← New search

2006 Dodge Grand Caravan

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2006 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.

About this comparison →

When problems were reported

Mileage at the reported incident

255 reports with mileage · 29 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Steering. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Air Bags. Review the 54 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

12 crash reports3 fire reports17 injury reports

Steering complaints

61 reports
Clear category filter
51,000 miles · Dec 1, 2009
Steering

STEERING SYSTEM MAKES A LOUD HUMMING NOISE ALL OF THE TIME. VEHICLE HAS 51000 MILES ON IT, AND MY MECHANIC TOLD ME THE RACK AND PINION HAS TO BE REPLACED. I ASKED HOW HE COULD TELL WITHOUT LOOKING, AND HE TOLD ME THAT THIS IS WELL KNOWN PROBLEM, WITH THESE VEHICLES. *TR

NHTSA ODI #10294155

47,000 miles · Nov 23, 2009
Steering

WE BOUGHT ALMOST THREE YEARS AGO 2006 DODGE GRAND CARAVAN. RIGHT NOW IT ONLY HAS 47000 MILES. RECENTLY WE NOTICED A LEAK AND WE TOOK THE CAR FOR SERVICE & WE FOUND OUT THE POWER STEERING RACK IS BROKEN AND LEAKING OIL. WE THOUGHT IT WAS COVERED BY THE WARRANTY. BUT THE DEALER TOLD US IT WASN'T COVERED BY THE WARRANTY. THEY EST…

Read full complaint

WE BOUGHT ALMOST THREE YEARS AGO 2006 DODGE GRAND CARAVAN. RIGHT NOW IT ONLY HAS 47000 MILES. RECENTLY WE NOTICED A LEAK AND WE TOOK THE CAR FOR SERVICE & WE FOUND OUT THE POWER STEERING RACK IS BROKEN AND LEAKING OIL. WE THOUGHT IT WAS COVERED BY THE WARRANTY. BUT THE DEALER TOLD US IT WASN'T COVERED BY THE WARRANTY. THEY ESTIMATED THE COST AROUND $1300. WE CALLED CHRYSLER AND THEY FAILED TO HELP US. AFTER WE DID SOME SEARCH WE FOUND OUT SO MANY DODGE GRAND CARAVANS GETTING END UP BREAKING THE POWER STEERING RACK AT EARLY AGE. WE BELIEVE CHRYSLER NEED TO RECALL THIS AND FIX THE ISSUE. IT IS NOT FAIR FOR US WHEN OUR CAR HAS ONLY 47,000 MILES . *TR

NHTSA ODI #10293301

45,120 miles · Nov 17, 2009
Steering

MY 2006 DODGE GRAND CARAVAN HAS DEVELOPED A LOUD WHINING SOUND FROM UNDER THE HOOD AT A COLD START AND CONTINUING FOR SEVERAL MINUTES. THE NOISE IS PRESENT WHEN SITTING STILL WITH THE WHEELS STRAIGHT BUT GETS WORSE WHEN THE WHEEL IS TURNED. *TR

NHTSA ODI #10292636

4,300 miles · May 20, 2009
Engine And Engine CoolingEquipmentSteering

TL*THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE AIR CONDITIONER BECAME INOPERATIVE AND HAD TO BE REPLACED. THE POWER STEERING RACK ALSO HAD TO BE REPLACED DUE TO A LOUD GRINDING NOISE THAT WAS HEARD COMING FROM THE STEERING COLUMN. IN ADDITION, THE RADIATOR FANS WOULD OVERHEAT AND WERE REPLACED. T…

Read full complaint

TL*THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE AIR CONDITIONER BECAME INOPERATIVE AND HAD TO BE REPLACED. THE POWER STEERING RACK ALSO HAD TO BE REPLACED DUE TO A LOUD GRINDING NOISE THAT WAS HEARD COMING FROM THE STEERING COLUMN. IN ADDITION, THE RADIATOR FANS WOULD OVERHEAT AND WERE REPLACED. THE MANUFACTURER DID NOT ASSIST. THE FAILURE MILEAGE WAS 4,300 AND CURRENT MILEAGE WAS 58,000.

