GRAND CARAVAN, FROM THE TIME I BROUGHT THE VEHICLE THERE WERE ISSUES. FIRST I…
Read full complaint
A NEED A RECALL ON TIPM PART WHICH CONTROLS THE ENGINE WHICH TURNS IT ON AND OFF. NOW A RECALL IS DUE>BECAUASE IT IS THE ISSUE WITH VEHICLE BECAUSE NOW THE EALERSHIPS ARE SAYING IT IS THE ISSUE OR WHAT IS CAUSING IT TO TURN OFF.AS A DODGE OWNER OF A GRAND CARAVAN, FROM THE TIME I BROUGHT THE VEHICLE THERE WERE ISSUES. FIRST IT STARTED WITH THE VEHICLE TURNING ITSELF OFF AND DID START BACK. SO THE DEALERSHIP FIX IT. THEN IT WAS THE BRAKES AND ROTORS ON THE FRONT END. FIX , REPAIR, ISSUES AGAIN, THEN ISSUES AGAIN. SO MANY OTHER ISSUES WITH THIS VAN LATER ON. BUT I DECIDED NOT TO COMPLAIN TO DODGE COMPANY.. BOY DO I REGRET IT NOW..IT'S BEEN ALMOST 4 YEARS NOW, I STILL HAVE ISSUES WITH THE ENGINE CUTTING OFF WHILE DRIVING. THIS HAS GONE ON FOR AWHILE, THEN RECALL COME OUT SAYING IT'S THE ENGINE SWITCH, SO NOW WE ARE WAITING ON THE IT, STILL... WHEN I HAVE DID SOME RESEARCH AND ASK SOME PEOPLE WITH COMPUTER KNOWLEDGE ON VEHICLES AND THEY SAY BY THE ENGINE CUTTING OFF WHILE DRIVING CAN CAUSE ISSUES WITH THE TIPM PART (COMPUTER). I HAVE TAKEN IT SO MANY TIMES TO THE DEALERSHIP FOR THIS REASON FOR THE ENGINE SHUTTING IT SELF OFF, THEY WOULD BRUSH IT OFF IT'S THE BATTERY, GOT NEW BATTERY THEN IT HAPPEN AGAIN. THEN TOOK IT BACK AGAIN , NO ENGINE LIGHT ON , THEN THEY CAN'T DIAGNOSE ANY ISSUES. NOW WARRANTY IS OUT.. STILL NO PART FOR THE RECALL ENGINE SWITCH.... 2015. NOW THAT THE ENGINE IS STILL SHUTTING IT SELF OFF, DEALERSHIP IS NOW SAYING ITS THE TIPM PART WHICH IS 1200. OR MORE... I BELIEVE IT HAS BEEN THE ISSUE THE WHOLE TIME, SO DODGE NEEDS TO HAVE A RECALL ON THIS PART BEFORE SOMEONE IS KILL... I WORRY ABOUT IT HAPPENING TO MY FAMILY.I HAVE THREE CHILDREN. IT'S OUR ONLY VEHICLE.. AS OF TODAY STILL NO PART AVAILABLE.CALL DODGE - NO HELP FROM THEM. THEY NEED TO HAVE A RECALL ON THE TIPM PART BEFORE ITS TO LATE.
