NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
815 reportsClear category filter127,600 miles · Jan 19, 2018
Electrical SystemExterior LightingVisibility/wiper
WHILE PARKED IN DRIVEWAY, THE HORN STARTED BLOWING ERRATICALLY, HEADLIGHTS WERE ON, AND FRONT AND REAR WINDSHIELD WIPERS AND WASHERS OPERATING. DOOR LOCKS WOULD NOT RESPOND TO REMOTE. AFTER S SHORT PERIOD OF TRYING TO UNLOCK THE DOORS WITH THE REMOTE, THEY EITHER RESPONDED TO THE REMOTE OR UNLOCKED BY THEMSELVES. AT THAT POINT I…
Read full complaint
WHILE PARKED IN DRIVEWAY, THE HORN STARTED BLOWING ERRATICALLY, HEADLIGHTS WERE ON, AND FRONT AND REAR WINDSHIELD WIPERS AND WASHERS OPERATING. DOOR LOCKS WOULD NOT RESPOND TO REMOTE. AFTER S SHORT PERIOD OF TRYING TO UNLOCK THE DOORS WITH THE REMOTE, THEY EITHER RESPONDED TO THE REMOTE OR UNLOCKED BY THEMSELVES. AT THAT POINT I ATTEMPTED TO TURN THE IGNITION ON AND START THE VEHICLE. I STARTED IT AND THEN TURNED IT OFF BUT THAT DID NOT STOP THE HORN, WIPERS, ETC. A FEW SECONDS AFTER SHUTTING THE IGNITION OFF, EVERYTHING STOPPED. FRONT AND REAR WIPERS DID NOT RETURN TO PARK POSITION UNTIL I MANUALLY TURNED THEM ON AND OFF. I STARTED THE ENGINE AGAIN AND HAD A CHECK ENGINE LIGHT WITH ERROR CODES RELATED TO THE TCM, TRANSMISSION CONTROL MODULE. IN ADDITION, WHILE DRIVING, THE HEATER BLOWER MOTOR INTERMITTENTLY STOPS WORKING. ALL OF THIS APPEARS TO BE THE RESULT OF A FAULTY TIPM,TOTALLY INTEGRATED POWER MODULE. THIS HAS HAPPENED TWICE IN THE LAST TWO WEEKS. FIRST OCCURRENCE WAS 1/11/18 AND SECOND OCCURRENCE WAS 1/16/18. SEARCHING ONLINE REVEALED THAT MINE IS NOT AN ISOLATED PROBLEM AS THERE ARE MANY REPORTED INSTANCES OF TIPM FAILURES WITH SIMILAR SYMPTOMS.
NHTSA ODI #11063674
175,000 miles · Jan 11, 2018
Air BagsElectrical SystemExterior Lighting
ALL THE CODE LIGHT FLASHING ON THE DASHBOARD, WIPER AUTOMATICALLY COME ON, SPEEDOMETER CUTS DOWN TO 0 WHEN DRIVING, DRIVER SIDE WINDOWS WOULDN'T ROLL DOWN OR THE LOCK SWITCH WOULDN'T UNLOCK DOORS, LIGHTS FLICKER ON AND OFF WHILE THEY ARE SHUT OFF, IF LIGHTS ON CAN'T USE BRIGHT LIGHT THEY CUT OUT WHEN ALL THE CODE LIGHT FLICKER O…
Read full complaint
ALL THE CODE LIGHT FLASHING ON THE DASHBOARD, WIPER AUTOMATICALLY COME ON, SPEEDOMETER CUTS DOWN TO 0 WHEN DRIVING, DRIVER SIDE WINDOWS WOULDN'T ROLL DOWN OR THE LOCK SWITCH WOULDN'T UNLOCK DOORS, LIGHTS FLICKER ON AND OFF WHILE THEY ARE SHUT OFF, IF LIGHTS ON CAN'T USE BRIGHT LIGHT THEY CUT OUT WHEN ALL THE CODE LIGHT FLICKER ON. LIKE IT SHORTING OUT. IT DOES THIS SITTING STILL OR IN MOTION. HAPPENS WHEN I AM DRIVING OR SITTING IN A PARKING LOT
NHTSA ODI #11062293
125,000 miles · Jan 4, 2018
Electrical SystemEngineVisibility/wiper
I WAS DRIVING ON A BUSY MAIN CITY ROAD AT NIGHT, TRAVELING AROUND 35 MPH WHEN MY VAN SHUT OFF AND THE WIPERS AND HORN WENT CRAZY. I LOST ALL POWER STEERING AND BRAKES. HEADLIGHTS ALSO CUT OUT. I STRUGGLED TO GET TO THE SIDE OF THE ROAD AND INTO A PARKING LOT. THE FRONT WIPERS STOPPED WHEN I TURNED THE KEY OFF, BUT THE BACK W…