NHTSA ODI #10269473

49,628 miles · May 14, 2009
Steering

I GOT UP AND WENT OUT TO START THE VAN AND NOTICED A AWFUL WHINING SOUND I TOOK IT TO A GARAGE AND THEY TOLD ME THAT IT WAS THE RACK AND PINION I TOLD THEM I JUST BOUGHT THIS VAN.THEY TOLD ME TO TAKE IT BACK TO THE DEALER AND FIND OUT IF THERE IS A RECALL ON IT. HE SAID THIS IS A KNOWN PROBLEM FOR THIS VAN AND THE PART IS PROBAB…

Read full complaint

I GOT UP AND WENT OUT TO START THE VAN AND NOTICED A AWFUL WHINING SOUND I TOOK IT TO A GARAGE AND THEY TOLD ME THAT IT WAS THE RACK AND PINION I TOLD THEM I JUST BOUGHT THIS VAN.THEY TOLD ME TO TAKE IT BACK TO THE DEALER AND FIND OUT IF THERE IS A RECALL ON IT. HE SAID THIS IS A KNOWN PROBLEM FOR THIS VAN AND THE PART IS PROBABLY ON BACK ORDER. SO MY QUESTION IS IF IT KNOWN FOR THIS PROBLEM WHY WOULD A DEALER SELL ME THIS VAN KNOWING I HAVE A FAMILY OF SIX. I DID TAKE IT BACK TO THE DEALER IM STILL WAITING FOR THEM TO CALL ME BACK AND LET ME NOW WHAT'S GOING ON. SOUND LIKE A BIG LAW SUIT WAITING TO HAPPEN IF SOMETHING ISN'T DONE AND IT CAUSES A ACCIDENT. WHAT GETS ME IS THEY SOLD THIS VAN TO ME WITH THIS EXISTING PROBLEM. VAN WAS BOUGHT IN MARCH 2009 MILEAGE 49,628. THEY SHOULD HAVE TO START TELLING PEOPLE ABOUT RECALLS OR KNOWN PROBLEMS ON VEHICLES THEY ARE SELLING. *TR

NHTSA ODI #10268719

44,187 miles · Apr 28, 2009
Steering

RACK AND PINION LEAKING FLUID FROM RUBBER BOOT AND NEEDS REPLACED; MECHANIC SAID VERY COMMON PROBLEM FOR 2006 GRAND CARAVANS WITH OVER 40,000 MILES. HAS REPLACED MORE THAN HE CARES TO ADMIT. OF COURSE NO LONGER UNDER WARRANTY AND PART IS ON BACK ORDER? MUST REALLY HAPPEN ALOT WHEN THE PART IS ON BACK ORDER, MAYBE TIME FOR A…

Read full complaint

RACK AND PINION LEAKING FLUID FROM RUBBER BOOT AND NEEDS REPLACED; MECHANIC SAID VERY COMMON PROBLEM FOR 2006 GRAND CARAVANS WITH OVER 40,000 MILES. HAS REPLACED MORE THAN HE CARES TO ADMIT. OF COURSE NO LONGER UNDER WARRANTY AND PART IS ON BACK ORDER? MUST REALLY HAPPEN ALOT WHEN THE PART IS ON BACK ORDER, MAYBE TIME FOR A RECALL. *TR

NHTSA ODI #10267063

Mileage unknown · Apr 4, 2009
Steering

MAINTAINED OIL CHANGES & AT 14670 MI DID 15000 MILE SERVICE/MAINTENANCE KIT; 3/6/08-20565 MILES,LEAKING STEERING RACK, UNDER WARRANTY, GEAR ASSEMBLY POWER STEERING REPLACED & CHECKED BRAKES FOR NOISE BUT NO REPAIR OF THEM; 3/11/08-20740 MILES, SES LIGHT IS ON & JUST REPLACED RACK & PINION, CAUSE=LEAK DETECTION PUMP FAILURE,PUM…