MY WIFE WAS DRIVING THE MINIVAN TODAY AROUND 6:45 AM. SHE WAS DROPPING OFF OUR DAUGHTER TO SCHOOL. HER SPEED LIMIT WAS 25 MPH. 2 TIMES, THE TRACTION STABILITY CONTROL LIT UP IN THE DASHBOARD. THE ENGINE STOPPED, BRAKE WAS NOT WORKING AND STEERING WHEEL CANNOT BE MOVED. BOTH TIMES, SHE WAS ABLE TO TURN ON THE HAZARD LIGHT TO…
Read full complaint
MY WIFE WAS DRIVING THE MINIVAN TODAY AROUND 6:45 AM. SHE WAS DROPPING OFF OUR DAUGHTER TO SCHOOL. HER SPEED LIMIT WAS 25 MPH. 2 TIMES, THE TRACTION STABILITY CONTROL LIT UP IN THE DASHBOARD. THE ENGINE STOPPED, BRAKE WAS NOT WORKING AND STEERING WHEEL CANNOT BE MOVED. BOTH TIMES, SHE WAS ABLE TO TURN ON THE HAZARD LIGHT TO ALERT ANY VEHICLES BEHIND HER. LUCKILY SHE WAS NOT TRAVELING FAST AND THE VEHICLES BEHIND HER WERE SLOW. BOTH TIMES SHE HAD TO REMOVE THE KEY AND REINSERT IT AND RESTART THE MINIVAN. SHE WAS ABLE TO RESTART THE MINIVAN. THIS IS THE 2ND TIME THAT THIS HAPPENED. OUR DEALER HAVE OPEN APPOINTMENTS 6 DAYS FROM NOW. THIS IS A DANGEROUS SITUATION THAT OTHERS ARE ALSO EXPERIENCING. BELOW IS A LINK OF COMPLAINTS... HTTP://WWW.CARCOMPLAINTS.COM/DODGE/GRAND_CARAVAN/2008/BRAKES/ELECTRONIC_STABILITY_CONTROL.SHTML. *TR
ENGINE SHUT OFF COMPLETE AND HARD TO CONTROL THE STEERING WHEEL AND THE BRAKES DON'T RESPONSE AT ALL AND CHRYSLER GROUP LLC DON'T DO NOTHING TO FIX THE PROBLEM AT ALL AND I HAVE OVER 5 MONTH STILL PAYING THE VAN AND I CAN'T DRIVE AT ALL. *TR
MY 18YR SON WAS DRIVING THE VAN AT HIGHWAY SPEEDS (65 MPH) WHEN HE DESCRIBED A SUDDEN INABILITY TO CONTROL THE VEHICLE. THE STEERING BECAME HARD TO CONTROL AND THE BRAKES HERE HARD TO PUSH. HE THOUGHT THE BRAKES HAD FAILED. DUE TO THE INABILITY TO CONTROL THE VAN HE DRIFTED INTO THE PASSING LANE WHERE A CAR TO THE REAR OF HIM ST…
Read full complaint
MY 18YR SON WAS DRIVING THE VAN AT HIGHWAY SPEEDS (65 MPH) WHEN HE DESCRIBED A SUDDEN INABILITY TO CONTROL THE VEHICLE. THE STEERING BECAME HARD TO CONTROL AND THE BRAKES HERE HARD TO PUSH. HE THOUGHT THE BRAKES HAD FAILED. DUE TO THE INABILITY TO CONTROL THE VAN HE DRIFTED INTO THE PASSING LANE WHERE A CAR TO THE REAR OF HIM STRUCK HIS REAR QUARTER PANEL, CAUSING HIS VAN TO SPIN OUT OF CONTROL. THE VEHICLE SPUN AND CAME TO REST IN THE MERIDIAN. THE POLICE REPORT STATED" NO EVIDENCE OF BRAKES LOCKING UP" AS THERE WAS NO SKID MARKS IN THE ROAD WAY UNTIL THE VEHICLE WAS LEAVING THE ROAD SIDEWAYS. THE AIR BAGS DID NOT DEPLOY. THE DAMAGE TO THE VEHICLE INCLUDES SUBSTANTIAL FRONT, SIDE AND REAR PANEL DAMAGE THE FRONT AND REAR TIRES ARE OUT OF ALIGNMENT, EXHAUST PUSHED UP INTO REAR QUARTER PANEL AND THE FORCE CAUSED