Read full complaint
I WAS DRIVING ON A BUSY MAIN CITY ROAD AT NIGHT, TRAVELING AROUND 35 MPH WHEN MY VAN SHUT OFF AND THE WIPERS AND HORN WENT CRAZY. I LOST ALL POWER STEERING AND BRAKES. HEADLIGHTS ALSO CUT OUT. I STRUGGLED TO GET TO THE SIDE OF THE ROAD AND INTO A PARKING LOT. THE FRONT WIPERS STOPPED WHEN I TURNED THE KEY OFF, BUT THE BACK WIPER AND HORN CONTINUED FOR ABOUT 10 MIN. I DID NOT HAVE TOOLS TO DISCONNECT THE BATTERY. SUDDENLY THERE WAS A FLASH OF ALL THE LIGHTS IN THE CAR AND EVERYTHING SEEMED TO BE BACK TO NORMAL WITH THE EXCEPTION OF THE CHECK ENGINE LIGHT APPEARING ON THE DASH. I WAS ABLE TO RESTART THE VEHICLE AND DRIVE ANOTHER HALF MILE TO MY HOME. THIS IS THE FIRST TIME THIS HAS HAPPENED WHILE DRIVING, THAT I HAVE LOST ALL ENGINE POWER AND STEERING, IT IS NOT THE FIRST TIME THE VAN HAS ACTED OUT. WIPERS WILL SUDDENLY START MOVING WHEN I AM DRIVING OR THE HORN WITH SUDDENLY SOUND AND RADIO WILL CUT OUT. I HAVE ALSO HAD IT GO CRAZY WITH WINDSHIELD WIPERS MOVING, HORN HONKING, LOCKS MALFUNCTIONING AND FLUID SPRAYED ALL OVER THE CAR WHEN I UNLOCKED IT. MY WIFE ONCE HAD MY KIDS TRAPPED INSIDE OF THE CARE FOR 10 MINS UNTIL I COULD I DRIVE OVER AND DISCONNECTED THE BATTERY. I HAVE BEEN TOLD IT IS THE TIPM ACTING UP. IT HAS HAPPENED MORE THAN 10 TIMES. I DO NOT TRUST THE VEHICLE. I HAVE READ ABOUT MANY MORE INSTANCES ONLINE. THIS COULD CAUSE AN ACCIDENT IF IT WAS IN RUSH HOUR OR ON A BUSIER ROAD.
NHTSA ODI #11058601
Mileage unknown · Sep 27, 2017
Air BagsElectrical System
TL* THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V373000 (ELECTRICAL SYSTEM, AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. ON SEVERAL OCCASIONS, THE…
Read full complaint
TL* THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V373000 (ELECTRICAL SYSTEM, AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. ON SEVERAL OCCASIONS, THE CONTACT CALLED PORT CITY CHRYSLER DODGE AT (888) 496-5156 (155 GREENLEAF AVE, PORTSMOUTH, NH 03801) WHERE IT WAS CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #11030172
163,000 miles · Sep 1, 2017
Electrical SystemEngine
IN JUNE HAD THE TIPM REPLACED AS IT WAS CAUSING THE HORN TO GO OFF AND STAY ON, THE WIPERS TO GO OFF AND STAY ON AND OTHER ELECTICAL ISSUES. THESE SYMPTOMS RETURNED IN THE LAST MONTH (I WAS TRAVELING DURING THE RETURN OF THE ISSUES) AND THIS TIME, ABOUT TWO WEEKS AGO, WHILE DOING 55MPH DOWN A SECONDARY HIGHWAY, THE CAR'S HORN …
Read full complaint
IN JUNE HAD THE TIPM REPLACED AS IT WAS CAUSING THE HORN TO GO OFF AND STAY ON, THE WIPERS TO GO OFF AND STAY ON AND OTHER ELECTICAL ISSUES. THESE SYMPTOMS RETURNED IN THE LAST MONTH (I WAS TRAVELING DURING THE RETURN OF THE ISSUES) AND THIS TIME, ABOUT TWO WEEKS AGO, WHILE DOING 55MPH DOWN A SECONDARY HIGHWAY, THE CAR'S HORN AND WIPERS CAME ON AND THE CAR COMPLETELY SHUT OFF - THE ENGINE SHUT DOWN. THE DEALER REPLACED THE TIPM AGAIN.