Read full complaint

MAINTAINED OIL CHANGES & AT 14670 MI DID 15000 MILE SERVICE/MAINTENANCE KIT; 3/6/08-20565 MILES,LEAKING STEERING RACK, UNDER WARRANTY, GEAR ASSEMBLY POWER STEERING REPLACED & CHECKED BRAKES FOR NOISE BUT NO REPAIR OF THEM; 3/11/08-20740 MILES, SES LIGHT IS ON & JUST REPLACED RACK & PINION, CAUSE=LEAK DETECTION PUMP FAILURE,PUMP NATURAL VACUUM LEAK DETECTION, EMISSIONS,UNDER WARRANTY; 5/12/08-22282 MILES, CHECKED BRAKES FOR NOISE, REPLACED FRONT BRAKE PADS & ROTORS,I PAID & REFLASH FOR HARSH 1-2 @/OR 2-3 SHIFT SO REFLASHED PCM PER TSB 21-018-07 FOR HARSH SHIFT, NO CHARGE BUT DON'T KNOW IF IT WAS B/C OF WARRANTY; 9/09/08 25192 OIL CHANGE & ON 9/19/08 25562 MILES CK ENGINE LIGHT ON & VAN DIED TWICE WHILE DRIVING, CAUSE VALVE EXHAUST GAS RECIRCULATION CONTROL SO REPLACED EGR VALVE, COVERED UNDER WARRANTY; 10/13/08 26324 MILES, BRAKES SQUEAKING, CLEAN & ADJUSTED BRAKES; 10/31/08 26788 MILES,BREAKS SQUEAKING, REPLACED FRONT BRAKE PADS,UNDER WARRANTY; 1/13/09 28092 MILES REPLACED RIGHT FAULTY RIGHT SLIDING DOOR TRACK,UNDER WARRANTY; 2/2/09 28463 MILES REPLACED BATTERY B/C BATTERY FAILED VAT TEST & DID OIL CHANGE; 2/20/09 28945 MILES DID 30K SERVICE SAID WILL NEED REAR BRAKES SOON HAD NO CHOICE BUT TO GET THE EXTENDED WARRANTY DUE TO ALL THE TIME SPENT AT THE DEALER. REPORTED ALL PROBLEMS TO CHRYSLER BUT ALL THEY DID WAS NOTATE IT BUT DOESN'T APPEAR ARE GOING TO DO ANYTHING ABOUT ALL OF THE ISSUES I HAD. THEY SAID, WELL THE CAR WAS REPAIRED. NO ONE SHOULD HAVE TO BE AT A DEALER THIS MANY TIMES &SO FREQUENTLY ESPECIALLY SINCE I ONLY AVG OVER 9000 BUT LESS THAN 10000 A YR. 3/30/09 CAR TURNED OFF BY ITSELF AT STOP LIGHT, I TURNED IT ON, VAN SHOOK, GAS PEDAL WOULDN'T MOVE, TURNED ON &OFF A COUPLE OF TIMES &KEPT SHAKING &PEDAL WOULDN'T MOVE &THEN FINALLY IT STOPPED SHAKING& I DROVE OFF. I SET UP APPT & WAS SCH FOR 2 DAYS LATER BUT WAS ABLE TO DRIVE THE CAR SO I CANCELLED & WAS TOLD TO BRING IN IF HAPPENS AGAIN. APPROX INCIDENT DATE IS DATE OF 1ST ISSUE SINCE MULTIPLE ISSUES. *TR

NHTSA ODI #10264133

40,000 miles · Mar 11, 2009
Steering

TL*THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE WOULD MAKE A WHINING SOUND, ESPECIALLY IN COLDER TEMPERATURES, AND DISTRACT THE CONCENTRATION OF THE DRIVER. SHE STATED THAT THE NOISE WAS LOUD ENOUGH TO CAUSE A CONCERN. THE NOISE OCCURRED EVERY TIME THE VEHICLE WAS DRIVEN AND WOULD INTENSIFY…