THE BATTERY TO SLIDE OUT OF PLACE. THE ENGINE WARNING LIGHTS WERE ALL ON TO INCLUDE THE AIR BAG LIGHT. WE CALLED CHRYSLER BECAUSE WE SAW THE RECALL ON LINE. MEANWHILE 5 DAYS AFTER THE ACCIDENT WE RECEIVED THE RECALL NOTICE IN THE MAIL STATING IT WAS FINE TO DRIVE THE CAN UNTIL THE RECALL WAS PERFORMED.THEY SENT AN INVESTIGATION TEAM TO EXAMINE THE VAN AND DETERMINED THE BRAKES WERE AT FAULT. HOWEVER THE BRAKES WERE NEW INCLUDING ROTORS 2 WEEKS PRIOR AND UPON HAVING MY OWN INSPECTION DONE THE BRAKES WERE FOUND IN WORKING ORDER, NO WARPED ROTORS OR BURNT PADS THAT WOULD SUGGEST A BRAKE LOCK UP AT 65MPH,TIRES(SNOW TIRES AS MY SON WAS HEADING TO COLLEGE IN NORTHERN MAINE ) ARE IN GOOD CONDITION WITH NO EVIDENCE OF FLAT AREAS (AS ONE MIGHT EXPECT WITH BRAKES LOCKING UP) WE HAD ENGINE DIAGNOSTICS CHECKED AND FOUND AN YAW WARNING AT THE TIME OF THE ACCIDENT WITH NO OTHER ENGINE CODES NOTED. ALL ENGINE LIGHTS WERE LIT UP AT THE TIME OF THE ACCIDENT MUCH LIKE WHAT HAPPENS WHEN YOU SHUT THE IGNITION OFF WHILE THE VEHICLE IS IN MOTION ONLY TO RESET UPON NORMAL RESTART. *TR
WIFE WAS DRIVING AROUND 40 MPH WHEN TRACTION CONTROL LIGHT CAME ON AND SHE LOST POWER STEERING AND BRAKES. SHE WAS FINALLY ABLE TO STOP IN THE MIDDLE OF THE INTERSECTION, LUCKILY THERE WAS NO CAR COMING. SHE THEN TURNED THE VAN OFF AND RESTARTED AND EVERYTHING WAS FINE. SHE SAID SHE IS NEVER DRIVING IT AGAIN BECAUSE IT IS UN…
Read full complaint
WIFE WAS DRIVING AROUND 40 MPH WHEN TRACTION CONTROL LIGHT CAME ON AND SHE LOST POWER STEERING AND BRAKES. SHE WAS FINALLY ABLE TO STOP IN THE MIDDLE OF THE INTERSECTION, LUCKILY THERE WAS NO CAR COMING. SHE THEN TURNED THE VAN OFF AND RESTARTED AND EVERYTHING WAS FINE. SHE SAID SHE IS NEVER DRIVING IT AGAIN BECAUSE IT IS UNSAFE. LAST YEAR WE HAD THE TIPM REPLACED AFTER THE SEEMINGLY COMMON PROBLEM OF HORN HONKING, WINDSHIELD WIPERS GOING AND SOLVENT SPRAYING RANDOMLY SEVERAL TIMES. NOT SURE HOW CHRYSLER CAN GET AWAY WITH HAVING ALL OF THESE LIFE ENDANGERING ISSUES WITHOUT HAVING RECALLS AND FIXING THEM. BUT WHAT I DO KNOW IS WE WILL NEVER BUY A CHRYSLER PRODUCT AGAIN. *TR
ON OCCASION THE VEHICLE WILL SET OF A SIGNAL ALARM AND DISPLAY ESP BAS BRAKE ABS AND THE ESP SYMBOL WILL ILLUMINATE - ALSO THE PANEL LIGHTS WILL FLICKER. I WILL ALSO FEEL A VERY SLIGHT HESITATION ON MY FORWARD MOTION. IT DOES NOT ALWAYS HAPPEN - BUT ALWAYS WHILE VEHICLE WAS JUST STARTING TO HEAT UP. *TR
AS I WAS DRIVING ON THE INTERSTATE IN ATLANTA, MY VEHICLE ABS EPS BAS AND ESP LIGHT CAME ON. AT THIS TIME I WAS UNABLE TO USE CRUISE CONTROL. NOW IT COMES ON INTERMITTENTLY AND SLOWS MY VEHICLE DOWN AT ODD TIMES. I HAVE TAKEN IT TO THE MECHANIC AND THEY SAY THEY DON'T SEE ANYTHING WRONG WITH IT. I TRAVEL A LOT AND WOULD HATE FOR…
