IllustrationDRIVER SIDE SLIDING DOOR STUCK IN LOCKED POSITION. UNABLE TO UNLOCK USING DOOR LOCK SWITCH, UPPER CONSOLE DOOR SWITCH, KEY FOB OR MANUALLY. PASSENGER STUCK AND HAD TO CRAWL OUT DIFFERENT DOOR.
2006 Dodge Grand Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2006 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
310–25K
6525–50K
5850–75K
4575–100K
40100–150K
16150K+
255 reports with mileage · 29 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 54 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports3 fire reports17 injury reports
Structure complaints
36 reportsSLIDING DOOR LOCK ACTUATOR FROZE UP. THIS RENDERS THE SLIDING DOOR COMPLETELY INOPERABLE. IF THAT DOOR WAS NEEDED FOREGRESS, IT WOULDN'T BE AVAILABLE.
*TAKATA RECALLS" MY SLIDING SIDE DOORS ON BOTH SIDES SCRATCHES THE SIDES OF MY VAN ON THE EXTERIOR.
RUSTING BODY PANELS CAN RESULT IN SEVERE SAFETY ISSUES IN NEAR FUTURE, EVEN WITH GREAT CARE, SOME VEHICLES ARE PRONE TO THE RUSTING BODY PANELS. THE 4TH GENERATION (GRAND) CARAVAN ISN'T THE EXCEPTION WHICH HAD EXCESSIVELY AGGRESSIVE RUST FORMING ON THE BODY PANELS. MY GRAND CARAVAN CURRENTLY HAS JUST OVER 65000 MILES WITH RUST F…
Read full complaint
RUSTING BODY PANELS CAN RESULT IN SEVERE SAFETY ISSUES IN NEAR FUTURE, EVEN WITH GREAT CARE, SOME VEHICLES ARE PRONE TO THE RUSTING BODY PANELS. THE 4TH GENERATION (GRAND) CARAVAN ISN'T THE EXCEPTION WHICH HAD EXCESSIVELY AGGRESSIVE RUST FORMING ON THE BODY PANELS. MY GRAND CARAVAN CURRENTLY HAS JUST OVER 65000 MILES WITH RUST FORMING ON MAJOR PANELS. I PERSONALLY TOOK OVERLY ATTENTION TO THE VEHICLE MAINTAINING AND CARING BY WAXING AND WASHING THE VEHICLE THE PROPER WAY, YET THE VEHICLE IS PILING WITH MORE AND MORE RUST EACH WEEK. ON THE ROAD, I HAVEN'T GOT TO SEE THE DODGE CARAVAN THAT HAS NO RUST WHAT SO EVER. THEREFORE, THE RUSTING HAS TO BE THE MOST CONCERNING ISSUE FOR THE CARAVAN OWNERS.
WAS DRIVING ABOUT 35 MPH AND SLIDING DOOR CAME OPEN WHILE THE CAR WAS IN MOTION AND DOORS WERE LOCKED AND CHILD LOCK WAS ENGAGED ON THAT SIDE. IT HAS ALSO HAPPENED ON THE PASSENGER SIDE AS WELL ON THE INTERSTATE AT HIGHWAY SPEEDS.
TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING AT AN UNKNOWN SPEED, BOTH REAR SLIDING DOORS OPENED INDEPENDENTLY. THE CONTACT STOPPED THE VEHICLE AND MANUALLY CLOSED THE DOORS. WHILE PARKED, THE REAR SLIDING DOORS CLOSED INDEPENDENTLY AND HAD TO BE FORCED OPEN. THE VEHICLE WAS TAKEN TO A DEALER AND DIAGNOSED THE …
Read full complaint
TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING AT AN UNKNOWN SPEED, BOTH REAR SLIDING DOORS OPENED INDEPENDENTLY. THE CONTACT STOPPED THE VEHICLE AND MANUALLY CLOSED THE DOORS. WHILE PARKED, THE REAR SLIDING DOORS CLOSED INDEPENDENTLY AND HAD TO BE FORCED OPEN. THE VEHICLE WAS TAKEN TO A DEALER AND DIAGNOSED THE CAUSE OF FAILURE AS ELECTRICAL. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000. MA 08/11/15 THE CONSUMER STATED THE FAILURE CAUSES PHYSICAL PAIN AND ANXIETY TO OCCUPANTS. THE DOORS WOULD LOCK CHILDREN INSIDE THE VEHICLE. THE INTERIOR LIGHTS AND RADIO WOULD NOT OPERATE. THE VEHICLE WOULD ALSO SHAKE VIOLENTLY. UPDATED 8/14/15 *JS UPDATED 09/03/15*LJ UPDATED 3/29/2016 *JS THE CONSUMER STATED SHE AS WELL AS HER CHILDREN HAVE BEEN SMASHED BY THE DOORS AND HER FAMILY HAS BEEN UNDER DOCTOR'S CARE SINCE THE VEHICLE WAS PURCHASED. UPDATED 04/05/16.*JB