NHTSA ODI #11021070
208,047 miles · Aug 31, 2017
Air BagsElectrical SystemUnknown Or Other
TOOK MY VAN INTO JEFF WYLER EASTGATE AUTO MALL, IN BATAVIA, OH 45103, TO HAVE THE TWO RECALLS FIXED ON MY VAN AND WHEN I CALL TO CHECK UP ON THE PROGRESS I GET TOLD THAT THE TIPM NEEDS REPLACED AND THEY ARE WANTING TO CHARGE ME $1,337.60 TO FIX IT BEFORE THEY WILL EVEN BE ABLE TO FIX MY RECALLS. BOTH RECALLS ARE THE IGNITION AND…
Read full complaint
TOOK MY VAN INTO JEFF WYLER EASTGATE AUTO MALL, IN BATAVIA, OH 45103, TO HAVE THE TWO RECALLS FIXED ON MY VAN AND WHEN I CALL TO CHECK UP ON THE PROGRESS I GET TOLD THAT THE TIPM NEEDS REPLACED AND THEY ARE WANTING TO CHARGE ME $1,337.60 TO FIX IT BEFORE THEY WILL EVEN BE ABLE TO FIX MY RECALLS. BOTH RECALLS ARE THE IGNITION AND THE AIR BAGS, BOTH OF WHICH ARE CAUSED BY THE FAULTY TIPM. SO WHAT ARE THEY REPAIRING AND REPLACING ON MY RECALLS KNOWING THAT THE TIPM IS THE MAIN REASON MY VAN HAS RECALLS TO BEGIN WITH. THE RECALL FOR MY AIR BAGS IS AS FOLLOWS: THE AIRBAGS WILL EITHER DEPLOY AT WILL OR NOT DEPLOY AT ALL. THE LETTER I GOT INFORMING ME OF MY RECALLS STATED THAT IT COULD BE IN THE WIRING HARNESS OR OTHER PLACES CONNECTING MY VAN TO THE AIRBAGS. THE RECALL FOR MY IGNITION IS AS FOLLOWS: THE AIRBAGS WILL EITHER DEPLOY AT WILL OR NOT DEPLOY AT ALL. THE LETTER I GOT INFORMING ME OF MY RECALLS STATED THAT IT COULD BE IN THE WIRING HARNESS OR OTHER PLACES CONNECTING MY VAN TO THE IGNITION.
NHTSA ODI #11020989
85,000 miles · Aug 7, 2017
Electrical System
TL* THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. WHILE DRIVING ON SEVERAL OCCASIONS, THE HORN SOUNDED INDEPENDENTLY, THE HEADLIGHTS FLICKERED ON AND OFF, THE WINDSHIELD WIPERS OPERATED INDEPENDENTLY, AND THE RADIO INCREASED IN VOLUME INDEPENDENTLY. IN ADDITION, THE VEHICLE STALLED AND WAS TOWED TO SEAVIEW DODGE (LOCATED AT 810 N…
Read full complaint
TL* THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. WHILE DRIVING ON SEVERAL OCCASIONS, THE HORN SOUNDED INDEPENDENTLY, THE HEADLIGHTS FLICKERED ON AND OFF, THE WINDSHIELD WIPERS OPERATED INDEPENDENTLY, AND THE RADIO INCREASED IN VOLUME INDEPENDENTLY. IN ADDITION, THE VEHICLE STALLED AND WAS TOWED TO SEAVIEW DODGE (LOCATED AT 810 NJ-35, OCEAN TOWNSHIP, NJ 07712, (888) 382-6788) TO BE DIAGNOSED. THE MECHANIC WAS NOT ABLE TO DUPLICATE THE ISSUE OR RETRIEVE A FAULT CODE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED CASE NUMBER: 32145138. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.