Read full complaint
AS I WAS DRIVING ON THE INTERSTATE IN ATLANTA, MY VEHICLE ABS EPS BAS AND ESP LIGHT CAME ON. AT THIS TIME I WAS UNABLE TO USE CRUISE CONTROL. NOW IT COMES ON INTERMITTENTLY AND SLOWS MY VEHICLE DOWN AT ODD TIMES. I HAVE TAKEN IT TO THE MECHANIC AND THEY SAY THEY DON'T SEE ANYTHING WRONG WITH IT. I TRAVEL A LOT AND WOULD HATE FOR THIS TO HAPPEN TO ME AGAIN ESPECIALLY WITH MY CHILDREN WITH ME. *TR
WHILE DRIVING DOWN THE ROAD THE CAR LOSES COMPLETE POWER--STEERING, BRAKES. ELECTRONIC STABILITY/TRACTION CONTROL LIGHT COMES ON. VERY SCARY/DANGEROUS SITUATION. I AM USUALLY ABLE WRESTLE IT TO SIDE OF ROAD WITHOUT ANY POWER STEERING OR POWER BRAKES. AFTER GETTING THE VAN TO A STOP AND SHUTTING OFF THE IGNITION, THE VAN WIL…
Read full complaint
WHILE DRIVING DOWN THE ROAD THE CAR LOSES COMPLETE POWER--STEERING, BRAKES. ELECTRONIC STABILITY/TRACTION CONTROL LIGHT COMES ON. VERY SCARY/DANGEROUS SITUATION. I AM USUALLY ABLE WRESTLE IT TO SIDE OF ROAD WITHOUT ANY POWER STEERING OR POWER BRAKES. AFTER GETTING THE VAN TO A STOP AND SHUTTING OFF THE IGNITION, THE VAN WILL FIRE RIGHT UP AND NOT HAVE ANY PROBLEMS FOR A FEW DAYS. THEN IT HAPPENS AGAIN. I HAVE HAD IT IN THE SHOP NUMEROUS TIMES TO TRY AND DIAGNOSIS. NO LUCK.....I'VE REPLACED BATTERIES, WHEEL BEARINGS, YOU NAME IT. ANY ADVICE?????? *TR
ELECTRONIC STABILITY CONTROL TURNS ITSELF OFF AND ON AT RANDOM. WARNING LIGHT ESP/BAS ILLUMINATES AND ESP IS TURNED OFF AUTOMATICALLY. THIS LIGHT TURNS ON AND OFF AT SEEMINGLY RANDOM TIMES. DEALER IS NOT SURE WHY WANTS TO CHARGE ME TO START CHANGING PARTS IT IS NOT SURE ARE BROKEN. *TR
Official recalls
820V396000 · Air Bags:frontal:driver Side:inflator Module; Steering: Steering Wheel/handle Bar
Jul 7, 2020
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence & remedy
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Steering: Steering Wheel/handle Bar
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
16V047000 · Air Bags:frontal
Jan 29, 2016
FCA US LLC (Chrysler) is recalling certain model year 2009 Dodge Journey vehicles manufactured December 31, 2007, to August 31, 2008, 2008-2009 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured June 18, 2007, to August 31, 2008. In the affected vehicles, the air bag control units may corrode and fail.
Consequence & remedy
Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began on December 6, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S07.