COMING FROM A CHRISTIAN CAMP DRIVING ON THE 5 SOUTH IN CASTAIC LAKE THE REAR RIGHT TIRE PART OF THE OUTER LAYER CAME OFF THEN IT WENT FLAT THIS IS TIRES 215-75R 15.I SHOW TO FIRESTONE THE TIRE THEY DID NOT HONOR THE WARRANTY ,THEN I HAD TWO MORE TIRES BLOWN IT WAS A TOTAL OF THREE IN LESS THAN A YEAR. *TR
PASSENGER SIDE SLIDING DOOR WILL NOT LOCK BY REMOTE KEY. DRIVER SIDE SLIDING DOOR WILL NOT OPEN OR CLOSE BY REMOTE KEY OR INTERIOR CONSOLE KEY. I BELIEVE THE SYSTEM IS DEFECTIVE AND THAT SWITCHES ARE DEFECTIVE AS WELL. *TR
TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT ATTEMPTED TO OPEN THE PASSENGER SIDE SLIDING DOOR, BUT IT WOULD NOT OPEN WHEN THE REMOTE DOOR CONTROL WAS ACTIVATED. THE FAILURE OCCURRED FOR FOUR YEARS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 4…
Read full complaint
TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT ATTEMPTED TO OPEN THE PASSENGER SIDE SLIDING DOOR, BUT IT WOULD NOT OPEN WHEN THE REMOTE DOOR CONTROL WAS ACTIVATED. THE FAILURE OCCURRED FOR FOUR YEARS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 45,000.
I WAS DRIVING MY 2006 DODGE GRAND CARAVAN SE ON THE NIGHT OF I02/11/2014 WHEN A WRONG-WAY DRIVER HIT ME (HEAD ON COLLISION). SHE TURNED RIGHT TO GET GASOLINE (NOTE: NOT TO AVOID US, DID NOT KNOW SHE WAS GOING WRONG WAY UNTIL WE HIT HER), AND WE HIT HER SIDE DOOR, TIRE AREA, AND THE VEHICLE BOUNCED BACKWARDS. I HAD TO PUSH OFF TH…
Read full complaint
I WAS DRIVING MY 2006 DODGE GRAND CARAVAN SE ON THE NIGHT OF I02/11/2014 WHEN A WRONG-WAY DRIVER HIT ME (HEAD ON COLLISION). SHE TURNED RIGHT TO GET GASOLINE (NOTE: NOT TO AVOID US, DID NOT KNOW SHE WAS GOING WRONG WAY UNTIL WE HIT HER), AND WE HIT HER SIDE DOOR, TIRE AREA, AND THE VEHICLE BOUNCED BACKWARDS. I HAD TO PUSH OFF THE STEERING WHEEL TO PREVENT MY HEAD FROM GOING THRU THE WINDSHIELD, MY FATHER WHO WAS THE PASSENGER, HIT HIS ARM OFF THE DASHBOARD. THE AIR BAGS DID NOT DEPLOY, WHICH WAS THE ISSUE. THE MANUFACTURER WAS CONTACTED, THEY LOOKED AT THE CAR AND SAID NOTHING IS WRONG WITH IT AND THAT THE CAR WOULD HAVE TO BE CRUSHED FOR THE AIR BAGS TO DEPLOY, THE AIR BAGS HAVE BEEN RECALLED BEFORE, WHICH IS A CONCERN TO ME. WHEN LOOKING AT THE VEHICLE DASH BOARD, IT DOES NOT APPEAR THAT THERE IS EVEN A PASSENGER AIR BAG IN PLACE. MY BUMPER HAD DAMAGE, A LONG WITH MY HEAD LIGHT, ALONG WITH MY HOOD. I WAS TRAVELING ABOUT 40MPH IN A 45MPH ZONE, AS WE WERE SLOWING DOWN AT A RED LIGHT AND WHEN IT TURNED GREEN AGAIN I CONTINUED ON. WE HAD INJURIES OF OUR NECK AND BACK AS WELL AS THE DRIVERS LEFT FOOT, MY WRIST HURT FROM TIME TO TIME AND STILL SOMEWHAT DOES, FROM PUSHING OFF THE WHEEL.UPDATED 06/03/14 *BF UPDATED 06/06/2014 *JS
Official recalls
310V338000 · Seats
Jul 27, 2010
DRIVING SPECIALTIES LTD IS RECALLING 2 MODEL YEAR 2006 AND 2007 CONVERSION VANS EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THERE IS A POSSIBILITY OF A DEFECTIVE WELD AT THE JOINT BETWEEN THE PIVOTING PLATE AND THE PIVOTING PLATE PIN.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: DRIVING SPECIALTIES WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 28, 2010. OWNERS MAY CONTACT DRIVING SPECIALTIES AT 1-707-553-1515.