NHTSA ODI #11013374
Mileage unknown · Jul 29, 2017
Electrical SystemElectronic Stability Control (esc)Visibility/wiper
SEVERAL TIMES THE HORN BEGAN SOUNDING A LONG BLARE, THE WINDSHIELD WIPERS CAME ON, THE WASHER FLUID STARTED SPRAYING, THE DOORS LOCKED, AND THE HEADLIGHTS AND REAR LIGHTS BEGAN FLASHING, ALL LASTING SEVERAL MINUTES. IT BEGAN WHILE DRIVING AND CONTINUED AFTER I STOPPED THE CAR, TURNED IT OFF, AND REMOVED THE KEY. THE SYMPTOMS WOR…
Read full complaint
SEVERAL TIMES THE HORN BEGAN SOUNDING A LONG BLARE, THE WINDSHIELD WIPERS CAME ON, THE WASHER FLUID STARTED SPRAYING, THE DOORS LOCKED, AND THE HEADLIGHTS AND REAR LIGHTS BEGAN FLASHING, ALL LASTING SEVERAL MINUTES. IT BEGAN WHILE DRIVING AND CONTINUED AFTER I STOPPED THE CAR, TURNED IT OFF, AND REMOVED THE KEY. THE SYMPTOMS WORSENED ABOUT A WEEK LATER WHEN ALL OF THE ABOVE HAPPENED AS WELL AS THE GEAR SHIFT INDICATOR LIGHTS BEGAN FLASHING, THE STABILITY CONTROL LIGHT CAME ON, THE CHECK ENGINE LIGHT CAME ON, THE BAS LIGHT CAME ON, AND THEN THE CAR SHIFTED ITSELF INTO NEUTRAL. THIS HAS HAPPENED SEVERAL TIMES AND HAS BECOME MORE FREQUENT.
NHTSA ODI #11011489
89,000 miles · Jul 27, 2017
Electrical System
I RECEIVED THE RECALL IN THE MAIL AND WENT TO THE DODGE DEALER OVER A YEAR AGO AND NEVER HEARD A THING FROM THEM AGAIN. RECALL R03 / NHTSA 14V-373. SOMETIMES I HAVE TO PUT THE VAN IN NETURAL TO START THE VAN. IT STOPPED ON ME WHILE I WAS OUT (PARKED) AND FIRESTONE ADVISED ME TO START THE VAN THIS WAY BECAUSE NOTHING WAS WRONG OT…
Read full complaint
I RECEIVED THE RECALL IN THE MAIL AND WENT TO THE DODGE DEALER OVER A YEAR AGO AND NEVER HEARD A THING FROM THEM AGAIN. RECALL R03 / NHTSA 14V-373. SOMETIMES I HAVE TO PUT THE VAN IN NETURAL TO START THE VAN. IT STOPPED ON ME WHILE I WAS OUT (PARKED) AND FIRESTONE ADVISED ME TO START THE VAN THIS WAY BECAUSE NOTHING WAS WRONG OTHERWISE. SOMETIMES MY REAR WINDOW WILL CLOSE ITSELF.
NHTSA ODI #11011090
137,500 miles · Jun 26, 2017
Electrical System
DRIVING, PARKED, STARTING, AND ON ITS OWN SITTING IN GARAGE. THE ELECTRICAL SYSTEM GOES CRAZY INTERMITENTLY. HORN, WIPERS (FRONT AND REAR), DOOR LOCKS, AND WIPER FLUID ENGAGE. WHILE DRIVING THE POWER STEERING AND BRAKES FAIL. VERY DANGEROUS PROBLEM AND NEEDS ATTENTION WITH THE AMOUNT OF COMPLAINTS I AM SEEING ON THE INTERN…
Read full complaint
DRIVING, PARKED, STARTING, AND ON ITS OWN SITTING IN GARAGE. THE ELECTRICAL SYSTEM GOES CRAZY INTERMITENTLY. HORN, WIPERS (FRONT AND REAR), DOOR LOCKS, AND WIPER FLUID ENGAGE. WHILE DRIVING THE POWER STEERING AND BRAKES FAIL. VERY DANGEROUS PROBLEM AND NEEDS ATTENTION WITH THE AMOUNT OF COMPLAINTS I AM SEEING ON THE INTERNET ON FORUMS FOR THIS MODEL OF VAN.