14V373000 · Air Bags; Electrical System:ignition:switch
Jun 26, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
14V055000 · SUSPENSION:REAR:AXLE:NON-POWERED Axle Assembly
Feb 11, 2014
Freedom Motors Inc., (Freedom Motors) of Savaria Vehicle Group (formerly The Liberty Motor Company) is recalling one model year 2009 Volkswagen Routan and certain model year 2008-2010 Dodge Grand Caravan and Chrysler Town & Country wheelchair accessible vehicles modified by The Liberty Motor Company from February 2008 through January 2011. Over time and with use, the vehicle's rear axle may develop cracks which could lead to axle failure.
Consequence & remedy
Consequence: Failure of the rear axle may increase the risk of a crash.
Remedy: Freedom Motors will notify owners, and dealers will replace the affected axles, free of charge. The recall began on April 1, 2014. Owners can contact Freedom Motors at 1-800-561-9600. Freedom Motors' number for this recall is ENGF0216-3.
11V394000 · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Equipment:appliance:air Conditioner
Aug 3, 2011
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence & remedy
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (3)
Equipment:appliance:air Conditioner
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags:frontal:sensor/control MODULE-INACTIVE
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags:frontal
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
10V611000 · Equipment:appliance:air Conditioner
Dec 8, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES. THESE VEHICLES MAY EXPERIENCE A WATER LEAK At THE HEATING AND AIR CONDITIONER (HVAC) DRAIN GROMMET WHICH CAN LEAD TO ILLUMINATION OF AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT.
Consequence & remedy
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE HVAC DRAIN GROMMET FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
10V235000 · Electrical System:wiring
Jun 3, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY PASSENGER VEHICLES MANUFACTURED FROM FEBRUARY 2007 THROUGH SEPTEMBER 2009. SOME OF THE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPERLY ROUTED WIRE HARNESS THAT MAY HAVE A CONDITION WHERE THE LOWER SLIDING DOOR HINGE BRACKET CAN MAKE CONTACT AND WEAR THROUGH THE WIRE INSULATION.
Consequence & remedy
Consequence: A SHORT CIRCUIT COULD OCCUR INSIDE THE SLIDING DOOR, OVERHEATING THE LATCH, POSSIBLY RESULTING IN A FIRE.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT CHRYSLER TOLL-FREE AT 1-800-853-1403.
09V351000 · Service Brakes, Hydraulic
Sep 11, 2009
ELDORADO NATIONAL IS RECALLING MODEL YEAR 2008-2009 AMERIVAN MOBILITY VEHICLES BUILT ON CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN PLATFORMS VEHICLES. THE REAR BRAKE LINES MAY HAVE BEEN IMPROPERLY ROUTED AND NOT SECURED PROPERLY DURING THE ALTERATION. IF NOT ROUTED AND SECURED PROPERLY, THE BRAKE LINES COULD RUB AGAINST THE VEHICLE CAUSING A BRAKE FLUID LEAK.
Consequence & remedy
Consequence: A BRAKE FLUID LEAK COULD RESULT IN A LOSS OF BRAKING ABILITY, POSSIBLY CAUSING A CRASH.
Remedy: ELDORADO NATIONAL AMERIVAN DEALERS WILL INSPECT THE VEHICLES AND IF THE BRAKE LINES WERE IMPROPERLY ROUTED THEY WILL BE CORRECTLY REINSTALLED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 13, 2009. OWNERS MAY CONTACT ELDORADO NATIONAL AT 1-800-955-9086. THESE MINIVANS HAVE BEEN ALTERED INTO WHEELCHAIR ACCESSIBLE VEHICLES BY ELDORADO. THIS RECALL IS NOT BEING CONDUCTED BY CHRYSLER GROUP LLC AND WILL NOT BE PERFORMED AT NO COST BY DODGE OR CHRYSLER DEALERS UNLESS THEY ARE ALSO AN ELDORADO NATIONAL DEALER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972