10V008000 · Air Bags:frontal:sensor/control MODULE-INACTIVE
Jan 11, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2005-2006 DODGE CARAVAN, GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, KANSAS, KENTUCKY, MASSACHUSETTS, MAINE, MARYLAND, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, ALASKA AND THE DISTRICT OF COLUMBIA. THE FRONT CRASH SENSORS MAY CRACK UNDER CERTAIN ENVIRONMENTAL CONDITIONS AND ALLOW WATER TO ENTER INTO THE SENSOR. THIS CAN CAUSE THE SENSOR TO BECOME INOPERATIVE AND ILLUMINATE THE AIRBAG WARNING LIGHT. THESE SENSORS WERE ADDED TO ENHANCE THE PERFORMANCE OF THE AIRBAG SYSTEM IN CERTAIN FRONTAL CRASHES.
Consequence & remedy
Consequence: IF THE FRONT CRASH SENSORS BECOME INOPERATIVE, THE DRIVER IS IMMEDIATELY ALERTED BY ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE VEHICLE SHOULD BE PROMPTLY SERVICED. UNTIL THE VEHICLE IS REPAIRED, THE AIRBAGS MAY NOT PROVIDE THE ENHANCED PROTECTION IN THE EVENT OF A CRASH.
Remedy: CHRYSLER WILL REPLACE THE FRONT AIRBAG SENSORS WITH A NEW DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY IMPROVEMENT CAMPAIGN WILL BEGIN DURING JUNE 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
06V067000 · Visibility:windshield Wiper/washer:motor
Mar 8, 2006
ON CERTAIN VANS AND SPORT UTILITY VEHICLES, THE FRONT WINDSHIELD WIPER MOTOR ARMATURE SHAFT MAY BREAK.
Consequence & remedy
Consequence: DURING CERTAIN OPERATING CONDITIONS, LOSS OF FRONT WINDSHIELD WIPING CAPABILITY COULD OCCUR, AND THE DRIVER'S VISION COULD BE OBSCURED WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE WINDSHIELD WIPER MOTOR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2006, TO DODGE DURANGO OWNERS. MINIVAN OWNERS WILL BE NOTIFIED DURING JULY 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5DP14002 · Engine Stall After Refueling
Opened Sep 5, 2014 · Closed Apr 6, 2015
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
This defect petition evaluates July 7, 2014 allegations from an owner of a model year (MY) 2007 Dodge Grand Caravan minivan that engine stall occurs in these vehicles without warning after refueling.The petitioner's vehicle is a Chrysler RS platform minivan.The RS platform includes MY 2003 through 2007 Dodge Grand Caravan, Dodge Caravan, Chrysler Town and Country and Chrysler Voyager minivans.NHTSA evaluated the petition by analyzing consumer complaints submitted to the Agency, analyzing field data, reviewing technical information provided in Chrysler's response to an Agency information request and testing an RS minivan identified by its owner as experiencing post-refuel engine stalls.After completing this evaluation, NHTSA has concluded that further investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists.The stalls occurring in these vehicles only occur immediately after filling up the fuel tank and happen at low engine speeds. The failure rate is low, even after 8 to 13 years of the vehicles being in service, and there are no reports of crashes or injuries resulting from the stall condition.In the Agency's view, additional investigation is unlikely to result in finding the existence of a safety-related defect in the subject vehicles.Given the need to allocate and prioritize NHTSA's limited resources to best accomplish the Agency's safety mission, the petition is denied.This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will take further action if warranted by future circumstances. More details concerning our review can be found in the Federal Register Notice for this action.The following 161 VOQs are included in the petition evaluation: 10209242, 10229468, 10240708, 10260923, 10275939, 10276532, 10296487, 10298175, 10328669, 10330144, 10346517, 10349789, 10354758, 10363689, 10372112, 10372368, 10372514, 10378031, 10379764, 10382938, 10387448, 10394063, 10398877, 10413918, 10418652, 10420924, 10427063, 10437525, 10445392, 10446902, 10470028, 10471249, 10473733, 10502231, 10503114, 10504260, 10509862, 10511988, 10512120, 10512385, 10512650, 10513147, 10538154, 10549841, 10551763, 10555188, 10555418, 10556754, 10565367, 10574012, 10574398, 10586555, 10587212, 10587559, 10593433, 10607841, 10607913, 10608922, 10615810, 10622468, 10628141, 10632112, 10632128, 10632172, 10632175, 10632231, 10632262, 10632266, 10632270, 10632305, 10632316, 10632326, 10632370, 10632385, 10632399, 10632492, 10632542, 10632765, 10632833, 10632928, 10633197, 10633281, 10633409, 10633421, 