NHTSA ODI #11001452
Official recalls
8Jul 7, 2020
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence & remedy
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Steering: Steering Wheel/handle Bar
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Jan 29, 2016
FCA US LLC (Chrysler) is recalling certain model year 2009 Dodge Journey vehicles manufactured December 31, 2007, to August 31, 2008, 2008-2009 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured June 18, 2007, to August 31, 2008. In the affected vehicles, the air bag control units may corrode and fail.
Consequence & remedy
Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began on December 6, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S07.
Jun 26, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Feb 11, 2014
Freedom Motors Inc., (Freedom Motors) of Savaria Vehicle Group (formerly The Liberty Motor Company) is recalling one model year 2009 Volkswagen Routan and certain model year 2008-2010 Dodge Grand Caravan and Chrysler Town & Country wheelchair accessible vehicles modified by The Liberty Motor Company from February 2008 through January 2011. Over time and with use, the vehicle's rear axle may develop cracks which could lead to axle failure.
Consequence & remedy
Consequence: Failure of the rear axle may increase the risk of a crash.
Remedy: Freedom Motors will notify owners, and dealers will replace the affected axles, free of charge. The recall began on April 1, 2014. Owners can contact Freedom Motors at 1-800-561-9600. Freedom Motors' number for this recall is ENGF0216-3.
Aug 3, 2011
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence & remedy
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (3)
Equipment:appliance:air Conditioner
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags:frontal:sensor/control MODULE-INACTIVE
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags:frontal
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Dec 8, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES. THESE VEHICLES MAY EXPERIENCE A WATER LEAK At THE HEATING AND AIR CONDITIONER (HVAC) DRAIN GROMMET WHICH CAN LEAD TO ILLUMINATION OF AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT.
Consequence & remedy
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE HVAC DRAIN GROMMET FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Jun 3, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY PASSENGER VEHICLES MANUFACTURED FROM FEBRUARY 2007 THROUGH SEPTEMBER 2009. SOME OF THE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPERLY ROUTED WIRE HARNESS THAT MAY HAVE A CONDITION WHERE THE LOWER SLIDING DOOR HINGE BRACKET CAN MAKE CONTACT AND WEAR THROUGH THE WIRE INSULATION.
Consequence & remedy
Consequence: A SHORT CIRCUIT COULD OCCUR INSIDE THE SLIDING DOOR, OVERHEATING THE LATCH, POSSIBLY RESULTING IN A FIRE.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT CHRYSLER TOLL-FREE AT 1-800-853-1403.
Sep 11, 2009
ELDORADO NATIONAL IS RECALLING MODEL YEAR 2008-2009 AMERIVAN MOBILITY VEHICLES BUILT ON CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN PLATFORMS VEHICLES. THE REAR BRAKE LINES MAY HAVE BEEN IMPROPERLY ROUTED AND NOT SECURED PROPERLY DURING THE ALTERATION. IF NOT ROUTED AND SECURED PROPERLY, THE BRAKE LINES COULD RUB AGAINST THE VEHICLE CAUSING A BRAKE FLUID LEAK.
Consequence & remedy
Consequence: A BRAKE FLUID LEAK COULD RESULT IN A LOSS OF BRAKING ABILITY, POSSIBLY CAUSING A CRASH.
Remedy: ELDORADO NATIONAL AMERIVAN DEALERS WILL INSPECT THE VEHICLES AND IF THE BRAKE LINES WERE IMPROPERLY ROUTED THEY WILL BE CORRECTLY REINSTALLED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 13, 2009. OWNERS MAY CONTACT ELDORADO NATIONAL AT 1-800-955-9086. THESE MINIVANS HAVE BEEN ALTERED INTO WHEELCHAIR ACCESSIBLE VEHICLES BY ELDORADO. THIS RECALL IS NOT BEING CONDUCTED BY CHRYSLER GROUP LLC AND WILL NOT BE PERFORMED AT NO COST BY DODGE OR CHRYSLER DEALERS UNLESS THEY ARE ALSO AN ELDORADO NATIONAL DEALER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Illustration