Read full complaint

TL*THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE WOULD MAKE A WHINING SOUND, ESPECIALLY IN COLDER TEMPERATURES, AND DISTRACT THE CONCENTRATION OF THE DRIVER. SHE STATED THAT THE NOISE WAS LOUD ENOUGH TO CAUSE A CONCERN. THE NOISE OCCURRED EVERY TIME THE VEHICLE WAS DRIVEN AND WOULD INTENSIFY WHEN MAKING TURNS AT VARIOUS SPEEDS. SHE HAS SCHEDULED AN APPOINTMENT WITH THE DEALER, BUT HAS NOT NOTIFIED THE MANUFACTURER. THE CURRENT MILEAGE WAS APPROXIMATELY 50,000 AND FAILURE MILEAGE WAS APPROXIMATELY 40,000.

NHTSA ODI #10261522

42,300 miles · Feb 11, 2009
Steering

MY 2006 DODGE GRAND CARAVAN WITH ONLY 42,000 MILES HAS DEVELOPED A POWER STEERING FLUID LEAK. REPAIR SHOP SAYS STEERING RACK NEEDS TO BE REPLACED. HAVE NOT HAD THIS EXPENSIVE REPAIR DONE AS YET. SEEMS TO BE A UNIVERSAL CHRYSLER PROBLEM, NUMEROUS OTHER OWNERS OF SAME AUTOMOBILE HAVE INDICATED THE SAME PROBLEM. *TR

NHTSA ODI #10258376

24,500 miles · Oct 11, 2008
Steering

I SUBMITTED THIS COMPLAINT TO A LOCAL DEALERSHIP THAT SERVICED MY VEHICLE. I WORRY THAT THERE COULD BE A MAJOR SAFETY ISSUE. I OWN A 2006 DODGE GRAND CARAVAN SXT. IN THE PAST YEAR, I HAVE BROUGHT IT INTO DODGE CITY OF MILWAUKEE FOR TWO SERVICE APPOINTMENTS, ONE IN WINTER 2007 AND ANOTHER IN SPRING 2008. DURING BOTH VISITS,…

Read full complaint

I SUBMITTED THIS COMPLAINT TO A LOCAL DEALERSHIP THAT SERVICED MY VEHICLE. I WORRY THAT THERE COULD BE A MAJOR SAFETY ISSUE. I OWN A 2006 DODGE GRAND CARAVAN SXT. IN THE PAST YEAR, I HAVE BROUGHT IT INTO DODGE CITY OF MILWAUKEE FOR TWO SERVICE APPOINTMENTS, ONE IN WINTER 2007 AND ANOTHER IN SPRING 2008. DURING BOTH VISITS, I COMPLAINED OF AN PERSISTENT PROBLEM WITH THE STEERING SYSTEM. ON SHARP LEFT TURNS, THE VAN OFTEN MAKES A "PULSING" OR "HOWLING" SOUND. ON BOTH OCCASIONS, DODGE CITY OF MILWAUKEE FIXED SOMETHING IN THE STEERING SYSTEM, BUT THE SOUND NEVER WENT AWAY. EARLIER TODAY, AS I WAS PULLING INTO THE ALLEY BEHIND MY HOUSE, THE CAR'S STEERING SUDDENLY FROZE AND THE OIL LIGHT CAME ON. I AM NOT SURE OF THE REASON FOR THIS, BUT IF THERE HAD BEEN ANY TRAFFIC, OR IF I WAS TRAVELING AT A HIGH SPEED, THIS WOULD HAVE BEEN A MAJOR SAFETY HAZARD. I CHECKED THE OIL, WHICH WAS A BIT LOW BUT STILL IN THE NORMAL RANGE (I ALSO COMPLAINED ON BOTH VISITS THAT THE CAR LOSES OIL QUICKLY AND WAS ASSURED BY DODGE CITY OF MILWAUKEE THAT THIS IS NORMAL). I SHUT OFF THE CAR, TURNED IT ON AGAIN, AND IT SEEMED TO WORK NORMALLY. SINCE THE STEERING WAS AFFECTED, I STRONGLY SUSPECT THAT THIS INCIDENT IS SOMEHOW RELATED TO THE PROBLEM THAT YOUR TECHNICIANS NEGLIGENTLY FAILED TO ADDRESS. WHEN I PURCHASED A NEW DODGE VAN IN 2006 FOR MY FAMILY OF SIX, I NEVER IMAGINED THAT IT WOULD CAUSE ME TO FEAR FOR OUR SAFETY WITHIN TWO YEARS. THIS IS AN ENTIRELY UNACCEPTABLE SITUATION. I BELIEVE THAT IT IS LARGELY DUE TO THE FAILURE OF DODGE CITY OF MILWAUKEE'S SERVICE DEPARTMENT TO ADDRESS PROBLEMS THAT I REPEATEDLY MENTIONED. I AM COPYING MY LAWYER ON THIS MESSAGE, ALONG WITH THE WILDE DODGE SALESMAN WHO ORIGINALLY SOLD ME THE CAR, AND I ALSO PLAN TO INFORM THE NATIONAL CHRYSLER CUSTOMER SERVICE DEPARTMENT. IF THE PROBLEM WITH THIS CAR IS TOO OBSCURE TO IDENTIFY, THEN I SHOULD BE PROVIDED WITH A NEW VEHICLE THAT WILL NOT PUT MY FOUR SMALL CHILDREN AT RISK. *TR