10633483, 10633507, 10637752, 10637804, 10637950, 10637975, 10638032, 10638289, 10638290, 10638401, 10638968, 10639218, 10639623, 10641157, 10641603, 10641614, 10641836, 10644339, 10644705, 10649713, 10649895, 10649932, 10650313, 10652590, 10653147, 10653783, 10654533, 10655226, 10658900, 10659679, 10660320, 10662588, 10662645, 10662662, 10663473, 10667056, 10667437, 10668081, 10668094, 10668131, 10668612, 10668969, 10668970, 10669584, 10669678, 10669729, 10669775, 10669866, 10669895, 10669992, 10670422, 10670506, 10676348, 10676732, 10677120, 10679795, 10679934, 10680057, 10680290, 10680342, 10680714, 10681512, 10682584, 10682906, 10683022, 10683114, 10683549, 10683620, 10683697, 10683743, 10689898, 10690761, 10691284, 10691556, 10691751, 10693061, 10694300
EA11010 · Loss Of Headlight Illumination
Opened Sep 6, 2011 · Closed Nov 29, 2012
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
Additional source detail variants (4)
Electrical System
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
Exterior Lighting
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
Exterior Lighting:headlights
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
Exterior Lighting:headlights:switch
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
RQ09003 · Front Air Bag Crash Sensor Failure
Opened Jul 1, 2009 · Closed Feb 18, 2010
Status: closed (inferred from source dates) · Air Bags:frontal; Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:sensor/control MODULE-INACTIVE
CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Air Bags:frontal
CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Air Bags:frontal:driver Side:inflator Module
CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Air Bags:frontal:sensor/control MODULE-INACTIVE
CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
EA06003 · Front Air Bag Crash Sensor Failure
Opened Mar 8, 2006 · Closed May 22, 2007
Status: closed (inferred from source dates) · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
DAIMLERCHRYSLER (DCC) WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 270,958 MY 2005 DAIMLERCHRYSLER MINIVANS (NHTSA RECALL NO. 07V-192).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH BRASS BUSHINGS AND WERE BUILT BETWEEN APRIL 24, 2003 AND FEBRUARY 2, 2005.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 133,128 MY 2005 MINIVANS, WILL RECEIVE A LIFETIME WARRANTY ON THE FRONT CRASH SENSORS.ALTHOUGH THESE VEHICLES USE THE SAME BRASS BUSHING SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.DCC WILL ALSO PROVIDE WRITTEN NOTIFICATION TO ALL AFFECTED VEHICLE OWNERS.NHTSA AND DCC DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, DCC IS IMPLEMENTING STEPS TO REPLACE THE SUBJECT COMPONENTS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Additional source detail variants (2)
Air Bags:frontal
DAIMLERCHRYSLER (DCC) WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 270,958 MY 2005 DAIMLERCHRYSLER MINIVANS (NHTSA RECALL NO. 07V-192).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH BRASS BUSHINGS AND WERE BUILT BETWEEN APRIL 24, 2003 AND FEBRUARY 2, 2005.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 133,128 MY 2005 MINIVANS, WILL RECEIVE A LIFETIME WARRANTY ON THE FRONT CRASH SENSORS.ALTHOUGH THESE VEHICLES USE THE SAME BRASS BUSHING SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.DCC WILL ALSO PROVIDE WRITTEN NOTIFICATION TO ALL AFFECTED VEHICLE OWNERS.NHTSA AND DCC DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, DCC IS IMPLEMENTING STEPS TO REPLACE THE SUBJECT COMPONENTS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Air Bags:frontal:sensor/control MODULE-INACTIVE
DAIMLERCHRYSLER (DCC) WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 270,958 MY 2005 DAIMLERCHRYSLER MINIVANS (NHTSA RECALL NO. 07V-192).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH BRASS BUSHINGS AND WERE BUILT BETWEEN APRIL 24, 2003 AND FEBRUARY 2, 2005.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 133,128 MY 2005 MINIVANS, WILL RECEIVE A LIFETIME WARRANTY ON THE FRONT CRASH SENSORS.ALTHOUGH THESE VEHICLES USE THE SAME BRASS BUSHING SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.DCC WILL ALSO PROVIDE WRITTEN NOTIFICATION TO ALL AFFECTED VEHICLE OWNERS.NHTSA AND DCC DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, DCC IS IMPLEMENTING STEPS TO REPLACE THE SUBJECT COMPONENTS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.