NHTSA ODI #10245165

Official recalls

3

10V338000 · Seats

Jul 27, 2010

DRIVING SPECIALTIES LTD IS RECALLING 2 MODEL YEAR 2006 AND 2007 CONVERSION VANS EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THERE IS A POSSIBILITY OF A DEFECTIVE WELD AT THE JOINT BETWEEN THE PIVOTING PLATE AND THE PIVOTING PLATE PIN.

Consequence & remedy

Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.

Remedy: DRIVING SPECIALTIES WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 28, 2010. OWNERS MAY CONTACT DRIVING SPECIALTIES AT 1-707-553-1515.

10V008000 · Air Bags:frontal:sensor/control MODULE-INACTIVE

Jan 11, 2010

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2005-2006 DODGE CARAVAN, GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, KANSAS, KENTUCKY, MASSACHUSETTS, MAINE, MARYLAND, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, ALASKA AND THE DISTRICT OF COLUMBIA. THE FRONT CRASH SENSORS MAY CRACK UNDER CERTAIN ENVIRONMENTAL CONDITIONS AND ALLOW WATER TO ENTER INTO THE SENSOR. THIS CAN CAUSE THE SENSOR TO BECOME INOPERATIVE AND ILLUMINATE THE AIRBAG WARNING LIGHT. THESE SENSORS WERE ADDED TO ENHANCE THE PERFORMANCE OF THE AIRBAG SYSTEM IN CERTAIN FRONTAL CRASHES.

Consequence & remedy

Consequence: IF THE FRONT CRASH SENSORS BECOME INOPERATIVE, THE DRIVER IS IMMEDIATELY ALERTED BY ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE VEHICLE SHOULD BE PROMPTLY SERVICED. UNTIL THE VEHICLE IS REPAIRED, THE AIRBAGS MAY NOT PROVIDE THE ENHANCED PROTECTION IN THE EVENT OF A CRASH.

Remedy: CHRYSLER WILL REPLACE THE FRONT AIRBAG SENSORS WITH A NEW DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY IMPROVEMENT CAMPAIGN WILL BEGIN DURING JUNE 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

06V067000 · Visibility:windshield Wiper/washer:motor

Mar 8, 2006

ON CERTAIN VANS AND SPORT UTILITY VEHICLES, THE FRONT WINDSHIELD WIPER MOTOR ARMATURE SHAFT MAY BREAK.

Consequence & remedy

Consequence: DURING CERTAIN OPERATING CONDITIONS, LOSS OF FRONT WINDSHIELD WIPING CAPABILITY COULD OCCUR, AND THE DRIVER'S VISION COULD BE OBSCURED WHICH COULD RESULT IN A CRASH.

Remedy: DEALERS WILL INSPECT AND REPLACE THE WINDSHIELD WIPER MOTOR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2006, TO DODGE DURANGO OWNERS. MINIVAN OWNERS WILL BE NOTIFIED DURING JULY 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

5

DP14002 · Engine Stall After Refueling

Opened Sep 5, 2014 · Closed Apr 6, 2015

Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly

This defect petition evaluates July 7, 2014 allegations from an owner of a model year (MY) 2007 Dodge Grand Caravan minivan that engine stall occurs in these vehicles without warning after refueling.The petitioner's vehicle is a Chrysler RS platform minivan.The RS platform includes MY 2003 through 2007 Dodge Grand Caravan, Dodge Caravan, Chrysler Town and Country and Chrysler Voyager minivans.NHTSA evaluated the petition by analyzing consumer complaints submitted to the Agency, analyzing field data, reviewing technical information provided in Chrysler's response to an Agency information request and testing an RS minivan identified by its owner as experiencing post-refuel engine stalls.After completing this evaluation, NHTSA has concluded that further investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists.The stalls occurring in these vehicles only occur immediately after filling up the fuel tank and happen at low engine speeds. The failure rate is low, even after 8 to 13 years of the vehicles being in service, and there are no reports of crashes or injuries resulting from the stall condition.In the Agency's view, additional investigation is unlikely to result in finding the existence of a safety-related defect in the subject vehicles.Given the need to allocate and prioritize NHTSA's limited resources to best accomplish the Agency's safety mission, the petition is denied.This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will take further action if warranted by future circumstances. More details concerning our review can be found in the Federal Register Notice for this action.The following 161 VOQs are included in the petition evaluation: 10209242, 10229468, 10240708, 10260923, 10275939, 10276532, 10296487, 10298175, 10328669, 10330144, 10346517, 10349789, 10354758, 10363689, 10372112, 10372368, 10372514, 10378031, 10379764, 10382938, 10387448, 10394063, 10398877, 10413918, 10418652, 10420924, 10427063, 10437525, 10445392, 10446902, 10470028, 10471249, 10473733, 10502231, 10503114, 10504260, 10509862, 10511988, 10512120, 10512385, 10512650, 10513147, 10538154, 10549841, 10551763, 10555188, 10555418, 10556754, 10565367, 10574012, 10574398, 10586555, 10587212, 10587559, 10593433, 10607841, 10607913, 10608922, 10615810, 10622468, 10628141, 10632112, 10632128, 10632172, 10632175, 10632231, 10632262, 10632266, 10632270, 10632305, 10632316, 10632326, 10632370, 10632385, 10632399, 10632492, 10632542, 10632765, 10632833, 10632928, 10633197, 10633281, 10633409, 10633421, 10633483, 10633507, 10637752, 10637804, 10637950, 10637975, 10638032, 10638289, 10638290, 10638401, 10638968, 10639218, 10639623, 10641157, 10641603, 10641614, 10641836, 10644339, 10644705, 10649713, 10649895, 10649932, 10650313, 10652590, 10653147, 10653783, 10654533, 10655226, 10658900, 10659679, 10660320, 10662588, 10662645, 10662662, 10663473, 10667056, 10667437, 10668081, 10668094, 10668131, 10668612, 10668969, 10668970, 10669584, 10669678, 10669729, 10669775, 10669866, 10669895, 10669992, 10670422, 10670506, 10676348, 10676732, 10677120, 10679795, 10679934, 10680057, 10680290, 10680342, 10680714, 10681512, 10682584, 10682906, 10683022, 10683114, 10683549, 10683620, 10683697, 10683743, 10689898, 10690761, 10691284, 10691556, 10691751, 10693061, 10694300

EA11010 · Loss Of Headlight Illumination

Opened Sep 6, 2011 · Closed Nov 29, 2012

Status: closed (inferred from source dates) · Electrical System; Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch

The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.

Additional source detail variants (4)

Electrical System

The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.

Exterior Lighting

The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.

Exterior Lighting:headlights

The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.

Exterior Lighting:headlights:switch

The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.

AQ10001 · Fleet Vehicle Recall Completion Audit

Opened Nov 18, 2010 · Closed Dec 28, 2015

Status: closed (inferred from source dates) · Unknown Or Other

On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.

RQ09003 · Front Air Bag Crash Sensor Failure

Opened Jul 1, 2009 · Closed Feb 18, 2010

Status: closed (inferred from source dates) · Air Bags:frontal; Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:sensor/control MODULE-INACTIVE

CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.

Additional source detail variants (3)

Air Bags:frontal

CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.

Air Bags:frontal:driver Side:inflator Module

CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.

Air Bags:frontal:sensor/control MODULE-INACTIVE

CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.

EA06003 · Front Air Bag Crash Sensor Failure

Opened Mar 8, 2006 · Closed May 22, 2007

Status: closed (inferred from source dates) · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE

DAIMLERCHRYSLER (DCC) WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 270,958 MY 2005 DAIMLERCHRYSLER MINIVANS (NHTSA RECALL NO. 07V-192).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH BRASS BUSHINGS AND WERE BUILT BETWEEN APRIL 24, 2003 AND FEBRUARY 2, 2005.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 133,128 MY 2005 MINIVANS, WILL RECEIVE A LIFETIME WARRANTY ON THE FRONT CRASH SENSORS.ALTHOUGH THESE VEHICLES USE THE SAME BRASS BUSHING SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.DCC WILL ALSO PROVIDE WRITTEN NOTIFICATION TO ALL AFFECTED VEHICLE OWNERS.NHTSA AND DCC DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, DCC IS IMPLEMENTING STEPS TO REPLACE THE SUBJECT COMPONENTS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.

Additional source detail variants (2)

Air Bags:frontal

DAIMLERCHRYSLER (DCC) WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 270,958 MY 2005 DAIMLERCHRYSLER MINIVANS (NHTSA RECALL NO. 07V-192).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH BRASS BUSHINGS AND WERE BUILT BETWEEN APRIL 24, 2003 AND FEBRUARY 2, 2005.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 133,128 MY 2005 MINIVANS, WILL RECEIVE A LIFETIME WARRANTY ON THE FRONT CRASH SENSORS.ALTHOUGH THESE VEHICLES USE THE SAME BRASS BUSHING SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.DCC WILL ALSO PROVIDE WRITTEN NOTIFICATION TO ALL AFFECTED VEHICLE OWNERS.NHTSA AND DCC DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, DCC IS IMPLEMENTING STEPS TO REPLACE THE SUBJECT COMPONENTS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.

Air Bags:frontal:sensor/control MODULE-INACTIVE

DAIMLERCHRYSLER (DCC) WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 270,958 MY 2005 DAIMLERCHRYSLER MINIVANS (NHTSA RECALL NO. 07V-192).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH BRASS BUSHINGS AND WERE BUILT BETWEEN APRIL 24, 2003 AND FEBRUARY 2, 2005.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 133,128 MY 2005 MINIVANS, WILL RECEIVE A LIFETIME WARRANTY ON THE FRONT CRASH SENSORS.ALTHOUGH THESE VEHICLES USE THE SAME BRASS BUSHING SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.DCC WILL ALSO PROVIDE WRITTEN NOTIFICATION TO ALL AFFECTED VEHICLE OWNERS.NHTSA AND DCC DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, DCC IS IMPLEMENTING STEPS TO REPLACE THE SUBJECT COMPONENTS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.